Professional Documents
Culture Documents
Methodology: 1. Surface Preparation
Methodology: 1. Surface Preparation
Methodology: 1. Surface Preparation
1. SURFACE PREPARATION
The surface must be clean1 and free from all traces of loose material, old coatings, curing
membranes, release agents, laitance, oil and grease, etc. Surfaces may be damp but free from
standing water. Substrate compression strength should be at least 20 Mpa. Structurally unsound
layers and surface containments must be mechanically removed. Power washing 1a followed by
blowing2to remove fine aggregates is recommended.
Fig. 1
Fig 1
Fig. 1a Fig. 2
2. REPAIR ON FLOORS
Repair crack areas by placing a pre-cut mesh.
Fig. 2 Fig. 2
Fig. 2
Fig. 2
Fig. 3
3.2 APPLICATION OF RECEPROOF FC
RECEPROOF FC can be applied by brush4 or steel trowel. Two coats is required, horizontal
then vertical or vice versa. The second coating must be done after the first coat is dry to touch.
Fig 4 Fig 4a
Fig. 3
With an airless sprayerfig.4, roller or brush apply the first layer of the waterproofing system
over the field.
Allow the application to dry and cure prior to applying the second layer. Average curing time
during sunny warm humidity will roughly take 1-2 hours.
Fig. 4