Professional Documents
Culture Documents
CFLab Sheet 1
CFLab Sheet 1
CFLab Sheet 1
Objective:
(1) be familiar with basic drawing capabilities, how to save/open a file and run the simulator of the
‘Multimedia Logic’ (ML) software
(2) understand the behavior of Basic Logic gates (AND, OR, NOT, NOR, NAND) using ML
Pre-requisites: Followed the Orientation Program. Followed lecture 1& 2
In CF lab sessions you will use MultiMedia Logic Version 1.3 to understand the logic circuits learned in
lectures and tutorials.
Stop Simulation
Start Simulation
Tool palette
To draw any device, click the tool in the palette and click the drawing canvas. Nodes also can be drawn
same way. Use wire tool to connect devices. Nodes may be useful to arrange the circuits nicely.
Use pointer tool to select any device drawn on the canvas. Then they can be moved, copied or deleted.
Wires cannot be moved separately but by moving the devices wires also will move.
Students are advised to create a separate folder in their Z drive to save CF Lab work. Create separate folder
for each week and save all files there.
Use ‘Run’ button to run the simulator. Then change the input and observe the output. Probe tool can be
used to check the state of a node at any time while in run mode. Refer ( b) above for other useful modes.
AND OR NOT
b) Do the same for 3 input AND and OR gate. Save your file as basicGates2.lgi
AND OR
ii) Draw the truth table of NAND and NOR gates and implement them in ML. Compare them with
the truth tables of (1) above.