Professional Documents
Culture Documents
Target DPP Test: Ω Hz Hz Hz 500 Hz
Target DPP Test: Ω Hz Hz Hz 500 Hz
Target DPP Test: Ω Hz Hz Hz 500 Hz
1. 5.
In a LCR circuit having L = 8.0 henry, C = 0.5 μF In a region of uniform magnetic induction B =
and R = 100 Ω in series, the resonance 10–2 tesla, a circular coil of radius 30 cm and
frequency (in Hz) is resistance π2 ohm is rotated about an axis that is
250 perpendicular to the direction of B and which
1. Hz
π forms a diameter of the coil. If the coil rotates at
600 200 rpm the amplitude of the alternating
2. Hz
π
current induced in the coil is :
500
3. π
Hz
(1) 4π2 mA
4. 500 Hz (2) 30 mA
(3) 6 mA
2. (4) 200 mA
1. Hysteresis 6.
2. Eddy current loss In the circuit shown in figure neglecting source
resistance the voltmeter and ammeter reading
3. Leakage of flux
will respectively, will be
4. All of these
3.
An electric motor operating on a 60 V dc supply
draws a current of 10 A. If the efficiency of the
motor is 50%, the resistance of its winding is
(1) 3Ω (1) 0V, 3A
(2) 6Ω (2) 150V, 3A
(3) 15Ω (3) 150V, 6A
(4) 30Ω (4) 0V, 8A
4.
The peak value of an alternating e.m.f. E is given
by E = E0 cos ω t is 10 volts and its frequency
1
is 50 Hz. At time t =
600
sec , the instantaneous
e.m.f. is
(1) 10 V
(2) 5√3 V
(3) 5 V
(4) 1 V
Page: 1
Target DPP Test Contact Number: 9667591930 / 8527521718
7. 9.
An ac source of angular frequency ω is fed The potential differences across the resistance,
across a resistor r and a capacitor C in series. capacitance and inductance are 80V, 40Vand
The current registered is I. If now the frequency 100V respectively in an L-C-R circuit. The power
of the source is changed to ω/3 (but maintaining factor of this circuit is
the same voltage), the current in the circuit is
(1) 0.4
found to be halved. Calculate the ratio of
reactance to resistance at the original frequency (2) 0.5
ω.
(3) 0.8
(4) 1.0
3
(1) √ 5
2
(2) √ 5 10.
A small-signal voltage V(t)=Vo sinωt is applied
1
(3) √ 5 across an ideal capacitor C
(1)
(3)
(4)
Page: 2
Target DPP Test Contact Number: 9667591930 / 8527521718
12. 15.
An AC voltage is applied to a resistance R and an In an AC circuit, the emf (e) and the current (I)
inductor L in series. If R and the inductive at any instant are given respectively by
current in the circuit is The average power in the circuit over one cycle
(1) π/4 of AC is:
E o Io
(2) π/2 1. 2
(4) π/6 E o Io
3. 2
cos ϕ
4. Eo Io
13.
2. 50%
14. 3. 90%
1
2
2
C(V −V ) 1 2
(1) ( L
) difference between the voltage and the current
2
C(V −V )
2 from the circuit the phase difference is again
1 2
2 2
1. 1
C(V +V )
(3)
1 2
L 2. √3/2
1
1
2
C(V −V )
2 2
3. 2
(4) (
1 2
)
L
1
4.
√2
Page: 3
Target DPP Test Contact Number: 9667591930 / 8527521718
18. 21.
In an ac circuit, I = 100 sin 200 πt. The time An electricbulb is connected in series with an
required for the current to achieve its peak inductor across a.c supply. When an iron is
value will be inserted in the inductor, the brightness of bulb
1
1. 100 sec 1. Increases
1 2. Decreases
2. 200 sec
3. First increases the deceares
1
3. 300 sec
4. Remains the same
1
4. 400 sec
22.
4.
C
23.
E0
2.
√2
E0
3.
2
4. zero
Page: 4
Target DPP Test Contact Number: 9667591930 / 8527521718
24. 27.
What is the reading of the A.C voltmeter in the The time required for a 50 Hz sinusoidal
network as shown in the figure? alternating current to change its value from
zero to the r.m.s. value
−2
1. 1. 5 × 10 s
−3
2. 2. 5 × 10 s
−1
3. 10 s
−6
4. 10 s
1. zero
28.
2. 100 V
In the given figure, a lamp P is in series with an
3. 200 V iron-core inductor L. When the switch S is
closed, the brightness of the lamp rises
4. 400 v
relatively slowly to its full brightness than it
to:
25.
An L-C-R series circuit with 100 Ω resistance is
connected to AC source of 200 V and angular
frequency 300 rad/s. When only the capacitance
is removed, the current lags behind the voltage
by 60°. When only the inductance is removed,
the current leads the voltage by 60°. Calculate
the power dissipated in the L-C-R circuit.
1. 200 W 1. the low resistance of P
2. 400 W 2. the induced emf in L
3. 300 W 3. the low resistance of L
4. Zero 4. the low voltage of the battery B
26.
What is the Q-value of a series LCR circuit with
L = 2.0 H, C = 32 µF and R = 10 Ω?
1. 35
2. 20
3. 15
4. 25
Page: 5
Target DPP Test Contact Number: 9667591930 / 8527521718
29.
(4) (c, d)
30.
A step down transformer connected to an ac
mains supply of 220 V is made to operate at 11 V,
44 W lamp. Ignoring power losses in the
transformer, what is the current in the primary
circuit?
1. 2 A
2. 4 A
3. 0.2 A
4. 0.4 A
Page: 6