Professional Documents
Culture Documents
Gypsum Formboard: Standard Specification For
Gypsum Formboard: Standard Specification For
1
C 318/C 318M – 00 (2005)
6.2.2 Width—The nominal width shall be 32 in. [813 mm] 8. Sampling, Inspection, Rejection, Certification,
with a tolerance of 1⁄8 in. [3 mm] over the specified width, and Packaging and Package Marking, Shipping, Handling
1⁄4 in. [6 mm] under the specified width.
and Storage
6.2.3 Length—The nominal length of gypsum formboard
8.1 The sampling, inspection, rejection, certification, pack-
shall conform to the purlin spacing of multiples thereof, with
tolerances of 61⁄4 in. [6 mm] from the nominal length. aging and package marking, shipping, handling and storage
6.2.4 End Squareness—Corners shall be square with a shall be conducted in accordance with Specification C 1264.
tolerance of 61⁄8 in. [63 mm] in the full width of the board.
6.3 Edges and Ends—The edges and ends shall be square 9. Keywords
(90 6 10°), straight, and solid. 9.1 gypsum; gypsum concrete; gypsum formboard; gypsum
7. Finish and Appearance panel product; roof decks
7.1 The surfaces of gypsum formboard shall be true and free
from imperfections that would render it unfit for use with or
without decoration.
SUMMARY OF CHANGES
Committee C11 has identified the location of selected changes to this specification since the last issue,
C 318/C 318M – 96, that may impact the use of this specification. (Approved July 10, 2000)
ASTM International takes no position respecting the validity of any patent rights asserted in connection with any item mentioned
in this standard. Users of this standard are expressly advised that determination of the validity of any such patent rights, and the risk
of infringement of such rights, are entirely their own responsibility.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM International Headquarters. Your comments will receive careful consideration at a meeting of the
responsible technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should
make your views known to the ASTM Committee on Standards, at the address shown below.
This standard is copyrighted by ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959,
United States. Individual reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above
address or at 610-832-9585 (phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website
(www.astm.org).