Professional Documents
Culture Documents
Corsa C Guide For When ALL Modules Are Reset
Corsa C Guide For When ALL Modules Are Reset
This guide has been produced for the unlikely event that you may
accidently reset the Instruments, Body control module, Engine
control unit and the Immobilisers 2 all at the same time.
If you have done this the first thing you need to do is order NEW
ID40 chips for all keys and when they arrive fit them into all existing
keys. NOTE – If the immobiliser and ECU are erased at the same time
without programming then OLD ID40 chips CANNOT be used as the
data is stored and will be erased.
Connect your interface to the car and turn on ignition. Start the
program
Diagnostics>
Year>
Corsa C>
Body>
Immobiliser II>
Programming>
Security Code> Enter you code If the lower menus greyed out
Program immobiliser function> Choose “Immobiliser and ECM” and
click program/Do it
Program Immobiliser Output> [select the appropriate system] click
Program/Do it
Program VIN> Enter VIN – Click- Program/Do it
Program MKN> Write the MKN Click Program/Do it
Program Transponder Keys > Follow onscreen instructions
Once ALL keys are programmed. Exit the module, shut opcom down
and turn off ignition for 10 minutes.
Diagnostics>
Year>
Corsa C>
Engine> (Pick your engine code)
Programming>
Security code> (enter your code)
Can configurations> Set the configuration – Click program/Do it
Variant configurations> Set the configuration – Click Program/Do it
VIN> Write the VIN and click Program/Do it
Exit the module and shut opcom down and turn ignition off for 60
seconds.
Diagnostics>
Year>
Corsa C>
Body>
BCM>
Programming>
Programming>
Program BCM> Enter security code when asked – you will get
confirmation its programmed.
VIN programming> Enter VIN – You will get confirmation once its
programmed.
Go back into the programming menu and click “Variant
configuration” – enter the correct configuration for the car and
program it
Go to “code index” and select the correct one and click program
Diagnostics>
Year>
Corsa C>
Body>
Instruments>
Programming>
Immobiliser Related>
Program IPC> Enter Security code and program it
Exit the module, close opcom and turn ignition off for 60 seconds.
After 60 seconds turn ignition on and start opcom
After 60 seconds, turn the ignition on – Does the spanner light come
on and go off. If so you should be able to start the car.