Professional Documents
Culture Documents
Astm F1495
Astm F1495
Copyright © ASTM, 100 Barr Harbor Drive, West Conshohocken, PA 19428-2959, United States.
--`,,`,``,,,``,,,,,``,,,`,``,,`-`-`,,`,,`,`,,`---
turer’s standard practice. 13.1 baking oven; combination oven; convection oven; food
7.3 Threaded Parts—All threaded parts shall conform to service equipment; oven; roasting; steamer; atmospheric
ANSI B1.1. steamer
SUPPLEMENTARY REQUIREMENTS
S1. Where provisions of this supplement conflict with the not constitute a requirement for the contractor. These classes
main body, this supplement shall prevail. are the same as those in Section 4. The PINs to be used for
S2. Manual—A manual complying with Specification F 760 items acquired to this Specification are as follows:
and this Supplement shall be provided. ASTM F XXXX - - - - - 2 B 1 6
| | | | |
S3. First Article Inspection—When required, the first article | | | | |
inspection shall be performed on one unit. The first article may Spec. No. – – – Type__________| | | |
Class_____________| | |
be either a first production or a standard production item from Style_________________| |
the supplier’s current inventory, provided the item meets the Electrical__________________ |
requirements of the specification and is representative of the
Type 1 Table or countertop units
design, construction, and manufacturing technique applicable Type 2 Stand mounted units
to the remaining items to be furnished under the contract. Type 3 Floor units/roll-in units
S4. Data Nameplate—When required by purchaser, a name- Class A Half-size
plate shall contain the following: Class B Full-size
S4.1 National stock number (NSN), and Style 1 Gas-fired combination oven steamer
Style 2 Electric combination oven steamer
S4.2 Government approved manual number.
S5. Part Identifying Number—The following part identify- Electrical Class 1 208 V, 60 Hz, 1-phase
Electrical Class 2 208 V, 60 Hz, 3-phase
ing numbering procedure is for government purposes and does
APPENDIXES
(Nonmandatory Information)
X1.1 Typically features are added to basic models at an into the procurement contract as desired.
additional cost. Any options that are required can be written
The American Society for Testing and Materials takes no position respecting the validity of any patent rights asserted in connection
--`,,`,``,,,``,,,,,``,,,`,``,,`-`-`,,`,,`,`,,`---
with any item mentioned in this standard. Users of this standard are expressly advised that determination of the validity of any such
patent rights, and the risk of infringement of such rights, are entirely their own responsibility.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM Headquarters. Your comments will receive careful consideration at a meeting of the responsible
technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should make your
views known to the ASTM Committee on Standards, at the address shown below.
This standard is copyrighted by ASTM, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959, United States.
Individual reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above address or at
610-832-9585 (phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website (www.astm.org).