Download as pdf or txt
Download as pdf or txt
You are on page 1of 38

Massey Har ris

Service Manual
M a s s e y Fe r g u s o n
Service Manual
MF50E
Volume 1 of 2

THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF


MASSEY HARRIS MASSEY FERGUSON OR IT’S SUCCESSORS. MASSEY HARRIS MASSEY FERGUSON AND IT’S SUCCESSORS
ARE NOT RESPONSIBLE FOR THE QUALITY OR ACCURACY OF THIS MANUAL.

TRADE MARKS AND TRADE NAMES CONTAINED AND USED HEREIN ARE THOSE OF OTHERS,
AND ARE USED HERE IN A DESCRIPTIVE SENSE TO REFER TO THE PRODUCTS OF OTHERS.

MH-S-MF50E
WORKSHOP SERVICE MANUAL
~l
'<s/
1472231 M1

MF SOE
TRACTOR
GROUP SECTION CONTENTS
1 A Safety Precautions
B Using the Service Manual
C Basic Workshop Practice
D Conversion Data
G Specifications

2 C Major Assemblies Remove/refit

3 C Battery
.D Charging System
E Starting System
F Electrical System

4 A A4.236 and A4.248 Engines


C Fuel and Air System .
D Cooling System

5 D Powershuttle Transmission
E 8 Speed Non-Synch Transmission
F Dual/Split-torque Clutches

6 A Rear Axle and Brakes


B Front Axle - 2 Wheel Drive
E Front Axle - 4 Wheel Drive
G P.t.o. and l.p.t.o.

7 C Power Steering

8 A Hydraulic System General


B Loader and Digger Control Valves
C Slew Motor
D Hydraulic Cylinders
E Control Valves - Kontak

9 C Loader and Digger Structures

10 B Rops and Cab

11 A Internal Hydraulics

12 A Drawbar and Linkage


B Attachments and Accessories

13 A Wheels and Tyres


WORKSHOP SERVICE MANUAL
1472231 M1

MF SOE
TRACTOR

GROUP1

1A Safety Precautions
18 Using the Service Manual
1C Basic Workshop Practice
1D Conversion Data
1G Specifications
Issue 2 18-01

USING THE SERVICE MANUAL

Group 1 Section B
USING THE SERVICE MANUAL

Page
Introduction 02
Explanation of Index 02
Special Tools 03
Repairs and Replacements 03
Repair Time Schedule (ATS} 03
Service Bulletins 03
Amendments 04
1C-01

BASIC WORKSHOP PRACTICE

Group 1 Section C
BASIC WORKSHOP PRACTICE

page
System Faults 02
Handling of Heavy Components 02
Removal and Installation of Components 03
Bolt and Nut Identification 04
Bolt Installation and Tightening Torques 06
Bolt and Nut Locking Systems 07
Hydraulic Hoses and Fittings 08
Seals 09
Sealants 09
10-01

CONVERSION TABLES

Group 1 Section D

CONVERSION TABLES
Metric units 02
Length and temperature 04
Pressure 05
Torque 06
Power 07
Volume 08
Mass 09
Force 10
1G-01

SPECIFICATIONS

Group 1 Section G

SPECIFICATIONS

page

General dimensions 2
Weights and capacities 5
Machine specifications 6
1G-03

SPECIFICATIONS

GENERAL DIMENSIONS
MF SOE Tractor {fig 1)
All dimensions are in mm with {inches)

16.9-28
rear tyres
A Wheelbase 2070 (81.5)
B Overall length {linkage horizontal) 3590 (141.3)
C Height to top of steering wheel 1610 (63.4)
D Front track 1550 (61.0)
E Rear track 1448- (57-85)

2176
F Overall width 1897 (74.7)
Turning circle without brakes {LH) 8040 (316.5)

Mounting points (fig 2)


1 102 (4) 10 92 (3.62)
2 102 (4) 11 4 holes (Si in 11 UNC X 1¼ in)
3 5 holes(¾ in 10 UNC x Hin) 12 102 (4)
4 57 (2.25) 13 1092 (43)
5 73 (2.87) 14 4 holes(¾ in 10 UNC x Hin)
6 60 (2.38) 15 76 (3)
7 1836 (72.3) 16 152 (6)
8 254 (10) 17 43.1 (1.69)
9 184 (7.25) 18 86 (3.38)

MF 34 Loader (fig 3) 11L-16 front, 19.5-24 rear tyres


All dimensions in mm with (inch)

A Forward reach at ground level 1956 (77)

B Maximum cutting height 3937 (155)

C Maximum height to bucket hinge pin 3175 (125)

D Dump height - bucket at 45° 2642 (104)

E Forward reach at maximum height/45° dump 792 (31)

F Digging depth 102 (4)

G Maximum dump angle at full height 48°

H Maximum roll-back angle at ground level 47°

Tractor/loader/counterweight
Overall transport length 5601 (220.5)
2C-01

MAJOR ASSEMBLIES

Group2 Section C

MAJOR ASSEMBLIES
Remove/Refit

Op. No. Operation page


Special tools 02
2C • 01 -03 Hood,R/R 03
2C • 02-03 Hardnose, R/R 03
2C • 03-04 Radiator and oil coolers, R/R 04
2C • 04-06 Joint 1 , front axle support to engine separation/refitment 06
2C • 05- 08 Joint 2, engine to transmission separation/refitment 08
2C • 06-10 Joint 3, transmission to centre housing, separation/refitment 10
2C • 07-13 R.H. Axle housing, R/R 13
3C-01

BATIERY

Group3 Section C

BATIERY

Op. No. Operation page


Special tools 02
Preparation of dry-charged batteries for service 03
Preparation of dry-uncharged batteries for service 04
Preparation of electrolyte 04
Battery charging and maintenance 05
Fast charging 07
Maintenance-free batteries 07
3C • 01 -08 Capacitance testing 08
30-01

CHARGING SYSTEM

Group3 Section D

CHARGING SYSTEM

Op. No. Operation page


Special tools 02
The charging circuit 03
General diagnosis 04
30 • 01 - 05 Cable continuity, test 05
30 • 02- 06 Lucas alternator, voltage regulator test 06
30 • 03-07 Lucas alternator, voltage drop test 07
Lucas A115 Alternator
30 • 04-09 Regulator and brushbox, remove/refit 09
30 • 05-10 Alternator, service 10
Lucas 23/25 ACR Alternator
Technical date 15
30 • 06-17 Suppression capacitor and surge diode,
remove/refit 17
30 • 07 -18 Brushbox and regulator, remove/refit 18
30 • 08-19 Alternator performance, test 19
30 • 09- 20 Alternator, service 20
Lucas A127 Alternator
Technical data 26
30 • 10- 27 Suppression capacity 27
30 • 11 - 27 Regulator and brushbox 27
30 • 12- 28 Rotor field circuit, test 28
30 • 13- 28 Alternator output, test 28
30 • 14 - 29 Alternator, service 29
Perkins Alternator - LR150
Technical data 33
Fault diagnosis 34
30 • 15- 35 Alternator test (alternator fitted to machine) 35
30 • 16- 35 Regulator output, test 35
30 • 17 - 36 Output current, test 36
30 • 18- 36 Alternator output, test 36
3D-'Zl

CHARGING SYSTEM

SUPPRESSION CAPACITOR
Remove and refit 3D• 10-'Zl
The suppression capacitor can be removed with the
alternator in situ.
Remove
1. Remove nut from tie-bolt.
2. Pull off spade connector.
3. Remove capacitor.
Refit
Reverse instructions 1 to 3:

REGULATOR AND BRUSH BOX


Remove and refit 3D•11-'Zl
The regulator/brush box assembly can be removed with
the alternator in situ.
Remove
1. Remove three screws.
2. Lift regulator /brush box away from alternator.
3. Separate the spade connector.
4. Check brush lengths.
A - new length
B - minimum length. Replace brushes if they are at
or below this length.
5. Check brush spring pressure using a compression
type spring balance. Press brush to brush box
moulding. Spring pressure should be:
1.3N (4.7oz} minimum
2. 7N (9.8oz) new brushes
A= 17mm
B =5mm Refit
Reverse instructions 1 to 3 except:
6. Be careful to avoid damaging the brushes when
refitting the regulator/brush box assembly.

...
3E-01

STARTING SYSTEM

Group3 Section E

STARTING SYSTEM

Op. No. Operation page


Special tools 02
Specifications 03
3E • 01 - 04 Battery voltage under load conditions test 04
3E • 02-04 Starter motor terminal voltage under load, test 04
3E • 03-04 Voltage drop on the insulated line, test 04
3E • 04- 05 Voltage drop across the solenoid contacts 05
3E • 05-05 Voltage drop in earth line, test 05
3E • 06-06 No load current and speed, test . 06
3E • 07- 06 Continuity of contacts, test 06
3E • 08-07 Voltage drop across contacts, test 07
3E • 09-07 Lock torque and running torque, test 07
3E • 10- 08 Pinion stroke, adjustment 08
3E • 11 -08 End cover and brush carrier, service 08
3E • 12- 09 Starter motor solenoid, remove/refit 09
3E • 13-10 Starter motor, service 10
3F-01

ELECTRICAL SYSTEM

Group3 Section F

ELECTRICAL SYSTEM

Op. No. Operation page


Wiring diagrams 02
Fuses and diodes 06
3F • 01 - 07 Line fuses, remove/refit 07
3F • 02-08 Battery, remove/refit 08
3F • 03-08 Alternator, remove/refit 08
3F • 04-08 Starter motor, remove/refit 08
3F • 05-09 Brake light switch,
(hydraulic brake models) remove/refit 09
3F • 06-09 Brake light switch,
(mechanical brake models) remove/refit 09
3F • 07 -10 Starter switch, remove/refit 10
3F • 08-10 Light switch and horn push, remove/refit 10
3F • 09-10 Turn indicator, hazard warning switch
and relay, remove/refit 10
3F • 10 -11 Pilot light bulbs, turn indicator switch
remove/refit 11
3F • 11 - 11 Cigar lighter, remove/refit 11
3F • 12 -11 Warning light bulb, remove/refit 11
3F • 13-12 Instrument light bulb, remove/refit 12
3F • 14-12 Fuel and temperature guages, remove/refit 12
3F • 15 -12 Tachometer and speedometer, remove/refit 12
3F • 16-13 Trailer socket, remove/refit 13
3F • 17 -14 Neutral safety start switches,
remove/refit 14
3F • 18-14 Headlights, main beam adjustment 14
3F • 19-15 Headlight bulb, remove/refit 15
3F • 20-16 Front wiring harness 16
Bulb replacement 17
4A-01

A4.236 / A4.248 ENGINES

Group4 Section A

A4.236 and A4.248 ENGINES

Op. No. Operation page


Special tools 2
General description 4
Glossary of terms 4
Fault diagnosis chart 5
Technical data 6
Service wear limits 13
4A • 01 -14 Rocker cover, remove/refit 14
4A • 02-14 Valve tip clearance, adjust 14
4A • 03-14 Rocker assembly, remove/refit 14
4A • 04-15 Rocker assembly, servicing 15
4A • 05-15 Valve springs, remove/refit
(with cylinder head fitted to engine) 15
4A • 06-16 Cylinder head, remove/refit 16
4A • 07-17 Cylinder head, servicing 17
4A • 08-19 Valve seat inserts 19
4A • 09- 21 Timing case cover, remove/refit 21
4A • 10- 22 Idler gear, remove/refit 22
4A • 11 -23 Camshaft drive gear, remove/refit 23
4A • 12- 23 Fuel pump drive gear, remove/refit 23
4A • 13-24 Crankshaft gear, remove/refit 24
4A • 14-24 Timing case, remove/refit 24
4A • 15- 25 Flywheel, remove/refit 25
4A • 16-26 Ring gear, replacement 26
4A • 17-26 Crankshaft rear oil seal, remove/refit 26
4A • 18- 28 Engine sump, remove/refit 28
4A • 19-28 Oil pump, remove/refit 28
4A • 20-29 Oil pump, servicing 29
4A • 21 -29 Balancer unit, remove/refit
(with timing case accessible) 29
4A • 22-30 Balance unit, remove/refit
(with engine in situ) 30
4A • 23- 31 Balancer unit, servicing 31
4A • 24- 32 Connecting rod big-end bearing, remove/refit 32
4A • 25- 33 Pistons and connecting rods, remove/refit 33
4A • 26- 34 Pistons and connecting rods, servicing 34
4A • 27- 35 Cylinder liners, remove/refit 35
4A • 28- 36 Crankshaft thrust washers, remove/refit 36
4A • 29- 37 Crankshaft, servicing 37
4A • 30- 39 Camshaft and tappets, remove/refit 39
4C-01

COOLING SYSTEM

Group4 Section C
COOLING SYSTEM

Op.No. Operation page

Special tools 2
General information 3
Technical data 4
4C • 01 -05 Adjust fan belt tension 5
4C • 02-05 Thermostat, remove/refit 5
4C • 03-06 Water pump, remove/refit 6
4C • 04-06 Water pump, servicing 6
40-01

AIR/FUEL SYSTEM

Group4 Section D

AIR/FUEL SYSTEM

Op. No. Operation page

Special tools 2
General, air filtration 3
General, fuel system 4
Technical data, fuel system 7
4D • 01 -09 Fuel gauge sender unit 9
4D • 02-09 Thermostat, remove/refit 9
4D • 03-10 Fuel lift pump, remove/refit 10
4D • 04-10 Fuel lift pump, servicing 10
4D • 05-12 Fuel injection pump, remove/refit 12
4D • 06-13 Static fuel injection pump timing adjustment 13
4D • 07-14 Marking angle of fuel injection pump adjustment 14
4D • 08-16 Atomisers, remove/refit 16
4D • 09-17 Fuel system, de-aeration 17
50-01

POWERSHUTTLE TRANSMISSION

Group 5 Section D

POWERSHUTTLE TRANSMISSION

Op. No. Operation page


Special tools and sealants 02
General description 03
Description of the hydraulic circuit 06
Description of the electrical system 08
Fault diagnosis 09
5D-01 -11 Stall torque test 11
5D-02-11 Transmission output check 11
5D-03-11 Pump flow check 11
5D-04-12 Transmission clutch pressure, test 12
5D-05-12 Torque converter pressure, test 12
5D-06-13 Torque converter safety valve, test 13
50-07-13 F/R clutch pack leakage, test 13
5D-08-14 Venting valve, test 14
5D-09-14 4 WO clutch pack, leakage test 14
5D-10-15 Torque converter, R/R 15
5D-11 -16 Hydraulic shuttle transmission, servicing 16
5D-12-23 Output shaft assembly, se,rvicing 23
5D-13-24 Main-shaft assembly, sen.~icing 24
5D-14-24 Layshaft assembly, servicing 24
50-15-25 ZF synchromesh, servicing 25
5D-16-26 Clutches and shaft asssembly, servicing 26
50-17-27 Forward/reverse control valve, test 27
5D-18-27 Forward/reverse control valve, servicing 27
5D-19-28 Transmission pressure maintaining valve, servicing 28
5D-20-28 Torque converter safety valve, servicing 28
5D-21-29 4 WO power take-off pod, servicing 29
SE-01

8 SPEED N.S. TRANSMISSION

Groups Section E

8 SPEED N.S. TRANSMISSION

Op. No. Operation page

Special tools 2
General description 3
5E • 01 - 07 Selector rail mechanism, remove/refit 7
5E • 02 - 08 Normal/heavy duty gearbox epicydic, remove/refit 8
5E • 03 - 08 Normal duty gearbox epicydic, servicing 8
5E • 04 - 09 Heavy duty gearbox epicydic, servicing 9
SE• 05 -10 Clutch release mechanism, remove/refit 10
SE• 06 - 11 Input shaft housing and p.t.o. input shaft, remove/refit 11
5E • 07 -12 P.t.o. drive shaft front bearing, remove/refit 12
5E • 08-13 Main input shaft, remove/refit 13
5E • 09-13 Third gear (mainshaft), remove/refit 13
5E • 10 -14 Mainshaft, first/reverse gear, second and fourth g~ar, 14
remove I refit
5E • 11 - 15 Layshaft and gears, p.t.o. shaft and gear, remove/refit 15
SE• 12 -16 Reverse gear cluster 16
SE• 13 - 17 Transmission case remove/refit, or complete gearbox overhaul 17
5E • 14 -19 Gear shift lever, remove/refit 19
5E • 15 - 19 High/low range shift lever, remove/refit 19
SF-01

DUAL/SPLIT TORQUE CLUTCHES

Groups Section F

DUAL/SPLIT TORQUE CLUTCH

Op. No. Operation page


Special tools 2
Fault finding 3
General description, split torque clutch 4
General description, dual clutch 5
SF• 01 - 06 Dual clutch assembly, remove/refit 6
SF• 02- 07 Dual clutch assembly, servicing 7
SF• 03- 08 Split torque clutch assembly, remove/refit 8
SF• 04 - 09 Split torque clutch assembly, servicing 9
SF• 05 -10 Clutch release bearing, remove/refit 10
SF• 06-10 Clutch release mechanism, remove/refit 10
SF• 07 - 11 Clutch adjustment 11
ISSUE 2 &A-01

REAR AXLE & BRAKES

Group6 Section A
REAR AXLE AND BRAKES

Op. No. Operation page


General description 02
Special tools 03
6A • 01 - 06 Rear wheel studs R/R 06
6A • 02- 06 Epicyclic outer housing and ring gear 06
6A • 03- 07 Epicyclic planet and sungear 07
6A • 04- 08 Epicyclic unit 08
6A • 05-10 Epicyclic pre-load 1O
6A • 06 -11 Axle trumpet housings R/R 11
6A • 07 -11 R.H. carrier plate R/R 11
6A • 08-12 L.H. carrier plate R/R 12
6A • 09-13 Differential lock actuator mechanism R/R 13
6A • 10 -14 Differential lock coupler cap 14
6A • 11 - 15 Differential Preload checking and adjustment 15
6A • 12-16 R.H. differential bearing R/R 16
6A • 13-17 Differential unit R/R ·17
6A • 14-17 Differential LH bearing R/R 17
6A • 15-18 Differential unit, servicing 18
6A • 16-19 Crown wheel R/R 19
6A • 17 - 21 Pinion assembly 21
6A • 18- 21 Pinion assembly, servicing 21
6A • 19- 23 Rear drive shaft, servicing 23
6A • 20- 24 Brake actuator R/R 24
6A • 21 - 25 RH and LH Brake units, servicing 25
6A • 22- 26 Adjusting the brakes 26
6A • 23- 27 Bleeding the brake system 27
6A • 24 - 28 Brake slave cylinders R/R 28
6A • 25- 28 Brake slave cylinder servicing 28
6A • 26- 29 Brake master cylinders servicing (ccv-type) 29
6A • 27 - 31 Brake master cylinder R/R, (non-compensating type) 31
6A • 28- 32 Brake master cylinder servicing (non-compensating type) 32
6A • 29- 32 Brake adjustment, (non-compensated hydraulic brakes) 32
6A • 30- 33 Brake pedal assembly, (non-compensated hydraulic brakes) 33
6A • 31 - 33 De-aerating the brake system
(non-compensated hydraulic brakes) 33
6A • 32- 34 Brake linkage and pedals (mechanically operated brakes) 34
6A • 33- 34 Brake adjustment, (mechanically operated brakes) 34
6A • 33- 35 L.H. brake actuator R/R (mechanically oper~ted brakes) 35
6A • 35- 36 Differential lock actuator R/R (footstep tractors) 36
6A • 36- 36 Speedometer drive R/R 36
68-01

FRONT AXLE 2WD

Group 6 Section B

FRONT AXLE - 2 WHEEL DRIVE

Op No. Operation page

Special tools 02
68 - 01 - 03 Toe-in adjustment 03
68 - 02 - 03 Front hub dismantle/refit 03
68 - 03- 04 King pin remove/refit 04
68 - 04 - 05 King pin bushes remove/refit 05
68 - 05 - 06 Axle beam remove/refit 06
68 - 06 - 07 Axle beam bushes 07
68 - 07 - 07 Axle support casting 07
6E-01
FRONT AXLE - 4 WHEEL DRIVE

Group 6 Section E

FRONT AXLE - 4 WHEEL DRIVE


Operation No. Operation page
Special tools 02
General description 04
6E • 01 - 07 Toe-in adjustment 07
6E • 02-07 Steering lock adjustment 07
6E • 03- 08 Final drive assembly, remove/refit 08
6E • 04-·09 King pins, servicing 09
6E • 05-11 Drive shaft, remove/refit 11
6E • 06-13 Final drive hub, servicing 13
6E • 07 -15 Differential, servicing 15
6G-01

POWER TAKE-OFF

Group6 Section C

POWER TAKE-OFF

Op. No. Operation page


Special tools 02
General description - power take-off 03
General description independent power take-off clutch unit 06
6G • 01 - 07 P.t.o. shaft oil seal, remove/refit 07
6G • 02-08 P.t.o. shaft, (standard flow linkage pump) remove/refit 08
6G • 03-08 P.t.o. shaft, (high flow linkage pump) remove/refit 08
6G • 04-09 P.t.o. shaft rear bearing, (standard flow linkage pump),
remove/refit 09
6G • 05-09 P.t.o. shaft rear bearing, (high flow linkage pump)
remove replace 09
6G • 06-10 Needle roller bearing, (standard flow linkage pump)
remove/refit 10
6G • 07-10 Ground speed gear, bush and pinion shaft gear assembly,
(standard flow linkage pump) remove/refit 10
6G • 08-11 Needle roller bearing and reduction gears (high flow linkage
pump) remove/refit 11
6G • 09-12 P.t.o. side cover (live p.t.o. tractors), remove and refit 12
6G • 10-12 P.t.o. side cover (live p.t.o. tractors), servicing • 12
6G • 11 -13 P.t.o. side cover (independent p.t.o. tractors), remove/refit 13
6G • 12-14 P.t.o. side cover (independent p.t.o. tractors), servicing 14
6G • 13-14 l.p.t.o. clutch unit, remove/refit 14
6G • 14-15 l.p.t.o. clutch unit, servicing 15
6G • 15-16 l.p.t.o. control valve, remove/refit 16
6G • 16-16 l.p.t.o. control valve, servicing 16
6G • 17 -17 l.p.t.o. brake unit, remove/refit 17
6G • 18-17 l.p.t.o. brake unit, servicing 17
7C-01

POWER STEERING SYSTEM

Group7 Section C

POWER STEERING SYSTEM

Op. No. Operation page


Special tools 02
General description, Orbitrol
Steering valve 03
General description, Powershuttle
Steering circuit 06
7C • 01 - 08 Venting valve, test 08
7C • 02- 09 Steering main relief valve, test 09
7C • 03- 09 Pump safety valve, test 09
7C • 04-09 Pump flow, test 09
7C • 05-10 Steering pump, remove refit 10
7C • 06-10 Steering pump, service 10
7C • 07-11 Steering valve, remove/refit 11
7C • 08-12 Steering valve, service 12
7C • 09-15 Steering system, de-aeration 15
7C • 10-15 Steering pump reservoir check oil level 15
7C • 11 -16 Steering pump, remove/refit 16
7C • 12 -16 SteerJng pump, service 16
7C • 13-17 Steering wheel, remove/refit 17
7C • 14 -18 Steering ram (non-drive axle) remove/refit 18
7C • 15-18 Steering ram (non-drive axle) service 18
7C • 16-19 Steering ram (ZF drive axle) remove/refit 19
7C • 17 - 20 Steering ram (ZF drive axle) service 20
7C • 18 - 21 Steering ram (MF drive axle) remove/refit 21
7C • 19- 21 Steering ram (MF drive axle) service 21
7C • 20- 22 Spherical bearings (MF drive axle ram) 22
7C • 21 - 23 Lock-wire, reclamation of failed drive lug 23
SA-01

HYDRAULIC SYSTEM

Group 8 Section A

HYDRAULIC SYSTEM GENERAL


Op No. Operation page
Special tools 02
General description 03
Fault diagnosis 04
8A-01 -06 Checking hydraulic oil level 06
8A-02-06 Draining the hydraulic system 06
8A-03-07 Main relief valve, pressure test 07
8A-04-07 Hydraulic pump, flow test 07
8A-05- 08 Circuit relief valves, pressure test 08
8A- 06- 09 Slew cushion valve, setting clock 09
8A-07-09 Slew actuator, leakage test 09
8A-08-10 Slew actuator cross line relief valve test 10
8A- 09- 11 Suction line filter R/R 11
8A-10 -12 Pressure line filter R/R 12
8A- 11 -13 Hydraulic pump R/R 13
8A- 12 - 14 Hydraulic pump servicing 14
8A- 13 -18 Hydraulic pump driveshaft R/R 18
Issue 2 88-01

LOADER AND OIGGER CONTROL VALVES

Group 8 Section B

LOADER AND DIGGER


CONTROL VALVES
Issue Two

Op. No. Operation page


General description 02
88 • 01-06 Loader control valve R/R 06
88 • 02-06 Digger control valve R/R 06
88 • 03-07 Main relief valve servicing 07
88 • 04-07 Circuit relief valve servicing 07
88 • 05-09 Standard spool section, servicing 09
88 • 06-10 Loader boom spool section, servicing 10
88 • 07-11 Digger side-shift clamp spool,- servicing 11
88 • 08-11 Pilot operated check valve servicing 11
(clamp spool, side-shift diggers only)
88 • 09-12 Check valves, servicing 12
88 • 09-12 Restrictor plates, checking 12
Pressure - beyond plug 12
Issue 2 BC-01

SLEW MOTOR

Group 8 Section C

SLEW MOTOR
Issue Two

Op. No. Operation page


Special tools 02
General description 04
BC• 01 -08 Rotary actuator R/R 08
BC• 02-08 Rotary actuator, servicing 08
BC• 03-12 Cross line relief valve, servicing 12
BC• 04-13 Cross line relief valve, pressure 13
adjustment
BC• 05-13 Check valves, servicing 13
BC• 06-14 Differential orifice valves, servicing 14
Issue 2 SD-01

HYDRAULIC CYLINDERS

Group 8 Section D

HYDRAULIC CYLINDERS
Issue Two

Op. No. Operation page


Special tools 02
General description 02
80 • 01 -03 Hydraulic ram type A, servicing 03
80 • 02-04 Hydraulic ram type B, servicing 04
80 • 03-05 Hydraulic ram type C, servicing 05
80 • 04-06 Hydraulic ram type 0, servicing 06
80 • 05-07 Hydraulic ram type E, servicing 07
80 • 06-08 Hydraulic ram type F, servicing 08
80 • 07 -10 Hydraulic ram type G, servicing 10
80 • 08-11 Reclamation of failed lockwire 11
BE-01

CONTROL VALVES - KONTAK

Groups Section E

CONTROL VALVES - KONTAK

Op. No. Operation page


General description 02
Valve identification 02
BE• 01 -05 Loader control valve - R/R 05
BE• 02-06 Spool valves types Band E, service 06
BE• 03-07 Spool valves types AC and D, service 07
BE• 04-08 Detent mechanism, spool type A, service 08
BE• 05-09 Detent mechanism, spool types C and D, service 09
BE• 06-10 Main relief valve/circuit relief valve, service 10
9C-01

LOADER/DIGGER STRUCTURES

Group9 Section C

LOADER/DIGGER STRUCTURES

Op. No. Operation page


Torque values MF 32/34 Loaders 02
Lubrication MF 32/34 Loaders 03
9C • 01 -04 Oil filters - change, MF 32/34 Loaders 04
9C• 02-05 Loader boom - R/R, MF 32/34 Loaders 05
Torque values, MF 250 Loader 06
Lubrication, MF 250 Loader 06
9C • 03-07 Suction line filter - change, MF 250 Loader 07
9C • 04-08 Pressure line filter - change, MF 250 Loader 08
9C • 05-08 Loader boom - R/R, MF 250 Loader 08
9C • 06-09 Digger frame - R/R, MF 252 side-shift model 09
9C • 07-10 Stabilizer leg - R/R, MF 252 side-shift model 10
9C • 08-10 Stabilizer slides - service, MF 252 side-shift model 10
9C • 09-11 Slew ram - R/R, MF 54 centre-mount model 11
108-01

ROPS/CAB

Group 10 Section B

ROPS/CAB

Op. No. Operation page


General description 02
108 • 01 -03 2 post ROPS, R/R 03
108 • 02-04 4 post ROPS, R/R 04
108 • 03-05 Spring suspension seat, R/R 05
108 • 04-06 Spring suspension seat, service 06
11A-01

INTERNAL HYDRAULICS

Group.11 Section A

INTERNAL HYDRAULICS

Op.No. Operation page

Special tools 02
General description 04
11A • 01 - 05 Control spring assembly, R/R 05
11A • 02- 05 Control spring assembly, service 05
11A • 03-06 Hydraulic lift cover, R/R (footstep models) 06
11A • 04- 08 Hydraulic lift cover, R/R (cab models 08
11A • 05 -10 Hydraulic lift control, service 10
11A • 06 -12 Linkage lift ram, service 12
11A • 07 -13 Quadrant and support assembly, R/R 13
11A • 08 -13 Quadrant and support assembly, service 13
11A • 09 -14 1-lydraulic controls, adjustment 14
11A•10-18 Hydraulic pump, R/R 18
11A•11-19 Hydraulic pump, R/R (tractors f!tted with l.p.t.o. pump) 19
11A • 12 - 20 Hydraulic pump, service 20
11A • 13 - 23 Main relief valve, R/R 23
11A • 14 - 24 l.p.t.o. pump, R/R 24
11A • 15 - 25 l.p.t.o. pump, service 25
11A • 16 - 26 Plated drive, service 26
11A • 17 - 26 Pressure maintaining valve, R/R (8 speed l.p.t.o. tractors only) 26
11A • 18 - 26 Pressure maintaining valve, service 26
11A • 19 - 27 l.p.t.o. hydraulic pressure, test 27
11A-15

INTERNAL HYDRAULICS

Uft arm end float


1. Release the tabwasher.
2. Slacken the bolt.
3. Release the tabwasher.
4. Fully tighten the bolt.
5. Secure the bolt with the tabwasher.
6. Tighten the bolt, until the lift arms will move freely
throughout their range, but without any end float.
7. Secure the bolt with the tabwasher.

Quadrant location
1. Slacken the two bolts.
2. Slacken the two barrel nuts.
3. Locate the inner quadrant in the centre of the
5 elongated hole.
4. Tighten the two barrel nuts.
5. Locate the outer quadrant in the centre of the

- elongated hole.
6. Tighten the two bolts.

Draft control rod


1. Place the Draft control lever in the UP position.
2. Place the Position control lever in the TRANSPORT
position.
3. Using MF 333, adjust the set screw to give a
clearance of 5,8 mm (0.230 in) between the
setscrew and the lift cover casting.
11A-16

INTERNAL HYDRAULICS

Draft Control
1. Slacken the locknut.
2. Unscrew the Allen screw to the end of its thread.
3. Release the tabwasher.
4. Slacken the nut.
5. Position MF 273 on the lift cover.
6. Apply a load of 1,4 kg (31b) to the end of the vertical
lever.
7. Locate MF 356 on the lift cover.
8. Place the Draft Control lever in the SECTOR
position.
9. Place the Position Control lever in the TRANSPORT
position.
10. Adjust the slide pivot, until the vertical lever just
touches the pin on MF 356.
11. Tighten the nut.
12. Recheck the setting.
13. Secure the nut with the tabwasher.
IMPORTANT: On later model tractors the cut-out in the
vertical link has been modified. Therefore care must be
P.,... taken to ensure that the straight edge of the lever rests
~ against the setting pin on tool MF 356, and not the cut-
out, as this would result in an incorrect setting. The
tool can bf! converted using Kit MF 356-Z to
compensate for this change. Tools stamped MF 356C
have been adjusted by the manufacturers to suit the
new link.

Position Control
1. Position MF 272 on the lift cover.
2. Locate the ram arm on MF 272.
3. Place the Draft Control lever in the UP position.
4. Place the POSITION CONTROL LEVER in the
TRANSPORT position.
5. Adjust the Allen screw until the vertical lever just
contacts the pin on MF 356.
L. Tighten the locknut.
7. Recheck the setting.
8. Remove MF 272, MF 273, MF 356 and MF 363.
9. Refit the nut to retain the lever. DO NOT fit the plate,
spacers and bolts at this stage.
12A-01

LINKAGE

Group 12 Section A

LINKAGE

Op.No. Operation page


General description 02
12A • 01 - 04 Lift arm, remove/refit 04
12A • 02 - 05 Lower link, remove/refit 05
12A • 03- 05 Levelling box, servicing 05
12A • 04 - 06 Check chains, remove/refit 06
12A • 05 - 07 Stabilizer chains, remove/refit 07
12A • 06- 07 Wristed lower link, service 07
12B-01

ACCESSORIES

Group 12 Section B

ACCESSORIES

Op.No. Operation page


Auto-hitch, general 2
128 • 01 - 03 Auto-hitch, kit fitment 3
128 • 02- 05 Auto-hitch, latch adjustment 5
128 • 03- 06 Swinging drawbar, kit fitment 6
128 • 04- 07 Stabilisers, kit fitment 7
13A-01

WHEELS AND TYRES

Group 13 Section A

WHEELS AND TYRES

Op. No. Operation page


Special tools 2
Safety precautions 2
13A • 01 - 04 Inner tube, remove/refit 4
13A • 02 - 06 Tyre, remove/refit 5
Liquid filling of tyres 6

You might also like