Professional Documents
Culture Documents
PDF M 182 Des - Compress
PDF M 182 Des - Compress
1.2. Classifications —The
—The burlap shall
shall be of one ttype
ype and four classes
classes (mass based on a 1016 mm
(40 in.) width), as specified:
Class 1 —233 g/m (7.5 oz/yd)
Class 2 —248 g/m (8 oz/yd)
oz/yd)
Class 3 —310 g/m (10 oz/yd)
Class 4 —372 g/m (12 oz/yd)
1.4. The values stated in SI units are to be regarded as the preferred standard.
2. MATERIAL
2.1. The burlap cloth shall be made of jute or kenaf at the option of the manufacturer. It shall have a
plain weave and conform to the physical requirements
requirements given in TaTables
bles 1 or 2.
Table 1 —Physical Requirements
Requirements (SI)
(SI)
Mass per Yarns per Yarns per
Linear Meter Meter of Meter of Mass per
Class (1016 mm Basis), g Warp Filling Square Meter,a g
This website stores 1 data such as 233 315 to 433 inclusive 315 to 433 inclusive 229
2 248 354 to 472 inclusive 354 to 433 inclusive 244
cookies to enable essential site
3 310 433 to 512 inclusive 394 to 472 inclusive 305
functionality, as well as marketing,
4 372 433 to 512 inclusive 433 to 512 inclusive 366
personalization,
a
and analytics. You
A plus or minus tolerance of five percent will be permitted.
may change your settings at any time
or accept the default settings.
Table 2 —Physical Requirements
Requirements (inch/pound)
(inch/pound)
Weight per
Privacy Policy Linear Yard Weight per
(40-Inch Basis), Yarns per Inch Yarns per Inch Square
MarketingClass Ounces of Warp of Filling Yarda
1 71/2 8 to 11, inclusive 8 to 11, inclusive 6.7
Personalization
2 8 9 to 12, inclusive 9 to 11, inclusive 7.2
3 10 11 to 13, inclusive 10 to 12, inclusive 9.0
Analytics 4 12 11 to 13, inclusive 11 to 13, inclusive 10.8
a
A plus or minus tolerance of five percent will be permitted.
Save Accept All
2.2. Unless otherwise specified, the burlap shall have minimum width of 1016 mm (40 in.) inclusive of
selvage, and shall be in one continuous piece of not less than 23 m (25 yd).
2.3. The selvages shall be firm and straight, and may contain cotton yarn.
3.1. The burlap shall be clean, evenly woven, and shall conform to the quality and grade of product
established by this specification. The occurrence of defects shall not exceed the applicable
acceptable quality levels.
3.2. The burlap shall be examined visually for defects that would impair its suitability for use. Cuts,
tears, broken or missing yarns, thin, open, or weak places, uneven weaving, and grease spots or
stains shall be noted.
4.1. Lot
—Unless otherwise
otherwise specified, cloth of the sam
samee class present
presented
ed at one time sshall
hall be considered
a lot for purposes of inspection and tests.
Analytics
6. PACKING
6.1. The burlap cloth shall be packed in a manner acceptable to common carriers for safe transportation
to point of destination specified in shipping instructions at the lowest transportation rate for
such supplies.
6.2. Each roll shall have a ticket attached to the selvage at the inner end of the cloth giving the length
and width, and name and address of the manufacturer.
Privacy Policy
Marketing
Personalization
Analytics