Professional Documents
Culture Documents
KLR College of Enginnering & Technology: BCM Road, Paloncha-507115, Khammam Dist Iv B.Tech I-Sem Mid-I Examination
KLR College of Enginnering & Technology: BCM Road, Paloncha-507115, Khammam Dist Iv B.Tech I-Sem Mid-I Examination
PART-A
2X2=4M
1. Explain the vehicle power source characterization
2. Explain the power flow control in series hybrid vehicles
3. Explain the social and environmental importance of hybrid and electric vehicles
PART-B
2x3=6M
4. Explain the impact of modern drive trains on energy supplies
5. Explain mechanical translation system
6. Explain the standard test signals that are used in the time domain analysis
PART-A
2*2=4M
1. Explain the vehicle power source characterization
2. Explain the power flow control in series hybrid vehicles
3. Explain the social and environmental importance of hybrid and electric vehicles
PART-B 2*3=6
2
1. Which of the following grounding methods is used to reduce the tower footing resistance where an
earth resistance is low? ( )
A. single driven rod
B. multiple rods
C. counter poises
D. plates
2. Impulse ratios of insulators and lightning arresters should be ( )
A. both low
B. high and low
C. low and high
D. both high
3. To protect the power transformer (Y-Y with neutral grounded) against fault what type of connection
do the CTS have? ( )
A. delta – star
B. delta-delta
C. star – star
D. star-delta
4. Which is the main relay for protecting up to 90% of the transmission line length in the forward
direction? ( )
A. directional over current relay
B. mho relay
C. carrier current relay
D. impedance relay
5. The rating of lightning arrester used for 220KV, 3 phase system is ( )
A. 220KV,10KA
B. 220KV,5KA
C. 198KV,10KA
D. 198KV,2KA
6. Severe over voltages are produced during arcing faults in a power system with the neutral ( )
A. isolated
B. solidly earthed
C. earthed through a low resistance
D. earthed through an inductive coil
7. In the protection of transformers, harmonic restraint is used to guard against ( )
A. magnetizing inrush current
B. unbalanced operation
C. lightning
D. switch over voltages
8. The various protection schemes as applied to feeder protection ( )
A. time graded protection
B. distance protection
C. carrier current protection
D. All the above
9. Which of the following is true with respect to valve type lightning arrester? ( )
A. also known as non linear arresters
B. consist of a stack of spark gaps and resistor discs
C. ohmic value decreases as current increases
D. All the above
10. The common transformer faults are ( )
A. open circuits
B. over heating
C. winding short circuits
D. All the above
12.In resonant grounding, the function of the ______________ coil is to make arcing earth faults self
extinguishing.
13. The valve type arresters can be classified as ___________ and __________types.
14. In a transformer ____________ relays protect against phase to phase faults and overloading
16. The two most commonly used schemes for bus bar protection are ______________ and
________________.
17 A _________________ connected to the line and earth in power system protects the terminal
equipment
against travelling surges.
18. A ________________ relay is used for protection of a transformer against all internal faults
19. _______________ grounding is normally employed on systems operating at voltages between 2KV
and 33KV.