Professional Documents
Culture Documents
Few Words About Frequency Converters
Few Words About Frequency Converters
com/few-words-about-frequency-converters
Few Words About Frequency Converters (on photo cabinet with Danfoss FC302 frequency converters)
Introduction
Since the late 1960’s, frequency converters have undergone extremely rapid changes, largely as a result of the
development of microprocessor and semi-conductor technologies and their reduction in prices. However,
the basic principles of frequency converters remains the same.
1. Rectifier
The rectifier, which is connected to a single/three-phase AC mains supply and generates a pulsating DC
voltage. There are two basic types of rectifiers – controlled and uncontrolled.
2. Intermediate circuit
3. Inverter
The inverter which generates the frequency of the motor voltage. Alternatively, some inverters may also convert
the constant DC voltage into a variable AC voltage.
Control circuit
The control circuit electronics, which transmit signals to- and receive signals from the rectifier, the intermediate
circuit and the inverter. The parts that are controlled in detail depends on the design of the individual frequency
converter (see Figure 2).
What all frequency converters have in common is that the control circuit uses signals to switch the inverter semi-
conductors on or off. Frequency converters are divided according to the switching pattern that controls the supply
voltage to the motor.
1. Is a controlled rectifier,
2. Is an uncontrolled rectifier,
3. Is a variable DC intermediate circuit,
4. Is a constant DC voltage intermediate circuit,
5. Is a variable DC intermediate circuit,
6. Is a PAM inverter and
7. PWM inverter.
Direct converters, which do not have an intermediate circuit should also be briefly mentioned for completeness.
These converters are used in the Mega-watt power range to generate alow-frequency supply directly from the 50
Hz mains and their maximum output frequency is about 30 Hz.