Professional Documents
Culture Documents
Api 576 Q 2
Api 576 Q 2
Api 576 Q 2
PRV shall prevent the pressure from rising more than _______
above the maximum allowable working pressure. (UG-125 (c) )
10% or 3 PSI whichever is greater
A _______ is a pressure relief valve characterized by rapid opening or pop action or by
opening in proportion to the increase in pressure over the opening pressure, depending on
application
safety relief valve
A______ is a PRV in which the major relieving device or
main valve is combined with and controlled by a self actuated auxiliary pressure relief valve
pilot-operated safety relief valve
A conventional domed rupture disk is a _____ solid metal disk
pre-bulged
_______rupture disks are intended to be used as
capturing
Refer to the manufacturer's installation instructions, especially those
concerning limits on what of PRV & rupture disks
bolt torque
Since rupture disks are designed to burst at a specified differential pressure, pressure build
up on
the____ side of the disk may inhibit the disk's ability to provide overpressure protection
down-stream
When a rupture disk device is used with a pressure relief valve, consult the _______ for the
capacity reduction and installation details.
API 577 Q
ASME Code
UG-127 of the ASME Code states that a rupture disk device may be used as the____ pressure
relieving device on a vessel
sole (only)
The use of an _____ seat in a pressure relief valve will sometimes stop leakage past the
seating
surface and eliminate corrosion in the valve's working parts
O-ring
Some users stamp____ with device numbers. This identification specifies the
location of the valve and, by reference to the specification record, its limitations and
construction
During a visual the ____ should be inspected for evidence of pitting, roughening, or decreases
in the width of seating surfaces
flanges
At each stage in the dismantling process, the various parts of the valve should be visually
inspected for evidence of _____ and corrosion
wear
Bellows should be checked for leaks, cracks, or thin spots that may develop into leaks. In
API 577 Q
addition, if the bellows has collapsed, it has probably been subjected to ______ greater
than its design pressure
back pressure
Because most test blocks do not have enough_______ to measure the actual blow down,
manufacturer's recommendations and past performance should be evaluated to estimate any
necessary adjustment
capacity
Once the relief valve is set to pop at its CDTP, it should be checked for?
leakage.
________ rupture disks may be used to
facilitate and allow more frequent
When the static inlet pressure reaches the set pressure, it will increase the pressure upstream
of the disc and
overcome the seating force on the disc. what valve
safety valve
graphite rupture disk are flat what is required when the disk is expected to encounter
vacuum or backpressure?
support
reverse acting rupture disks are designed to open by?
API 577 Q
tooth rings
scored lines
shear
specification data
history of inspections
history of test results
API 577 Q
inspection and testing of PRD left on a unit during extended shutdown should be
accomplished prior to the resumption of operations including? checking for
corrosion
tampering
fouling
All pressure vessels other than _______________
shall be protected by a pressure relief device