Professional Documents
Culture Documents
Instrument Mechanicchemicalplant ATS
Instrument Mechanicchemicalplant ATS
id=27
Q 1) What should your first action be when treating an electrical burn? / िबजली से जलने पर
उपचार करते समय आपको सबसे पहले ा करना चािहए?
1) Ensure that the casualty is still breathing / सुिनि त कर िक पीिड़त अभी भी साँ स ले
रहा है
2) Check for danger and ensure that contact with the electrical source is broken / खतरे की
जाँ च कर और सुिनि त कर िक िवद् युत ोत से संपक टू ट गया है ।
3) Wash the burn with cold water / ठं डे पानी से जले ए को साफ कर
4) Check for level of response / िति या के र की जाँ च कर
Q 3) What steps would you take to control bleeding from a nosebleed? / नाक से र बहने को
िनयंि त करने के िलए आप ा कदम उठाएं गे?
1) Sit casualty down, lean forward and pinch soft part of nose / पीिड़त को नीचे बैठाकर
आगे की ओर झुकाएं और नाक के कोमल िह े को दबाएँ
2) Sit casualty down, lean backward and pinch soft part of nose / पीिड़त को नीचे
बैठाकर पीछे की ओर झुकाएं और नाक के कोमल िह े को दबाएँ
3) Lie casualty down and pinch soft part of nose / पीिड़त को िलटाए और नाक के कोमल
िह े को दबाएँ
4) Lie casualty down and pinch top of nose / पीिड़त को िलटाए और नाक के उपरी िह े
को दबाएँ
1) Hysteresis / िह ै रसीस
2) Dead space / डे ड ेस
3) Zero drift / शू बहाव
4) Sensitivity drift / संवेदनशील बहाव
1) Range of different input values over which there is no change in output values / िविभ
इनपुट मानों की ेणी िजस पर आउटपुट मानों म कोई प रवतन नहीं होता है ।
2) Range of different output values for the same input values / समान इनपुट मानों के िलए
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 1/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) Difference of the measured value and the true value / मापे गए मान और सही मान का अंतर
2) Ratio of absolute error to the measured value of the quantity under measurement / िनरपे
ुिट से माप के तहत मा ा के मापे गये मान तक का अनुपात
3) Ratio of absolute error to the true value of the quantity under measurement/ िनरपे ुिट से
माप के तहत मा ा के वा िवक मान तक का अनुपात
4) none of these / इनम से कोई नहीं
1) Hacksaw / है कसॉ
2) Steel rule / ील ल
3) Drill bit / िडल िबट
4) Chisel / छे नी
Q 9) The least count of Vernier caliper is / विनयर कैिलपर की ूनतम िगनती होती है
1) Ohms / ओ
2) Pascal / पा ल
3) Joules / जूल
4) Watts / वाट
Q 11) Bourdon tube is used for the measurement of gauge pressure of / बोडन ूब का
इ ेमाल ________ के गेज दबाव मापने के िलए िकया जाता है |
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 2/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) Gas / गैस
2) Liquid fluid / िल ड ूइड
3) Both gas and liquid fluid / गैस और िल ड ूइड दोनों
4) Solid / सॉिलड
Q 13) In neutralization titration, acid react with a base to form / िन भावन टाइटे शन म, अ
एक ार के साथ िति या कर िकसका िनमाण करता है ?
1) an alloy / एक िम धातु
2) a compound / एक यौिगक
3) a mixture / एक िम ण
4) an element / एक त
1) molecule / अणु
2) electron / इले ान
3) compound / यौिगक
4) metal / धातु
Q 17) A manometric liquid should suitably have / एक मनोिमतीय तरल म ______ उपयु
प से होना चािहए|
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 औ 3/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 18) In a measuring system what is the term used to specify difference between higher and
lower calibration values? / एक मापने की णाली म उ और िन अंशां कन मानों के बीच अंतर
को करने के िलए िन िल खत म से िकस श का इ ेमाल िकया जाता है ?
1) Range / ेणी
2) Span / िव ार
3) Drift / िड
4) Threshold / सीमा
Q 19) Which of the following is detected using manometer devices? / मनोमीटर उपकरण का
इ ेमाल कर िन िल खत म से ा ात िकया जाता है ?
1) Pressure difference between manometric and measuring liquid / मनोिमतीय और मापने तरल
के बीच दबाव म अंतर
2) pH difference between manometric and measuring liquid / मनोिमतीय और मापने तरल के
बीच पीएच का अंतर
3) Density difference between manometric and measuring liquid / मनोिमतीय और मापने तरल
के बीच घन म अंतर
4) none of these / इनम से कोई नहीं
Q 20) Water that easily gives lather with soap is called / वह पानी जो साबुन के साथ आसानी से
झाग दे ता है , उसे _______ कहते ह|
Q 21) Hardness which can be removed by boiling is called / कड़ापन िजसे उबालने से दू र िकया
जा सकता है वह ______ कहलाता है |
Q 22) Hardness of water is due to the presence of salts of / पानी का कड़ापन ________ के
लवण की उप थित के कारण होता है |
Q 23) Remaining sewage after it has passed through sludge tank is known as / ज टक से
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 ै 4/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 24) Which gas is often used as a energy source at city s wastewater treatment plants? /
शहर के अपिश जल उपचार संयं ों म ऊजा ोत के प म अ र िकस गैस का इ ेमाल िकया
जाता है ?
1) Ethane / इथेन
2) Carbon / काबन
3) Methane / मीथेन
4) Nitrogen / नाइटोजन
1) Water / पानी
2) Lime / चूना
3) Mercury / पारा
4) Copper Sulphate / कॉपर स े ट
Q 26) Boiling point of mercury is 357 °C, which is equal to / पारे का थनां क 357° से यस
होता है , जो _______ के बराबर है |
1) 84 K / 84 के
2) −84 K / - 84 के
3) −630 K / −630 के
4) 630 K / 630 के
Q 28) What device is similar to an RTD but has a negative temperature coefficient? / कौन-
सा उपकरण आरटीडी के समान है , लेिकन ऋणा क तापमान गुणां क से लैस है ?
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 5/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 30) Which of the following is the formula for pH calculation? / पीएच ात करने के िलए
िन िल खत म से िकस सू का इ ेमाल िकया जाता है ?
1) log10[H+]
2) -log10[H+]
3) log2[H+]
4) -log2[H+]
Q 31) If pH value is greater than 7, then solution is / यिद pH का मान 7 से अिधक होता है , तो
िवलयन _____ होगा|
1) acidic / अ ीय
2) basic / ारीय
3) neutral / तट थ
4) salty / लवणीय
Q 32) The deformation per unit length is called / ित ईकाई लंबाई म िव पण को _________
कहते है |
1) Strain / िवकृित
2) Stress / तनाव
3) Elasticity / लोच
4) none of these / इनम से कोई नहीं
Q 33) The thermocouple circuit which is used to measure temperature works on / थम कपल
प रपथ िजसका इ ेमाल तापमान को मापने के िलए िकया जाता है , वह _______ पर काय करता है |
1) magnitude and direction of current remains constant / िवद् युत धारा का प रमाण और िदशा
थर रहता है ।
2) magnitude and direction of current changes with time / िवद् युत धारा का प रमाण और िदशा
ै
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 6/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 36) Electronic multimeter measures / इले ॉिनक म ीमीटर ________की माप करता है |
1) a fluid which has no viscosity / एक तरल िजसम कोई िचपिचपापन नहीं होता है
2) a fluid which is incompressible / एक व जो असंपीिड़त है
3) a fluid which has no surface tension / एक व िजसम कोई पृ तनाव नहीं होता है
4) all of these / ये सभी
Q 38) The devices used for flow obstruction is/are / वाह म बाधा उ करने के िलए यु
उपकरण है /ह-
Q 39) If four, 12 Farad capacitors are connected in parallel, then, equivalent capacitance will
be / यिद चार, 12 फैराडे कैपीिसटस को सामानां तर ेणी म जोड़ा जाता है , तब समतु धा रता
________ होगी|
1) 3 Farad / 3 फैराडे
2) 6 Farad / 6 फैराडे
3) 12 Farad / 12 फैराडे
4) 48 Farad / 48 फैराडे
Q 40) For the measurement of flow rate of liquid, the method used is / तरल के वाह की दर
को मापने के िलए, _______ िविध का इ ेमाल िकया जाता है |
1) To monitor the fuel tank level in motor vehicle / मोटर वाहन म ईंधन टक के र की
िनगरानी करने के िलए
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 7/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) an amplifier / एक ए ीफायर
2) a rectifier / एक रे फायर
3) an oscillator / एक दोलक
4) a voltage regulator / एक वो े ज रे गुलेटर
1) Recuperator / रकूपरे टर
2) Regenerator / रजेनरे टर
3) Mixer / िम र
4) all of these / ये सभी
Q 44) PLC can be ___________ in plant to change the sequence of operation / प रचालन के
म को बदलने के िलए पीएलसी को संयं म केवल _____ िकया जा सकता है |
Q 45) The acronym PLC stands for / संि नाम पीएलसी का ता य ________ होता है |
Q 46) Evaporation from surface of any liquid depends on / िकसी भी तरल की सतह से
वा ीकरण _______ कारकों पर िनभर करता है |
1) temperature / तापमान
2) wind / हवा
3) nature of liquid / तरल की कृित
4) all of these / ये सभी
Q 47) How can you protect your laboratory from an electrical fire ?/ आप अपनी योगशाला
को िबजली की आग से िकस कार से बचा सकते ह?
1) Don t overload an outlet with too many plugs/एक ही आउटलेट पर ब त सारे ग का भार न
डाल
2) replace or dispose of frayed electrical cords/खराब िबजली के तारों को बदल द या हटा द
3) have a fire inspector examine your office/फायर इं े र से अपने कायालय की जाँ च कराएँ
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 8/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
4) Both Don t overload an outlet with too many plugs and replace or dispose of frayed
electrical cords / एक ही आउटलेट पर ब त सारे ग का भार न डाल और खराब िबजली के तारों
को बदल द या हटा द दोनों
Q 48) In case of electric fire, the fire extinguisher used is /िबजली की आग लगने पर आप िकस
कार के अि शामक यं का उपयोग करगे
Q 50) The tri-square, combination square, framing square and bevel set are all/ टाई- ायर,
कॉ नेशन- ायर, े िमंग ायर और बेवल सेट यह सभी ______ ह
Q 51) Identify the double cut file in the given diagram./िदए गए िच म डबल कट रे ती को
पहचान।
1) A
2) B
3) C
4) D
Q 52) Which of the following is used for locking purposes?/इनम से िकसका उपयोग लॉिकंग
के िलए िकया जाता है ?
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 ै 9/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 53) The least count of micrometer is/ माइ ोमीटर पर अंिकत ूनतम मान _____ है
Q 54) The symbol represents ______ valve. /िदया गया तीक ______ वा को िन िपत करता
है ।
1) Butterfly /बटर ाई
2) Ball/बॉल
3) Globe/ ोब
4) Check /चेक
Q 55) The nature of calcium phosphate is present in tooth enamel is/ दां त के इनेमल म मौजूद
कै शयम फॉ े ट की कृित ______ होती है ।
1) Basic/ ारीय
2) Amphoteric/उभयधम
3) Acidic/अ ीय
4) Neutral/उदासीन
Q 56) What is the pH value of very strong acid solution?/ ब त गाढ़े अ ीय घोल का पीएच
मान िकतना होता है ?
Q 57) The law which states that within elastic limits strain produced is proportional to the
stress producing it is known as/ िकस िनयम के अनुसार, ा थ सीमा के भीतर उ खंचाव,
उसके ारा उ तनाव के समानुपाती होता है
Q 58) Gold color of resistance shows tolerance up to the/ ितरोध का सुनहरा रं ग _______
स ता को दशाता है
1) 0.01
2) 0.02
3) 0.05
4) 0.1
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 10/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 59) The diagram shows ________ type of earthing. /िदए गए िच म ______ कार का
अिथग दशाया गया है ।
1) pipe/पाइप
2) plate/ ेट
3) electrode/इले ोड
4) waterman/वाटरमैन
1) DC generator/डीसी जनरे टर
2) electric lamp/िवद् युत लप
3) Transformer/टां सफामर
4) Capacitor/कैपीिसटर
Q 61) In a transformer, the energy is transferred from primary to secondary through/ िकसी
टां सफामर म, ऊजा को _______ के मा म से ाथिमक से ि तीयक म थानां त रत िकया जाता है
Q 62) In terms of the division on screen, the voltage of the waveform in CRO is/ ीन पर
िवभाजन के संदभ म, सीआरओ म तरं ग का वो े ज _______ होता है ।
1) Average voltage/औसत वो े ज
2) RMS voltage/आरएमएस वो े ज
3) Peak to peak voltage/पीक टू पीक वो े ज
4) Maximum voltage/मह म वो े ज
Q 64) The voltage gain in a transistor connected in _______ arrangement is the highest.
/_______ व था म जुड़े टां िज र का वो े ज लाभ सबसे अिधक होता है ।
Q 65) Unit of the rate of heat transfer is/ ऊ ा थानां तरण की दर की इकाई है :
1) Joule/जूल
2) Newton/ ूटन
3) Pascal/पा ल
4) Watt/वाट
Q 66) Which gas is often used as a energy source at city s wastewater treatment plants?/
शहरों के वे वाटर टीटमट संयं ों म अ र ऊजा ोत के प म िकस गैस का उपयोग िकया जाता
है ?
1) Ethane/इथेन
2) Carbon/काबन
3) Methane/मीथेन
4) Nitrogen/नाइटोजन
1) Centrifugal/से ी ूगल
2) Vacuume/वै ूम
3) Horizontal/ ैितज
4) Vertical/विटकल या ऊ ाधर
Q 68) Porcelain pieces are put into the distillation flask to avoid/ आसवन ा म चीनी
िम ी के बरतन के टु कड़े रखे जाते ह तािक ______ से बचा जा सके।
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 ँ 12/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 69) The desirable static characteristics of a measuring system are/मापन णाली की वाँ िछत
अचल िवशेषताएँ ___________ ह।
1) Vapour-pressure/वेपर ेशर
2) Liquid-expansion/िल ड-ए पशन
3) Metal-expansion/मेटल-ए पशन
4) Resistance/ ितरोध
Q 73) Which of these is/are a type of head type flow meter?/ इनम से कौन सा एक कार का
हे ड टाइप ो मीटर है ?
1) Venturi tube/वटु री ूब
2) Rotameter/रोटामीटर
3) Electromagnetic meter/इले ोमै ेिटक मीटर
4) Turbine flow meter/टरबाइन ो मीटर
Q 74) A magnetic flowmeter will not properly measure the flow rate of/ एक मै ेिटक
ोमीटर संभवतः _____ की वाह दर को ठीक से नहीं माप पाएगा।
Q 75) Which of the following conversions take place in float element?/ ोट एिलमट म इनम
ौ ै
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 13/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 76) The diagram shows ________ type of level measurement in a closed tank. /इस िच म
एक बंद टक म ________ कार का लेवल मापन दशाया गया है ।
Q 77) The most common application of float system is/ ोट िस म का सबसे सामा
अनु योग है
1) To monitor the fuel tank level in motor vehicle/ मोटर वाहन म ईंधन टक र की जाँ च करना
2) To monitor the flow of solid/ठोस के वाह की जाँ च करना
3) To monitor the flow of liquid/तरल के वाह की जाँ च करना
4) all of these/यह सभी
Q 78) In ultrasonic level gauge, the ultrasonic source is placed at the/अ ासोिनक लेवल गेज
म अ ासोिनक ोत _________ के िनकट रखा जाता है ।
Q 79) All of the following are general types of check valves EXCEPT/इनम से ____ के
अलावा सभी सामा कार के चेक वा ह।
1) butterfly/बटर ाई
2) plug/ ग
3) diaphragm/डाया ाम
4) ball/बॉल
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 14/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) Output module/आउटपुट मो ूल
2) Power supply/िवद् युत् आपूित
3) Programming device/ ो ािमंग िडवाइस
4) None of these/ इनम से कोई नहीं
Q 81) Which of these is not the manufacturers PLCs?/इनम से कौन पीएलसीज़ के िनमाता नहीं
ह?
1) multimeter/म ीमीटर
2) digital voltmeter/िडिजटल वो मीटर
3) CRO/सीआरओ
4) calibrator/कैली ेटर
Q 83) The symbol represents ______ valve. /िदया गया तीक ______ वा को िन िपत करता
है ।
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 15/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) Butterfly /बटर ाई
2) Ball/बॉल
3) Globe/ ोब
4) Check /चेक
1) Ammeter/अमीटर
2) Voltmeter/ वो मीटर
3) Wattmeter/ वाटमीटर
4) Energy meter/ ऊजा मीटर
Q 85) If measuring tape is too long as compared to standard, the error will be known
as____/ यिद मापने वाली टे प मानक की तुलना म ब त लंबी है , होने वाली गलती को ______ कहा
जाएगा
Q 86) Which one quantities consists of S.I. unit as Hertz?/ िकस मा ा की एसआई इकाई हट् ज
है ?
1) Frequency/ आवृि
2) Charge/ चाज
3) Force/ बल
4) Power/ पावर
1) Tachometer/ टे ोमीटर
2) Ammeter/ अमीटर
3) Potentiometer/ पोटिशओमीटर
4) None of these/ इनम से कोई नहीं
Q 88) For platinum thermocouple, lead wires are made of____/ ैिटनम थम कपल के िलए,
लेड वायर ______ की बनी होती ह
1) 298K/ 298 के
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 16/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
2) 100K/ 100 के
3) 250K/ 250 के
4) 320K/ 320 के
Q 91) In the thermocouple, the heat energy is converted into ____/ थम कपल म, ताप ऊजा
______ म प रवितत होती है
Q 92) Absolute pressure is measured by ____/ सटीक दबाव ________ ारा मापा जाता है
Q 94) The resistivity of the conductor depends on____/ सुचालक की ितरोधकता ______ पर
िनभर करती है
Q 95) The property used to oppose the flow of current is____/ करट के बहाव का िवरोध के
िलए योग की जाने वाली िवशेषता को _______ कहते ह
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 17/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) Manometer/ मनोमीटर
2) Vortex/ वोरटे
3) RTD/ आरटीडी
4) Thermocouple/ थम कपल
Q 98) The formula to find I when the values of V and R are known is ____/ जब वी तथा आर
की वै ू पता हो, आई को ा करने के फॉमूला को ______ कहते ह
1) I=VR/ आई=वीआर
2) I=R/V/ आई=आर/वी
3) V=IR/ वी= आईआर
4) I=V/R/ आई=वी/आर
Q 99) When 12 V are applied across a 68 Ω resistor, the current is ____/ जब 68 Ω ितरोधक
के साथ 12 वी का लगाई जाती है , करट _____ होता है
Q 100) Junction Field Effect Transistors (JFET) contain how many diodes?/ जं न फी
इफै टां िस र (जेएफ़ईटी) म िकतने िडओड़ होते ह ?
1) 4
2) 3
3) 2
4) 1
Q 101) ____ is not a basic element within the microprocessor./ _______ माइ ो ोसेसर का
मूल अ य नहीं है
Q 102) Flapper nozzle is used in a/an ____/ ैपर नोजल का योग _____ म होता है
Q 103) On-off controllers are used for____/ ऑन-ऑफ िनयं कों का योग ______ के िलए होता
है
Q 104) Accidents in chemical plants are mostly due to____/ रासायिनक ां ट म दु घटनाएँ
आमतौर पर _____ के कारण होती ह
Q 106) The fluid used in hydraulic controller is____ / जलीय िनयं क म योग िकया जाने वाला
तरल _____ है
1) Water/ पानी
2) Steam/ भाप
3) Air/ वायु
4) Oil/ तेल
Q 107) The liquid used in manometers should have____/ मनोमीटर म योग िकए जाने वाले
तरल म _____ होना चािहए
1) Low density/ कम घन
2) High density/ उ घन
3) High surface tension/ उ सतह तनाव
4) Low surface tension/ कम सतह तनाव
Q 108) ____ is not a differential pressure flow meter./ ______ एक िवशेषक दबाव वाह मीटर
नहीं है
1) Rotameter/ रोटमीटर
2) Orifice meter/ ओ रिफस मीटर
3) Flow nozzle/ बहाव नोजल
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 19/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 109) Which of the following controllers has the least maximum deviation?/ िन िल खत म
से िकस िनयं क म सबसे कम अिधकतम िवचलन है ?
1) Reproducibility/ जननता
2) Sensitivity/ संवेदनशीलता
3) Dead zone/ मृत े
4) Fidelity/ िव ता
Q 111) Magnetic flow meters are generally not used for the velocity/flow measurement of
hydrocarbons due to their ____/ चुंबकीय वाह मीटर आमतौर पर उनके _______ के कारण
हाइडोकाबन के वेग / वाह माप के िलए उपयोग नहीं िकया जाता है
1) Viscometer/ िव ोमीटर
2) pH meter/ पीएच मीटर
3) Calorimeter/ कैलोरीमीटर
4) None of these/ इनम से कोई नहीं
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 20/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 116) A SCADA system will include ____/ एससीएडीए णाली म ______ स िलत होगा
1) Networks/ नेटवक
2) Signal hardware (I/O) controller/ िस ल हाडवेयर (आई/ओ) िनयं क
3) User Interface (HMI)/ यूसर इं टरफेस (एचएमआई)
4) All of these/ ये सभी
Q 117) PLCs are programmed using ____ / पीएलसी को ______ के योग से ो ाम िकया गया
है
1) C language/ सी भाषा
2) Natural language such as English/ अँ ेजी जैसी ाकृितक भाषा
3) Relay-ladder logic language/ रले लेड़र तक भाषा
4) None of these/ इनम से कोई नहीं
Q 119) If voltage across a resistance doubles then the____/ ितरोधक के साथ वो े ज दु गुनी हो
जाती है जब ______ होता है
1 2 31 2 61 2 91 2
2 4 32 1 62 2 92 2
3 1 33 3 63 1 93 3
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 21/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
4 2 34 3 64 2 94 3
5 1 35 1 65 4 95 4
6 2 36 1 66 3 96 3
7 3 37 4 67 4 97 4
8 2 38 4 68 3 98 4
9 2 39 4 69 2 99 3
10 2 40 3 70 4 100 4
11 3 41 1 71 3 101 1
12 2 42 2 72 3 102 2
13 1 43 4 73 1 103 1
14 1 44 3 74 4 104 2
15 1 45 2 75 4 105 2
16 1 46 4 76 4 106 4
17 3 47 4 77 1 107 3
18 2 48 2 78 1 108 1
19 1 49 4 79 1 109 1
20 2 50 2 80 2 110 4
21 1 51 2 81 2 111 2
22 3 52 1 82 4 112 3
23 2 53 1 83 3 113 4
24 3 54 2 84 4 114 4
25 3 55 1 85 1 115 3
26 4 56 3 86 1 116 4
27 1 57 2 87 3 117 3
28 2 58 1 88 1 118 1
29 1 59 1 89 1 119 4
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 22/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
30 2 60 3 90 1
Q 2) C.T. and P.T. are used for / सी.टी. और पी.टी. का इ ेमाल _______ के िलए िकया जाता है |
Q 3) In ultrasonic level gauge, the ultrasonic source is placed at the / एक अ ासोिनक लेवल
गेज म, अ ासोिनक ोत को ______ पर रखा जाता है |
Q 5) Hardness of water is due to the presence of salts of/ पानी की कठोरता _______ लवण की
उप थित के कारण होती है ।
1) Potassium/पोटै िशयम
2) Chlorine/ ोरीन
3) Magnesium/मै ीिशयम
4) Boron/बोरान
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 23/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
1) ammeter/अमीटर
2) voltmeter/वो मीटर
3) flux-meter/ -मीटर
4) ballistic galvanometer/बैिल क गै ेनोमीटर
Q 7) In a full-wave rectifier, the current in each of the diodes flows for /एक फुल-वेव
रे फायर म, ेक डायोड म िवद् युत धारा _______ के िलए वािहत होती है
Q 8) In a shunt capacitor filter, the mechanism that helps the removal of ripples is/ एक शंट
कैपेिसटर िफ र म __________ रप को हटाने म मदद करती है ।
1) The current passing through the capacitor/कैपेिसटर से होकर गुजरने वाली िवद् युत धारा
2) The property of capacitor to store electrical energy/िवद् युत ऊजा को सं हीत करने का
कैपेिसटर का गुण
3) The voltage variations produced by shunting the capacitor/ कैपेिसटर की शंिटं ग के ारा
उ वो े ज म बदलाव
4) Uniform charge flow through the rectifier/ रे फायर से होकर आवेश का एक समान वाह
Q 9) Boiling point of mercury is 357 °C, which is equal to/ पारे का थनां क 357 ° C है , जो
______ के बराबर है ।
1) 84 K
2) −84 K
3) −630 K
4) 630 K
Q 10) Which of following factors do not affect rate of evaporation?/इनम से कौन सा कारक
वा ीकरण की दर को भािवत नहीं करता है ?
Q 11) Which of the following errors are regularly repetitive in nature?/ िन िल खत ुिटयों म
से िकसकी कृित िनयिमत प से दोहराए जाने की होती है ?
Q 12) In the manometer given above, 2 immiscible fluids mercury (ρ = 13600 kg/m3) and
water (ρ = 1000 kg/m3) are used as manometric fluids. The water end is exposed to
atmosphere (100 kPa) and the mercury end is exposed to a gas. At this position, the
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 24/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
interface
1) 100 kPa
2) 50 kPa
3) 200 kPa
4) 0 kPa
Q 13) The diagram represents pressure measurement, Part A is /यह िच दबाव मापन को
दशाता है । भाग A _____ है
1) manometer/मैनोमीटर
2) Limit switch/िलिमट च
3) control valve/कंटोल वा
4) Pressure transmitter/ ेशर टां समीटर
Q 14) The disadvantage of using Optical Pyrometer for temperature measurement is that it /
तापमान मापने के िलए ऑि कल पाइरोमीटर के उपयोग म असुिवधा यह है िक यह
1) is not useful for obtaining continuous values of temperatures at small intervals./ थोड़े
अंतराल पर तापमान का िनरं तर मान ा करने के िलए उपयोगी नहीं है ।
2) Can t measure the moving objects./चलायमान व ुओं को माप नहीं सकता
3) Can t be used where physical approach is difficult /जहाँ प ँ च पाना किठन है वहाँ उपयोग
नहीं िकया जा सकता
4) require need of any direct body contact between the optical pyrometer and the object./
ऑि कल पाइरोमीटर और उस व ु के बीच िकसी भी शारी रक संपक की आव कता होती
है ।
Q 15) In closed container type level measuring system, pressure at top of container is due to
/ बंद कंटे नर कार की लेवल माप णाली म, कंटे नर के शीष पर दबाव __________ के कारण होता
है ।
Q 16) C.T. and P.T. are used for/सीटी और पीटी _________ के िलए उपयोग िकए जाते ह।
Q 17) Recuperator, Regenerator, Mixer are the types of / रकूपरे टर, रीजनरे टर और िम र
_____ के कार ह
1) calorimeter/कैलोरीमीटर
2) flow meters/ ो मीटर
3) level indicators/लेवल इं िडकेटर
4) heat exchanger/हीट ए चजर
Q 18) Which of these controllers is termed as reset controller./इन कंटोलस म से िकसे रीसेट
कंटोलर कहा जाता है
1) Volumetric expansion./ मा ा क िव ार
2) Pressure rise with temperature/ तापमान के साथ दबाव म वृ
3) Linear expansion./ रै खक िव ार
4) None of these/ इनम से कोई नहीं
Q 21) Absolute zero pressure can be attained at a temperature of____/ सटीक शू दबाव
_____ तापमान पर ा िकया जा सकता है
1) 0° C/ 0 िड ी से यस
2) 50° K/ 50 िड ी के न
3) 0° R/ ओ िड ी आर
4) None of these/ इनम से कोई नहीं
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 26/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 22) Which is the example of digital device from the given option ?/ िदये गए िवक ों म से
ा िडिजटल उपकरण का उदाहरण है ?
1) Sensors/ ससर
2) Recorders/ रकॉडर
3) Microprocessors/ माइ ो ोसेसर
4) None of these/ इनम से कोई नहीं
Q 23) Ohm s law describes the mathematical relationship between____/ ओहम का िनयम
_______ के बीच गिणतीय संबंध को प रभािषत करता है
Q 25) All the thermocouples used for temperature measurement use dissimilar metal____/
तापमान माप के िलए उपयोग िकए जाने वाले सभी थम कॉ असमान धातु ______ का उपयोग
करते ह
1) Strips/ प
2) Bars/ बास
3) Wires/ तार
4) Beads/ बीड् स
Q 26) The commonly used flux in brazing is____/ टां कों म आमतौर पर योग होने वाला वाह
______ है
1) Borax/ बोर
2) Resin/ रे िसन
3) Lead sulphide/ लेड स ाइट
4) Zinc chloride/ िजंक ोराइड
Q 27) Composition of alloys can be determined by___/ िम धातुओं की रचना ______ ारा
जानी जा सकती है
1) Polarograph/ पोलरो ाफ
2) Chromatograph/ ोमटो ाफ
3) Refractometer/ रे े ोमीटर
4) None of the these / इनम से कोई नहीं
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 27/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 29) Faraday s law of electrolysis is related to the____/ फैराडे का इले ोलीज़ का िनयम
_______ से संबंिधत है
Q 30) Ohm’s law is valid for only current flowing in____/ ओहम का िनयम केवल ______ म
वाह होने वाले करट के िलए वैध है
1) Conductors/ सुचालक
2) Transistors/ टां िस र
3) Diodes/ िडओड़
4) Electric area/ िवद् युत े
Q 31) The Boolean expression for a 3-input AND gate is _____./ एक 3-इनपुट एएनडी गेट के
िलए बूिलन दशन ______ है
1) X = AB/ ए =एबी
2) X = ABC/ ए =एबीसी
3) X = A + B + C/ ए = ए+बी+सी
4) X = AB + C/ ए =एबी+सी
Q 32) Relative humidity of air can be determined by a____/ हवा की सापे नमी ______ ारा
जानी जा सकती है
1) Chromatograph/ ोमटो ाफ
2) Mass spectrometer/ मास े ोमीटर
3) Polarimeter/ पोलारीमीटर
4) Relative hygrometer/ सापे हय ोमीटर
Q 33) The maximum allowable limit that a measurement may vary from the true value is
called____/ अिधकतम ीकाय सीमा जहां एक माप वा िवक मू से िभ हो सकता है ______
कहलाती है
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 28/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
Q 35) The advantage of digital instruments is____/ िडिजटल उपकरण का लाभ _____ है
Q 36) The degree of perfection used in instruments,the techniques and the observations is
known as ____/ उपकरणों, तकनीकों और अवलोकनों म उपयोग की जाने वाली पूणता की िड ी को
______ के प म जाना जाता है
1) Accuracy/ सटीकता
2) Precision/ शु ता
3) Least count/ ूनतम सं ा
4) None of these/ इनम से कोई नहीं
Q 37) Temperature of a hot moving body can be measured by____/ गितमान गरम इकाई का
तापमान _____ ारा मापा जा सकता है
1 4 31 2
2 3 32 4
3 1 33 1
4 2 34 3
5 3 35 4
6 3 36 2
7 2 37 2
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 29/30
7/26/2019 10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27
8 2
9 3
10 3
11 1
12 1
13 4
14 1
15 2
16 3
17 4
18 2
19 1
20 1
21 3
22 3
23 3
24 4
25 3
26 1
27 2
28 3
29 3
30 2
10.6.60.71:8080/qbexcel/admin/Download.aspx?id=27 30/30