Professional Documents
Culture Documents
Protective & Marine Coatings: General Polymers 3479
Protective & Marine Coatings: General Polymers 3479
Surface Preparation
Proper inspection and preparation of the substrate to receive
resinous material is critical. Read and follow the “Instructions for
Concrete Surface Preparation” (Form G-1) for complete details.
3. Allow to cure for a minimum of 3-4 hours depending upon air Maintenance
movement before applying next coat.
Occasional inspection of the installed material and spot repair can
prolong system life. For specific information, contact the Technical
* 3479 Water Based Epoxy Wall Coating should only be used on Service Department.
unpainted, porous surfaces. If the surface is painted with latex or
an epoxy coating, clean and abrade the surface then apply the 3479
base coat. Strictly follow mix ratio recommendations. Shipping
• Destinations East of the Rocky Mountains are shipped F.O.B.
Cincinnati, Ohio.
Instructions for Tinting • Destinations West of the Rocky Mountains are shipped F.O.B.
Tint Part A with Envirotoners at 150% strength. Five minutes Victorville, California.
minimum mixing on a mechanical shaker is required for complete
mixing of color. DO NOT EXCEED 8 ounces of colorant per gallon For specific information relating to international shipments, contact
of Part A resin. your local sales representative.
www.sherwin-williams.com/protective