Professional Documents
Culture Documents
工艺设计过程中阻火器的设置 孙琳玮
工艺设计过程中阻火器的设置 孙琳玮
10.
159
10/j.cnki.
100
7-6
247.
200
4.0
3.0
05
2004
14(3) 孙琳玮等 工艺设计过程中阻火器的设置 21
工艺设计过程中阻火器的设置
孙琳玮● 张宁夏 中国石化兰州设计院 兰州 730060
摘要 介绍阻火器的分类、选型及安装。
关键词 阻火器 分类 设置 选用
● 孙琳玮:工程师。1994年毕业于西北大学化学工程专业。一直从事化工工艺设计工作。联系电话:(0931) 7557201-3611。
22
CHEMICAL ENGINEERING DESIGN 化工设计 2004
14(3)
或阻火装置。 4∙4 火焰速度
(4) 其它应设置管道阻火器的场合。
火焰速度是指阻火器入口处的速度火焰速
4 选用 度与介质和操作工况 (温度、压力、管径大小、
管道长度、配管形状及安装位置等) 有关若资
4∙1 使用场所 料中查找不到则需要进行实际测试。
根据使用场所决定采用放空阻火器还是管道 阻火器的鉴定书中应注明该产品能阻止的最
阻火器。 大火焰速度。确定阻火器的原则是介质的火焰速
4∙2 性能 度应小于鉴定书上注明的最大火焰速度。
火焰波在管道内的传播速度不仅与介质种 4∙5 压力降校核
类、温度、压力有关还与阻火器与点火源之间 根据初选的阻火器的型号和管内介质的流
的距离、安装位置、阻火器与点火源间的管道形 量查阅阻火器产品资料中流量-压力曲线是否
状有关。因此选用的阻火器阻火元件的通道直径 满足工艺过程的要求。
要能阻止这种情况下的火焰蔓延这就需要确定
5 安装
是采用阻爆燃型还是阻爆轰型阻火器通常由试
验或根据经验来确定。 (1) 阻火器应安装在接近点火源的部位。
4∙3 MESG 值 (2) 放空阻火器应尽量靠近管道末端设置
同时要考虑检修方便。一般选用管端型放空阻火
(1) 国标 《 爆炸性环境用防爆电气设备通用
器;如果选用普通型放空阻火器应考虑到由于
要求》(GB3836∙1-83) 中对爆炸性气体混合
下游接管的配管长度、形状对阻火器选型 (阻爆
物按最大安全间隙 (MESG) 分成不同的技术安
燃型还是阻爆轰型) 的影响并根据介质工况和
全等级见表1。
表1 最大安全间隙 (MESG) 的分级 安装条件来确定普通型放空阻火器的规格。
级别 最大安全间隙 (MESG)mm (3) 安装管道阻爆轰型阻火器时要注意其
IA MESG≥0∙9 爆轰波吸收器应朝有可能产生爆轰的方向否则
IB 0∙5<MESG<0∙9
将失去阻爆轰的作用。
IC MESG≤0∙5
(4) 阻火器与管道的连接一般为法兰形式
各种介质的 MESG 值与工作压力、工作温
小直径的管道采用螺纹连接。
度及安装位置距点火源的距离和配管情况有关
但标准状况 (1bar20℃) 下由标准试验装置测 6 保养与防冻
得的 MESG 值可在有关资料中查到 [4] [5] 。
6∙1 保养
(2) 阻火器的鉴定书已注明该产品适用的
MESG 值。因此选用阻火器的原则是要求介质 (1) 为了确保阻火器的性能达到安全使用
在操作工况下的 MESG 值大于阻火器鉴定书上 的目的阻火器应定期检查和清洗及时更换已
标明的 MESG 值。 堵塞、变形、腐蚀的阻火元件。
例如:阻火器的鉴定书上标明适用的 MESG (2) 放空阻火器的放空端头应安装防风雨
∙
值为065mm这表明该产品适用于在操作工况 帽以防灰尘和雨水进入阻火元件。
(温度、压力和管径大小、管道长度、配管形状及 6∙2 防冻
安装位置等) 下的 MESG 值大于0∙
65mm 的介质。 阻火器具有散发热量的能力当物料通过时
MESG 值比0
∙65mm 小的介质不能选用该产品。 会由于冷却而降温。对于凝固点高或易结晶的物
(3) 对于有多种可燃气体组成的混合气选 料在通过阻火器时有时会发生凝固和结晶使
用阻火器要进行试验以确定混合气体的 MESG 阻火器的阻力增加;若物料中含有水 (汽)在
值。若没有试验条件则按混合气各组分中最小 寒冷地区或冬季可能会发生冻结堵塞阻火
的 MESG 值来选用阻火器。 器。因此有上述可能性存在的场合应配有防
2004
14(3) 孙琳玮等 工艺设计过程中阻火器的设置 23
(上接第25页) 品畅销全国。
成 ZnCl 的转化率:96%~98% (包括反应物在 4∙4 经济效益
贮槽继续反应后);③反应温度:70~96℃。
该厂自投产以来生产1000多吨氯化锌每
4 效果 吨纯利近1000元总共盈利100多万元。其中
反应装置的稳定运行给企业生产创造了良好的条
4∙1 提高生产强度 件。
采用连续反应装置当反应器内的物料升温
至70~90℃以后靠反应热能长期保持此温度 5 结论
而且物料连续不断地流进流出物料在器内的平 (1) 以锌灰和盐酸为原料采用连续反应装
均停留时间约为6~8h与间歇反应器相比连 置生产电池级固体氯化锌是可行的。
续反应装置的生产强度要大3倍以上。 (2) 采用全混流反应器可消除 HCl 气体和
4∙2 消除污染 锌灰的污染操作环境良好。
连续反应器在较高转速下接近全混流出口 (3) 连续稳定运行的反应装置带来了稳定洁
物料的组成与器内物料组成相近pH =3∙3~ 净的生产和良好的经济效益。
3∙5。在此 pH 值下物料上方的 HCl 浓度极低 参 考 文 献
1 天津化工研究院等编∙无机盐工业手册 (上册) [ M ] ∙北
几乎闻不到 HCl 气味消除了 HCl 的污染。另
京:化学工业出版社∙1979
外加料斗深入反应器内液面以下无锌灰飘逸 2 Dacscu C.Gyorgy V .Continuous Praparation of Zinc Chloride
污染从根本上消除了间歇反应器的污染。 [p ].Rom.RO 912141987
3 陈甘棠主编∙化学反应工程 [ M ] ∙北京:化学工业出版社
4∙3 反应稳定
1981
连续反应器出口的反应液温度和组成稳定 4 周新月∙液体氯化锌生产工艺的研究 [ J ] ∙福州大学学报
有利于后工序的操作最终使产品质量稳定。生 (自然科学版)199523 (2);115~117
产厂家投产以来生产的优质电池级氯化锌产 (收稿日期 2004-01-04)
2004 1
14(3) ABST RACT S OF CHEMICAL ENGI NEERI NG DESIGN
Development and Selection of Nitric Acid Resistance Steel reflux section is adoptedthereby the equipment controlling reflux
Gang Yimin and reflux operation are removed.T he experimental results of batch
T he authorfrom the practical view systemically summarized the that the operation and control of the equipment is easythe quality of
research and development results of new type Austenic steel with ni- distillate steady and the speed of distillate high.So the new experi-
tric acid resistance and corrosion resistance characteristicsand ana- mental equipment has a good applied foreground.
lyzes the materials selection under different nitric acid medium and Key words distillation small distillation equipment reflux section
different environmental factors.
Key words nitric acid corrosion Austenic steel Design of Inlet Piping of Catalyst Cracking Flue Gas Turbine
Yang Qinget al
Analysis and Discussion on Process and Equipment of Titanium ( L uoyang Pet rochemicla Engineering Corporation L uoyang
White Production by Sulfuric Acid Process 471003)
T ang Wenqian Introduces the materials selectionarrangementforce analysis and
( Shandong Chemical Planning Design Instit ute Jinan 250013) design points of catalyst cracking flue gas turbine.
Introduces the latest development of titanium w hite production Key words inlet piping flue gas turbine design
process and equipment and further discusses the localization of process
and major equipment. Reliability Safety Factor of Static Strength for
Key words titanium w hite import localization technology Steel Thiness Walled Pressure Cylinder
Liu Xiaoninget al
Application of NHD in Sulfur Removal and Carbon Removal ( W uhan Polytechnic Collage of Indust ry and Com m unication
in Chemical Fertilizer Plants W uhan 430015)
Qing Yishenget al In this paperby using the method of reliability design basis on
( Jiangsu T ianyin Chemical Co.L td.Y ixing 214262) probability and statistical theorystatic strength of steel thinness
Introduces the application conditions of NHD in five chemical w alled pressure cylinder w as statistically analyzed.T he safety factor
plants in China that indicates the NHD technology is advanced tech- is discussed from the side of analysis initial reliability on static
nology with higher gas purification and obvious low er energy con- strengthtake for safety factor ns is greater than1.
55in yield failure
sumption and low flash gas CO2purification is also higher. criteria and nb not less than 2.
05in explosion failure criteria.
Key words NHD sulfur removal and carbon removal Key words steel thinness w alled pressure cylinder static strength
initial reliability safety factor
Set Up of Fire Arresters in Process Design
SunLinw eiet al Localization of Shaft Seal for Alkylate Reactor in Refinery
( L anz hou Design Instit ute of SinopecL anz hou 7300760) Shi Youmin
Introduces the categories of fire arresters and their type selection (2nd Const ruction Company of China National Pet rolium Corpo-
and installation. rationL anz hou 730060)
Key words fire arrester categories set up selection Introduces the w hole process of localization of shaft seal for alky-
late reactor in refinery.
Application of Continuous Reaction Device Key words mechanical seal localization modification
in Production of Zinc Chloride
Lu Fangyi Application of Water Spray Extinguishing System in
( College of Env ironmental Engineering and Chemical Engineer- Liquefied Hydrocarbon Tank Fire Protection
ingNanchang U niversityNanchang330029) Zhang Xuejun
Zinc chloride is produced with continuous reaction device instead of ( Nanjing Y angtz e Pet rochemical Design and Engineering Inco.
intermittent reaction device.T his process not only has high produc- Nanjing 210048)
tion intensitybut also can eliminate the pollution of hydrogen chlo- T he process units and tank farm of large-scale petrochemical en-
ride and zinc ash.Reaction products with steady -components can terprises are becoming larger and larger recentlythat is the develop-
also be obtained. ing trend.And the quantity and volume of liquefied hydrocarbon
Key words zinc chloride successive reaction device tankthe necessary associated facilities in petrochemical complex is
also increasing continuously.T herefore the w ater spray system with