Professional Documents
Culture Documents
Error Code Full Code
Error Code Full Code
LED Status
Operation Description
Lamp Timer Lamp
Flashes at 5Hz OFF Indoor Fan speed has been out of control for over 1 minute
OFF Flashes at 5Hz Over current protection of the compressor occurs 4 times
Action to be taken
Check the following:
1. Run capacitor; replace if defective
2. Compressor; replace if defective
Replace air sensor
Replace coil sensor
Replace PCB
CARRIER HI-WALL EXPRESSION (FP-42EXP, any size/capacity)
Fault Code
Description Possible Causes
(no. of blinks)
The room air sensor not properly connected to the PCB
2 Room Air Thermistor board
The room air sensor is damaged
The indoor coil thermistor is not properly connected to
Indoor Coil the PCB board
3 Thermostat
The indoor coil thermistor is damaged
The system cycles on indoor coil thermistor
a. Icing due to blocked air filters or clogged evaporator
coil
c. System restricted
d. System out of gas
CDU not functioning
Compressor Drive a. Magnetic contactor defective
5
Malfunction
b. PCB board defective
Compressor runs but condenser fan not functioning
a. Fan capacitor is defective
b. Fan motor is defective
Compressor hums
a. Run capacitor defective
b. Compressor defective
PCB board defective
Action to be taken
Replace Contactor
Replace PCB board
tioning
Replace Capacitor
Replace Fan Motor
Replace Capacitor
Replace Compressor
Replace PCB board
CARRIER HI-WALL ZEN (FP-42LUC, 9K to 24K)
LED STATUS
Operation Timer Defrosting Auto
ON ON ON ON
OFF OFF ON ON
OFF ON ON ON
OFF OFF OFF ON
Description
Replace PCB
Check wiring
CONDURA HI-WALL (FP-42KCR)
OPERATION LAMP
DISPLAY TIMER LAMP FAILURE
FLASH TIMES
E1 1 X EEPROM error
P2 Temperature protection of O X X
compressor top. ☆
Operation
Display lamp flash Timer Lamp
E0 1 X
E1 2 X
E2 3 X
E3 4 X
E4 5 X
E5 6 X
EC 7 X
F1 2 O
F2 3 O
F3 4 O
F4 5 O
P0 1 ☆
P1 2 ☆
P2 3 ☆
P4 5 ☆
Failure
EEPROM error
Zero crossing