Download as pdf or txt
Download as pdf or txt
You are on page 1of 19

THE UNITED KINGDOM VEHICLE APPROVAL AUTHORITY Rev 1/103

COMMUNICATION CONCERNING THE APPROVAL GRANTED OF A


COMPRESSION-IGNITION ENGINE TYPE OR FAMILY OF ENGINE TYPES
AS SEPARATE TECHNICAL UNITS WITH REGARD TO THE EMISSION OF
POLLUTANTS PURSUANT TO REGULATION NO: 96.01

Approval No: 96R-010245

Reason for Extension: Not applicable

1. Trade name or mark of engine: Perkins, also branded as Caterpillar

2. Engine type(s):
2.1. Engine family: Perkins: 1104C-44T and 1103C-33T
Caterpillar: 3054C and C3.3
2.2. Types included in the engine family: See manufacturers documentation
2.3. Tested type of engine or the representative of the engine family: 2359/2100 (parent engine)

3. Manufacturer's name and address:


Perkins Engines Company Limited
Eastfield
Peterborough
PE1 5NA
United Kingdom

4. If applicable, name and address of manufacturer's representative: Not applicable

5. Maximum allowable intake depression: 5.0 kPa

6. Maximum allowable back pressure: 15.0 kPa

7. Maximum permissible power absorbed by the engine-driven equipment:

Intermediate: 0.0 kW

Rated: 0.0 kW

10-Dec-07
ity
UK

A
or

An executive agency of the Department for Transport pp h


roval Aut
ECE REGULATION NO: 96 .01

8. Restriction of use (if any): None

9. Emission levels - 8 mode emission test values:

CO: 0.753 g/kWh

HC: 0.119 g/kWh

NOx: 6.463 g/kWh

Particulates: 0.287 g/kWh

10. Engine submitted for test on: Cross refer to approval no. e11*97/68GA*2001/63*0245*06

11. Technical service responsible for conducting approval test: Vehicle Certification Agency

12. Date of test report issued by that service: Cross refer to approval no. e11*97/68GA*2001/63*0245*06

13. Number of test report issued by that service: Cross refer to approval no. e11*97/68GA*2001/63*0245*06

14. Site of approval mark on the engine: Left hand side of the cylinder block, top cover or where it will
be visible with the engine installed

15. Place: BRISTOL

16. Date: 10 DECEMBER 2007

17. Signature: A. W. STENNING


Product Certification

18. The following documents, bearing the approval number shown above, are annexed to this
communication

One copy of annex 1A or annex 1B to this Regulation completed and with drawings and diagrams
referred to attached.

ESH184734

10-Dec-07
ity
UK

A
or

pp t h
Au
roval 2
APPLICATION FOR APPROVAL OF:

Engine Type Perkins 1104C-44T


Also Branded as Caterpillar 3054C DIT

Engine Code As Information Document

Directive No. UN/ECE R96.01

Issue No. of Submission 1

Job No. ESH184734

Reason for Extension or Revision New Submission - test data referenced


from approval: e11*97/68GA*2001/63*0245*06

Extension History

Contents Annex II Information Document


Appendix 1 and 3
Appendix 2

10-Dec-07
ity
UK

A
or

pp h
roval Aut
ANNEX II INFORMATION DOCUMENT Pertaining to
UNECE Regulation 96

Information Document relating to type-approval and referring to measures against the emissions of
gaseous and particulate pollutants from internal combustion engines to be installed in non-road

(UN/ECE R96.01)

Parent engine/engine type:

0 General

0.1 Make (name of undertaking): Perkins also branded as Caterpillar

0.2 Type and commercial description of the parent-and (if applicable) of the family engine(s):
2359/2100 2359/2200 2162/2200 2163/2200 2164/2200 2165/2200 2166/2000 2166/2100
2166/2200 2166/2300 2167/2000 2167/2100 2167/2200 2167/2300 2168/2200 2168/2300
2168/2400 2169/2200 2169/2400 2230/2200 2232/2200 2890/2200

0.3 Manufacturer's type coding as marked on the engine: As item 0.2

0.4 Specification of machinery to be propelled by the engine


As defined in Annex 1 1.A of the Directive

0.5 Name and address of manufacturer: PERKINS ENGINES COMPANY Ltd.,


EASTFIELD, PETERBOROUGH,
PE1 5NA.

Name and address of manufacturer's authorised representative:

N/A

0.6 Location, coding and method of affixing the engine identification number:

The engine type coding is specified on a plastic self adhesive label in a position
on left hand side of cylinder block, on the top cover or a position where it will be
visible with the engine installed. The serial number is on an aluminium plate,
riveted to a located on the left hand side of the cylinder block, when viewed
from the rear of the engine.

7 Location and method of affixing of the EC approval mark

Plastic self adhesive label in a position on the left hand side of the cylinder
block, top cover or where it will be visible with the engine installed.

8 Address(es) of assembly plants: PERKINS ENGINES COMPANY Ltd.,


EASTFIELD, PETERBOROUGH, PE1 5NA

10-Dec-07
ity
UK

Ref No. ESH184734 2 of 17


A
or

pp h
roval Aut
ANNEX II INFORMATION DOCUMENT Pertaining to
UNECE Regulation 96

Perkins Motores do Brasil Ltda


Rua João Chede, 2489
CEP: 81.170-220,
Curitiba / Paraná
Brasil

Attachments

1.1 Essential characteristics of the parent engine(s)

1.2. Essential characteristics of engine family

1.3 Essential characteristics of engine types within family

2 Characteristics of engine-related parts of the mobile machinery (if applicable)

3 Photographs of the parent engine

4 List further attachments if any.

10-Dec-07
ity
UK

Ref No. ESH184734 3 of 17


A
or

pp h
roval Aut
4 of 17 Appendix 1 Pertaining to UN/ECE Regulation 96

Essential Characteristics of the Parent Engine

Appendix 1
1 DESCRIPTION OF ENGINE
Perkins also branded as
1.1 Manufacturer Caterpillar
1.2 Manufacturer's engine code 2359/2100
1.3 Cycle: four stroke/two stroke four stroke
1.4 Bore: mm 105
1.5 Stroke: mm 127
1.6 Number and layout of cylinders 4 in line
3
1.7 Engine capacity cm 4400
1.8 Rated speed rev/min 2200 ± 50
1.9 Maximum torque speed rev/min 1400
1.10 Volumetric compression ratio (2) ± 1 Ratio 17.5:1 ± 1 Ratio
1.11 Combustion system description Re-entrant bowl in piston
1.12 Drawing of combustion chamber and piston crown LEG 2800/6
2
inlet mm 1194
1.13 2
Minimum cross sectional area of inlet and outlet ports exhaust mm 911.8
1.14 Cooling system
1.14.1 Liquid
1.14.1.1 Nature of liquid Water
1.14.1.2 Circulating pump(s) yes/no yes
1.14.1.3. Characteristics or make(s) and type(s) (if applicable) Perkins centrifugal
1.14.1.4. Drive ratio(s) (if applicable) 1.55 : 1
1.14.2 Air N/A
1.15. Temperature permitted by the manufacturer
1.15.1. Liquid cooling: maximum temperature at outlet K 366 ± 5
1.15.2. Air cooling: reference point N/A
Maximum charge air outlet temperature of the inlet of the intercooler (if applicable)
1.15.3.
K N/A
Maximum exhaust temperature at the point in the exhaust pipe(s) adjacent to the
1.15.4.
outer flange(s) of the exhaust manifold(s) K 953
min K 353
1.15.5. Lubricant temperature
max K 398
1.16. Pressure charger yes/no yes
1.16.1. Make Garrett
2674A200, 2674A209, 2674A226,
1.16.2. Type 2674A232, 2674A432

1.16.3 Description of system (e.g. max charge pressure, waste-gate, if applicable Turbocharger with waste gate
1.16.4 Intercooler yes/no no
Intake system: Maximum allowable intake depression at rated engine speed and at
1.17. kPa
100% load 5.0
Exhaust system: Maximum allowable exhaust backpressure at rated engine speed
1.18. kPa
and at 100% load 15.0
ADDITIONAL ANTI-POLLUTION DEVICES (if any and not covered by another
2 heading)
Description and/or diagram(s) Boost
3 FUEL FEED
3.1 Feed pump
(2)
Pressure or characteristic diagram kPa 10 - 70 kPa
3.2. Injection system
3.2.1 Pump
3.2.1.1. Make(s) Delphi
3.2.1.2. Type(s) 1434
3.2.1.3. Delivery
rated mm3/stroke 82
rev/min 2200 ± 50
3
maximum torque mm /stroke 94.5
rev/min 1374
Mention the method used: On engine/on pump bench on pump bench
3.2.1.4 Injection advance
0.5deg BTDC @ 1000 rev/min:
2.5deg BTDC @ 1400 rev/min: 0.5
BTDC @ 2100 rev/min
3.2.1.4.1. Injection advance curve (2)
3.2.1.4.2. Timing (2) pin timed 0deg ATDC
3.2.2. Injection piping
3.2.2.1 Length mm 667
3.2.2.2. Internal diameter mm 1.8
3.2.3. Injectors(s)
3.2.3.1. Make(s) Delphi
3.2.3.2. Type(s) LJBX6921101

3.2.3.3. Opening pressure(2) or characteristic diagram kPa 29.4 +/-0.5


3.2.4. Governor
3.2.4.1. Make(s) Delphi
3.2.4.2. Type(s) Mechanical
3.2.4.3. Speed at which cut-off starts under full load (2) rev/min 2200 ± 50
(2)
3.2.4.4. Maximum no-load speed rev/min 2197 - 2297
3.2.4.5. (2) rev/min 700 - 1200
Idling speed
3.3
3.3.1.
Cold start system
Make(s) BERU
10-Dec-07
ity
UK

3.3.2 Type(s) Glowplug


A
or

3.3.3. Description Heated plug


pp h
roval Aut
Ref. No. ESH184734
5 of 17 Appendix 1 Pertaining to UN/ECE Regulation 96

Essential Characteristics of the Parent Engine

2359/2100
5 VALVE TIMING
Maximum lift and angle of opening and closing in relation to dead centres or
5.1 equivalent data:
Maximum lift: Inlet mm 10.76
Maximum lift: Exhaust mm 11.94

Inlet valve opening deg BTDC 20.2


Inlet valve closing deg ABDC 50.9
Exhaust valve opening deg BBDC 54.7
Exhaust valve closing deg ATDC 30.7
5.2 Reference and/or setting range Reference

10-Dec-07
ity
UK

A
or

pp h
roval Aut
Ref. No. ESH184734
Appendix 2 6 of 17

Essential Characteristics of the Engine Family

1 Common parameters (1)


1.1 Combustion cycle four stroke
1.2 Cooling medium Water
1.3 Method of air aspiration Turbocharged
1.4 Combustion chamber type/design Re-entrant bowl in piston
1.5 Valve and porting - configuration, size and number two valves/cylinder

Inlet mm dia 46.3


Exhaust mm dia 41.6
Minimum cross-sectional area of inlet and outlet ports
Inlet mm2 1194
Exhaust mm2 911.8
1.6 Fuel system Distributor pump, direct injection
1.7 Engine management systems N/A

Proof of identity pursuant to drawing numbers(s)


-charge cooling system(2) Requirements as specified by calibration document number in
Appendix 1 & 3, item 3.2.1.4.1
-exhaust gas re-calculation(2) no
-Water injection/emulsion(2) no
-air injection(2) no
1.8 Exhaust after-treatment(2) no
Proof of identical (or lowest for the parent engine) ratio:
system capacity/fuel delivery per stroke, pursuant
to diagram number(s)

10-Dec-07

ity
UK
Ref. No. ESH184734
A

or
pp h
roval Aut
Appendix 2 7 of 17

Essential Characteristics of the Engine Family

2 ENGINE FAMILY LISTING


2.1 Name of Engine Family Perkins 1104C-44T also branded as Caterpillar 3054C DIT
2.2 Specific of engines within family:

Parent
Engine type 2359/2100 2359/2200 2162/2200 2163/2200 2164/2200 2165/2200 2166/2000 2166/2100 2166/2200 2166/2300
No of cylinders 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line
Rated speed rev/min 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2000 ± 50 2100 ± 50 2200 ± 50 2300 ± 50
Fuel delivery per stroke (mm3) 82 80 66 66 73 73 83 81.5 80 78.5
Rated Net Power kW 74.5 74 62 60 68.5 67 72.5 74 74.5 74.5
Maximum Torque speed rev/min 1400 1400 1400 1400 1350 1350 1400 1400 1400 1400
3
Fuel delivery per stroke (mm ) 94.5 94.5 77.7 77.7 85 85 92.5 92.5 92.5 92.5
Maximum Torque Nm 415 415 353 345 388 380 408 408 408 408
Low idle speed rev/min 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200
Cylinder displacement % of parent 100 100 100 100 100 100 100 100 100 100

Engine type 2167/2000 2167/2100 2167/2200 2167/2300 2168/2200 2168/2300 2168/2400 2169/2200 2169/2400 2230/2200
No of cylinders 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line 3 in line
Rated speed rev/min 2000 ± 50 2100 ± 50 2200 ± 50 2300 ± 50 2200 ± 50 2300 ± 50 2400 ± 50 2200 ± 50 2200 ± 50 2200 ± 50
Fuel delivery per stroke (mm3) 83 81.5 80 78.5 76 75 74 76 74 72
Rated Net Power kW 72 72 72.5 72.5 74.5 74.5 74.5 72.5 74.5 48
Maximum Torque speed rev/min 1400 1400 1400 1400 1400 1400 1400 1400 1400 1400
Fuel delivery per stroke (mm3) 92.5 92.5 92.5 92.5 82 82 82 82 82 80
Maximum Torque Nm 407 407 407 407 372 372 372 364 364 270
Low idle speed Nm 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200
Cylinder displacement rev/min 100 100 100 100 100 100 100 100 100 100

10-Dec-07

ity
UK
Ref. No. ESH184734
A

or
pp h
roval Aut
Appendix 2 8 of 17

Essential Characteristics of the Engine Family

2 ENGINE FAMILY LISTING


2.1 Name of Engine Family
2.2 Specific of engines within family:

Engine type 2232/2200 2890/2200


No of cylinders 3 in line 4 in line
Rated speed rev/min 2200 ± 50 2200 ± 50
Fuel delivery per stroke (mm3) 81 73
Rated Net Power kW 55 68.5
Maximum Torque speed rev/min 1400 1350
3
Fuel delivery per stroke (mm ) 89 85
Maximum Torque Nm 291 395
Low idle speed rev/min 700 - 1200 700 - 1200
Cylinder displacement % of parent 100 100

Engine type
No of cylinders
Rated speed rev/min
Fuel delivery per stroke (mm3)
Rated Net Power kW
Maximum Torque speed rev/min
Fuel delivery per stroke (mm3)
Maximum Torque Nm
Low idle speed rev/min
Cylinder displacement % of parent

10-Dec-07

ity
UK
Ref. No. ESH184734
A

or
pp h
roval Aut
9 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

Appendix 3 Appendix 3 Appendix 3 Appendix 3 Appendix 3 Appendix 3


1 DESCRIPTION OF ENGINE
Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as
1.1 Manufacturer Caterpillar Caterpillar Caterpillar Caterpillar Caterpillar Caterpillar
1.2 Manufacturer's engine code 2359/2200 2162/2200 2163/2200 2164/2200 2165/2200 2166/2000
1.3 Cycle: four stroke/two stroke four stroke four stroke four stroke four stroke four stroke four stroke
1.4 Bore: mm 105 105 105 105 105 105
1.5 Stroke: mm 127 127 127 127 127 127
1.6 Number and layout of cylinders 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line
3
1.7 Engine capacity cm 4400 4400 4400 4400 4400 4400
1.8 Rated speed rev/min 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2000 ± 50
1.9 Maximum torque speed rev/min 1400 1400 1400 1350 1350 1400
1.10 (2) ± 1 Ratio
Volumetric compression ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio
1.11 Combustion system description Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston
1.12 Drawing of combustion chamber and piston LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6
crown
Minimum cross sectional area of inlet and outlet inlet mm2 1194 1194 1194 1194 1194 1194
1.13
ports exhaust mm2 911.8 911.8 911.8 911.8 911.8 911.8
1.14 Cooling system
1.14.1 Liquid
1.14.1.1 Nature of liquid Water Water Water Water Water Water
1.14.1.2 Circulating pump(s) yes/no yes yes yes yes yes yes
1.14.1.3. Characteristics or make(s) and type(s) (if Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal
applicable)
1.14.1.4. Drive ratio(s) (if applicable) 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1
1.14.2 Air N/A N/A N/A N/A N/A N/A
1.15. Temperature permitted by the manufacturer
1.15.1. Liquid cooling: maximum temperature at outlet K 366 ± 5 366 ± 5 366 ± 5 366 ± 5 366 ± 5 366 ± 5
1.15.2. Air cooling: reference point N/A N/A N/A N/A N/A N/A
Maximum charge air outlet temperature of the
1.15.3.
inlet of the intercooler (if applicable) K N/A N/A N/A N/A N/A N/A
Maximum exhaust temperature at the point in the
1.15.4. exhaust pipe(s) adjacent to the outer flange(s) of
the exhaust manifold(s) K 953 953 953 953 953 953
min K 353 353 353 353 353 353
1.15.5. Lubricant temperature
max K 398 398 398 398 398 398
1.16. Pressure charger yes/no yes yes yes yes yes yes
1.16.1. Make Garrett Garrett Garrett Garrett Garrett Garrett
2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209,
2674A200, 2674A209, 2674A200, 2674A209,
1.16.2. Type 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232
2674A226, 2674A232, 2674A226, 2674A232
2674A432
Description of system (e.g. max charge pressure, Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste
waste-gate, if applicable gate gate gate gate gate gate
1.16.3

1.16.4 Intercooler yes/no no no no no no no


Intake system: Maximum allowable intake
1.17. depression at rated engine speed and at 100% kPa
load 5.0 5.0 5.0 5.0 5.0 5.0
Exhaust system: Maximum allowable exhaust
1.18. backpressure at rated engine speed and at kPa
100% load 15.0 15.0 15.0 15.0 15.0 15.0
ADDITIONAL ANTI-POLLUTION DEVICES (if
2 any and not covered by another heading)
Description and/or diagram(s) Boost None None Boost Boost Boost

10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
10 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

2359/2200 2162/2200 2163/2200 2164/2200 2165/2200 2166/2000


3 FUEL FEED
3.1 Feed pump
Pressure(2) or characteristic diagram kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa
3.2. Injection system
3.2.1 Pump
3.2.1.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.1.2. Type(s) 1434 1433 1433 1405 1405 1398

3.2.1.3. Delivery
3
rated mm /stroke 80 66 66 73 73 83
rev/min 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2000 ± 50
maximum torque mm3/stroke 94.5 77.7 77.7 85 85 92.5
rev/min 1400 1400 1400 1350 1350 1400
Mention the method used: On engine/on pump
bench on pump bench on pump bench on pump bench on pump bench on pump bench on pump bench
3.2.1.4 Injection advance
0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000
rev/min: 2.5deg BTDC @ rev/min: 3.5deg BTDC @ rev/min: 3.5deg BTDC @ rev/min: 3.5deg BTDC @ rev/min: 3.5deg BTDC @ rev/min: 2.5deg BTDC @
1400 rev/min: 0.5 BTDC 1400 rev/min: 2.0 BTDC 1400 rev/min: 2.0 BTDC 1400 rev/min: 2.0 BTDC 1400 rev/min: 2.0 BTDC 1400 rev/min: 0.5 BTDC
3.2.1.4.1. Injection advance curve (2) @ 2200 rev/min @ 2200 rev/min @ 2200 rev/min @ 2200 rev/min @ 2200 rev/min @ 2000 rev/min
3.2.1.4.2. (2) pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC
Timing
3.2.2. Injection piping
3.2.2.1 Length mm 667 667 667 667 667 667
3.2.2.2. Internal diameter mm 1.8 1.8 1.8 1.8 1.8 1.8
3.2.3. Injectors(s)
3.2.3.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.3.2. Type(s) LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101

3.2.3.3. (2) kPa 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5
Opening pressure or characteristic diagram
3.2.4. Governor
3.2.4.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.4.2. Type(s) Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical
3.2.4.3. Speed at which cut-off starts under full load (2) rev/min 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2200 ± 50 2000 ± 50
3.2.4.4. Maximum no-load speed (2) rev/min 2304 - 2404 2304 - 2404 2304 - 2404 2304 - 2404 2304 - 2404 2090 - 2190
3.2.4.5. (2) rev/min 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200
Idling speed
3.3 Cold start system
3.3.1. Make(s) BERU BERU BERU BERU BERU BERU
3.3.2 Type(s) Glowplug Glowplug Glowplug Glowplug Glowplug Glowplug
3.3.3. Description Heated plug Heated plug Heated plug Heated plug Heated plug Heated plug

4 VALVE TIMING
Maximum lift and angle of opening and closing in
relation to dead centres or equivalent data:
4.1 N/A N/A N/A N/A N/A N/A
Maximum lift: Inlet mm 10.76 10.76 10.76 10.76 10.76 10.76
Maximum lift: Exhaust mm 11.94 11.94 11.94 11.94 11.94 11.94

Inlet valve opening deg BTDC 20.2 20.2 20.2 20.2 20.2 20.2
Inlet valve closing deg ABDC 50.9 50.9 50.9 50.9 50.9 50.9
Exhaust valve opening deg BBDC 54.7 54.7 54.7 54.7 54.7 54.7
Exhaust valve closing deg ATDC 30.7 30.7 30.7 30.7 30.7 30.7
4.2 Reference and/or setting range Reference Reference Reference Reference Reference Reference
Variable valve timing system (if applicable and
5.3 where: intake and/or exhaust N/A N/A N/A N/A N/A N/A
5.3.1 Type: continuous or on/off N/A N/A N/A N/A N/A N/A
5.3.2. Cam phase shift angle N/A N/A N/A N/A N/A N/A 10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
11 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

Appendix 3 Appendix 3 Appendix 3 Appendix 3 Appendix 3 Appendix 3


1 DESCRIPTION OF ENGINE
Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as
1.1 Manufacturer Caterpillar Caterpillar Caterpillar Caterpillar Caterpillar Caterpillar
1.2 Manufacturer's engine code 2166/2100 2166/2200 2166/2300 2167/2000 2167/2100 2167/2200
1.3 Cycle: four stroke/two stroke four stroke four stroke four stroke four stroke four stroke four stroke
1.4 Bore: mm 105 105 105 105 105 105
1.5 Stroke: mm 127 127 127 127 127 127
1.6 Number and layout of cylinders 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line
3
1.7 Engine capacity cm 4400 4400 4400 4400 4400 4400
1.8 Rated speed rev/min 2100 ± 50 2200 ± 50 2300 ± 50 2000 ± 50 2100 ± 50 2200 ± 50
1.9 Maximum torque speed rev/min 1400 1400 1400 1400 1400 1400
1.10 (2) ± 1 Ratio
Volumetric compression ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio
1.11 Combustion system description Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston
1.12 Drawing of combustion chamber and piston LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6
crown
Minimum cross sectional area of inlet and outlet inlet mm2 1194 1194 1194 1194 1194 1194
1.13
ports exhaust mm2 911.8 911.8 911.8 911.8 911.8 911.8
1.14 Cooling system
1.14.1 Liquid
1.14.1.1 Nature of liquid Water Water Water Water Water Water
1.14.1.2 Circulating pump(s) yes/no yes yes yes yes yes yes
1.14.1.3. Characteristics or make(s) and type(s) (if Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal
applicable)
1.14.1.4. Drive ratio(s) (if applicable) 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1
1.14.2 Air N/A N/A N/A N/A N/A N/A
1.15. Temperature permitted by the manufacturer
1.15.1. Liquid cooling: maximum temperature at outlet K 366 ± 5 366 ± 5 366 ± 5 366 ± 5 366 ± 5 366 ± 5
1.15.2. Air cooling: reference point N/A N/A N/A N/A N/A N/A
Maximum charge air outlet temperature of the
1.15.3.
inlet of the intercooler (if applicable) K N/A N/A N/A N/A N/A N/A
Maximum exhaust temperature at the point in the
1.15.4. exhaust pipe(s) adjacent to the outer flange(s) of
the exhaust manifold(s) K 953 953 953 953 953 953
min K 353 353 353 353 353 353
1.15.5. Lubricant temperature
max K 398 398 398 398 398 398
1.16. Pressure charger yes/no yes yes yes yes yes yes
1.16.1. Make Garrett Garrett Garrett Garrett Garrett Garrett
2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209,
1.16.2. Type 2674A226, 2674A232 2674A226, 2674A232, 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232
2674A432
Description of system (e.g. max charge pressure, Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste
waste-gate, if applicable gate gate gate gate gate gate
1.16.3

1.16.4 Intercooler yes/no no no no no no no


Intake system: Maximum allowable intake
1.17. depression at rated engine speed and at 100% kPa
load 5.0 5.0 5.0 5.0 5.0 5.0
Exhaust system: Maximum allowable exhaust
1.18. backpressure at rated engine speed and at kPa
100% load 15.0 15.0 15.0 15.0 15.0 15.0
ADDITIONAL ANTI-POLLUTION DEVICES (if
2 any and not covered by another heading)
Description and/or diagram(s) Boost Boost Boost Boost Boost Boost

10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
12 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

2166/2100 2166/2200 2166/2300 2167/2000 2167/2100 2167/2200


3 FUEL FEED
3.1 Feed pump
Pressure(2) or characteristic diagram kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa
3.2. Injection system
3.2.1 Pump
3.2.1.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.1.2. Type(s) 1398 1398 1398 1398 1398 1398

3.2.1.3. Delivery
3
rated mm /stroke 81.5 80 78.5 83 81.5 80
rev/min 2100 ± 50 2200 ± 50 2300 ± 50 2000 ± 50 2100 ± 50 2200 ± 50
maximum torque mm3/stroke 92.5 92.5 92.5 92.5 92.5 92.5
rev/min 1400 1400 1400 1400 1400 1400
Mention the method used: On engine/on pump
bench on pump bench on pump bench on pump bench on pump bench on pump bench on pump bench
3.2.1.4 Injection advance
0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000
rev/min: 2.5deg BTDC @ rev/min: 2.5deg BTDC @ rev/min: 2.5deg BTDC @ rev/min: 2.5deg BTDC @ rev/min: 2.5deg BTDC @ rev/min: 2.5deg BTDC @
1400 rev/min: 0.5 BTDC 1400 rev/min: 0.5 BTDC 1400 rev/min: 0.5 BTDC 1400 rev/min: 0.5 BTDC 1400 rev/min: 0.5 BTDC 1400 rev/min: 0.5 BTDC
3.2.1.4.1. Injection advance curve (2) @ 2100 rev/min @ 2200 rev/min @ 2300 rev/min @ 2000 rev/min @ 2100 rev/min @ 2200 rev/min
3.2.1.4.2. (2) pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC
Timing
3.2.2. Injection piping
3.2.2.1 Length mm 667 667 667 667 667 667
3.2.2.2. Internal diameter mm 1.8 1.8 1.8 1.8 1.8 1.8
3.2.3. Injectors(s)
3.2.3.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.3.2. Type(s) LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101

3.2.3.3. (2) kPa 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5
Opening pressure or characteristic diagram
3.2.4. Governor
3.2.4.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.4.2. Type(s) Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical
3.2.4.3. Speed at which cut-off starts under full load (2) rev/min 2100 ± 50 2200 ± 50 2300 ± 50 2000 ± 50 2100 ± 50 2200 ± 50
3.2.4.4. Maximum no-load speed (2) rev/min 2197 - 2297 2304 - 2404 2411 - 2511 2090 - 2190 2197 - 2297 2304 - 2404
3.2.4.5. (2) rev/min 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200
Idling speed
3.3 Cold start system
3.3.1. Make(s) BERU BERU BERU BERU BERU BERU
3.3.2 Type(s) Glowplug Glowplug Glowplug Glowplug Glowplug Glowplug
3.3.3. Description Heated plug Heated plug Heated plug Heated plug Heated plug Heated plug

4 VALVE TIMING
Maximum lift and angle of opening and closing in
relation to dead centres or equivalent data:
4.1 N/A N/A N/A N/A N/A N/A
Maximum lift: Inlet mm 10.76 10.76 10.76 10.76 10.76 10.76
Maximum lift: Exhaust mm 11.94 11.94 11.94 11.94 11.94 11.94

Inlet valve opening deg BTDC 20.2 20.2 20.2 20.2 20.2 20.2
Inlet valve closing deg ABDC 50.9 50.9 50.9 50.9 50.9 50.9
Exhaust valve opening deg BBDC 54.7 54.7 54.7 54.7 54.7 54.7
Exhaust valve closing deg ATDC 30.7 30.7 30.7 30.7 30.7 30.7
4.2 Reference and/or setting range Reference Reference Reference Reference Reference Reference
Variable valve timing system (if applicable and
5.3 where: intake and/or exhaust N/A N/A N/A N/A N/A N/A
5.3.1 Type: continuous or on/off N/A N/A N/A N/A N/A N/A
5.3.2. Cam phase shift angle N/A N/A N/A N/A N/A N/A 10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
13 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

Appendix 3 Appendix 3 Appendix 3 Appendix 3 Appendix 3 Appendix 3


1 DESCRIPTION OF ENGINE
Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as Perkins also branded as
1.1 Manufacturer Caterpillar Caterpillar Caterpillar Caterpillar Caterpillar Caterpillar
1.2 Manufacturer's engine code 2167/2300 2168/2200 2168/2300 2168/2400 2169/2200 2169/2400
1.3 Cycle: four stroke/two stroke four stroke four stroke four stroke four stroke four stroke four stroke
1.4 Bore: mm 105 105 105 105 105 105
1.5 Stroke: mm 127 127 127 127 127 127
1.6 Number and layout of cylinders 4 in line 4 in line 4 in line 4 in line 4 in line 4 in line
3
1.7 Engine capacity cm 4400 4400 4400 4400 4400 4400
1.8 Rated speed rev/min 2300 ± 50 2200 ± 50 2300 ± 50 2400 ± 50 2200 ± 50 2200 ± 50
1.9 Maximum torque speed rev/min 1400 1400 1400 1400 1400 1400
1.10 (2) ± 1 Ratio
Volumetric compression ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio 17.5:1 ± 1 Ratio
1.11 Combustion system description Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston
1.12 Drawing of combustion chamber and piston LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6 LEG 2800/6
crown
Minimum cross sectional area of inlet and outlet inlet mm2 1194 1194 1194 1194 1194 1194
1.13
ports exhaust mm2 911.8 911.8 911.8 911.8 911.8 911.8
1.14 Cooling system
1.14.1 Liquid
1.14.1.1 Nature of liquid Water Water Water Water Water Water
1.14.1.2 Circulating pump(s) yes/no yes yes yes yes yes yes
1.14.1.3. Characteristics or make(s) and type(s) (if Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal Perkins centrifugal
applicable)
1.14.1.4. Drive ratio(s) (if applicable) 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1 1.55 : 1
1.14.2 Air N/A N/A N/A N/A N/A N/A
1.15. Temperature permitted by the manufacturer
1.15.1. Liquid cooling: maximum temperature at outlet K 366 ± 5 366 ± 5 366 ± 5 366 ± 5 366 ± 5 366 ± 5
1.15.2. Air cooling: reference point N/A N/A N/A N/A N/A N/A
Maximum charge air outlet temperature of the
1.15.3.
inlet of the intercooler (if applicable) K N/A N/A N/A N/A N/A N/A
Maximum exhaust temperature at the point in the
1.15.4. exhaust pipe(s) adjacent to the outer flange(s) of
the exhaust manifold(s) K 953 953 953 953 953 953
min K 353 353 353 353 353 353
1.15.5. Lubricant temperature
max K 398 398 398 398 398 398
1.16. Pressure charger yes/no yes yes yes yes yes yes
1.16.1. Make Garrett Garrett Garrett Garrett Garrett Garrett
2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209, 2674A200, 2674A209,
1.16.2. Type 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232 2674A226, 2674A232

Description of system (e.g. max charge pressure, Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste Turbocharger with waste
waste-gate, if applicable gate gate gate gate gate gate
1.16.3

1.16.4 Intercooler yes/no no no no no no no


Intake system: Maximum allowable intake
1.17. depression at rated engine speed and at 100% kPa
load 5.0 5.0 5.0 5.0 5.0 5.0
Exhaust system: Maximum allowable exhaust
1.18. backpressure at rated engine speed and at kPa
100% load 15.0 15.0 15.0 15.0 15.0 15.0
ADDITIONAL ANTI-POLLUTION DEVICES (if
2 any and not covered by another heading)
Description and/or diagram(s) Boost Boost Boost Boost Boost Boost

10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
14 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

2167/2300 2168/2200 2168/2300 2168/2400 2169/2200 2169/2400


3 FUEL FEED
3.1 Feed pump
Pressure(2) or characteristic diagram kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa
3.2. Injection system
3.2.1 Pump
3.2.1.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.1.2. Type(s) 1398 1408 1408 1408 1408 1408

3.2.1.3. Delivery
3
rated mm /stroke 78.5 76 75 74 76 74
rev/min 2300 ± 50 2200 ± 50 2300 ± 50 2400 ± 50 2200 ± 50 2200 ± 50
maximum torque mm3/stroke 92.5 82 82 82 82 82
rev/min 1400 1400 1400 1400 1400 1400
Mention the method used: On engine/on pump
bench on pump bench on pump bench on pump bench on pump bench on pump bench on pump bench
3.2.1.4 Injection advance
0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000 0.5deg BTDC @ 1000
rev/min: 2.5deg BTDC @ rev/min: 0.5deg BTDC @ rev/min: 0.5deg BTDC @ rev/min: 0.5deg BTDC @ rev/min: 0.5deg BTDC @ rev/min: 0.5deg BTDC @
1400 rev/min: 0.5 BTDC 1400 rev/min: 1.0 BTDC 1400 rev/min: 1.0 BTDC 1400 rev/min: 1.0 BTDC 1400 rev/min: 1.0 BTDC 1400 rev/min: 1.0 BTDC
3.2.1.4.1. Injection advance curve (2) @ 2300 rev/min @ 2200 rev/min @ 2300 rev/min @ 2400 rev/min @ 2200 rev/min @ 2400 rev/min
3.2.1.4.2. (2) pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC
Timing
3.2.2. Injection piping
3.2.2.1 Length mm 667 667 667 667 667 667
3.2.2.2. Internal diameter mm 1.8 1.8 1.8 1.8 1.8 1.8
3.2.3. Injectors(s)
3.2.3.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.3.2. Type(s) LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101 LJBX6921101

3.2.3.3. (2) kPa 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5
Opening pressure or characteristic diagram
3.2.4. Governor
3.2.4.1. Make(s) Delphi Delphi Delphi Delphi Delphi Delphi
3.2.4.2. Type(s) Mechanical Mechanical Mechanical Mechanical Mechanical Mechanical
3.2.4.3. Speed at which cut-off starts under full load (2) rev/min 2300 ± 50 2200 ± 50 2300 ± 50 2400 ± 50 2200 ± 50 2200 ± 50
3.2.4.4. Maximum no-load speed (2) rev/min 2411 - 2511 2304 - 2404 2411 - 2511 2518 - 2618 2304 - 2404 2518 - 2618
3.2.4.5. (2) rev/min 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200 700 - 1200
Idling speed
3.3 Cold start system
3.3.1. Make(s) BERU BERU BERU BERU BERU BERU
3.3.2 Type(s) Glowplug Glowplug Glowplug Glowplug Glowplug Glowplug
3.3.3. Description Heated plug Heated plug Heated plug Heated plug Heated plug Heated plug

4 VALVE TIMING
Maximum lift and angle of opening and closing in
relation to dead centres or equivalent data:
4.1 N/A N/A N/A N/A N/A N/A
Maximum lift: Inlet mm 10.76 10.76 10.76 10.76 10.76 10.76
Maximum lift: Exhaust mm 11.94 11.94 11.94 11.94 11.94 11.94

Inlet valve opening deg BTDC 20.2 20.2 20.2 20.2 20.2 20.2
Inlet valve closing deg ABDC 50.9 50.9 50.9 50.9 50.9 50.9
Exhaust valve opening deg BBDC 54.7 54.7 54.7 54.7 54.7 54.7
Exhaust valve closing deg ATDC 30.7 30.7 30.7 30.7 30.7 30.7
4.2 Reference and/or setting range Reference Reference Reference Reference Reference Reference
Variable valve timing system (if applicable and
5.3 where: intake and/or exhaust N/A N/A N/A N/A N/A N/A
5.3.1 Type: continuous or on/off N/A N/A N/A N/A N/A N/A
5.3.2. Cam phase shift angle N/A N/A N/A N/A N/A N/A 10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
15 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

Appendix 3 Appendix 3 Appendix 3


1 DESCRIPTION OF ENGINE
Perkins also branded as Perkins also branded as Perkins also branded as
1.1 Manufacturer Caterpillar Caterpillar Caterpillar
1.2 Manufacturer's engine code 2230/2200 2232/2200 2890/2200
1.3 Cycle: four stroke/two stroke four stroke four stroke four stroke
1.4 Bore: mm 105 105 105
1.5 Stroke: mm 127 127 127
1.6 Number and layout of cylinders 3 in line 3 in line 4 in line
3
1.7 Engine capacity cm 3300 3300 4400
1.8 Rated speed rev/min 2200 ± 50 2200 ± 50 2200 ± 50
1.9 Maximum torque speed rev/min 1400 1400 1350
1.10 (2) ± 1 Ratio
Volumetric compression ratio 18.25:1 ± 1 Ratio 18.25:1 ± 1 Ratio 17.5:1 ± 1 Ratio
1.11 Combustion system description Re-entrant bowl in piston Re-entrant bowl in piston Re-entrant bowl in piston
1.12 Drawing of combustion chamber and piston LEG 2800/6 LEG 2800/6 LEG 2800/6
crown
Minimum cross sectional area of inlet and outlet inlet mm2 1194 1194 1194
1.13
ports exhaust mm2 911.8 911.8 911.8
1.14 Cooling system
1.14.1 Liquid
1.14.1.1 Nature of liquid Water Water Water
1.14.1.2 Circulating pump(s) yes/no yes yes yes
1.14.1.3. Characteristics or make(s) and type(s) (if Perkins centrifugal Perkins centrifugal Perkins centrifugal
applicable)
1.14.1.4. Drive ratio(s) (if applicable) 1.55 : 1 1.55 : 1 1.55 : 1
1.14.2 Air N/A N/A N/A
1.15. Temperature permitted by the manufacturer
1.15.1. Liquid cooling: maximum temperature at outlet K 366 ± 5 366 ± 5 366 ± 5
1.15.2. Air cooling: reference point N/A N/A N/A
Maximum charge air outlet temperature of the
1.15.3.
inlet of the intercooler (if applicable) K N/A N/A N/A
Maximum exhaust temperature at the point in the
1.15.4. exhaust pipe(s) adjacent to the outer flange(s) of
the exhaust manifold(s) K 953 953 953
min K 353 353 353
1.15.5. Lubricant temperature
max K 398 398 398
1.16. Pressure charger yes/no yes yes yes
1.16.1. Make Garrett Garrett Garrett
2674A405 2674A405 2674A200, 2674A209,
1.16.2. Type 2674A226, 2674A232,
2674A432
Description of system (e.g. max charge pressure, Turbocharger with waste Turbocharger with waste Turbocharger with waste
waste-gate, if applicable gate gate gate
1.16.3

1.16.4 Intercooler yes/no no no no


Intake system: Maximum allowable intake
1.17. depression at rated engine speed and at 100% kPa
load 5.0 5.0 5.0
Exhaust system: Maximum allowable exhaust
1.18. backpressure at rated engine speed and at kPa
100% load 15.0 15.0 15.0
ADDITIONAL ANTI-POLLUTION DEVICES (if
2 any and not covered by another heading)
Description and/or diagram(s) Boost Boost None

10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
16 of 17 Appendix 3 Pertaining to Directive 97/68/EC
of the European Parliament and of the Council and UN ECE Regulation 96.01
Essential Characteristics of Engine Types Within the Family

2230/2200 2232/2200 2890/2200


3 FUEL FEED
3.1 Feed pump
Pressure(2) or characteristic diagram kPa 10 - 70 kPa 10 - 70 kPa 10 - 70 kPa
3.2. Injection system
3.2.1 Pump
3.2.1.1. Make(s) Delphi Delphi Delphi
3.2.1.2. Type(s) Prototype 9322L16210 Prototype 9322L16277 1405
Production 1423 Production 1428
3.2.1.3. Delivery
3
rated mm /stroke 72 81 73
rev/min 2200 ± 50 2200 ± 50 2200 ± 50
maximum torque mm3/stroke 80 89 85
rev/min 1400 1400 1350
Mention the method used: On engine/on pump
bench on pump bench on pump bench on pump bench
3.2.1.4 Injection advance
4.0 deg BTDC @ 1000 3.0 deg BTDC @ 1000 0.5deg BTDC @ 1000
rev/min: 2.0 deg BTDC rev/min: 2.5 deg BTDC rev/min: 3.5deg BTDC @
@ 1400 rev/min: 0.5 @ 1400 rev/min: TDC @ 1400 rev/min: 2.0 BTDC
3.2.1.4.1. Injection advance curve (2) ATDC @ 2200 rev/min 2200 rev/min @ 2200 rev/min
3.2.1.4.2. (2) pin timed 0deg ATDC pin timed 0deg ATDC pin timed 0deg ATDC
Timing
3.2.2. Injection piping
3.2.2.1 Length mm 600 600 667
3.2.2.2. Internal diameter mm 1.8 1.8 1.8
3.2.3. Injectors(s)
3.2.3.1. Make(s) Delphi Delphi Delphi
3.2.3.2. Type(s) Injector 2645K017 Injector 2645K017 LJBX6921101
Nozzle 2645K611 Nozzle 2645K611

3.2.3.3. (2) kPa 29.4 +/-0.5 29.4 +/-0.5 29.4 +/-0.5


Opening pressure or characteristic diagram
3.2.4. Governor
3.2.4.1. Make(s) Delphi Delphi Delphi
3.2.4.2. Type(s) Mechanical Mechanical Mechanical
3.2.4.3. Speed at which cut-off starts under full load (2) rev/min 2200 ± 50 2200 ± 50 2200 ± 50
3.2.4.4. Maximum no-load speed (2) rev/min 2304 - 2404 2304 - 2404 2304 - 2404
3.2.4.5. (2) rev/min 700 - 1200 700 - 1200 700 - 1200
Idling speed
3.3 Cold start system
3.3.1. Make(s) BERU BERU BERU
3.3.2 Type(s) Glowplug Glowplug Glowplug
3.3.3. Description Heated plug Heated plug Heated plug

4 VALVE TIMING
Maximum lift and angle of opening and closing in
relation to dead centres or equivalent data:
4.1 N/A N/A N/A
Maximum lift: Inlet mm 10.76 10.76 10.76
Maximum lift: Exhaust mm 11.94 11.94 11.94

Inlet valve opening deg BTDC 20.2 20.2 20.2


Inlet valve closing deg ABDC 50.9 50.9 50.9
Exhaust valve opening deg BBDC 54.7 54.7 54.7
Exhaust valve closing deg ATDC 30.7 30.7 30.7
4.2 Reference and/or setting range Reference Reference Reference
Variable valve timing system (if applicable and
5.3 where: intake and/or exhaust N/A N/A N/A
5.3.1 Type: continuous or on/off N/A N/A N/A
5.3.2. Cam phase shift angle N/A N/A N/A 10-Dec-07

ity
UK
A

or
pp
Ref. No. ESH184734 th
r oval Au
Perkins 1104C-44T
Also Branded as Caterpillar 3054C DIT

ESH184734

10-Dec-07
ity
UK

REF: ESH184734
A
or

pp h
roval Aut

You might also like