Engine Control System (6(WF1) 1-137
‘ation
Valve(s)
Yes
No.
Inspect the injector power supply cicult for short
circuits
41. Disconnect the harness from the ECM.
2. Measure the voltage between ECM connector
terminals
3. If fault is dotected, repair or replace as
necessary
Was an abnormality detected?
Between pins
106/107 and
‘GND: OV
Goto Step 7
Goto Step 5
Inspect te injector unit
1. Remove the hamess from the injectors (1st
‘oylinder, 3rd cylinder, 5th cylinder).
2. Measure the resistance values between
injector terminals.
+ Between injector terminals: 0.3 - 1.30
+ Between terminals - body: 0.
3. If fault is detected, repair or replace as
necessary.
IMPORTANT:
fan injector is replaced, you need to program the
Injector 1D code,
Was an abnormality detected?
Goto Step 7
Goto Step 6
1. Replace the ECM.
IMPORTANT:
‘After replacing the ECM, perform the folowing
items of programming,
+ Qadjustment data
+ Injector 10 code
Is the procedure complete?
Goto Step 7
Recheck the DTC.
4. Connect all hamesses.
2. Clear the DTC,
3. Turn the starter switch OFF, wat for more than
416 seconds, then turn the Switch ON and start
the engine.
4. Check the DTC.
Was OTC PO15S detected?
Goto Step 2
Goto Step 8
Use the scan lool Wo check olher BTC are
detected
Ave other DTCs detected?
Goto applicable
Dre
Verity repair