Professional Documents
Culture Documents
Service: Audi Q5 2017 Audi Q5 China 2019
Service: Audi Q5 2017 Audi Q5 China 2019
Service: Audi Q5 2017 Audi Q5 China 2019
Repair Manual
Audi Q5 2017 ➤
Audi Q5 China 2019 ➤
Communication
Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Repair Group
00 - General, Technical Data
91 - Communication
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Technical information should always be available to the foremen and mechanics, because their
careful and constant adherence to the instructions is essential to ensure vehicle road-worthiness
and safety. In addition, the normal basic safety precautions for working on motor vehicles must, as
a matter of course, be observed.
Contents
91 - Communication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
1 Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
2 Infotainment System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.1 Overview - Infotainment System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.2 Component Location Overview - Infotainment System . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
2.3 Infotainment System Display, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
2.4 Information Electronics Control Module 1 J794, Removing and Installing . . . . . . . . . . . . . . 21
2.5 Multimedia System Control Head E380, Removing and Installing . . . . . . . . . . . . . . . . . . . . 23
2.6 Driver Volume Control E67, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
2.7 Multimedia Button Module E817, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . 25
3 Sound System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
3.1 Overview - Sound System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
3.2 Copying
Protected by copyright. Component Location
for private or commercial Overview
purposes, in part or- inSound
whole, is System
not ................................ 32
3.3 Control Module/Digital Sound System Amplifier, Removing and Installing . . . . . . . . . . . . 36
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
3.4 Left Rear Treble Speaker R14/Right Rear Treble Speaker R16, Removing and Installing . . 39
3.5 Left Front Treble Speaker R20/Right Front Treble Speaker R22, Removing and Installing . . 40
3.6 Left Front Treble Speaker 2 R220/Right Front Treble Speaker 2 R221, Removing and
Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
3.7 Left Front Midrange Speaker R103/Right Front Midrange Speaker R104, Removing and
Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
3.8 Left Front Midrange Speaker 2 R276/Right Front Midrange Speaker 2 R277, Removing
and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
3.9 Left Rear Bass Speaker R15/Right Rear Bass Speaker R17, Removing and Installing . . 45
3.10 Left Front Bass Speaker R21/Right Front Bass Speaker R23, Removing and Installing . . 46
3.11 Subwoofer R211, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
3.12 Effects Speaker, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
3.13 Center Speaker R208, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
3.14 Center Speaker 2 R219, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
3.15 Interior Microphone R74, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
4 Antenna Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
4.1 Overview - Antenna Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
4.2 Component Location Overview - Antenna Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
4.3 Antenna Amplifier, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
4.4 Windshield Antenna Suppression Filter C18, Removing and Installing . . . . . . . . . . . . . . . . 66
4.5 Roof Antenna, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
4.6 GPS Antenna, Removing and Installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Contents i
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
ii Contents
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Contents iii
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
iv Contents
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
1. Safety Precautions 1
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1. Safety Precautions 3
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
2 Repair Information
⇒ f2.1 or Clean Working Conditions”, page 4
⇒ I2.2 nformation”, page 4
⇒ C2.3 orrosion”, page 4
⇒ D2.4 ischarge Work Surface”, page 5
⇒ R2.5 outing and Securing”, page 5
⇒ P2.6 lates”, page 6
⇒ W2.7 rench, Using”, page 6
⇒ R2.8 epair Information”, page 6
⇒ B2.9 us Wires Repair Information”, page 7
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
If there are doubts about whether parts can be used or not, then
use new parts. Refer to the ⇒ Electronic Parts Catalog (ETKA).
Note:
♦ Only original replacement parts are recommended. They are
checked and compatible with aluminum.
♦ The use of Audi accessories is recommended.
♦ Contact corrosion damage is not covered under warranty.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
♦ Make sure also when handling the open housing that no oil,
with respect to the correctness of information in this document. Copyright by AUDI AG.
2. Repair Information 5
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
2. Repair Information 7
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
91 – Communication
1 Safety Precautions
Note the safety precautions. Refer to ⇒ P1 recautions”, page 1 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
2 Infotainment System
⇒ -2.1 Infotainment System”, page 9
⇒ L2.2 ocation Overview - Infotainment System”, page 16
⇒ S2.3 ystem Display, Removing and Installing”, page 18
⇒ I2.4 nformation Electronics Control Module 1J794, Removing
and Installing”, page 21
⇒ M2.5 ultimedia System Control HeadE380, Removing and
Installing”, page 23
⇒ D2.6 river Volume ControlE67, Removing and Installing”,
page 24
⇒ M2.7 ultimedia Button ModuleE817, Removing and Instal‐
ling”, page 25
2. Infotainment System 9
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
2. Infotainment System 11
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
2. Infotainment System 13
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
2. Infotainment System 15
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - Bolt
❑ Quantity: 4
❑ 3 Nm
3 - Front Information Display
Control Head -J685-
❑ Inside the center of the
instrument panel
❑ Removing and Instal‐
ling. Refer to ⇒
S2.3.1 ystem Display,
Removing and Instal‐
ling, before Product Im‐
provement”, page 18 .
4 - Driver Volume Control -
E67-
❑ In the center console
❑ Removing and Instal‐
ling. Refer to ⇒
D2.6 river Volume Con‐
trolE67, Removing and
Installing”, page 24 .
5 - Bolt
❑ Quantity: 2
❑ 1.5 Nm
6 - Multimedia Button Module -E817-
❑ Vehicles with Manual Transmission
❑ In the center console
❑ Removing and Installing. Refer to ⇒ M2.7 ultimedia Button ModuleE817, Removing and Installing”,
page 25 .
7 - Multimedia System Control Head -E380-
❑ Vehicles with Manual Transmission
❑ In the center console
❑ Removing and Installing. Refer to ⇒ M2.5.1 ultimedia System Control HeadE380, Removing and
Installing, Manual
Protected Transmission”,
by copyright. page
Copying for private 23 . purposes, in part or in whole, is not
or commercial
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
8 - Bolt with respect to the correctness of information in this document. Copyright by AUDI AG.
❑ Quantity: 4
❑ 1.5 Nm
9 - Bolt
❑ Quantity: 4
❑ 1.5 Nm
10 - Multimedia System Control Head -E380-
❑ Vehicles with Automatic Transmission
❑ In the center console
2. Infotainment System 17
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
❑ Removing and Installing. Refer to ⇒ M2.5.2 ultimedia System Control HeadE380, Removing and
Installing, Automatic Transmission”, page 23 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the center and front passenger side instrument
panel vent. Refer to ⇒ Body Interior; Rep. Gr. 70; Instrument
Panel; Center Vent, Removing and Installing.
– Remove the bolts -arrows-.
– Pull the display -1- toward the rear out of the instrument
panel until the connector is accessible.
– Remove the wiring harness bracket -2- from the display -1-.
– Release and disconnect the connector -3- on the display -1-.
Installing
Install in the reverse order of removal while noting the following:
– Protect the new display with film.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
Tightening Specifications with respect to the correctness of information in this document. Copyright by AUDI AG.
2. Infotainment System 19
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
♦ Electrical system
♦ 01 - OBD-capable systems
♦ 005F - Information Electronics Control Module 1 - J794 (MIB
3)
♦ 005F - Information Electronics Control Module 1, functions
♦ 0636 - Front Information Display Control Head -J685-, re‐
placing
– Start the selected program and follow the instructions on the
Vehicle Diagnostic Tester display.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the center and front passenger side instrument
panel vent. Refer to ⇒ Body Interior; Rep. Gr. 70; Instrument
Panel; Center Vent, Removing and Installing.
– Remove the bolts -arrows-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Pull the display -1- toward the rear out of the instrument
panel until the connector is accessible.
– Remove the wiring harness bracket -2- from the display sup‐
port.
– Release and disconnect the connector -3- on the display -1-.
– Remove the bolts -arrows-.
2. Infotainment System 21
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
– Insert two of the Radio Removal Tool -T10057- into the re‐
lease slots on the Information Electronics Control Module
1 -J794- -1- until they engage. The points on the gripping
eyelets face outward.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Installing
Install in reverse order of removal.
Tightening Specifications
♦ Refer to ⇒ L2.2.1 ocation Overview - Infotainment System,
before Product Improvement”, page 16
2. Infotainment System 23
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Installing
Install in reverse order of removal.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
Tightening Specifications
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
♦ Refer to ⇒ L2.2.1 ocation Overview - Infotainment System,
before Product Improvement”, page 16
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Installing
Install in reverse order of removal.
Tightening Specifications
♦ Refer to ⇒ L2.2.1 ocation Overview - Infotainment System,
before Product Improvement”, page 16
♦ Refer to ⇒ L2.2.2 ocation Overview - Infotainment System,
from Product Improvement”, page 18
2. Infotainment System 25
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
3 Sound System
⇒ -3.1 Sound System”, page 27
⇒ L3.2 ocation Overview - Sound System”, page 32
⇒ M3.3 odule/Digital Sound System Amplifier, Removing and
Installing”, page 36
⇒ L3.4 eft Rear Treble SpeakerR14/Right Rear Treble Speak‐
erR16, Removing and Installing”, page 39
⇒ L3.5 eft Front Treble SpeakerR20/Right Front Treble Speak‐
erR22, Removing and Installing”, page 40
⇒ L3.6 eft Front Treble Speaker 2R220/Right Front Treble
Speaker 2R221, Removing and Installing”, page 42
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
⇒ L3.7 eft Front Midrange SpeakerR103/Right
permitted Front Midrange
unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
SpeakerR104, Removing and Installing”, page 43 to the correctness of information in this document. Copyright by AUDI AG.
with respect
3. Sound System 27
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
1 - Information Electronics
Control Module 1 -J794- in
the Glove Compartment
2 - Left Front Treble Speak‐
er -R20-/Right Front Treble
Speaker -R22- on Left and
Right Sides of the Panel
3 - Left Front Bass Speaker -
R21-/Right Front Bass Speak‐
er -R23- in the Lower Front
Doors
4 - Left Rear Treble Speak‐
er -R14-/Right Rear Treble
Speaker -R16- in the Rear
Door Trim Panels
5 - Left Rear Bass Speaker -
R15-/Right Rear Bass Speak‐
er -R17- at Bottom of the
Rear Doors
6 - MOST Bus
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794- in
the Glove Compartment
2 - Left Front Treble Speak‐
er -R20-/Right Front Treble
Speaker -R22- on Left and
Right Sides of the Panel
3 - Left Front Bass Speaker -
R21-/Right Front Bass Speak‐
er -R23- in the Lower Front
Doors
4 - Left Rear Treble Speak‐
er -R14-/Right Rear Treble
Speaker -R16- in the Rear
Door Trim Panels
5 - Left Rear Bass Speaker -
R15-/Right Rear Bass Speak‐
er -R17- at Bottom of the
Rear Doors
6 - Center Speaker -R208- in
the Center Instrument Panel
7 - Subwoofer -R211- in the
Spare Tire Well/in the Lug‐
gage Compartment
8 - MOST Bus
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
3.1.3 Overview - Sound System, Premium Sound System, 9VS, before Product
Improvement
3. Sound System 29
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
3.1.4 Overview - Sound System, Premium Sound System, 9VS, from Product
Improvement
1 - Information Electronics
Control Module 1 -J794- in
the Glove Compartment
2 - Interior Microphone -R74-
in Front Roof Module -WX3-
3 - Left Front Midrange
Speaker 2 -R276- in the In‐
strument Panel on the Left
Side
4 - Left Front Treble Speaker
-R20- at the Top of the Left A-
Pillar, at Height of the Exterior Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
Rearview Mirror permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
5 - Left Front Midrange
Speaker -R103- in the Left
Front Door in the Center
6 - Left Effects Speaker -
R209- in the Left D-Pillar Trim
Panel
7 - Center Speaker 2 -R219-
in the Center of the Instru‐
ment Panel
8 - Center Speaker -R208- in
the Center Instrument Panel
9 - Right Effects Speaker -
R210- in the Right D-Pillar
Trim Panel
10 - Right Front Midrange
Speaker -R104- in the Right
Front Door Trim Panel in the
Center
11 - Right Front Treble
Speaker -R22- at the Top of
the Right A-Pillar, at Height of
the Exterior Rearview Mirror
12 - Right Front Midrange Speaker 2 -R277- in the Instrument Panel on the Right Side
13 - Left Front Bass Speaker -R21- in the Left Lower Front Door
14 - Left Front Treble Speaker 2 -R220- in the Left A-Pillar at the Top
15 - Left Rear Treble Speaker -R14- in the Left Upper Rear Trim Panel
16 - Left Rear Bass Speaker -R15- in the Left Rear Door at the Bottom
17 - Subwoofer -R211- in the Spare Tire Well/in the Luggage Compartment
❑ With integrated Dual Subwoofer Speaker 1 -R298- / Dual Subwoofer Speaker 2 -R299-
18 - Right Rear Bass Speaker -R17- in the Right Rear Door at the Bottom
19 - Right Rear Treble Speaker -R16- in the Right Upper Rear Trim Panel
20 - Right Front Treble Speaker 2 -R221- at the Top of the Right A-Pillar
21 - Right Front Bass Speaker -R23- in the Right Front Door at the Bottom
22 - Digital Sound System Control Module -J525- in Luggage Compartment on Left Side
23 - Data Bus Wires for Audio Bus
24 - MOST Bus
3. Sound System 31
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
ling. Refer to ⇒
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
L3.5.2 eft Front Tre‐
ble SpeakerR20/Right
Front Treble Speak‐
erR22, Removing and
Installing, 9VS”, page
41 .
3 - Right Front Midrange
Speaker -R104-, 9VS
❑ Removing and Instal‐
ling. Refer to ⇒
L3.7 eft Front Midrange
SpeakerR103/Right
Front Midrange Speak‐
erR104, Removing and Installing”, page 43 .
4 - Right Front Treble Speaker 2 -R221-, 9VS
❑ Removing and Installing. Refer to ⇒ L3.6 eft Front Treble Speaker 2R220/Right Front Treble Speaker
2R221, Removing and Installing”, page 42 .
5 - Right Front Bass Speaker -R23-
❑ Removing and Installing. Refer to ⇒ L3.10 eft Front Bass SpeakerR21/Right Front Bass SpeakerR23,
Removing and Installing”, page 46 .
6 - Right Rear Treble Speaker -R16-
❑ Removing and Installing. Refer to ⇒ L3.4 eft Rear Treble SpeakerR14/Right Rear Treble SpeakerR16,
Removing and Installing”, page 39 .
7 - Right Rear Bass Speaker -R17-
❑ Removing and Installing. Refer to ⇒ L3.9 eft Rear Bass SpeakerR15/Right Rear Bass SpeakerR17,
Removing and Installing”, page 45 .
8 - Right Effects Speaker -R210-, 9VS
❑ Removing and Installing. Refer to ⇒ S3.12 peaker, Removing and Installing”, page 49 .
9 - Subwoofer -R211-, 9VD/9VS
❑ Vehicles without high-voltage system, 0K0/0K4
❑ Removing and Installing. Refer to ⇒ S3.11.1 ubwooferR211, Removing and Installing, Vehicles without
High-Voltage System (0K0/0K4)”, page 48 .
3. Sound System 33
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
36 .
with respect to the correctness of information in this document. Copyright by AUDI AG.
5 - Bolt
❑ Quantity: 2
❑ 6 Nm
3. Sound System 35
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
3. Sound System 37
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Remove the control module -1- from the adapter plate -2-.
– Disconnect the connector -4-.
Installing
Install in reverse order of removal.
Tightening Specifications
♦ Refer to ⇒ L3.2.3 ocation Overview - Sound System, Micro‐
phones and Amplifiers, from Product Improvement”, page 35
3. Sound System 39
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Removing and installing on the left and right sides are the
same.
Removing
– Turnpermitted
off theunless
ignition and by all electrical
AG. AUDI AGequipment. Setor the
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
authorised AUDI does not guarantee accept any liability
ignition
withkey outside
respect of the of
to the correctness vehicle.
information in this document. Copyright by AUDI AG.
– Turn the speaker -1- in the direction of the -arrow- until it can
be removed.
Installing
Install in reverse order of removal.
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the speaker trim mount. Refer to ⇒ Body Interior;
Rep. Gr. 70; Instrument Panel; Overview - Instrument Panel.
– Remove the bolts -1- and remove the speaker -2- upward.
panel
3. Sound System 41
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition andbyall
Protected electrical
copyright. Copyingequipment. Set the
for private or commercial purposes, in part or in whole, is not
ignition key outside of the
permitted vehicle.
unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Remove the A-pillar trim. Refer to ⇒ Body Interior; Rep.
Gr. 70; Vehicle Interior Trim Panels; Overview - A-Pillar
Trim.
– Disconnect the connector from the speaker -1-.
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the A-pillar trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70; Vehicle Interior Trim Panels; A-Pillar Trim Pan‐
el, Removing and Installing.
– Disconnect the connector -2-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
– Remove the bolt -arrow A-. permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Push the speaker -1- all the way in the direction of the
-arrow B-.
– Remove the speaker -1-.
Installing
Install in reverse order of removal.
Tightening Specifications
Components Tightening Specification
Front treble speaker 2 to A-pillar 2 Nm
3. Sound System 43
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the front door trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70; Front Door Trim Panels; Overview - Front Door
Trim Panel.
– Disconnect the connector from the speaker -1-.
Removing and installing on the left and right sides are the
same.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
Removing
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the speaker trim mount. Refer to ⇒ Body Interior;
Rep. Gr. 70; Instrument Panel; Overview - Instrument Panel.
– Remove the bolts -1- and remove the speaker -2- upward.
3. Sound System 45
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the rear door trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70; Rear Door Trim Panels; Overview - Rear Door
Trim Panel.
– Disconnect the connector -1-. Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the front door trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70; Front Door Trim Panels; Overview - Front Door
Trim Panel.
– Disconnect the connector from the speaker -1-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
3. Sound System 47
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the D-pillar trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70; Vehicle Interior Trim Panels; Overview - D-Pillar
Trim Panel.
3. Sound System 49
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the D-pillar trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70; Vehicle Interior Trim Panels; Overview - D-Pillar
Trim Panel.
– Remove the bolts -arrows- and then remove the Left Effects
Speaker -R209- -1- from the bracket.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the speaker trim mount. Refer to ⇒ Body Interior;
Rep. Gr. 70; Instrument Panel; Overview - Instrument Panel.
– Remove the bolts -arrows- and remove the speaker -1-.
3. Sound System 51
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the speaker trim mount. Refer to ⇒ Body Interior;
Rep. Gr. 70; Instrument Panel; Overview - Instrument Panel.
– Release the retainers -arrows-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the Front Roof Module -WX3-. Refer to ⇒ Electrical
Equipment; Rep. Gr. 96; Controls; Front Interior Lamp/Read‐
ing Lamp, Removing and Installing.
– Unclip the connector -2- from the retainer.
– Pry out the interior microphone -3-.
Installing
Install in reverse order of removal.
3. Sound System 53
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
4 Antenna Systems
⇒ -4.1 Antenna Systems”, page 54
⇒ L4.2 ocation Overview - Antenna Systems”, page 58
⇒ A4.3 mplifier, Removing and Installing”, page 64
⇒ W4.4 indshield Antenna Suppression FilterC18, Removing
and Installing”, page 66
⇒ A4.5 ntenna, Removing and Installing”, page 66
⇒ A4.6 ntenna, Removing and Installing”, page 68
⇒ A4.7 ntenna, Removing and Installing”, page 68
⇒ A4.8 ntennas, Removing and Installing”, page 69
⇒ S4.9 atellite Tuner AntennaR172, Removing and Installing”,
page 71
⇒ R4.10 adio Antenna, Removing and Installing”, page 71
⇒ C4.11 all Module Antennas, Removing and Installing”, page
71
⇒ A4.12 ntennas, Removing and Installing”, page 74
⇒ D4.13 ata Antenna, Removing and Installing”, page 75
⇒ F4.14 ield Communication Antenna, Removing and Instal‐
ling”, page 76
⇒ W4.15 ireless Data Transfer AntennaR336, Removing
AG. AUDI AGand
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI does not guarantee or accept any liability
Installing”, page 76 with respect to the correctness of information in this document. Copyright by AUDI AG.
4. Antenna Systems 55
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
4. Antenna Systems 57
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
4. Antenna Systems 59
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
❑ Removing and Installing. Refer to ⇒ A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page
64 .
12 - Bolt
❑ 2 Nm
13 - Antenna Amplifier -R24-
❑ Removing and Installing. Refer to ⇒ A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page
64 .
14 - Bolt
❑ 2 Nm
15 - Antenna Amplifier 3 -R112-
❑ Removing and Installing. Refer to ⇒ A4.3.2 ntenna Amplifier 3R112, Removing and Installing”, page
65 .
16 - Nut
❑ Quantity: 1 on each side
❑ 3.5 Nm
17 - Nut
❑ Quantity: 2 on each side
❑ 3.5 Nm
18 - Bracket
19 - Bumper Antennas
- Telephone Antenna -R65-
❑ Under the rear bumper cover on the right side, 9ZE and EL3/IV1 through IV6
❑ Removing and Installing. Refer to ⇒ A4.12 ntennas, Removing and Installing”, page 74 .
- LTE Antenna 1 -R297-
❑ Under the left rear bumper cover, EL3 and IV1 through IV6
❑ Removing and Installing. Refer to ⇒ A4.12 ntennas, Removing and Installing”, page 74 .
- LTE Antenna 2 -R306-
❑ Under the left rear bumper cover, EL3 and IV0
❑ Removing and
Protected Installing.
by copyright. Refer
Copying to ⇒or A4.12
for private ntennas,
commercial purposes, inRemoving
part or in whole,and
is notInstalling”, page 74 .
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
20 - Nut with respect to the correctness of information in this document. Copyright by AUDI AG.
❑ 9 Nm
21 - Nut
❑ Quantity: 2
❑ 9 Nm
22 - Windshield Antenna Suppression Filter -C18-
❑ Removing and Installing. Refer to ⇒ W4.4 indshield Antenna Suppression FilterC18, Removing and
Installing”, page 66 .
23 - Emergency Call Module Antenna -R263-
❑ IV0/IW3/IW5 and 4GR/4GY as well as IV1 through IV6
❑ Removing and Installing. Refer to ⇒ page 71 .
1 - Not Installed
2 - Bolt
❑ 5 Nm
3 - GPS Connection from
GPS Antenna -R50-
4 - Not Assigned
5 - byRoof
Protected Antenna
copyright. -R216-
Copying for private or commercial purposes, in part or in whole, is not
❑ Removing and Instal‐
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
ling. Refer to ⇒
A4.5 ntenna, Removing
and Installing”, page
66 .
6 - GSM Connection from Tel‐
ephone Antenna -R65-
❑ 9ZE and EL0/IW0
- LTE connection from LTE
Antenna 1 -R297-
❑ EL3 and IW0
GSM connection from Emer‐
gency Call Module Antenna -
R263-
❑ IW1
7 - RC Connection from Auxil‐
iary Heater Antenna -R182-
❑ 9M9
8 - Bolt
❑ 2 Nm
9 - Antenna Amplifier 2 -
R111-
❑ Removing and Instal‐
ling. Refer to ⇒
A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page 64 .
10 - Bolt
❑ 2 Nm
11 - TV Antenna Amplifier 3 -R84-
❑ Removing and Installing. Refer to ⇒ A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page
64 .
12 - Bolt
❑ 2 Nm
13 - Antenna Amplifier -R24-
❑ Removing and Installing. Refer to ⇒ A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page
64 .
14 - Bolt
❑ 2 Nm
15 - Antenna Amplifier 3 -R112-
❑ Removing and Installing. Refer to ⇒ A4.3.2 ntenna Amplifier 3R112, Removing and Installing”, page
65 .
16 - Nut
❑ Quantity: 1 on each side
4. Antenna Systems 61
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
❑ 3.5 Nm
17 - Nut
❑ Quantity: 2 on each side
❑ 3.5 Nm
18 - Bracket
19 - Bumper Antennas
- Telephone Antenna -R65-
❑ Under the rear bumper cover on the right side, 9ZE and EL3/IW1
❑ Removing and Installing. Refer to ⇒ A4.12 ntennas, Removing and Installing”, page 74 .
- LTE Antenna 1 -R297-
❑ Under the left rear bumper cover, EL3 and IW1
❑ Removing and Installing. Refer to ⇒ A4.12 ntennas, Removing and Installing”, page 74 .
- LTE Antenna 2 -R306-
❑ Under the left rear bumper cover, EL3 andProtected
IW0 by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
❑ Removing and Installing. Refer to ⇒ A4.12 ntennas, Removing
with respect to the correctnessand Installing”,
of information page 74
in this document. .
Copyright by AUDI AG.
20 - Nut
❑ 9 Nm
21 - Nut
❑ Quantity: 2
❑ 9 Nm
22 - Windshield Antenna Suppression Filter -C18-
❑ Removing and Installing. Refer to ⇒ W4.4 indshield Antenna Suppression FilterC18, Removing and
Installing”, page 66 .
23 - LTE Antenna 2 -R306-
❑ EL3 and IW1
❑ Removing and Installing. Refer to ⇒ A4.8.2 ntennas, Removing and Installing, before Product Improve‐
ment, only Russia (Not for North American Market)”, page 70 .
4. Antenna Systems 63
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
4. Antenna Systems 65
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
4. Antenna Systems 67
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
4. Antenna Systems 69
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
4. Antenna Systems 71
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
4. Antenna Systems 73
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
– Remove the left rear seat belt guide. Refer to ⇒ Body Interi‐
or; Rep. Gr. 69; Seat Belts; Rear Seat Belt Guide, Removing
and Installing.
– Disconnect the connector -4-.
4. Antenna Systems 75
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
– Loosen the bolt -2- several turns and remove the antenna
amplifier -1-.
Wireless Data Transmission Antenna -R336-, Installing
Install in reverse order of removal.
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the right C-pillar trim panel. Refer to ⇒ Body Interi‐
or; Rep. Gr. 70; Vehicle Interior Trim Panels; C-Pillar Trim
Panel, Removing and Installing.
– Disconnect the connectors -3-.
4. Antenna Systems 77
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Press the tabs in the direction of -arrow A- and pivot out the
control module -1- in the direction of -arrow B-.
Installing
Install in reverse order of removal.
4. Antenna Systems 79
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
5 Radio
⇒ -5.1 Radio”, page 80
⇒ L5.2 ocation Overview - Radio”, page 80
⇒ R5.3 emoving and Installing”, page 80
⇒ R5.4 adio/Satellite Radio, Removing and Installing”, page 80
6 Telephone System
⇒ -6.1 Telephone”, page 81
⇒ L6.2 ocation Overview - Telephone System”, page 91
⇒ -6.3 Microphone Unit”, page 94
⇒ a6.4 nd Right Front Microphone R140/R141, Removing and
Installing”, page 96
⇒ C6.5 ellular Telephone AmplifierR86, Removing and Instal‐
ling”, page 97
⇒ B6.6 aseplate, Removing and Installing”, page 98
6. Telephone System 81
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Antennas
9ZX - Bluetooth hands-free calling without Audi connect EL0:
♦ There are no antennas installed.
9ZX - Bluetooth hands-free calling with Audi connect EL3:
♦ No antenna is installed for the telephone function.
♦ The LTE Antenna 1 -R297- and the LTE Antenna 2 -R306- is
installed for data transmission.
Overview Antennas
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
2 - Not Installed
3 - Not Installed
4 - Right Bumper Antenna
❑ Not Installed
5 - Left Bumper Antenna
❑ LTE Antenna 2 -
R306-, EL3 and
IW0/IW3/IW5/IV0 (for
IV1 through IV6 under
the center front instru‐
ment panel)
❑ LTE Antenna 1 -R297-,
EL3 and IW1/IV1
through IV6
6 - LTE Antenna 2 -R306-
❑ EL3 and IW1
7 - Roof Antenna -R216-
❑ LTE Antenna 1 -
R297-, EL3 and
IW0/IW3/IW5/IV0
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
6. Telephone System 83
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Antennas
9ZE by
Protected - Audi phone
copyright. Copyingbox without
for private Audi connect
or commercial purposes, inEL0:
part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
♦ The Telephone Antenna -R65- in installed for phone func‐
with respect to the correctness of information in this document. Copyright by AUDI AG.
tion.
♦ There are no LTE antennas installed for data transmission.
9ZE - Audi phone box with Audi connect EL3:
6. Telephone System 85
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
1 - Information Electronics
Control Module 1 -J794-
2 - Telephone Baseplate -
R126-
3 - Cellular Telephone Ampli‐
fier -R86-
4 - Right Bumper Antenna
❑ Telephone Antenna
-R65-, EL3/IW1/IV1
through IV6
5 - Left Bumper Antenna
❑ LTE Antenna 2 -
R306-, EL3 and
IW0/IW3/IW5/IV0 (for
IV1 through IV6 under
the center front instru‐
ment panel)
❑ LTE Antenna 1 -R297-,
EL3 and IW1/IV1
through IV6
6 - LTE Antenna 2 -R306-
❑ EL3 and IW1
7 - Roof Antenna -R216-
❑ Telephone Anten‐
na -R65-,
EL0/IW0/IW3/IW5/IV0
❑ LTE Antenna 1 -
R297-, EL3Protected
and by copyright. Copying for private or commercial purposes, in part or in whole, is not
IW0/IW3/IW5/IV0
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
6. Telephone System 87
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Antennas
9ZV - Audi phone box light without Audi connect EL0:
♦ There are no antennas installed.
9ZV - Audi phone box light with Audi connect EL3:
♦ No antenna is installed for the telephone function.
♦ The LTE Antenna 1 -R297- and the LTE Antenna 2 -R306- is
installed for data transmission.
Overview Antennas
6. Telephone System 89
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
1 - Information Electronics
Control Module 1 -J794-
2 - Telephone Baseplate -
R126-
3 - Not Installed
4 - Right Bumper Antenna
❑ Not Installed
5 - Left Bumper Antenna
❑ LTE Antenna 2 -
R306-, EL3 and
IW0/IW3/IW5/IV0 (for
IV1 through IV6 under
the center front instru‐
ment panel)
❑ LTE Antenna 1 -R297-,
EL3 and IW1/IV1 Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
through IV6 permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
The Left Front Microphone -R140- and the Right Front Micro‐
phone -R141- are installed in the Front Roof Module -WX3-.
The Mobile Device Charger 1 -J1146- (Audi phone box light)
is installed in the multimedia device storage compartment. The
Mobile Device Charger 1 -J1146- is only equipped with a mod‐
ule for wireless charging of the corresponding Cellular Tele‐
phone -R54-.
9ZV - Audi Phone Box Light
6. Telephone System 91
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - Left Front Microphone -
R140-
❑ Microphone unit over‐
view. Refer to ⇒
-6.3.2 Microphone
Unit, from Product Im‐
provement”, page 95 .
❑ Removing and Instal‐
ling. Refer to ⇒ a6.4 nd
Right Front Microphone
R140/R141, Removing
and Installing”, page
96 .
3 - Right Front Microphone -
R141-
❑ Microphone unit over‐
view. Refer to ⇒
-6.3.2 Microphone
Unit, from Product Im‐
provement”, page 95 .
❑ Removing and Instal‐ Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
ling. Refer to ⇒ a6.4 nd permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
Right Front Microphone with respect to the correctness of information in this document. Copyright by AUDI AG.
R140/R141, Removing
and Installing”, page
96 .
4 - Bluetooth Antenna -R152-
❑ In the Roof Antenna -R216-
❑ Removing and Installing. Refer to ⇒ A4.5 ntenna, Removing and Installing”, page 66 .
5 - Wireless Data Transmission Antenna 2 -R366-
❑ ER5
❑ Removing and Installing. Refer to ⇒ W4.16 ireless Data Transfer Antenna 2R366, Removing and
Installing”, page 77 .
6 - Antenna Amplifier -R24-
❑ For Wireless Data Transfer Antenna 2 -R366- (window antennas), excluding ER5
❑ Removing and Installing. Refer to ⇒ A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page
64 .
7 - Cellular Telephone Amplifier -R86-
❑ In the rear luggage compartment on the upper right side
❑ Removing and Installing. Refer to ⇒ C6.5 ellular Telephone AmplifierR86, Removing and Installing”,
page 97 .
8 - Antenna Amplifier 2 -R111-
❑ For Wireless Data Transfer Antenna -R336- (window antennas), excluding ER5
❑ Removing and Installing. Refer to ⇒ A4.3.1 mplifiers R24/R111/R84, Removing and Installing”, page
64 .
9 - LTE Antenna 3 -R330-
6. Telephone System 93
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
❑ Removing and Installing. Refer to ⇒ A4.12 ntennas, Removing and Installing”, page 74 .
10 - Wireless Data Transmission Antenna -R336-
❑ ER5
❑ Removing and Installing. Refer to ⇒ W4.15 ireless Data Transfer AntennaR336, Removing and Instal‐
ling”, page 76 .
11 - Mobile Device Charger 1 -J1146-
❑ In the center console storage compartment
❑ Removing and Installing. Refer to ⇒ M6.6.2 obile Device Charger 1J1146, Removing and Installing”,
page 99 .
12 - Control Module for Emergency Call Module and Communication Unit -J949-
❑ Under the left front seat
❑ Removing and Installing. Refer to ⇒ C14.3 ontrol Module for Emergency Call Module and Communica‐
tion UnitJ949, Removing and Installing”, page 160 .
6. Telephone System 95
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
96 .
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the service cover from the right luggage compart‐
ment side trim panel. Refer to ⇒ Body Interior; Rep. Gr. 70;
Luggage Compartment Trim Panels; Overview - Luggage
Compartment Side Trim Panel.
– Disconnect the connectors -1-.
6. Telephone System 97
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
The rubber lip on the surface on which the Removal Tool for
Coupling - Aerial -T40388- was inserted must be slightly press‐
ed out.
– Push the rubber lip using the Removal Tool for Coupling -
Aerial -T40388- -A- carefully to the side and guide in the
Removal Tool for Coupling - Aerial -T40388- vertically from
above.
– The catch -2- is released and engages in the groove on the
Removal Tool for Coupling - Aerial -T40388- -A-.
– Remove the Removal Tool for Coupling - Aerial -T40388-
-A- vertically upward and remove the Telephone Baseplate
-R126- -1-.
– The Telephone Baseplate -R126- is clipped on the opposite
side. Tilt the Telephone Baseplate -R126- -1- out of the stor‐
age compartment.
– Disconnect the connectors.
Installing
Install in reverse order of removal.
6. Telephone System 99
Audi Q5 2017 ➤, Audi Q5 China 2019 ➤
Communication - Edition 10.2021
The rubber lip on the surface on which the Removal Tool for
Coupling - Aerial -T40388- was inserted must be slightly press‐
ed out.
– Push the rubber lip using the Removal Tool for Coupling -
Aerial -T40388- -A- carefully to the side and guide in the
Removal Tool for Coupling - Aerial -T40388- vertically from
above.
– The catch -2- is released and engages in the groove on the
Removal Tool for Coupling - Aerial -T40388- -A-.
– Pull the Removal Tool for Coupling - Aerial -T40388- -A-
vertically upward and remove the Mobile Device Charger 1
-J1146- -1-.
– The Mobile Device Charger 1 -J1146- is clipped in on the
opposite side. Pivot the Mobile Device Charger 1 -J1146- -1-
out of the storage compartment.
– Disconnect the connectors.
Installing
Install in reverse order of removal.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
7 Navigation System
⇒ -7.1 Navigation System”, page 101
⇒ L7.2 ocation Overview - Navigation System”, page 101
⇒ S7.3 ystem Control Module, Removing and Installing”, page
104
⇒ C7.4 ard Reader Control Module, Removing and Installing”,
page 105
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - GPS Antenna -R50-
❑ In the Roof Antenna -
R216-
❑ Removing and Instal‐
ling. Refer to ⇒
A4.5 ntenna, Removing
and Installing”, page
66 .
3 - Multimedia System Control
Head -E380-
❑ In the center console
❑ Removing and Instal‐
ling. Refer to ⇒ M2.5 ul‐
timedia System Control
HeadE380, Removing
and Installing”, page
23 .
4 - Front Information Display
Control Head -J685-
❑ Inside the center of the
instrument panel
❑ Removing and Instal‐
ling. Refer to ⇒
S2.3.1 ystem Display,
Removing and Instal‐
ling, before Product Im‐
provement”, page 18 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Make sure the tabs on the control module engage into the
trim.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - TV Tuner -R78-
❑ in rear right of luggage
compartment
❑ Removing and Instal‐
ling. Refer to ⇒
T8.3 uner, Removing
and Installing (Not for
North American Mar‐
ket)”, page 110 .
3 - Bracket
4 - Bolt
❑ 3 Nm
5 - Multimedia System Control
Head -E380-
❑ Vehicles Before Prod‐
uct Improvement
❑ In the center console
❑ Removing and Instal‐
ling. Refer to ⇒ M2.5 ul‐
timedia System Control
HeadE380, Removing
and Installing”, page
23 .
6 - Front Information Display
Control Head -J685-
❑ Inside the center of the instrument panel
❑ Removing and Installing. Refer to ⇒ S2.3 ystem Display, Removing and Installing”, page 18 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
The TV Tuner -R78- -1- is located in the bracket -2- behind the
right luggage compartment side trim panel.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Insert two of the Radio Removal Tool -T10057- -A- into the
release slots on the TV tuner -1-.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - Rearview Camera -R189-
❑ With Rearview Camera
System Control Module
-J772-
❑ In the rear lid handle
button.
❑ Removing and Instal‐
ling. Refer to ⇒
R9.3 earview Cam‐
eraR189, Removing
and Installing”, page
115 .
❑ Calibrating. Refer to ⇒
C9.5 amera System,
Calibrating”, page 116 .
3 - Front Information Display
Control Head -J685-
❑ Inside the center of the
instrument panel
❑ Removing and Instal‐
ling. Refer to ⇒
S2.3 ystem Display,
Removing and Instal‐
ling”, page 18 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
must be straight.
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Note
1 - Calibration Tool -
Wheel Center Mountings -
VAS6350/1-
❑ With wheel bolt adapter
and measuring paddle
2 - Calibration Tool -
Wheel Center Mountings -
VAS6350/1-
❑ With wheel bolt adapter
and measuring paddle
3 - Right Catch Bracket
❑ To mount the Spacing
Laser -VAS6350/2- for
the distance measure‐
ment
4 - Plastic Foot
❑ Quantity: 3
❑ Adjustable for adjusting
the horizontal position
of the Calibration Tool
-VAS6350A-
5 - Calibration Tool - Linear
Laser -VAS6350/3A-
❑ With “laser protective
eyewear”
❑ On the Calibration Tool
-VAS6350A-
❑ Refer to ⇒ Calibra‐
tion Tool - Line Laser
-VAS6350/3A- Owner's
Manual for handling.
6 - Calibration Tool - Spacing
Laser -VAS6350/2-
❑ For distance measure‐
ment
❑ Refer to the ⇒ Calibration Tool - Spacing Laser -VAS6350/2A- Operating Instructions for handling.
7 - Level
❑ On the Calibration Tool -VAS6350A-
❑ For checking the horizontal position
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
8 - Left Catch Bracket permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
❑ To mount the Spacing Laser -VAS6350/2- for the distance measurement
9 - Calibration Tool -VAS6350-
❑ Between the catch bracket on the calibration board and the Calibration Tool - Wheel Center Mounting
-VAS6350/1A- - dimension -a-: 1.47 m to 1.90 m (4.82 to 6.23 ft.)
– Twist the plastic feet under the calibration board so that the
air bubble in the level is located exactly in the center of the
indicator -arrow-.
Note
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
– Wear “laser protective eyewear”. with respect to the correctness of information in this document. Copyright by AUDI AG.
Note
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the driver airbag. Refer to ⇒ Body Interior; Rep.
Gr. 69; Driver Side Airbag; Airbag Unit with Igniter, Remov‐
ing and Installing.
– Draw sketches or take pictures of the wire routing in the
steering wheel. This will ensure the original wire routing
when installing.
– Loosen the catches -arrows- with the Trim Removal Wedge
-3409-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
Installing
with respect to the correctness of information in this document. Copyright by AUDI AG.
Tightening Specifications
♦ Refer to ⇒ -10.2 Multifunction Steering Wheel”, page 124
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the front center console storage compartment. Re‐
fer to ⇒ Body Interior; Rep. Gr. 68; Center Console; Front
Center Console Storage Compartment, Removing and In‐
stalling.
– Release the retaining tab -arrow- on both sides.
– At the same time push out the USB Connection 1 -U41- -1-.
Installing
Install in reverse order of removal.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
charging port.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the center console rear trim. Refer to ⇒ Body Interi‐
or; Rep. Gr. 68; Center Console; Center Console Rear Trim,
Removing and Installing.
– Press together the clips -A arrows-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - Multimedia Display Unit 3 -
Y31-/ Multimedia Display Unit
4 -Y32-
❑ On the Multimedia Dis‐
play Unit 3 Bracket -
R315-/ Multimedia Dis‐
play Unit 4 Bracket -
R316-
❑ Removing and Instal‐
ling. Refer to ⇒
M12.3 ultimedia Dis‐
play Unit 3Y31/Multi‐
media Display Unit
4Y32, Removing and
Installing”, page 137 .
3 - Multimedia Display Unit
3 Bracket -R315-/ Multimedia
Display Unit 4 Bracket -R316-
❑ On the left/right front
seat backrest
❑ Removing and Instal‐
ling. Refer to ⇒
M12.4 ultimedia Dis‐
play Unit 3 Bracket
R315/ Multimedia Dis‐
play Unit 4 Bracket
R316, Removing and
Installing”, page 138 .
4 - Left Rear Information Display Control Head Control Module -J648-/ Right Rear Information Display
Control Head Control Module -J649-
❑ On the right/left front seat backrest frame Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
❑ Removing and Installing. Refer to ⇒ L12.5 eft Rear Information
with respect Display
to the correctness Control
of information in thisHead Control
document. CopyrightModu‐
by AUDI AG.
leJ648/Right Rear Information Display Control Head Control ModuleJ649, Removing and Installing”,
page 139 .
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Release the catches -3- on the Multimedia Display Unit 4
Bracket -R316- -2- in the direction of the -arrow A-.by copyright. Copying for private or commercial purposes, in part or in whole, is not
Protected
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Removing and installing on the left and right sides are the
same.
Removing
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
– Remove the backrest cover and cushion. Refer to ⇒ Body
Interior; Rep. Gr. 74; Front Seat Covers and Cushions;
Backrest Cover and Cushion, Removing and Installing.
– Carefully push the Left Rear Information Display Control
Head Control Module -J648- -1- in the direction of the
-arrow A- from the upper eye on the backrest frame.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
13 Peripheral Camera
⇒ -13.1 Peripheral Camera System”, page 141
⇒ L13.2 ocation Overview - Peripheral Camera”, page 142
⇒ P13.3 eripheral Camera Control ModuleJ928, Removing and
Installing”, page 143
⇒ R13.4 ear Peripheral CameraR246, Removing and Installing”,
page 145
⇒ F13.5 ront Peripheral CameraR243, Removing and Instal‐
ling”, page 145
⇒ L13.6 eft Peripheral CameraR244/Right Peripheral Cam‐
eraR245, Removing and Installing”, page 146
⇒ C13.7 amera, Calibrating”, page 146
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Bolt
❑ Quantity: 2
❑ 2 Nm
2 - Right Peripheral Camera -
R245-/Left Peripheral Camera
-R244-
❑ Removing and Instal‐
ling. Refer to ⇒
L13.6 eft Peripheral
CameraR244/Right Pe‐
ripheral CameraR245,
Removing and Instal‐
ling”, page 146 .
❑ Calibrating. Refer to ⇒
C13.7 amera, Calibrat‐
ing”, page 146 .
3 - Bracket
4 - Rear Peripheral Camera
-R246-
❑ Removing and Instal‐
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
ling. Refer to ⇒ unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
permitted
R13.4 ear Peripheral
with respect to the correctness of information in this document. Copyright by AUDI AG.
CameraR246, Remov‐
ing and Installing”,
page 145 .
❑ Calibrating. Refer to ⇒
C13.7 amera, Calibrat‐
ing”, page 146 .
5 - Peripheral Camera Control
Module -J928-
❑ In the luggage compart‐
ment on the left side
❑ Removing and Instal‐
ling. Refer to ⇒
P13.3 eripheral Cam‐
era Control ModuleJ928, Removing and Installing”, page 143 .
❑ Calibrating. Refer to ⇒ C13.7 amera, Calibrating”, page 146 .
6 - Bolt
❑ Quantity: 2
❑ 3 Nm
7 - Front Peripheral Camera -R243-
❑ Removing and Installing. Refer to ⇒ F13.5 ront Peripheral CameraR243, Removing and Installing”,
page 145 .
❑ Calibrating. Refer to ⇒ C13.7 amera, Calibrating”, page 146 .
– Turn off the ignition and all electrical equipment. Set the
ignition key outside of the vehicle.
Vehicles with Digital Sound System Control Module -J525-
– Remove the luggage compartment left side trim panel. Refer
to ⇒ Body Interior; Rep. Gr. 70; Luggage Compartment Trim
Panels; Luggage Compartment Side Trim Panel, Removing
and Installing.
– Digital Sound System Control Module -J525-. Refer to ⇒
M3.3 odule/Digital Sound System Amplifier, Removing and
Installing”, page 36 .
– Remove the bracket for Digital Sound System Control Mod‐
ule -J525-.
Vehicles without Digital Sound System Control Module -J525-
– Remove the service cover from the left luggage compart‐
ment side trim panel. Refer to ⇒ Body Interior; Rep. Gr. 70;
Luggage Compartment Trim Panels; Overview - Luggage
Compartment Side Trim Panel.
Continuation for All Vehicles
– Disconnect the connectors -4-.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
– Remove theauthorised
permitted unless bolts -arrows-.
by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
– Remove the retaining plate -3- from the radiator grille.
– Remove the Front Peripheral Camera -R243- -2- from the
radiator grille.
Installing
Install in the reverse order of removal while noting the following:
– Perform the calibration. Refer to ⇒ C13.7 amera, Calibrat‐
ing”, page 146 .
Tightening Specifications
♦ Refer to ⇒ L13.2 ocation Overview - Peripheral Camera”,
page 142
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
– Remove the Leftunless
permitted Peripheral Camera
authorised by AUDI AG. -R244-
AUDI AG does-1-not
with the or accept any liability
guarantee
bracket -2- with
from the exterior rearview mirror.
respect to the correctness of information in this document. Copyright by AUDI AG.
– Release and disconnect the connector -3- from the Left Pe‐
ripheral Camera -R244- -1-.
– Remove the Left Peripheral Camera -R244- -1- from the
bracket -2-.
Installing
Install in the reverse order of removal while noting the following:
– Perform the calibration. Refer to ⇒ C13.7 amera, Calibrat‐
ing”, page 146 .
Tightening Specifications
♦ Refer to ⇒ L13.2 ocation Overview - Peripheral Camera”,
page 142
Note
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
Note
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794- in
the Glove Compartment
2 - Roadside Assistance But‐
ton -E275- in the Front Roof
Module -WX3-, IW3
3 - Emergency Call Button -
E276- in the Front Roof Mod‐
ule -WX3-, IW1/IW3
4 - Front Microphone in the
Front Roof Module -WX3-
❑ Left Front Microphone -
R140-, IW1/IW3
❑ Right Front Microphone
-R141-, IW3
5 - Emergency Call Module
Speaker -R335- in the Driver
Side Footwell Cover, IW1/IW3
6 - Data Bus On Board Diag‐
nostic Interface -J533- under
the Rear Bench Seat
7 - Antennas
❑ GPS Antenna -R50-
in the Roof Antenna -
R216-
❑ Emergency Call Mod‐
ule Antenna -R263-
in the Roof Antenna -
R216-, IW1 Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
❑ Emergency Call Mod‐ permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
ule Antenna -R263- with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794- in
the Glove Compartment
2 - Right Front Microphone -
R141- in the Front Roof Mod‐
ule -WX3-
3 - Emergency Call Module
Speaker -R335- in the Driver
Side Footwell Cover
4 - Control Module for Emer‐
gency Call Module and Com‐
munication Unit -J949- under
the left front seat
5 - Roof Antenna -R216-
❑ GPS Antenna -R50-
❑ Emergency Call Mod‐
ule Antenna 2 -R322-
6 - Emergency Call Module
Antenna -R263- on the left
rear seat belt guide
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
❑ Telematics Emergency Battery -A16-, Removing and Installing. Refer to ⇒ Maintenance; Booklet 830;
Maintenance; Connected Gateway; Emergency Battery, Replacing.
7 - Emergency Call Module Speaker -R335-
❑ On the driver side footwell cover
❑ Removing and Installing. Refer to ⇒ E14.5 mergency Call Module SpeakerR335, Removing and
Installing”, page 163 .
8 - Bolt
❑ Quantity: 2
❑ 1.5 Nm
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
1 - Information Electronics
Control Module 1 -J794-
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒
I2.4 nformation Elec‐
tronics Control Module
1J794, Removing and
Installing”, page 21 .
2 - Front Roof Module -WX3-
❑ With the Right Front Mi‐
crophone -R141-
❑ Removing and instal‐
ling. Refer to ⇒ Elec‐
trical Equipment; Rep.
Gr. 96; Controls; Front
Interior/Reading Lamp,
Removing and Instal‐
ling.
3 - Roof Antenna -R216-
❑ GPS Antenna -R50-
❑ Emergency Call Mod‐
ule Antenna 2 -R322-
❑ Removing and Instal‐
ling. Refer to ⇒
A4.5 ntenna, Removing
and Installing”, page
66 .
4 - Emergency Call Module
Antenna -R263-
❑ On the left rear seat
belt guide
❑ Removing and Instal‐
ling. Refer to ⇒
C4.11.1 all Module An‐
tennas, Removing and Installing, before Product Improvement, Excluding Russia”, page 71 .
5 - Control Module for Emergency Call Module and Communication Unit -J949-
❑ Under the left front seat
❑ Removing and Installing. Refer to ⇒ C14.3 ontrol Module for Emergency Call Module and Communica‐
tion UnitJ949, Removing and Installing”, page 160 .
❑ Telematics Emergency Battery -A16-, Checking. Refer to ⇒ Maintenance; Booklet 830; Maintenance;
Connectivity Box: Emergency Battery, Replacing.
❑ Telematics Emergency Battery -A16-, Removing and Installing. Refer to ⇒ T14.4.2 elematics Emer‐
gency BatteryA16, Removing and Installing, with Connect PLUS, (IV0 through IV6), through Product
Improvement”, page 161 .
6 - Bracket
❑ Nut: quantity 3
❑ 3.5 Nm
7 - Emergency Call Module Speaker -R335-
❑ On the driver side footwell cover
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
❑ Removing and Installing.
permitted ReferbytoAUDI
unless authorised ⇒ E14.5
AG. AUDImergency Call Module
AG does not guarantee SpeakerR335,
or accept any liability Removing and
Installing”, pagewith 163
respect. to the correctness of information in this document. Copyright by AUDI AG.
8 - Bolt
❑ Quantity: 2
❑ 1.5 Nm
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
❑ Removing and Installing. Refer to ⇒ C4.11.3 all Module Antenna, Removing and Installing, from
Product Improvement”, page 73 .
10 - Control Module for Emergency Call Module and Communication Unit -J949-
❑ Under the left front seat
❑ Removing and Installing. Refer to ⇒ C14.3 ontrol Module for Emergency Call Module and Communica‐
tion UnitJ949, Removing and Installing”, page 160 .
❑ Telematics Emergency Battery -A16-, Checking. Refer to ⇒ Maintenance; Booklet 830; Maintenance;
Connectivity Box: Emergency Battery, Replacing.
❑ Telematics Emergency Battery -A16-, Removing and Installing. Refer to ⇒ T14.4.3 elematics Emer‐
gency BatteryA16, Removing and Installing, with Connect Plus (IV1 through IV9 or JE0 through JE4),
from Product Improvement”, page 162 .
❑ Bracket nut tightening specification: 3.5 Nm
– Release the tab -2- and pivot out the control module -1- in
the direction of -arrow A-.
Installing
Install in reverse order of removal.
Tightening Specifications
♦ Refer to ⇒ L14.2.2 ocation Overview - Mobile Online Serv‐
ices, before Product Improvement, with Connect Plus (IV1 to
IV6)”, page 156
♦ Refer to ⇒ L14.2.3 ocation Overview - Mobile Online Serv‐
ices, from Product Improvement”, page 158
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
14.4permitted Telematics
unless authorised by AUDIEmergency
AG. AUDI AG does not Battery
guarantee or -A16-,
accept any liability
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Installing
Install in reverse order of removal.
Tightening Specifications
Components Tightening Specification
Control Module for Emergency Call 1 Nm
Module and Communication Unit -
J949- Battery Cover Bolt
1 - Exterior Speaker
❑ Behind the bumper
cover, left side panel
❑ Removing and Instal‐
ling. Refer to ⇒ Body
Exterior; Rep. Gr. 63;
Front Bumper; Bumper
Cover, Removing and
Installing.
2 - Exterior Microphones
❑ In the exterior mirror
housings
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
❑ Secured with commer‐ permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
cially available plastic with respect to the correctness of information in this document. Copyright by AUDI AG.
wedge
❑ Removing and Instal‐
ling. Refer to ⇒ Body
Exterior; Rep. Gr. 66;
Exterior Rearview Mir‐
ror; Mirror Trim, Re‐
moving and Installing.
3 - Interior Speaker
❑ In the left footwell cen‐
ter console trim panel
❑ Removing and Instal‐
ling. Refer to ⇒ Body
Interior; Rep. Gr. 68;
Center Console; Front
Footwell Center Con‐
sole Trim Panel, Re‐
moving and Installing.
4 - Emergency -Off- Button
❑ In the glove compart‐
ment
❑ Removing and Instal‐
ling. Refer to ⇒ Body
Interior; Rep. Gr. 68; Storage Compartments and Covers; Glove Compartment, Removing and Instal‐
ling.
5 - Interior Microphone
❑ In the roof module
❑ Removing and installing. Refer to ⇒ Electrical Equipment; Rep. Gr. 96; Controls; Front Interior/Read‐
ing Lamp, Removing and Installing.
6 - Control Panel
❑ In the center console
❑ Removing and Installing. Refer to ⇒ Body Interior; Rep. Gr. 68; Center Console; Center Console
Decorative Trim, Removing and Installing.
7 - Hazard Alarm Control Module
❑ Behind the luggage compartment side trim panel on the right side
❑ Removing and Installing. Refer to ⇒ Body Interior; Rep. Gr. 70; Luggage Compartment Trim Panels;
Luggage Compartment Side Trim Panel, Removing and Installing.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
Please read these WARNINGS and CAUTIONS before proceeding with maintenance and
repair work. You must answer that you have read and you understand these WARNINGS and
CAUTIONS before you will be allowed to view this information.
If you lack the skills, tools and equipment, or a suitable workshop for any procedure described
in this manual, we suggest you leave such repairs to an authorized Audi retailer or other
qualified shop. We especially urge you to consult an authorized Audi retailer before beginning
repairs on any vehicle that may still be covered wholly or in part by any of the extensive
warranties issued by Audi.
Disconnect the battery negative terminal (ground strap) whenever you work on the fuel system
or the electrical system. Do not smoke or work near heaters or other fire hazards. Keep an
approved fire extinguisher handy.
Audi is constantly improving its vehicles and sometimes these changes, both in parts and
specifications, are made applicable to earlier models. Therefore, part numbers listed in this
manual are for reference only. Always check with your authorized Audi retailer parts
department for the latest information.
Any time the battery has been disconnected on an automatic transmission vehicle, it will be
necessary to reestablish Transmission Control Module (TCM) basic settings using the Audi
Factory Approved Scan Tool (ST).
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
Never work under a liftedwith respect to the correctness of information in this document. Copyright by AUDI AG.
vehicle unless it is solidly supported on stands designed for the
purpose. Do not support a vehicle on cinder blocks, hollow tiles or other props that may
crumble under continuous load. Never work under a vehicle that is supported solely by a jack.
Never work under the vehicle while the engine is running.
For vehicles equipped with an anti-theft radio, be sure of the correct radio activation code
before disconnecting the battery or removing the radio. If the wrong code is entered when the
power is restored, the radio may lock up and become inoperable, even if the correct code is
used in a later attempt.
If you are going to work under a vehicle on the ground, make sure that the ground is level.
Block the wheels to keep the vehicle from rolling. Disconnect the battery negative terminal
(ground strap) to prevent others from starting the vehicle while you are under it.
Do not attempt to work on your vehicle if you do not feel well. You increase the danger of
injury to yourself and others if you are tired, upset or have taken medicine or any other
substances that may impair you or keep you from being fully alert.
Never run the engine unless the work area is well ventilated. Carbon monoxide (CO) kills.
Always observe good workshop practices. Wear goggles when you operate machine tools or
work with acid. Wear goggles, gloves and other protective clothing whenever the job requires
working with harmful substances.
Tie long hair behind your head. Do not wear a necktie, a scarf, loose clothing, or a necklace
when you work near machine tools or running engines. If your hair, clothing, or jewelry were to
get caught in the machinery, severe injury could result.
Page 1 of 3
© 2018 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of
this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise,
nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Version 2.0
Cautions & Warnings
Do not re-use any fasteners that are worn or deformed in normal use. Some fasteners are
designed to be used only once and are unreliable and may fail if used a second time. This
includes, but is not limited to, nuts, bolts, washers, circlips and cotter pins. Always follow the
recommendations in this manual - replace these fasteners with new parts where indicated,
and any other time it is deemed necessary by inspection.
Illuminate the work area adequately but safely. Use a portable safety light for working inside or
under the vehicle. Make sure the bulb is enclosed by a wire cage. The hot filament of an
accidentally broken bulb can ignite spilled fuel or oil.
Friction materials such as brake pads and clutch discs may contain asbestos fibers. Do not
create dust by grinding, sanding, or by cleaning with compressed air. Avoid breathing
asbestos fibers and asbestos dust. Breathing asbestos can cause serious diseases such as
asbestosis or cancer, and may result in death.
Finger rings should be removed so that they cannot cause electrical shorts, get caught in
running machinery, or be crushed by heavy parts.
Before starting a job, make certain that you have all the necessary tools and parts on hand.
Read all the instructions thoroughly, do not attempt shortcuts. Use tools that are appropriate to
the work and use only replacement parts meeting Audi specifications. Makeshift tools, parts
and procedures will not make good repairs.
Catch draining fuel, oil or brake fluid in suitable containers. Do not use empty food or
beverage containers that might mislead someone into drinking from them. Store flammable
fluids away from fire hazards. Wipe up spills at once, but do not store the oily rags, which can
ignite and burn spontaneously.
Use pneumatic and electric tools only to loosen threaded parts and fasteners. Never use these
tools to tighten fasteners, especially on light alloy parts. Always use a torque wrench to tighten
fasteners to the tightening torque listed.
Keep sparks, lighted matches, and open flame away from the top of the battery. If escaping
hydrogen gas is ignited, it will ignite gas trapped in the cells and cause the battery to explode.
Be mindful of the environment and ecology. Before you drain the crankcase, find out the
proper way to dispose of the oil. Do not pour oil onto the ground, down a drain, or into a
stream, pond, or lake. Consult local ordinances that govern the disposal of wastes.
The air-conditioning (A/C) system is filled with a chemical refrigerant that is hazardous. The
A/C system should be serviced only by trained automotive service technicians using approved
refrigerant recovery/recycling equipment, trained
Protected by copyright.inCopying
related safety
for private precautions,
or commercial purposes,and familiar
in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with regulations governing the discharging and disposal of automotive chemical refrigerants.
with respect to the correctness of information in this document. Copyright by AUDI AG.
Before doing any electrical welding on vehicles equipped with anti-lock brakes (ABS),
disconnect the battery negative terminal (ground strap) and the ABS control module
connector.
Do not expose any part of the A/C system to high temperatures such as open flame.
Excessive heat will increase system pressure and may cause the system to burst.
Page 2 of 3
© 2018 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of
this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise,
nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Version 2.0
Cautions & Warnings
When boost-charging the battery, first remove the fuses for the Engine Control Module (ECM),
the Transmission Control Module (TCM), the ABS control module, and the trip computer. In
cases where one or more of these components is not separately fused, disconnect the control
module connector(s).
Some of the vehicles covered by this manual are equipped with a supplemental restraint
system (SRS), that automatically deploys an airbag in the event of a frontal impact. The airbag
is operated by an explosive device. Handled improperly or without adequate safeguards, it can
be accidentally activated and cause serious personal injury. To guard against personal injury
or airbag system failure, only trained Audi Service technicians should test, disassemble or
service the airbag system.
Do not quick-charge the battery (for boost starting) for longer than one minute, and do not
exceed 16.5 volts at the battery with the boosting cables attached. Wait at least one minute
before boosting the battery a second time.
Never use a test light to conduct electrical tests of the airbag system. The system must only
be tested by trained Audi Service technicians using the Audi Factory Approved Scan Tool (ST)
or an approved equivalent. The airbag unit must never be electrically tested while it is not
installed in the vehicle.
Some aerosol tire inflators are highly flammable. Be extremely cautious when repairing a tire
that may have been inflated using an aerosol tire inflator. Keep sparks, open flame or other
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
sources of ignition away from the tire repair area. Inflate and unless
permitted deflate the tire
authorised at least
by AUDI AG. AUDIfour times
AG does not guarantee or accept any liability
before breaking the bead from the rim. Completely remove the tire
with respect from
to the the rim
correctness beforein this document. Copyright by AUDI AG.
of information
When driving or riding in an airbag-equipped vehicle, never hold test equipment in your hands
or lap while the vehicle is in motion. Objects between you and the airbag can increase the risk
of injury in an accident.
Page 3 of 3
© 2018 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of
this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise,
nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.
Version 2.0