Professional Documents
Culture Documents
Level 3 Repair: 8-1. Block Diagram
Level 3 Repair: 8-1. Block Diagram
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
ROSSA_TM O/ M PCS Block Diagram Confident ial
Ver 2015.05.22
BT/ WIFI BT_SSBI
WCN3620 WLAN_BBIQ
DATA[0:7]/ DQ[0:31] 8GB eM M C + 8Gb LPDDR3
CLK/ CM D/ RST
UME500
M IPI_DSI_2lane 4.5" WVGA TFT LCD + TSP
HDC600
SAW
GNSS LNA
MXDLN16U
SAW
WTR_GNSS_N
GPS TSP_I2C
GSM850/ 900/ 1800/ 1900 Tx/ Rx
LCD Backlight IC
WCDMA2/ 5 Tx/ Rx WTR_PDET U601 26V
LTE B2, B4, B5, B12 Tx/ Rx WTR_TX_B2/ 4
TX_B2_PA_OUT _GSM1800/ 1900
Coupling TX_B4_PA_OUT M IPI_CSI_1lane 2M Cam/ Proxi. Sensor
M M M B PA CAM , SENSOR_I2C
LPF TX_B5_PA_OUT (BAND2/ 4/ 5/ 12 WTR_TX_B5 HDC601
LPF _GSM850/ 900
TX_B12_PA_OUT GSM QUAD)
WTR_GNSSBBIQ M IPI_CSI_2lane M AIN CAM (5M )
TX_GSMLB_PA_OUT SAW WTR_TX_B12 CAM _I2C SLC600
HRPF59627BTB
TX_GSMHB_PA_OUT
SENSOR_I2C Accel. Sensor
Coupler WTR_GPDATA0 ACC_INT U602 (K2HHTR)
LDJ18829M24AD M ain FEM iD RFFE1_DATA RFFE1_DATA
011 (BAND2/ 4/ 5/ 12
RFFE1_CLK RFFE1_CLK UIM _RST/ CLK/ DATA
GSM QUAD) SIM / SD Card Conn.
TRX WTR_TXBBIQ M SM 8916 SDC3_CM D/ CLK/ DET
SIM600 (104168-1656)
LMSWKHGR-G95 SDC3_DATA[0:3]
WTR_PRX_B4 WTR4905 (UCP300)
8-1
M OTOR_EN
WTR_PRX_B2_GSMHB M OTOR
WTR_PRX_B5_GSM850 WTR_PRXBBIQ
HOM E_KEY
WTR_PRX_GSM900 Quad 1.2GHz HOME KEY
WTR_PRX_B12 VOLUM E_UP
Cort ex-A53 VOL. UP KEY
WTR_DRXBBIQ
512kB L2 cache PHONE_ON_N POWER KEY
VOLUM E_DOWN
VOL. Down KEY
WCDMA2/ 5 Rx Di versit y
LTE B2, B4, B5, B12 Rx Diversit y BATT_UIM _ALARM
RCV
SPK
WTR_DRX_B5_LNA
WTR_DRX_B2_LNA PDM _CLK/ SYNC/ TX
PM IC M AIN MIC
SUB FEM id
HFQRXEJGC-203 WTR_DRX_B4_LNA PDM _RX0/ 1/ 2 U400 (PM 8916)
SUB MIC
WTR_DRX_B12_LNA
M SM _RESIN_N 4 bucks / 20 LDOs Ear MIC
M SM _PS_HOLD 1 Boost EAR_ADC_3.5
PM IC_SPM I_CLK 4 GPIOs EAR_3.5_DET
HPH_REF
PM IC_SPM I_DATA Inner Codec EAR_3.5_DET
XO_THERM
GND_REF
PA_THERM
M AIN_THERM
DI _TT AB
8. Level 3 Repair
FG_ALERT
FG_I2C
IF_PM IC_I2C, INT
Charger IC
ES NES_T ABV
GF_ES NES_T ABV
(RT5033A)
FLASH_EN, TORCH_EN
Fuel Gauge
Flash LED
8-1. Block Diagram
T NI , C2I _ CI U M
P/ M_ D_S H_ BS U
Flash LED Drive
DXR_T RA U
DXT_T RA U
1 buck, 1 LDO
JIG_ON_N * PM IC
M UIC USB_ID/ DP/ DM USB Conn. Bat t ery Conn.
(U404) (IFC400) (BTC400)
Level 3 Repair
CON102
ZD511
R532
C546
ZD506
CON104
C649
R622
C648
C644
C645
ZD513 ZD514
R523
L503
ZD500 C539 C540
C643
L518 L519
C536 C537
F603
L139 C198
C609 C647
C624
ZD502
ZD501
CON105
R314
C611
SLC600
C610
R313
U602
C625
C607 C535 C534
F604
C623
C641
L601
C642
T P_ MIPI_ T X_ CP
F601
TP_601
TP_ACC_INT
T P_ MIPI_ T X_ CN
R623
T P_ MIPI_ T X_ DN6 0 0
C448
C600
U401
F602
C602
T P_ MIPI_ T X_ DP6 0 0
C449
T P_ MIPI_ T X_ DN6 0 1
C601
R600
ZD515
F600
T P_ MIPI_ T X_ DP6 0 1
C608 R508 L517 C640
ZD600
R414
U402
U500
R500
C512
C464
C511
R505
C317
C463
L502
R507
C638
C604
C639
L600
R601
CON100
U600
C603
C618
TP_UB
R504 R503 C617
C630
C305
C315
R310
R607
R611
C304
R612
R610
R345
TAC501 R306 C392
L300 C306
R341
R337
TP415
R305 R304 C312 C311 C300 C313
C523
TP_WCSS_WLAN_CLK
C515
TP_WCSS_WLAN_DATA
C514
UCP300
C503
C502
C524
UME500
CON103
C412
SC104
C485
TP414
C129
C125
C130
TP402
F103
C183
C148
C145
C147
TP302
F105
TP401
C182 L137 C303
C513
C525
R514
R518
R519
R515
R323
R511
R517
R513
R516
R512
R510
C526
C527
C136
C138
C137
VR400
C146 C126
TP301
U106
C113
L141
C391
C390
C387
R332
R312
R333
R338
R339
R302
R301
C301
C302
R300
C389
C388
R336
R340
C542
SC101
C439 D401
D400
TP405
TP300
C541
R330
R331
R311
R342
R343
C451
C385
C455
C460
R418
R315
R316
R417
C633
R335
C335
R334
C447
R421
R404
R411
U100
C461
C179
C482
L153
R329
C453
TP404
R524
R105 R423 C318 C452
TAC502
C181
C456
C185
SC105
L143
L140
L152
C196
R103 R424
C458
R106
TAC500
L407
C473
F101
U405
C457
L408
C462
C481
BTC400
TP413 TP410
C110
R427 C467
U404
R416 C476
C474
TP409
C459
R413
R107
R420
C116
C122 C109
C465
TP407
TP411
TP403
C469
C470
CON109
CON101
C408
R402
R401
CON107
CON106
CON108
FG102 FG103
ZD403
C487
ZD404 R425
R426
ZD402
ANT500
ANT503
ANT502
ANT501
C549
C554
R535
C551
L513
L514
MIC500
IFC400
8-2
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-2-2. Bottom
MIC501
BH401
L145
C155
L127
ANT102 C150
HDC500
ANT103
C184
TP102 HDC601
ANT201
C188
F104
C186
L520
L521
L525
L524
C187
ZD507 ZD508
L148 TP_600
C548 C547
TP103
L523 C559
R533
R531
L522
C560 ZD503
C562
C552
L512
L510
C561
LED400
C557
L511 R536
L515
C544 C543
R534 R539
L505
C222
C228
L204
C428
R501
TP_LCD_CLK
C151
C229
TP_VGH C152 L130
TP_LCD_D
L210
L132
L128
C195
C212
TP_FLM
U103
U205
L150 C197
C172 C160
C230
C213
C190 L149
C199
L151 C171
C223
L205
R348
R349
R350
C153
C173
C174
C156 BH402 U202
R529
R527
C545
L211
R530
TP_BL L508
C516
C517
C520
C510
C372
R604
R603
R602
C508
C622
U601
C327
C328
C324
C320
C319
C326
C522
C521
C519
C518
BAT400
R605
C621
R606
L604
C605
R616
R615
R617
R614
R618
R624
C321
C504
C505
C507
C506
C509
C431
C430
C486
C322
C413
C419
C620 C323
C371
R407
C421
R408
C325
C619
C370
C411
L602
L603
C378
C379
C380
C381
OSC400 C369
R403
C375
C410
C346
C414
C203
C225
C219
C220
C550
ANT200
C376
C202
C382
C422
C418
C207 C208
C416
C345
C438
C383
C377
L400
C435
C434
SC103
C206
C344
C204
C373
L209
C374
L200
C218
C211
C226
C433
C409
L203
U400
C336
C352
C350
C349
C348
C347
C205 C227
U204
L402
L207
C232
C217
C221
C445
C200
TP400
L401
F201
C214
C210
C354
C353
C351
C314
C443
C215 L202 L206
C444
C432
C339
C342 C343
L147
C165
C341
C368
C367
C366
C365
C216
C164 C170
L403
C167
C201
C446
R613 C180
C384
C634
R621
C163
L404
R619
C108 C159
U105
C632
SC106
C637 C386
C169
C401
U102
C107
C553
SIM600
C650
L146
C400
R628
TP406
L201 C106
L208
C436 C417 R400
C423
C426
L109
R409 C406
R428
R406
C427
C404 U603 C134
L111
C437 C403 C402
L133
L135
C407
C193
R630
L115
R629
C158
C429
C118
C636
R405
L118
L120
L102
C405
C440
L144
L405
C652
C140
C441 C442
C154
C177
C168
C162
C192
C415
C484
C420 L122
C189
C175
C191
L134
L131
L123
L136
C127
C209
C231
U101
F200
C128
ZD603
F106
ZD602
HDC603 ZD601
BH403
C111
ZD604
F100
R104
L101 C104
RFS100
BH406
R108
R538
R422 C483
C556
C488 C466
ZD512
C471
BH404
C501
C500
R509 L500
U501
C529
U403
D500
C472
C105
L516
C528
L501 C555
C478 R419 C468
L100 C102 C103
C477
C480
ZD401 L409
C101
TP101
C124 C135
ANT101
C157
ANT100
L106
F102
C133
C123 L116
TP100
TP104
BH400 BH405
8-3
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Equipments
8-4
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-1. Power On
Yes
No
Abnormal
Check the PWR_KEY Resolder or replace TAC500
(soldering crack, open, etc)
Yes
Yes
Change the OSC400.
No If OSC400 does not still work, Change the U400
Check the Clock OSC400
Is that frequency 19.2MHz? This problem is internal oscillator of U400
END
8-5
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
V_LCD_3.0V VREG_1P8_LCD
HDC600
1 1 2 2
3 3 4 4
TP_MIPI_TX_CP
5 5 6 6
TP_ACC_INT 7 7 8 8
TP_FLM 9 9 10 10
LCD_FLM
11 11 12 12
TP_MIPI_TX_DN600
MIPI_DSI0_LANE0_P_F TP_LCD_D 13 13 14 14
15 15 16 16
MIPI_DSI0_LANE0_M_F
17 17 18 18
TP_MIPI_TX_DN601
TP_LCD_CLK 19 19 20 20
MIPI_DSI0_CLK_P_F
21 21 22 22
MIPI_DSI0_CLK_M_F
23 23 24 24
25 25 26 26
MIPI_DSI0_LANE1_P_F
27 27 28 28
MIPI_DSI0_LANE1_M_F
29 29 30 30
NC
NC
NC
NC
31
32
33
34
TP_UB
C603 C601
10V 10V
VBATT_CON
L602
L603
C619
C620
U601
R602
LCD_PWM
2 6
VIN LX
R603 L604
1 3
LCD_BLIC_ON CTRL VOUT LED_P_26V
GND
GND
4
FB LED_N
5 7 R604
C622 C621
R606
R605
VREG_L6_1P8
OSC400
R403
2 1
19.2M_IN 3 4 XO_THERM
19.2M_OUT
6.3V
C421
C422
16V
GND_XOADC
8-6
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-2. Initial
Initial Failure
Yes
Abnormal
Normal
Abnormal
Change PBA
END
8-7
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VDD_GR7
VDD_GR6
VDD_GR5
VREG_L5_1P8
VPH_PWR
BBCLK1_MSM
VREG_L6_1P8
VDD_GR4
VDD_GR1
VDD_GR3
6.3V C300
VDD_GR2
VREG_L7_1P8
WTR_GNSSBBQ_P
BBCLK1_MSM_EN
PMIC_SPMI_DATA
WTR_GNSSBBI_P
JTAG_RESOUT_N
MSM_RESOUT_N
WTR_DRXBBQ_P
WTR_PRXBBQ_P
C400
PMIC_SPMI_CLK
WTR_DRXBBI_P
WTR_PRXBBI_P
WTR_TXBBQ_M
MSM_PS_HOLD
WTR_TXBBQ_P
MSM_RESIN_N
WTR_TXBBI_M
WLAN_BBQ_M
WLAN_BBQ_P
JTAG_TRST_N
WTR_TXBBI_P
VPH_PWR
USB_HS_D_M
USB_HS_D_P
BBCLK1_MSM
WLAN_BBI_M
WLAN_BBI_P
SLEEP_CLK
6.3V
VREF_DAC
JTAG_TMS
JTAG_TDO
JTAG_TCK
JTAG_TDI
C401 VREG_S4_1P85
10V
VDD_S4
VDD_S2
VDD_S3
VDD_S1
R303
R300
6.3V
VREG_L5_1P8
C301
C302
1%
1%
TP300
10V
C404
6.3V
C402 C403
BAT400
BD11
BC14
AU22
AC40
AD35
AC38
AR14
AR12
AU14
BE12
BB13
BD25
BC24
AU26
AR26
AB39
USB_HS_DP AA40
AP15
AP13
BA26
AY27
BE26
BE24
AY23
BB23
BC20
BD15
AU32
AK37
AT23
BD21
BC16
BB15
BE20
BA18
BE14
BB17
AT31
AY19
BB21
BA20
AF33
AT11
AL34
AJ36
AH5
AV1
G36
E36
A36
F35
C405
M1
M3
K3
K1
L2
J2
1
2
TX_DAC1_QP
TX_DAC0_VREF
TX_DAC1_IREF
TX_DAC1_VREF
USB_HS_REXT
VDD_MIPI_DSI_PLL
WLAN_REXT
TRST_N
TX_DAC1_IM
USB_HS_ID
GNSS_BB_IP
GNSS_BB_QP
MARK
MARK
USB_HS_DM
GNSS_BB_IM
GNSS_BB_QM
RESIN_N
RESOUT_N
SRST_N
TMS
TX_DAC0_IP
TX_DAC0_QP
TX_DAC1_IP
TX_DAC0_IREF
USB_HS_SYSCLOCK
TDI
TDO
TX_DAC0_IM
TX_DAC0_QM
TX_DAC1_QM
MODE_0
MODE_1
TCK
CXO
CXO_EN
PS_HOLD
WLAN_BB_IP
WLAN_BB_QP
WLAN_BB_IM
WLAN_BB_QM
PMIC_SPMI_CLK
PMIC_SPMI_DATA
VDD_P7
VDD_P3
BBRX_IP_CH1
BBRX_IP_CH2
BBRX_QM_CH0
BBRX_QM_CH1
BBRX_QM_CH2
BBRX_QP_CH0
BBRX_QP_CH1
BBRX_QP_CH2
SLEEP_CLK
BBRX_IM_CH0
BBRX_IM_CH1
BBRX_IM_CH2
BBRX_IP_CH0
6.3V
G14
C11
C12
H13
D12
A13
M12
BA38
N12
P12
L11
M6
E10
M5
M2
M3
N5
N6
GPIO_0
C6
C7
P5
P6
A7
B7
N2
N1
N9
B1
B2
A6
B6
P9
E1
E2
LPDDR3_CA(0) E8
EBI0_CA_0 BB39
GPIO_1
LPDDR3_CA(1) C6
EBI0_CA_1 AV35
MUIC_I2C_SDA
VDD_CP
VDD_CP
VDD_AUDIO_IO
GPIO_2
VDD_HPH
VDD_S4
VDD_S4
VDD_S4
VDD_CDC_VBAT
VDD_S1
VDD_S2
VDD_S2
VDD_S2
VDD_S3
VDD_S3
VDD_S3
VDD_EAR_SPKR
VDD_L9_10_12_13_17_18
VDD_L9_10_12_13_17_18
VDD_S1
VDD_S1
VDD_L8_11_14_15_16
VDD_L8_11_14_15_16
VDD_L7
VCOIN
VDD_XO_RFCLK
VDD_L2
VDD_L4_5_6
VDD_L4_5_6
GND_CP
VDD_L1_3
LPDDR3_CA(2) EBI0_CA_2
VBAT_SNS
VBAT
VBAT
D9 AY37
LPDDR3_CA(3) EBI0_CA_3 GPIO_3
AT9
MUIC_I2C_SCL
E6 GPIO_4 UART_TXD
LPDDR3_CA(4) B13
EBI0_CA_4
GPIO_5
AY1
UART_RXD
LPDDR3_CA(5) C12
EBI0_CA_5 AY3
LPDDR3_CA(6) EBI0_CA_6 GPIO_6
AV3
SENSOR_I2C_SDA
D13 GPIO_7 SENSOR_I2C_SCL
LPDDR3_CA(7) EBI0_CA_7 H5
B11 GPIO_8 PROXY_LDO_EN
LPDDR3_CA(8) E14
EBI0_CA_8 G2
P2 LPDDR3_CA(9) EBI0_CA_9 GPIO_9 HW_REV2
J7 GPIO_1_UIM_BATT_ALM VREG_L1 R310 F11 GPIO_10
H1
BATT_UIM_ALARM H6 VREG_L2
M1 C10
EBI0_CAL_REXT
GPIO_11
E2
GPIO_2_NFC_CLK_REQ LPDDR3_CKP 1% D11
EBI0_CK AM39
N11 P1 LPDDR3_CKM EBI0_CKB GPIO_12
AM35
MUIC_INT
GPIO_3_WTR_LDO_EN VREG_L3 A8 GPIO_13 TSP_INT
L8 M10 LPDDR3_CKE0 A10
EBI0_CKE_0 AN40
GPIO_4_EXT_BUCK_EN VREG_L4 LPDDR3_CKE1 EBI0_CKE_1 GPIO_14
AN36
FG_I2C_SDA
M9 B7 GPIO_15 FG_I2C_SCL
VREG_L4 LPDDR3_CS0 B9
EBI0_CS_N_0 K7
P10 LPDDR3_CS1 EBI0_CS_N_1 GPIO_16 G6 5M_CAM_STBY
L4 VREG_L5 F23 GPIO_17 2M_CAM_STBY
VDD_PX_BIAS_MPP1 MPP_1_VDD_PX_BIAS M8 LPDDR3_DM(0) EBI0_DM_0 J6
K4 VREG_L6 LPDDR3_DM(1)
E24
EBI0_DM_1 GPIO_18 TSP_I2C_SDA
EAR_ADC_3.5 MPP_2_HR_LED_SNK L3 B19 GPIO_19
J4
TSP_I2C_SCL
J4 VREG_L7 LPDDR3_DM(2) B31
EBI0_DM_2 AY7
VREF_DAC MPP_3_VREF_DAC F1 LPDDR3_DM(3) EBI0_DM_3 GPIO_20
AW6
J5 VREG_L8 E20 GPIO_21
AP_THERM MPP_4_WLED_PWM C1 LPDDR3_DQ(0) EBI0_DQ_0 AV7
LPDDR3_DQ(1)
E22
EBI0_DQ_1 GPIO_22 IF_PMIC_I2C_SDA
VREG_L9 A20 BA2
D4 EBI0_DQ_2 GPIO_23 IF_PMIC_I2C_SCL
J1 VREG_L10 LPDDR3_DQ(2) D21 GPIO_24
AT5
LCD_FLM
19.2M_IN XTAL_19M_IN G3 LPDDR3_DQ(3) EBI0_DQ_3 AU4
H2 B21 GPIO_25 MIPI_DSI0_RESET_N
XTAL_19M_OUT VREG_L11 LPDDR3_DQ(4) EBI0_DQ_4
VREF_BAT_THERM 19.2M_OUT L1 VREG_L12
B3 LPDDR3_DQ(5)
D23
EBI0_DQ_5 GPIO_26
H3
C2
CAM_MCLK0
RFCLK1_19.2M RF_CLK1 D3
B23 GPIO_27 VT_CAM_MCLK
TP400 L2 LPDDR3_DQ(6) A24
EBI0_DQ_6
GPIO_28
F1
CAM2_RST_N
RF_CLK2 VREG_L13 LPDDR3_DQ(7) EBI0_DQ_7
RFCLK2_WLAN F2 G2
LPDDR3_DQ(8)
E28
EBI0_DQ_8 GPIO_29
B3
CAM_I2C_SDA
BB_CLK1 VREG_L14 F3
VREF_XO_THM BBCLK1_MSM TP401 F3 VREG_L15
G1 LPDDR3_DQ(9)
C26
A26
EBI0_DQ_9 GPIO_30
D3
CAM_I2C_SCL
BB_CLK2 GPIO_31
E3 LPDDR3_DQ(10) EBI0_DQ_10 D1
E4 VREG_L16 LPDDR3_DQ(11)
B29
EBI0_DQ_11 GPIO_32
BBCLK1_MSM_EN BB_CLK1_EN A3 D29 G4
GPIO_33 F5 CAM_CORE_EN
TP402 VREG_L17 LPDDR3_DQ(12) C28
EBI0_DQ_12
GPIO_34 CAM_FLASH_EN
G6 SLEEP_CLK A1 LPDDR3_DQ(13) A30
EBI0_DQ_13 A4
VREG_L18 GPIO_35 CAM1_RST_N
SLEEP_CLK K3 LPDDR3_DQ(14) E30
EBI0_DQ_14
GPIO_36
C4
CAM_TORCH_EN
VREG_RFCLK LPDDR3_DQ(15) B17
EBI0_DQ_15 E4
N14 K1 LPDDR3_DQ(16) EBI0_DQ_16 GPIO_37
B37
MSM_FORCE_USB_BOOT
VREF_BAT_THM VREG_XO B15 GPIO_38 SDC3_DETECT_N
VUSB_FET_5V A2 LPDDR3_DQ(17) A14
EBI0_DQ_17 BC2
LPDDR3_DQ(18) EBI0_DQ_18 GPIO_39 BB5 BT_SSBI
VREF_LPDDR3 VREF_LPDDR
N13
USB_IN
U400 VSW_S1
VSW_S1
B5
A5 LPDDR3_DQ(19)
LPDDR3_DQ(20)
A18
D15
C14
EBI0_DQ_19
EBI0_DQ_20
GPIO_40
GPIO_41
GPIO_42
BB1
BD3
WCSS_WLAN_DATA_2
WCSS_WLAN_DATA_1
WCSS_WLAN_DATA_0
C5 LPDDR3_DQ(21) D17
EBI0_DQ_21 BA6
P13 VSW_S1 LPDDR3_DQ(22) EBI0_DQ_22 GPIO_43
BB3
WCSS_WLAN_SET
USB_IN E5 E16 GPIO_44 WCSS_WLAN_CLK
C410 C2 VREG_S1 LPDDR3_DQ(23) C34
EBI0_DQ_23
GPIO_45
AY5
AVDD_BYP A8 LPDDR3_DQ(24) EBI0_DQ_24 AY9
6.3V C417 P14 VSW_S2 F33 GPIO_46
VPRE_BYP B8 LPDDR3_DQ(25) C36
EBI0_DQ_25 BA4
6.3V LPDDR3_DQ(26) EBI0_DQ_26 GPIO_47 BT_CTL
VSW_S2 D35 GPIO_48
AW8
BT_DATA
C409 K2 C8 LPDDR3_DQ(27) E34
EBI0_DQ_27 Y37
XO_THERM VSW_S2 GPIO_49
XO_THERM F11 PA_THERM VREG_S2
F7 LPDDR3_DQ(28) B35
EBI0_DQ_28
GPIO_50
AA34
LPDDR3_DQ(29) EBI0_DQ_29 Y35
PA_THERM R404 M11 M4 LPDDR3_DQ(30)
A34
EBI0_DQ_30 GPIO_51
AA38
BAT_THERM VSW_S3 B33 GPIO_52
MAIN_THERM N4 LPDDR3_DQ(31) EBI0_DQ_31 L40
UCP300-1
VDD_MIC_BIAS1_1.8V G9 VSW_S3
C24 GPIO_53
BATT_ID BAT_ID P4 LPDDR3_DQSP(0) E26
EBI0_DQS_0 K39
EBI0_DQS_1 GPIO_54
VDD_MIC_BIAS2_2.8V VSW_S3 LPDDR3_DQSP(1) E18 GPIO_55
H39
L12 J8 LPDDR3_DQSP(2) E32
EBI0_DQS_2 AA36
MIC_BIAS1 VREG_S3 GPIO_56
M7 LPDDR3_DQSP(3) B25
EBI0_DQS_3
GPIO_57
G40
UIM1_DATA
J11 VSW_S4 LPDDR3_DQSM(0) EBI0_DQS_0B J40
MIC_BIAS2 N7 D25 GPIO_58 UIM1_CLK
D13 VSW_S4 LPDDR3_DQSM(1) D19
EBI0_DQS_1B L38
GND_CP CP_VNEG EBI0_DQS_2B GPIO_59 UIM1_RST
D14 P7 LPDDR3_DQSM(2) D31 Y39
C423
VSW_S4 GPIO_60
10V
GPIO_90
GND_XOADC
L300 MIPI_DSI0_LANE3_N
GND_BOOST
GND_BOOST
GPIO_91
CP_VNEG MIPI_DSI0_LANE3_P AY33
GND_DRV
GND_REF
GND_CP
MIPI_DSI_LDO
GND_RF
GND_S3
GND_S4
GND_S4
GND_S1
GND_S1
GND_S1
GND_S2
GND_S2
GND_S2
GND_S3
AG6 BD33
MIPI_DSI0_CAL GPIO_93 SWITCHABLE_ANT2
MARK
MARK
BC34
GPIO_94
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
AD37 BB31
GPIO_95
EMMC_DATA(0) AE38
SDC1_DATA_0 BC32
EMMC_DATA(1) SDC1_DATA_1 GPIO_96
C38
GPS_LNA_EN
AG34
1
2
TP301
N10
C13
E14
N3
P3
N8
P8
H3
J13
J12
GPIO_97
C4
C9
J2
J3
H12
D2
A9
B9
G8
G10
H7
H8
H10
H11
K5
K9
L13
A4
B4
D11
E7
E9
G4
G7
J6
D6
D7
D10
B13
A14
EMMC_DATA(2) AH37
SDC1_DATA_2 A38
C440 EMMC_DATA(3) SDC1_DATA_3 GPIO_98
BE34
LCD_BLIC_ON
AG40 GPIO_99 GPDATA
EMMC_DATA(4) AG38
SDC1_DATA_4 BE36
GPIO_100
6.3V EMMC_DATA(5) AF39
SDC1_DATA_5 BB33
GPIO_101
EMMC_DATA(6) AF35
SDC1_DATA_6
GPIO_102
BE32
LCD_LDO_EN
EMMC_DATA(7) P3
SDC1_DATA_7 AT35
R406 SDC3_DATA(0) SDC2_DATA_0 GPIO_103
AW40
RFFE5_CLK
R6 GPIO_104 RFFE5_DATA
SDC3_DATA(1) SDC2_DATA_1
S3_PGND
S4_PGND
S1_PGND
S2_PGND
AU36
GND_CP
T7 GPIO_105 TP302
SDC3_DATA(2) P7
SDC2_DATA_2 AY39
GPIO_106 HW_REV1
BOOST_GND
AE36 GPIO_108
R428 EMMC_CLK SDC1_CLK J34
R409
GPIO_110
SDC3_CLK N6
SDC2_CLK C40
SDC3_CMD SDC2_CMD GPIO_111
AW36
EAR_SWITCH
R306 5%
GPIO_112
D39
GPIO_113
E40
PROXY_INT
GPIO_114
E38
UART_BOOT_ON
GPIO_115
AW38
ACC_INT
GPIO_116
AV37
HW_REV0
GPIO_117
AR36
C392
GPIO_118
BA40
GPIO_119
F39
GND_SPKR
HW_REV3
GND_REF
GND_AUDIO_REF
GPIO_120
G38
GPIO_121 FG_ALERT
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
BC30 DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
AT25 DNC
DNC
DNC
DNC
DNC
DNC
AV21 DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
DNC
P23
P25
G26
H7
H11
H13
H15
H19
H23
H25
H27
H29
H31
M19
P19
D33
D37
F15
F17
F21
G22
BD1
BD9
BD29
BE2
BE40
AW18
AW20
AW22
AW24
AW26
AW28
AW30
AW32
AY15
AY17
AY25
AY29
AY35
B1
BA24
BA30
BA36
BB9
BB29
AU2
AU16
AU18
AU20
AU24
AV23
AV25
AV27
AV29
AV31
AW16
BA14
BA16
AN8
AP3
AP5
AP7
AP25
AT1
AT3
AT17
AT19
AT21
AD23
AD27
AD31
AM5
AM7
AM27
AN2
AN4
AN6
A2
A40
AC6
AD1
AD3
AD5
AJ6
AK3
AK5
AK25
AK27
AL4
AL6
AB11
AB19
AB23
VREG_L6_1P8
OSC400
R403
2 1
19.2M_IN 3 4 XO_THERM
19.2M_OUT
6.3V
C421
C422
16V
GND_XOADC
8-8
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-3. No Service
No service
Yes
PHONE : G360TXXXX
Menu → Phone → Keypad →
*#1234# → check Phone version → Check the Main Antenna exists or not
PHONE : G360TXXXX
Phone : unkwown
No
Check the components of Antenna Resolder the components
Path. Is it ok?
Yes
No
Check C420 > 1.8V Replace the U400
Abnormal
Abnormal
Yes
END
8-9
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VDD_GR7
VDD_GR6
VDD_GR5
VREG_L5_1P8
VPH_PWR
VDD_GR4
VDD_GR1
VDD_GR3
VDD_GR2
C400
6.3V
C401 VREG_S4_1P85
10V VREG_L4_1P8
R400
VDD_S4
VDD_S2
VDD_S3
VDD_S1
BOOST_5V
10V VREG_L2_1P2
C404
6.3V
C403
C405
C406 C407
6.3V VREG_L1_1P0 VREG_L6_1P8
10V 10V VREG_L3_1P15
G14
C11
C12
H13
D12
A13
M12
N12
P12
L11
VREG_L5_1P8
M5
M6
M2
M3
N6
N5
C6
C7
P6
P5
A6
B6
A7
B7
N2
N1
N9
B2
P9
E1
E2
B1
VREG_L7_1P8
VDD_CP
VDD_CP
VDD_S4
VDD_HPH
VDD_S3
VDD_S4
VDD_S4
VDD_AUDIO_IO
VDD_S2
VDD_S2
VDD_S2
VDD_S3
VDD_S3
VDD_EAR_SPKR
VDD_S1
VDD_S1
VDD_CDC_VBAT
VDD_S1
GND_SPKR
VDD_L7
VDD_L9_10_12_13_17_18
VDD_L9_10_12_13_17_18
GND_CP
VDD_L8_11_14_15_16
VDD_L8_11_14_15_16
VCOIN
VDD_L1_3
VDD_L2
VDD_L4_5_6
VDD_L4_5_6
VDD_XO_RFCLK
VBAT_SNS
VBAT
VBAT
BOOST_GND
P2
VREG_L1
M1
VREG_L2
P1
VREG_L3
M10
VREG_L4
M9
VREG_L4
P10
VREG_L5
M8
VREG_L6
L3
VREG_L7
F1
VREG_L8
C1
VREG_L9
D4
VREG_L10
G3
VREG_L11
B3
VREG_L12
D3
VREG_L13
G2
VREG_L14
G1
VREG_L15
E3
VREG_L16
A3
VREG_L17
A1
VREG_L18
K3
VREG_RFCLK
K1
VREG_XO
VREG_S1_1P15 VREG_S3_1P3
U400 VSW_S1
VSW_S1
B5
A5
VREG_S2_1P15 VREG_S4_1P85
6.3V
6.3V
6.3V
C5 L400
VSW_S1 C420 C484
C419
E5
6.3V
VREG_S1
A8
VREG_S1_VSENSE
25V
25V
25V
VSW_S2
B8 L401
VSW_S2
C414
C413
C412
6.3V
C411
C8 6.3V
C485
VSW_S2 C486
F7
VREG_S2 VREG_S2_VSENSE
M4
VSW_S3
N4 L402
VSW_S3
P4
VSW_S3
J8
VREG_S3
M7
VSW_S4 L403
VSW_S4
N7 VPH_PWR
P7
VSW_S4
K8
VREG_S4
A12
VSW_BOOST
B12 L404
VSW_BOOST
A11 BOOST_5V
VREG_BOOST
B11
VREG_BOOST
L10 TP403
CBL_PWR_N
K10 TP404 JIG_ON_N
KPD_PWR_N PHONE_ON_N C427
6.5V
6.5V
H5
6.3V
6.3V
OPT_2 OPT2
6.5V
6.5V
6.5V
D5
6.5V
A10
C436
C437
C434
C435
10V
C433
C432
C431
C430
SPMI_CLK
B10
PMIC_SPMI_CLK
SPMI_DATA
F5
PMIC_SPMI_DATA
PON_RST_N MSM_RESIN_N
BOOST_GND
D1 C438
REF_BYP GND_REF
M13
CHG_LED_SINK
S4_PGND
6.3V
S3_PGND
M14
GND_AUDIO_REF
VIB_DRV_N
F10
PDM_RX1 PDM_RX1
GND_XO_ISO
GND_XOADC
GND_BOOST
GND_BOOST
GND_CFILT
GND_SPKR
S1_PGND
S2_PGND
GND_DRV
GND_REF
C439
GND_XO
GND_CP
GND_RF
GND_S4
GND_S3
GND_S4
GND_S2
GND_S2
GND_S2
GND_S3
GND_S1
GND_S1
GND_S1
MARK
MARK
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
1
2
C13
E14
N10
H3
P8
J13
J12
N3
P3
N8
C4
C9
J2
J3
D2
B4
A9
B9
H11
H12
L13
A4
G10
H7
H8
H10
J6
K9
E9
G4
G7
G8
K5
D10
D11
E7
D6
D7
B13
GND_AUDIO_REF
MAIN_MIC_N
R406
S3_PGND
S4_PGND
S2_PGND
S1_PGND
BOOST_GND
GND_XOADC
EAR_MIC_3.5_M
R428
R409
GND_CP
SUB_MIC_N
GND_SPKR
GND_REF
GND_AUDIO_REF
8-10
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
Yes
END
VREG_L11_SDC_LDO
VREG_L11_SDC
VREG_L12_SDC
VREG_L14_UIM1
VREG_L5_1P8
R629
R630
SIM600
1
S1_VCC
UIM1_RST 2
S2_RST
UIM1_CLK 3
S3_CLK
4
S4
5
S5_GND
6
S6_VPP
UIM1_DATA 7
S7_IO
8
S8
SDC3_DATA(2) 9
T1_DAT2
SDC3_DATA(3) 10
T2_CD_DAT3
SDC3_CMD 11
T3_CMD
12
T4_VDD
SDC3_CLK 13
1
T5_CLK
14
T6_VSS
SDC3_DATA(0) 15
T7_DAT0
SDC3_DATA(1) 16
T8_DAT1
17
G1
18
G2
19
C636 G3
C605 20
G4
VOLT
2
6.3V 21
G5
22
G6
23
G7
R621 24
G8
25
C632
C633
SDC3_DETECT_N DETECT
ZD604
C634
ZD602
ZD603
1
2
ZD601
C637
R624
8-11
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
TA / USB Insert
No
No Reconnect TA or USB
Checking Volt at L409 = 5V? or
Swap the Sub PBA
Yes
Yes
Yes
END
VBATT_CON
U403
GND
1 4
IN OUT
3
GND
EN VBATT_CON
2
R419 VUSB_FET_5V_CON
5
VUSB_FET_5V
R422 C2 B1
TP407 VBAT
UART_BOOT_ON BOOT
JTAG_JIG_ON_N D2 E2
JIG VDDIO
JIG_ON_N
VUSB_FET_5V_CON E3 ID_CON
USB_ID
F2 A2
IFC400 MUIC_I2C_SDA SDA VBUS_OUT
L409 F3 A3
MUIC_I2C_SCL SCL VBUS_OUT
1 1
2 R425 TP408 B2 B3
2 USB_DM MUIC_INT INTB VBUSIN
3 R426
3
R427
USB_DP C469 C470
4
4 USB_ID TP409 C1 C467
5 5 UART_TXD TXD C465
6 V_BUS_JTAG_ID
S1 TP410 D1 RXD C3
7 UART_RXD DM_CON USB_DM
S2 ZD402
8 ZD403
NC 9 D3
DP_CON USB_DP
NC 10 A1
C479 GND
E1 TP412
25V
NC C487 C478
11 C477 DM_HOST USB_HS_D_M
NC 12 1
C480 35V MARK
NC
13 F1 TP413 USB_HS_D_P
NC ZD401 ZD404 ZD400 DP_HOST
2
MARK
VOLT
VOLT
8-12
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-13
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
No
No
Check the L514 soldering
status and Resolder or replace U400
Check the voltage at
L514 = 2.8V
Yes
END
VDD_MIC_BIAS1_1.8V
L514
MIC500
POWER
1
GND1
2
3 MAIN_MIC_N
GND2
OUT
4 L516
MAIN_MIC_P
2
8-14
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Yes
Yes
No
Check the signals on
L518, L519 Resolder or replace L518, L519
Yes
END
ZD501
ZD502
1
1
VOLT
C535 C534
50V
50V
VOLT
2
2
L520 RCV_P
L521 RCV_N
C544 C543
ZD508
TP_MIPI_TX_CP
5%
5%
25V
D502
25V
D501
VOLT
TP_ACC_INT
2
2
1 1 2
2
3 3 4 4
TP_MIPI_TX_DN600
5 5 6 6
7 7 8 8
9 9 10 L524 L518 SPK_OUT_P
10 L519
11 11 L525 SPK_OUT_N
12 12
TP_MIPI_TX_DN601
NC
NC
NC
NC
2
2
13 14 15 16
C537 C536
VOLT ZD513
ZD514
C540 C539
1
1
50V
VOLT
50V
TP_UB
8-15
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
No
Yes
Replace PCB
END
ZD501
ZD502
1
1
VOLT
C535 C534
50V
50V
VOLT
2
2
L520 RCV_P
L521 RCV_N
C544 C543
ZD508
5%
5%
D502
25V
25V
D501
VOLT
2
2
1 1 2
2
3 3 4 4
5 5 6 6
7 7 8 8
9 9 10 L524 L518 SPK_OUT_P
10 L519
11 11 L525 SPK_OUT_N
12 12
NC
NC
NC
NC
2
2
13 14 15 16
C537 C536
ZD513
ZD514
C540 C539
1
1
50V
VOLT
VOLT
50V
8-16
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-9. LCD
Yes
No
Check the connection of
HDC600 Reassemble FRONT assy
Yes
Yes
No
Check the voltage of Resolder C601, C603
C601=1.8V? C603=3.0V? or Replace the U400
Yes
Yes
END
8-17
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
F600
1 4
MIPI_DSI0_LANE0_M I|O I|O MIPI_DSI0_LANE0_M_F
2 3
MIPI_DSI0_LANE0_P I|O I|O MIPI_DSI0_LANE0_P_F
GND
GND
5
6
F601
1 8
MIPI_DSI0_LANE1_M I|O I|O MIPI_DSI0_LANE1_M_F
2 7
MIPI_DSI0_LANE1_P I|O I|O MIPI_DSI0_LANE1_P_F
3 6
MIPI_DSI0_CLK_M I|O I|O MIPI_DSI0_CLK_M_F
4 5
GND
MIPI_DSI0_CLK_P_F
GND
MIPI_DSI0_CLK_P I|O I|O
9
10
V_LCD_3.0V VREG_1P8_LCD
HDC600
1 1 2 2
3 3 4 4
5 5 6 6
7 7 8 8
TP_FLM 9 9 10 10
LCD_FLM
11 11 12 12
MIPI_DSI0_LANE0_P_F TP_LCD_D 13 13 14 14
15 15 16 16
MIPI_DSI0_LANE0_M_F
17 17 18 18
TP_LCD_CLK 19 19 20 20
MIPI_DSI0_CLK_P_F
21 21 22 22
MIPI_DSI0_CLK_M_F
23 23 24 24
25 25 26 26
MIPI_DSI0_LANE1_P_F
27 27 28 28
MIPI_DSI0_LANE1_M_F
29 29 30 30
NC
NC
NC
NC
31
32
33
34
C603 C601
10V 10V
8-18
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-10. TSP
Yes
No
Check the connection of Reconnect the Connecter of HDC600
HDC600
Yes
Yes
Yes
END
V_TSP_1.8V
VDD_TSP_A3.0V
R600
HDC600
1 1 2 2 L600
3 3 4 4
TSP_INT
5 5 6 6 TSP_I2C_SDA
7 7 8 8
TSP_I2C_SCL
9 9 10 10 TP_BL
LCD_PWM
11 11 12 12 MIPI_DSI0_RESET_N
13 13 14 14 TP_VGH
15 15 16 16
17 17 18 18
19 19 20 20 LED_P_26V
21 21 22 22
23 23 24 24 LED_N
25 25 26 26
27 28 TP_TSP_VALID
27 28
29 29 30 30
NC
NC
NC
NC
32
31
33
34
C638
C639
C640
25V
25V
25V
C602
C604
16V
50V
ZD600
VOLT
8-19
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-11. 5M CAM
Yes
Abnormal
Yes
Yes
Yes
END
CAM_SENSOR_IO_1P8
VREG_CAM_AF_2P8
VCAM_A_2.8V
SLC600
1 1 2 2
CAM_I2C_SCL
3 3 4 4
CAM_I2C_SDA 5 5 6
6
7 7 8 8
CAM1_RST_N
TP_601 9 9 10 10
5M_CAM_STBY 12 TP_MIPI_TX_CP
TP_MIPI_TX_CN 11 11 12 MIPI_CSI0_CLK_P_F
MIPI_CSI0_CLK_M_F 13 13 14 14 TP_MIPI_TX_DN600
MIPI_CSI0_LANE0_M_F
TP_MIPI_TX_DP600 15 15 16 16
MIPI_CSI0_LANE0_P_F 17 18 TP_MIPI_TX_DN601
TP_MIPI_TX_DP601 17 18 MIPI_CSI0_LANE1_M_F
MIPI_CSI0_LANE1_P_F 19 19 20
20 CAM_MCLK0
21 21
NC NC
22 23
C609 C610 C607
C608
C611
8-20
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-12. 2M CAM
Yes
Abnormal
Yes
Yes
Yes
END
8-21
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VDD_SENSOR_IO_1.8V VCAM_A_2.8V
VDD_SENSOR_IO_1.8V VREG_L17_2P85
VDD_PLS_3P3
R622
L601
R623
1%
1%
CAM_SENSOR_IO_1P8
HDC601
1 1 2 2
PROXY_INT 3 3 4 4
5 5 6 6 TP_600
2M_CAM_STBY
7 7 8 8
VT_CAM_MCLK
SENSOR_I2C_SCL 9 9 10 10
SENSOR_I2C_SDA 11 11 12 12 MIPI_CSI1_CLK_M_F
13 13 14 14 MIPI_CSI1_CLK_P_F
CAM_I2C_SCL 16 16
15 15
CAM_I2C_SDA 18 18
17 17 MIPI_CSI1_DATA0_M_F
19 19 20 20
MIPI_CSI1_DATA0_P_F
CAM2_RST_N 21 21 22 22
24 NC
26 NC
25 NC
NC
23
C641 C642
C643
C644
50V C645 C647 C646
10V C648 C649
6.3V 10V 6.3V
10V 50V
10V 6.3V
F603
1
MIPI_CSI1_LANE0_M I|O I|O 8 MIPI_CSI1_DATA0_M_F
MIPI_CSI1_LANE0_P 2 7
I|O I|O MIPI_CSI1_DATA0_P_F
3 6
MIPI_CSI1_CLK_M I|O I|O MIPI_CSI1_CLK_M_F
4 5
GND
GND
C184
C548
8-22
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
(Rx setting)
1. Active Cell : select GSM or GPRS
2. Connetion Type : select Auto(GSM), BLER(GPRS)
3. BCH Parameter : select measuring band (DCS or EGSM)
4. Cell power : -60dBm
(Tx setting)
※ After setting 8960 (or CMW500) ( EGSM / DCS )
1. After setting, prepare the call setup Display
2. Using an Originate Call, make a call.
3. Confirm the display "connected"
4. start the measuring
8-23
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
YES
YES
NO
Check voltage at Resolder L144, C189, C127 or Replace
C127 = 2.85V U101
YES
NO
Check the status of L113, C121 Resolder or Replace L113, C121
YES
YES
YES
END
8-24
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C219
C101
8-25
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-15. GSM900 Rx
YES
YES
NO
Check voltage at Resolder L144, C189, C127 or Replace
C127 = 2.85V U101
YES
NO
Check the status of L118, C134 Resolder or Replace L118, C134
YES
YES
YES
END
8-26
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C219
C101
8-27
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
YES
YES
NO
Check voltage at Resolder L144, C189, C127 or Replace
C127 = 2.85V U101
YES
YES
YES
YES
END
8-28
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C219
C101
8-29
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
YES
YES
NO
Check voltage at Resolder L144, C189, C127 or Replace
C127 = 2.85V U101
YES
YES
YES
YES
END
8-30
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C219
C101
8-31
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
YES
YES
NO
Check voltage at Resolder L144, C189, C127 or Replace
C127 = 2.85V U101
YES
NO
Check the status of L122, C140 Resolder or Replace L122, C140
YES
YES
YES
END
8-32
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C219
C101
8-33
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Still Abnormal
NO
Check the status of C101, C102, Resolder C101, C102, C103, R108, L101,
C103, R108, L101, C104, C111 C104, C111 or Replace F100
YES
NO
Check voltage at
C127 = 2.85V, C112 = 1.8V Resolder C127, C112
YES
YES
NO
Check the status of C136, C137,
Resolder C136, C137, L121
L121
YES
NO
Check the status of UCP300
Resolder or Replace UCP300
(crack, open, etc.)
YES
END
8-34
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-35
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C101
C142
C219
8-36
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Still Abnormal
NO
Check the status of C101, C102, Resolder C101, C102, C103, R108, L101,
C103, R108, L101, C104, C111 C104, C111 or Replace F100
YES
NO
Check voltage at
C127 = 2.85V, C112 = 1.8V Resolder C127, C112
YES
YES
NO
Check the status of C147, C145, Resolder C147, C145, C146, L124 or
C146, L124 Replace F105
YES
NO
Check the status of UCP300
Resolder or Replace UCP300
(crack, open, etc.)
YES
END
8-37
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-38
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C101
C142
C219
8-39
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Still Abnormal
NO
Check the status of C101, C102, Resolder C101, C102, C103, R108, L101,
C103, R108, L101, C104, C111 C104, C111 or Replace F100
YES
NO
Check voltage at
C127 = 2.85V, C112 = 1.8V Resolder C127, C112
YES
YES
NO
Check the status of C136, C137,
Resolder C136, C137, L104
L104
YES
NO
Check the status of UCP300
Resolder or Replace UCP300
(crack, open, etc.)
YES
END
8-40
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-41
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C101
C142
C219
8-42
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Still Abnormal
NO
Check the status of C101, C102, Resolder C101, C102, C103, R108, L101,
C103, R108, L101, C104, C111 C104, C111 or Replace F100
YES
NO
Check voltage at
C127 = 2.85V, C112 = 1.8V Resolder C127, C112
YES
YES
NO
Check the status of C147, C145, Resolder C147, C145, C146, L112 or
C146, L112 Replace F105
YES
NO
Check the status of UCP300
Resolder or Replace UCP300
(crack, open, etc.)
YES
END
8-43
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-44
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C101
C142
C219
8-45
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Still Abnormal
NO
Check the status of C101, C102, Resolder C101, C102, C103, R108, L101,
C103, R108, L101, C104, C111 C104, C111 or Replace F100
YES
NO
Check voltage at
C127 = 2.85V, C112 = 1.8V Resolder C127, C112
YES
YES
NO
Check the status of C136, C137,
Resolder C136, C137, L107
L107
YES
NO
Check the status of UCP300
Resolder or Replace UCP300
(crack, open, etc.)
YES
END
8-46
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-47
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C101
C142
C219
8-48
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
Still Abnormal
NO
Check the status of C101, C102, Resolder C101, C102, C103, R108, L101,
C103, R108, L101, C104, C111 C104, C111 or Replace F100
YES
NO
Check voltage at
C127 = 2.85V, C112 = 1.8V Resolder C127, C112
YES
YES
NO
Check the status of C129, C125, Resolder C129, C125, C126, L117 or
C126, L117 Replace F103
YES
NO
Check the status of UCP300
Resolder or Replace UCP300
(crack, open, etc.)
YES
END
8-49
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-50
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
C101
C142
C219
8-51
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-31. BT/WLAN
Yes
No
Check contact status of ANT200 Resolder or Replace ANT200
Is it normal contact on pad?
Yes
Abnormal
Check the status of Resolder C221, C211, C227 or
C221, C211, C227 Check(Crack, etc) and Replace F201
Yes
Abnormal
Check the status of
Resolder C207
C207 (CLK)
Yes
Abnormal
Check the status of U204
Resolder or Replace U204
(Outside Crack, etc)
Yes
Abnormal
Check the status of UCP300
Resolder or Replace UCP300
(Outside Crack, etc)
Yes
END
8-52
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VDD_IO_1P8
VDD_WLAN_1P3
62
40
38
31
15
63
C202
NC
NC
NC
NC
NC
NC
29 18
VDD_DIG_1P2 BT_CTL BT_CTL
C203
6.3V 22 28
C206
BT_DATA
6.3V
VDD_IO_1P8 BT_DATA
33
BT_SSBI BT_SSBI
6.3V 51
VDD_FM_VCO_1P3
L200 56 46
10V
25V
VDD_FM_RXFE_1P3 FM_DATA
57 50
VDD_FM_RXBB_1P3 FM_HS_RX
52 41
C204
C205
C232
36
VDD_WL_BB_1P3 WL_CMD_CLK WCSS_WLAN_CLK
48 TP_WCSS_WLAN_DATA F201
VDD_WL_LO_1P3 WL_CMD_DATA0 WCSS_WLAN_DATA_0 ANT2
58 26
VDD_WL_PLL_1P3 WL_CMD_DATA1
55
WCSS_WLAN_DATA_1
43
VDD_WL_UPC_1P3 WL_CMD_DATA2 L202
WCSS_WLAN_DATA_2 L203 C211 25V 1
24 6 C210 1 4 1
VDD_XO_1P8 WL_CMD_SET WCSS_WLAN_SET 25V IN OUT
25V 6
GGGNC 22
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
23 5
6.3V
8
2
1
C221
C226 C227
25V
25V
25V
25V
25V
25V
25V
C225
C220
C219
C217
C218
C216
C215
C214
25V 25V
25V
8-53
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
8-3-32. GPS
No
Check contact status of ANT201.
Resolder or Replace ANT201
Is it normal contact on pad?
Yes
Yes
Abnormal
Check the status of Resolder C213, L205 or
C213, L205 Replace U202
Yes
Abnormal
Check the status of C209, L208, Resolder C209, L208, L201
L201 or Check(Crack, etc) and Replace F200
Yes
Abnormal
Check the status of
Resolder C180
C180 (CLK)
Yes
Abnormal
Check the status of U105
Resolder or Replace U105
(Outside Crack, etc)
Yes
Abnormal
Check the status of UCP300
Resolder or Replace UCP300
(Outside Crack, etc)
Yes
END
8-54
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
VREG_GPS_1P8
L211
ANT201
U205
U202 F200
C212
4 3 C209 1 4 L201
GNDRF RF_OUT IN OUT WTR_GNSS_N
1 L204 1 C213 L205 5 2 25V 6
4
G
G
G
1 IN OUT RF_IN VCC
1 NC
2 6 16V 6
2
3
5
2
G
G
G
GPS_LNA_EN ENABLE GND
NC
25V 25V C231
2
3
5
C230 C224
6.3V
25V
L210
25V
25V
C223
L208
C222
C228 C229
VWTR_RF1_1.0V
C163 VWTR_RF2_1.8V
6.3V
C164
C165
6.3V
25V
6.3V
6.3V
6.3V
C167
C168
C169
C170
6.3V
50
33
23
44
34
VDD_RF2
VDD_RF1_DIG
VDD_RF1_RX
VDD_RF1_TX
VDD_RF2_LDO
17 47
WTR_PRX_B17 11
PRX_LB1 DRX_BB_IP
36
WTR_DRXBBI_P
WTR_PRX_GSM900 6
PRX_LB2 DRX_BB_QP WTR_DRXBBQ_P
WTR_PRX_B5_GSM850 4
PRX_LB3
46
PRX_MB1 GNSS_BB_IP
10 41 WTR_GNSSBBI_P
WTR_PRX_B4 5
PRX_MB2 GNSS_BB_QP
WTR_GNSSBBQ_P
WTR_PRX_B2_GSMHB 28
PRX_MB3
1
PRX_HB1
22
TX_DA1
18 WTR_TX_B2/4_GSM1800/1900
PRX_HB2 TX_DA2
12
WTR_TX_B5_GSM850/900
TX_DA3
49 2
WTR_DRX_B17_LNA 54
DRX_LB1
U105 TX_DA4
7
WTR_TX_B17
WTR_DRX_B5_LNA 60
DRX_LB2 TX_DA5
DRX_LB3
59 19
WTR_DRX_B4_LNA 53
DRX_MB1 TX_BB_IM
14 WTR_TXBBI_M
WTR_DRX_B2_LNA 38
DRX_MB2 TX_BB_IP
8 WTR_TXBBI_P
43
DRX_HB1 TX_BB_QM
3 WTR_TXBBQ_M
DRX_HB2 TX_BB_QP
WTR_TXBBQ_P
58 57
WTR_GNSS_N GNSS_IN GPDATA
GPDATA
C179 31 51
WTR_PDET FBRX_RFIP RFFE_CLK
56
RFFE5_CLK
RFFE_DATA RFFE5_DATA
25V 15
WTR_PRXBBI_P 20
PRX_BB_IP
55
GND_GPS_RXLO
WTR_PRXBBQ_P PRX_BB_QP
RFCLK1_19.2M
GND_DRX_LNA
XO_IN
GND_PRX_LNA
GND_RX_VCO
GND_TX_VCO
GND_RX_PLL
GND_TX_PLL
GND_RX_LO
GND_TXBBF
GND_TXLO
GND_ISO
C180
GND_DA
GND_XO
GND1
GND2
GND3
GND4
GND5
GND6
52
35
42
30
26
13
48
37
29
16
21
32
27
25
24
45
40
39
9
8-55
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.
Level 3 Repair
- NC Point(Top View)
8-56
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsung’s written authorization is strictly prohibited.