Professional Documents
Culture Documents
Exit Exm-Chemco
Exit Exm-Chemco
The residual discharge into the sea of substances in category-X outside special areas after
Pre wash may be discharged into the sea when the following conditions are satisfied
All of the above
Where applicable the following is to be taken into account in selecting the material of
construction
All of the above
In case of failure or erratic reading of fixed oxygen content meter the following operational
condition may be followed
By pass the oxy content meter
Or
Use portable oxygen content analyzer and discharge at slow rate
The lowest temperature at which oil will continue to flow if it is cooled is called the ___
Pour point
____ is the property which determines its resistance to flow:
Viscosity
____ is used in the pressure / vacuum system where the valve supervises the pressure
condition in the tanks.
Butterfly valve
Pitting in the suction areas of a centrifugal pump bronze impeller is usually caused by ___
Cavitation
_____ usually expressed in volume percent, is the lower end of the concentration range over
which a flammable mixture of gas or vapor in air can be ignited at a given temperature and
pressure
lower flammability
_____ means a cargo containment envelope which is not contiguous with, or part of the hull
structure
Independent tank
Is it compulsory to have permanent arrangement for hoisting injured persons in the cargo
pump room
yes
nonvolatile petroleum is
petroleum having flash point over 60 deg cel. And above
the effect of cavitation may be ___ damage to the impeller and housing
the vapors given out by the oil when mixed with air burn
false
inert gas is
all of the above
the category of chemical posing the greatest threat of harm to the marine environment is
category
X
____ is a chemical tanker intended to transport products requiring significant preventive
measures
ST2
prior to strange the hydraulically operated cargo pumps for discharge of cargo it must be
ensured that ___
all of the above
the lowest level of PPE level must be used while handling very dangerous chemicals
no