Professional Documents
Culture Documents
ITP For MCC HV LV Switchgear Boards Pane
ITP For MCC HV LV Switchgear Boards Pane
ITP For MCC HV LV Switchgear Boards Pane
Ltd, Mumbai
SHEET 1 OF 2
Oil , Gas & Petrochemical Division, Inspection Dept.
8 H P X Factory Acceptance Test as per FAT procedure including Routine test as per IS specification:
- Visual & dimensional check including accessories & name plate, paint shade, bus size, creepages, clearances,
bus marking, sleeving and joint shrouding , Bill of material etc.
- Compartmentalisation, interchangeability of CBS, termination space, glanding, operation height, earthling, cable
sizes, accessibility of components etc.
- Electrical performance / operation check ( wiring and scheme check) as per approved drawings at worst voltage
conditions
- Relay operation check including fault annucaition check ( primary and secondary injection )
- HV test
Final documentation before shipment to site , spares & issue of Inspection Release Note / Inspection
10 I H H X
Report.
___________
MMCI
11 H P X Site Acceptance Test of the complete items as per SAT procedure consisting of:
- ON / OFF Operation of breaker both manually & electrically in test as well as service positions.
- Interface PLC Panel functional and simulation test with TAS as well as from PLC Panel in
totality for L.V. Switchgear.
12 I H H X Final site documentation , spares & issue of site Inspection Report/ IRN
LEGENDS: H - Hold Point :- An activity , which requires inspection / Verification and acceptance by HPCL/MMCI /TPIA before any further
processing is permitted. The vendor shall not process activity/item beyond a hold point without written approval.,
W- Witness:- An activity, which requires witnessing by HPCL/ MMCI/ TPIA with prior notification of the same inspection agency. Vendor
is not obliged to hold further processing. Basis of acceptance shall be as per relevant technical specification/ drawings/PR/MR.
R - Review :-To examine the inspection records for confirming compliance to requirements.; A- Approval : -To approve the inspection
documents for conforming compliance to requirements.; P- Perform/Prepare; W/R- Witness or Review; I- Information; X- Submit,
PWHT- Post weld Heat Treatment, PO- Purchase Order,MR/PR- Material /Purchase Requisition, PS- Purchase Specification,
NDT- Non destructive Testing, TPIA - Third Party Inspection Agency, MMCI - Mott MacDonald Consultants (India) Pvt. Ltd
Note: This is an Indicative Inspection & Test Plan identifying scope of inspection & review of documents by MMCI / TPI Agency / HPCL
as a minimum requirement.
Detailed Quality Assurance/Control Plan indicating all specified requirements after issue of PO / PR/MR / PS to be generated by
Vendor & same duly approved by MMCI / TPI agency to be submitted to HPCL for review/comments.
___________
MMCI