Professional Documents
Culture Documents
C Ag E: Needle Roller Bearings
C Ag E: Needle Roller Bearings
ith g e
ca
s w
ize
na
l s
t ic
las
it o
di
A d
p
INA machined needle roller bearings NK and NKI are New sizes with plastic cage
successful machine elements for the design of radially INA needle roller bearings NK were previously produced
compact bearing arrangements with very high load carrying up to enveloping circle diameter FW = 10 mm with plastic
capacity. They consist of machined bearing rings and needle cages, while needle roller bearings NKI were produced up to
roller and cage assemblies with cages made from either a bore diameter of 7 mm with plastic cages. In order to
plastic or deep drawn steel strip. Bearings of series NKI have further exploit the advantages of these cages, additional
an inner ring while series NK is supplied without an inner ring. sizes now have plastic cages. The cages are designed to
Bearings without an inner ring are most suitable if the shaft accommodate more rolling elements than steel cages.
can be hardened and ground.
Since more rolling elements in the same space give higher
The material for the plastic cages is heat-stabilised, glass load carrying capacity, the new bearings have higher load
fibre-reinforced polyamide 66. This material has high strength capacities than comparable bearings with a conventional
and elasticity. Cage friction is low due to the positive sliding steel cage.
characteristics of the plastic on lubricated steel surfaces and
the low roughness of the cage surface. This leads to reduced The new series:
heat generation within the bearing. Since the material density ■ have proven, high performance plastic cages
is lower than that of steel cages, the mass inertia forces of ■ have higher basic dynamic and static load ratings than
the cage are lower. Polyamide cages have good emergency the previous designs
running characteristics, can be produced in the functionally ■ allow smaller bearing arrangements, if necessary,
correct form by the injection moulding process and are under the same load
resistant to organic solvents and diluted alkaline cleaning
agents. They also run with very little noise. ■ have little running noise
■ allow very economical bearing arrangements.
+11%
· Dimensions in mm
Dimension table (from Fatigue
Dimensions Basic
load Cata
logu limit load
Designation Needle e 30
7)
ratings withou roller beari
t
with ste ner ring ng
in
el cage
Basic
load
rating
s
103 236
+18%
Market Information MAI 90
Needle roller bearings
C
without inner ring, with plastic cage
r
Series NK..TN
D Fw
103 052
NK..TN
2
Needle roller
B s
bearings r
with inner ring, with plastic cage
r
Series NKI..TN
D d F
103 051
103 079
NKI..TN Permissible axial displacement “s“
3
· Printed in Germany