Professional Documents
Culture Documents
Install Guide: Gateway 500 MOST
Install Guide: Gateway 500 MOST
INSTALL GUIDE changer (typically the case for BMW and Porsche). Special note for BMW: for
song title display and browsing, it is necessary to have the BMW “MP3 Retrofit”
software option programmed by your car dealer. A quick test of your car’s
These vehicles allow selection of Gateway audio sources and
the original CD changer through the existing car audio con-
trols. Audi (MMI Basic Monochrome)
capability to display song titles and browse music is to see whether you can
ice4Link Gateway 500 MOST
m
browse an MP3 data CD inserted in the car’s single CD slot. If you can, then the Set the DIP switches to the following
position and install the Gateway BMW E87, E90, E60/61, E63/E64,
BMW MP3 Retrofit is already installed in the car.
500 as illustrated below: E70, E65 and Mini
(Exept E60/61, E63/E64 Business)
o
BMW E60/61, E63/E64 Business
Package Content & Electrical (M-ASK, non-text capable)
1a.
Installation
.c
CDC Mercedes (Audio 20/50 and Comand)
ns
for longer CDC and car side cable use
Remove the blue locking clip from the FOA1PO1 CDR PCM
middle of the fibre optic housing.
DIP switch 1b. Saab 9-3 (Rear CDC)
Car side
io
Volvo XC90 - MY 2002-2006, with Performance,
Strain the hook carefully with a High Performance and Premium sound system,
sharp tool, while pulling out the
optical fibre from the housing.
without AUX input, with CDC
ut
3 1c.
CDC side 2
1
ol
4
Power
harness
-s
Car side CDC side
3.
for media players, USB and Car side
Bluetooth devices
r
ca
Power harness:
-red wire
(+12V non switched)
-black (GND)
DEGW5-9210-7
1 2 3
support@car-solutions.com car-solutions.com
Installation Type 2b: Installation Type 3a: Installation Type 3b:
Text Configuration
Volvo S40/V50 - MY 2004-2007 with Basic and Vehicles with no existing CD changer If you are installing to a free fibre optic connector in the car
High Performance sound system, without AUX in- Saab & Mercedes vehicles require
Set the dip switches as shown below. (CDC preparation) use this method:
put, with CDC final configuration of the Gateway as
i
not all of the radios in these vehicles
Audi (MMI Basic Monochrome) support text display. After Gateway
500 has been installed, toggle the
mode selector switch six times (three
BMW E87, E90, E60/61, E63/E64, E70, E65 and Mini times on/off ) and a configuration
(Exept E60/61, E63/E64 Business) menu will appear on the radio
m
display. Select the configuration
BMW E60/61, E63/E64 Business mode according to your head unit
listed in the configuration table. To
(M-ASK, non-text capable) confirm the selection press and hold
o
; to discard the selection press
Mercedes (Audio 20/50 and Comand) and hold
Car side
.c
Porsche (CDR 23/24 and PCM I/II/2.1) Track # Config Mercedes Saab
Car side Command Text
CDR PCM
ns
#1 NO TEXT D D
Saab 9-3 (Rear CDC)
#2 Timeout - -
#3 Text - -
If you are connecting Gateway 500 to the back
of the head unit, use this diagram: #4 +Cache - -
ICM
io
(Display) #5 +Paging R R
#6 +Select - R
D: Default, R: Recommended
ut
For detailed information visit:
http://support.dension.com
ol
-s
Car side LED
i
ca
position otherwise the service
computer may detect an unknown
device in the fibre optic system which
can lead to errors reported.
HU
Service/CDC
mode
4 5 6 7
support@car-solutions.com car-solutions.com