Professional Documents
Culture Documents
Safety Data Sheet SDS For CB-G PG Precision Grout and CB-G MG Multipurpose Grout Documentation ASSET DOC APPROVAL 0536
Safety Data Sheet SDS For CB-G PG Precision Grout and CB-G MG Multipurpose Grout Documentation ASSET DOC APPROVAL 0536
Safety Data Sheet SDS For CB-G PG Precision Grout and CB-G MG Multipurpose Grout Documentation ASSET DOC APPROVAL 0536
1 Identification
*
· Product identifier
· Trade name: CB-G PG
CB-G MG
· Relevant identified uses of the substance or mixture and uses advised against No further relevant information
available. · Application of the substance / the mixture Construction chemicals
· Details of the supplier of the safety data
sheet · Manufacturer/Supplier:
Hilti, Inc.
5400 South 122nd East Ave.
US-Tulsa, OK 74146
Phone: (800) 879-8000
Fax: (800) 879-7000
Español: (800) 879-5000
· Information department:
chemicals.hse@hilti.com
see section 16
· Emergency telephone number:
Tox Info Suisse - 24 h Service
Tel.: 0041 / 44 251 51 51 (international)
.
Chem-Trec
Tel.: 1 800 424 9300
2 Hazard(s) identification
· Classification of the substance or mixture
* Acute Tox. 4 H302 Harmful if swallowed.
Skin Irrit. 2 H315 Causes skin irritation.
Eye Dam. 1 H318 Causes serious eye damage.
Skin Sens. 1 H317 May cause an allergic skin reaction.
Carc. 1A H350 May cause cancer.
STOT SE 3 H335 May cause respiratory irritation.
· Label elements
· GHS label elements The product is classified and labeled according to the Globally Harmonized System (GHS).
· Hazard pictograms
Health = 2
0 Fire = 0
2 0 Reactivity = 0
· Other hazards
· Results of PBT and vPvB
assessment · PBT: Not applicable.
(Contd. on page 2)
40.2.7
Page 2/4
(Contd. of page 1)
· vPvB: Not applicable.
* 3 Composition/information on ingredients
· Chemical characterization:
Mixtures · Description:
(Contd. of page 2)
Mixture of the substances listed below with nonhazardous additions.
REL Long-term value: 10* 5** mg/m³
· Dangerous components:
*total dust **respirable fraction
TLV Long-term
65997-15-1 value:
Cement, 1* mg/m³
portland, chemicals 25-50%
E; *as respirable fraction
14808-60-7 Quartz (SiO2) 25-50%
· 14808-60-7
Additional Quartz (SiO2)
information For the wording of the listed risk phrases refer to section 16.
* 4 PEL
First-aid measures
see Quartz listing
· REL Long-term
Description value:
of first aid0.05* mg/m³
measures
*respirable
· General dust; No
information Seespecial
Pocketmeasures
Guide App. A
required.
· TLV
AfterLong-term
inhalationvalue:
Supply0.025* mg/m³
fresh air; consult doctor in case of complaints.
· After*as
skinrespirable fraction
contact Immediately wash with water and soap and rinse thoroughly.
· Additional information:
After eye contact Rinse The lists eye
opened that for
were valid during
several minutestheunder
creation were water.
running used asThen
basis.consult a
doctor. · After
· Exposure controlsswallowing Seek immediate medical advice.
·· Personal
Information for doctor
protective equipment
·· Most
Generalimportant
protectivesymptoms and effects,
and hygienic bothKeep
measures acute and delayed No further relevant information available.
· away
Indication of any immediate
from foodstuffs, beveragesmedical attention and special treatment needed No further relevant information available.
and feed.
Wash hands before breaks and at the end of work.
Avoid contact with the eyes and skin.
5 DoFire-fighting measures
not inhale dust / smoke / mist.
· Extinguishing media
Do not eat, drink, smoke or sniff while working.
· Suitable extinguishing agents Not applicable
· Breathing equipment: If dust is produced.
· For safety reasons unsuitable extinguishing agents Not applicable
· Recommended filter device for short term use: Filter P2 ·
· Special hazards
Protection of hands:arising from the substance or mixture No further relevant information available.
* · Advice for firefighters
8· Exposure controls/personal
Protective equipment: protection
No special measures required.
· Additional information about design of technical systems: No further data; see item
7. · Control parameters
6· Accidental release measures
Components Protective
with limitgloves.
values that require monitoring at the workplace:
· Personal precautions, protective equipment and emergency procedures Avoid formation of dust.
65997-15-1 Cement, portland, chemicals
· Material
Environmental
of gloves
precautions:
Nitrile rubber,
Do not
NBR allow product to reach sewage system or any water course.
· PEL Long-term
Penetration
Methods andtime value: 50
formppcf
of glove
material materialor 15* 5**
containment andmg/m³
cleaning up: Pick up mechanically.
· The *total dust
exact break
Reference **respirable
to otherthrough fraction
time has to be found out by the manufacturer of the protective gloves and has to be
sections
observed. · Eye
See Section protection:
8 for information on personal protection equipment. (Contd. on page 3)
US
See Section 13 for disposal information.
· pH-value: 10 - 12
· Change in condition
Melting point/Melting range: Not determined.
Boiling point/Boiling range: undetermined
· Flash point: Not applicable
· Flammability (solid, gaseous) Product is not flammable.
· Ignition temperature: Not applicable
· Decomposition temperature: Not determined
· Auto igniting: Product is not selfigniting.
· Danger of explosion: Product does not present an explosion hazard.
· Density: Not determined
· Solubility in / Miscibility with
Water: Insoluble
(Contd. on page 4)
40.2.7
Page 3/4
(Contd. of page 3)
* · Other information No further relevant information available.
40.2.7
Page 4/4
40.2.7