Professional Documents
Culture Documents
ONU Auto Upgrade Guide Via INAS
ONU Auto Upgrade Guide Via INAS
Thanh.Nguyen
DASAN ZHONE SOLUTIONS (DZS)
ONU auto upgrade guide via INAS
Page 1 of 7
ONU auto upgrade guide via INAS
To do ONU firmware upgrade, we can perform it through INAS. The NMS system support to do it by two methods:
➢ Method 1: Do ONT upgrade via Task manager which it is performed by SNMP
➢ Method 2: Do ONT upgrade via shell script tool on INAS which it is performed like as put command lines.
Depending on, you can use method 1/2.
Page 2 of 7
ONU auto upgrade guide via INAS
o Profile for H646GM-V FTP/Fimrware information == > Fill in all information and then click Add
o Profile for H646GM-V Upgrade time == > Fill in all information and then click Add
- Step 3: Select ONT Upgrade profile and Node IP and then execute the ONT upgrade
Page 3 of 7
ONU auto upgrade guide via INAS
Page 4 of 7
ONU auto upgrade guide via INAS
2.1 Procedure
- Step 1: Prepare Configuration Template
- Step 2: Open Shell Script Tool on INAS
- Step 3: Configure command line on Shell Script Tool
- Step 4: Execute the Shell Script Tool
2.2 Procedure in Detail
Page 5 of 7
ONU auto upgrade guide via INAS
Note: If it is the first time of the Mass upgrade, you must enable auto upgrade on all GPON port by below command line. If you already
performed onu auto upgrade to other models on OLT then you don’t needed to configure it.
V8102_PA[B](config)# interface range gpon 1/1-16
V8102_PA[B](config-if-range[GPON1/1-16])# onu auto-upgrade enable
V8102_PA[B](config)# interface range gpon 2/1-16
V8102_PA[B](config-if-range[GPON1/1-16])# onu auto-upgrade enable
V8102_PA[B](config-if-range[GPON1/1-16])#end
V8102_PA[B]# write memory
Page 6 of 7
ONU auto upgrade guide via INAS
Page 7 of 7