Professional Documents
Culture Documents
Windows 2.0 Install Using Pendrive
Windows 2.0 Install Using Pendrive
Windows 2.0 Install Using Pendrive
Step 1.
Copy the additional files directory and the software rufus_v1.2.0. to your hard disk.
Make sure that the windows 2.0 iso file (winpe_x86_v2.0) is also downloaded to the PC’s hard disk.
Step 2.
Step 3.
Step 5.
Insert the pendrive to the hematology analyzer, also attach the USB keyboard and turn the analyzer
on. While the booting process is going, press „del” button to enter to BIOS.
In Advanced BIOS Features, set the first boot device to Hard disk.
On the same screen you have to enter to Hard Disk Boot Priority. Select the Pendrive to be first, so
the system will use the Pendrive as an external Hard Disk (use + and – buttons to change the order of
HDD).
If setting are ready, press F10 and save to exit from BIOS and restart.
Step 7.
Warning: In case of a new HDD, it can happen
that the „e” drive is not available. In this case,
remove the bootable pendrive and type in
the below commands into the console to
create proper partition on the HDD.
DISKPART
SELECT DISK 0
CLEAN
CREATE PARTITION PRIMARY SIZE=100000
FORMAT FS=NTFS QUICK
ACTIVE
ASSIGN LETTER = C
CREATE PARTITION PRIMARY
FORMAT FS=NTFS QUICK
ASSIGN LETTER = D
EXIT
EXIT
Replace the pendrive then wait until console
window returns.
After install is done, the high level software has to be set properly.
- Laser setting (power, low and high angle gains have to be set again for proper scatter values)
- Offsets on amplifiers (optical measurement and impedance meausrement offsets have to be set
(zeroed) in adjustments menu)
- Pressure sensor offsetting (also have to be set to make the pressure sensor work properly)
- Set the serial number of the instrument (the serial number is also stored on the HDD, after
windows install, the serial have to be set again. Use adjustements menu to enter the same serial
number as on the DIMMPC/DIMMBOARD or on the sticker on the back of the instruement).