Professional Documents
Culture Documents
S7 Programmer
S7 Programmer
S7 Programmer
1. General notes
-A practical assessment tests whether the participant is able to debug a small
Totally Integrated Automation (TIA) system and created an expanded PLC
program.
2. Test requirements
-A participant is admitted to the certification test for Siemens Certified S7
Programmer if they have completed following courses in an accredited
SITRAIN Training Center.
·SIMATIC S7-300/400System, Service & Programming Plus (Course ID: A7111)
·SIMATIC S7 Advanced Programming (Course ID: A7113)
- The participant submits the copy of their Certificates of the A7111 Course
and A7113 Course when apply the test.
-Take the Identity Card on the test day.
6. Test results
The test results are composed as follows:
Total number of points Maximum 100.0 points
SIMATIC S7 section Maximum 70.0 points
SIMATIC HMI section Maximum 15.0 points
Drives section Maximum 15.0 points
The participant has passed the test when the following conditions were
fulfilled:
Total number of points At least 70.0 points
SIMATIC S7 section At least 35.0 points
SIMATIC HMI section At least 7.5 points
Drives section At least 7.5 points
If the participant has not passed the test, they will be given
-A statement of attendance
-They are able to resit the test up to two times. Resitting the test is subject
to a separate charge.
7. Test discipline
-Participant must complete the test by himself (herself), Prohibit
communication and cheating.
-Prohibit using mobile phone、laptop、 U disk and other electronic devices.
- After the test, the examination paper、procedure and notes which including
test information are all prohibited.
-Participant who tries to cheat on the test will be considered as failure of the
test.