Professional Documents
Culture Documents
Communications-1 (Gate - 2021)
Communications-1 (Gate - 2021)
Communications-1 (Gate - 2021)
A 40%
B 50%
Solution :
(c)
D 70%
QUESTION ANALYTICS
A 20 MHz carrier is modulated by a 720 kHz modulator signal to a depth of 60%. If the rms value of the amplitude of the carrier signal is 50 V, then
the power of the modulated signal is equal to
A 1.475 kW
Solution :
(b)
C 5.9 kW
D 0.73 kW
QUESTION ANALYTICS
In an angle modulated signal, the modulating frequency is increased from 20 kHz to 40 kHz. If the signal is frequency modulated, then the modulated
signal bandwidth is
A Doubled
B Halved
Solution :
(c)
D Decreased by 40 kHz
QUESTION ANALYTICS
A 30 MHz
B 40 MHz
Solution :
(c)
D 80 MHz
QUESTION ANALYTICS
The amplitude of a sinusoidal carrier is modulated by a single sinusoidal signal to obtain the amplitude modulated signal
A 0.4
Solution :
(b)
C 0.7
D 0.8
QUESTION ANALYTICS
A superheterodyne receiver is to operate in the frequency range 550 kHz-1650 kHz, with intermediate frequency of 450 kHz. If the receiver is tuned to
650 kHz, then the image frequency is ______ MHz.
Solution :
1.55
QUESTION ANALYTICS
The aerial current of an AM transmitter increases to 50 A from 45 A when modulated with a single tone message signal, then the modulating index is
______ %.
Solution :
68.4 (67.0 - 69.0)
QUESTION ANALYTICS
8 signals, each bandlimited to 8 kHz are to be transmitted over a single channel by FDMA using an SSB-AM technique. Then the bandwidth of the
transmitted signal
A depends upon the total number of message signals. Your option is Correct
Solution :
(a, b, c)
QUESTION ANALYTICS
Then,
C the approximate bandwidth of the FM signal is equal to 22 kHz. Your option is Correct
Solution :
(a, c)
QUESTION ANALYTICS
A superheterodyne receiver is used to receive an FM signal in the range of 88 MHz - 108 MHz with IF frequency 10 MHz. In order to avoid image
frequency, the maximum and minimum capacitance ratio at the local oscillator section is (high side tuned is used)
A 1 : 1.449
Solution :
(b)
C 6.2 : 1
D 1 : 6.2
QUESTION ANALYTICS
A superheterodyne receive is designed to receive transmitted signals between 5 and 10 MHz. High-side tuning is to be used. The tuning range of the
local oscillator for IF frequency 500 kHz would be
Solution :
(b)
D 6 MHz - 8 MHz
QUESTION ANALYTICS
The modulation signal m (t) has zero mean and its absolute value is The nonlinear device has a input-output characteristic
If the modulation index of the wave is 0.8, then the value of A m is equal to
A 1.6
B 18
Solution :
(c)
D 2.5
QUESTION ANALYTICS
A AM-FC
B FM
Solution :
(c)
D DSB-SC
QUESTION ANALYTICS
The maximum amplitude of carrier signal and modulating signal are 2 and 4 respectively. Then the value of y(t) at t = 0 sec will be ______.
Solution :
5.66 (5.60 - 5.71)
Your Answer is 0
QUESTION ANALYTICS
A DSB modulated signal is mixed (multiplied) with a local carrier and the output is passed
through a LPF with a bandwidth equal to bandwidth of the message m ( t ). If the power of the signal at the output of the low pass filter is P out and the
Solution :
0.25
QUESTION ANALYTICS
In a broadcast superheterodyne receiver the quality factor of antenna coupling circuit is 150. If the intermediate frequency = 455 kHz, then
(Assume the message frequency to be 20 MHz)
C the image rejection ratio is equal to 22.536 dB. Your option is Correct
Solution :
(a, c)
QUESTION ANALYTICS
A certain communication channel is characterized by 80 dB attenuation and noise power spectral density of 10 –10 W/Hz. The transmitted power is
40 kW and the message signal has a bandwidth of 10 kHz. For conventional AM modulation, then
Solution :
(a, d)
QUESTION ANALYTICS