Professional Documents
Culture Documents
NE40E - Logging in To A Device Through The Console Interface
NE40E - Logging in To A Device Through The Console Interface
NE40E - Logging in To A Device Through The Console Interface
Prerequisite
Figure 1 Networking diagram of logging in to the NE80E/40E through the console interface
Before logging in to the NE80E/40E through the console interface, make sure that the NE80E/40E is properly powered on.
Procedure
1. Use a serial cable to connect the serial interface on the PC and the console interface on the NE80E/40E.
For details on the console interface, see HUAWEI NetEngine80E/40E Router - Hardware Description.
2. Start the HyperTerminal on the PC.
Choose Start > Programs > Accessories > Communications > HyperTerminal to start the HyperTerminal in
Windows.
3. Set up a connection.
As shown in Figure 2, enter the name of the new connection in the Name text box, and then select an icon. Click
OK.
Operation Result
After the preceding configurations are complete, press Enter. If the prompt <HUAWEI> is displayed on the screen, it
indicates that logging in to the NE80E/40E through the console interface is successful. Then, you can run commands to
configure or manage the NE80E/40E.
If the login fails, click Disconnect and then Call. If the login still fails, repeat Step 1 to check whether the parameters or
physical connections are correct. If they are correct, log in to the device again.