Professional Documents
Culture Documents
Final Inspection Report Buritica 金矿项目最终验收报告: Of Buritica Gold Project
Final Inspection Report Buritica 金矿项目最终验收报告: Of Buritica Gold Project
Final Inspection Report Buritica 金矿项目最终验收报告: Of Buritica Gold Project
Buritica 金矿项目最终验收报告
XCF/KYF-50 浮选机
X50-5,K50-6,K50-7,K50-8,X50-9,K50-10
X50-11,K50-12,X50-13,K50-14,X50-15,K50-16
X50-17
设备编号:X50-1,X50-2,X50-3,K50-4
X50-5,K50-6,K50-7,K50-8,X50-9,K50-10
X50-11,K50-12,X50-13,K50-14,X50-15,K50-16
X50-17
序 检验要求 检验仪器 检验结果 备注
号 检验项目 检验员
槽体、横梁 目测
1
Tank,beam Visual
目测
2 主轴部件 Agitator 如有破损,必须
油漆 Visual
修复
Painting 目测
3 电机装置 Motor Assembly Any damage
s
must be repaired Visual
给中尾矿箱
目测
4 Feed / Connection/Tailing
Visual
Box
目测
5 槽体 Tank
Visual
如有破损,必须
衬胶 给中尾矿箱
修复 目测
6 Rubber Feed / Connection/Tailing
lining Any damage Visual
Box
must be repaired
叶轮定子衬胶 目测
7
Impeller / Stator lining Visual
满足说明书要求 扭矩扳手(抽
连接螺栓扭矩 查)
8 Meet the
Connecting bolt torque specification Torque wrench
requirements (spot check)
大小皮带轮的水平度
水平仪
9 The levelness of the driver and driven <2mm
gradienter
pulleys
叶轮定子径向间隙
手盘试运转 灵活 目测
11
Test Run by Hands Rotate Smoothly Visual
电机转向测试 顺时针 目测
12
Motor steering test Clockwise Visual
槽体连接密封性 无漏水 水
13
The leakproofness of tank No liquid leak Water
4 小时或轴承温
度不再升高
试运转时间 表
14 4 h or Bearing
Test Operation Watch
tempreture begin
to fall
是否有异响 无异响 耳听
15
Abnormal Noise Abnormal Noise Ears
主轴上轴承温升 测温仪
16 Upper Bearing Tempreture Arise of ≤ 50℃
Agitator Thermodetector
主轴下轴承温升 测温仪
17 Lower Bearing Tempreture Arise of ≤ 50℃
Agitator Thermodetector
电机上轴承温升 测温仪
18 ≤ 50℃
Upper Bearing Tempreture Arise of Motor Thermodetector
电机下轴承温升 测温仪
19 Lower Bearing Tempreture Arise of ≤ 50℃
Motor Thermodetector
空转噪音 声级计
21 ≤85dBa
No Load Noise Soud level meter
After joint inspection of this XCF/KYF-50 flotation cell by LXML and BGRIMM-MAT, testing results
certify that this flotation cell complies with the technical specification and design requirements.
我们在此确认该浮选机验收合格。
大陆黄金有限公司哥伦比亚分公司 北矿机电科技有限责任公司