Professional Documents
Culture Documents
Regulador de Precisión
Regulador de Precisión
K Ordering information:
P3RA102 6 2
Products
Regulator
Springs
0.5 to 30 psig 3
1 to 60 psig 4
2 to 150 psig 6 Options
Blank No options
Pipe Size H BSPP
Note: Other spring ranges, port sizes, and options N Non-relieving
1/4 inch 2
available. Please consult factory
Most popular.
General
Body and housing Aluminum
P3RA102 1/4" Regulator
Diaphragms Buna N on dacron
Flow Characteristics
(standard unit only) Model P3RA102
110
Trim zinc plated steel, 700
Supply Pressure = 100 PSIG (690 kPa)
100
brass
90
Dial
400 60 60 PSIG Setpoint (414 kPa)
Pilot
Mounting bracket
-400 -200 0 200 400 600 800 1000 1200 1400 1600 1800
Q, LPM
9/16
(14.4)
27/32
1-7/8 to cL (21.6)
Proportional
(47.6) of Unit
Precision
Positive Bias
Spring
! WARNING
Product rupture can cause serious injury.
Do not connect regulator to bottled gas. Supply
Valve
Do not exceed Maximum primary pressure rating.
Diaphragm
Water
Inlet Assembly
Port
CAUTION:
Inner
REGULATOR PRESSURE ADJUSTMENT – The working range of knob
Valve
adjustment is designed to permit outlet pressures within their full range. Outlet
Assembly
Pressure adjustment beyond this range is also possible because the knob Port
is not a limiting device. This is a common characteristic of most industrial
regulators, and limiting devices may be obtained only by special design. For Gauge Port (2)
best performance, regulated pressure should always be set by increasing
the pressure up to the desired setting. K
Operating Principles
Regulator
Products
Plunger Operated Tamperproof
Standard 0.312 Dia.
The P3RA102 Series regulator use the force balance principal
to control the movement of the Valve Assembly that controls
0.38 0.38 the output pressure. When the regulator is adjusted for a
1/4-20 1/4-20
(9.4) (9.4) specific set point, the downward force of the Positive Bias
.5" Deep .5" Deep (2)
(2) Mounting Spring moves the Diaphragm Assembly downward. The
Mounting Holes Supply Valve opens and allows air to pass to the Outlet Port.
Holes 6.63
(168.5) 7.28 As the set point is reached, the downward force exerted
(184.9) by the Positive Bias Spring is balanced by the force of the
4.42 4.78 downstream pressure that acts on the Diaphragm Assembly.
(111.9) (121.6)
1/4" NPT The resultant force moves the Supply Valve upward to reduce
Gauge 1/4" NPT
Ports (2) Gauge the flow of air to the Outlet Port.
Ports (2)
Outlet pressure is maintained as a result of balance between
3.00 forces acting on the top and bottom of the Diaphragm
(76.2) 3.00 Assembly.
(76.2)
2 thru 200 PSIG Range 300 & 400 PSIG Range
Inches (mm)