Professional Documents
Culture Documents
PPE Inspection Checklist
PPE Inspection Checklist
PPE Inspection Checklist
Specification
Helmet shall be compatible with other ancillary equipment such as
Earmuffs, Welder's shields, Face shield, Miners Cap Lamp etc.
1 Suspension
Chin Strap
15 mm width and 55 cm long with buckle for adjustability.
Shell
Hard & smoothly finished HDPE / PVC material.
Realize the Vision Improving EHS Performance through meaningful Engagement of Workforce
Lanyard
1. Lanyard shall be of 12mm polypropylene rope and of length not
more than 2 m.
2. The ends shall be spliced and covered with transparent sleeve
& the curved portion protected with thimble.
3. The hook shall be non-separable from the lanyard.
4. Shall be single or double lanyard, based on the requirement.
Hook
1. Hooks shall be of self-closing type. The hooks should not
disengage if the pressure is exerted accidentally on the tongue
or latch.
2. The opening in the hook shall be minimum 18 mm.
3. Hooks shall be of any one of the following types
Carabiner
Snap Hook
Scaffold Hook
Class of Full body harness:
1. Approved Classes: Class A & Class L
2. Only Class L harness shall be used in conjunction with rope
grab fall arrestor.
LIFE LINE:
Minimum 20mm diameter polypropylene rope or Minimum 8 mm wire
rope shall be used as a lifeline.
Respirators
Conformance to standard
The respirator shall be certified to any of the Indian Standard given
below or DGMS certification or any internationally recognized
certification like CE, UL Mark.
3
IS 6194 : 1971 Specification for Intermittent Positive Pressure
Respirator, Bag Type, Manually Operated
IS 9473 : 2002 Respiratory Protective Devices - Filtering Half
Masks to Protect Against Particles Specification
IS 10245 : Part 1 : 1996 Breathing apparatus Part 1 Closed circuit
breathing apparatus (compressed oxygen cylinder) - Specification
Realize the Vision Improving EHS Performance through meaningful Engagement of Workforce
Safety Nets
5. The size of the net shall be as per site requirement. Unit of
measurement for Safety Net shall be Sq.m (square meters)
Realize the Vision Improving EHS Performance through meaningful Engagement of Workforce
EYE Protection
8 Goggles, Safety Spectacles, Face Shield shall conform to IS: 5983
1980 or shall have the certification from DGMS or any other
international certification such as CE or UL Mark.
Hand Gloves
The fit of gloves should be such that the fingers should have ample
room.
CANVAS Gloves canvas stitching with nylon thread conforming to
IS: 6994-(part-I) 1973.
CROME LEATHER gloves -
9
conforming to IS: 6994-(part-I) 1973.
RUBBER Gloves
15000 volts - conforming to IS: 4770-1991.
COTTON Gloves (for material handling) Leather cum canvas-304mm
long, double leather for five finger type, double stitching spaced at
1mm. - conforming to IS: 6994-(part-I) 1973.
Realize the Vision Improving EHS Performance through meaningful Engagement of Workforce
Realize the Vision Improving EHS Performance through meaningful Engagement of Workforce