Professional Documents
Culture Documents
8 CC Electromagnet
8 CC Electromagnet
Electromagnet
KNOW:
UNDERSTAND:
DO:
Materials required:
Base rubber sheet, Square rubber sheet, Battery jack, Iron bolt, Double sided tapes, Paper clips, Copper
coil, Cells
Construct an electromagnet accordingly to the teacher’s instructions and answer the following based on
your observations
1. Bring the setup near to the iron paper clips and note down your observations:
Checkpoint:
1.What happens when you replace the iron bolt in the with a plastic bolt?
2. John has made an electromagnet. But he has used a stainless steel bolt in place of iron bolt. He
observed the paperclips sticking to the bolt when the switch is turned ON, but the bolts are still stuck on
to the bolt, even after the switch is turned off. What would be the reason?
Materials required:
Base rubber sheet, Square rubber sheet, Battery jack, Iron bolt, Double sided tapes, Paper clips, Copper
coil, Cells, Compass
2. Reverse the negative and positive terminals, i.e., connect the red end of the battery holder to the end
of the coil which was previously connected to the black end, and vice-versa. What do you observe?
b. The magnetic needle deflects in the same manner as in the previous case.
c. The magnetic needle deflects, but in the opposite direction to that of previous case
a. The direction of the magnetic field produced doesn’t depend upon the direction of current
b. The direction of the magnetic field produced depends upon the direction of current
Checkpoint:
1. Bring a magnetic compass near the electromagnet and identify, mark the poles in the boxes given .
a. b.
2. Bring a magnetic compass near the electromagnet and draw the magnetic lines of force.
Grade - 8
Checkpoint:
1.In which of the following cases, the magnet is repelled? Circle the correct option.
Note: The long line indicates positive terminal and short line indicates the negative terminal of the
battery.
1.If a strong permanent magnet is used and AC power supply is given. (Magnet is placed inside the coil
and it is fixed at one place and coil is movable.) What do you observe when a magnetic compass is
placed near to it?
Task 3:
Materials required:
Base rubber sheet, Square rubber sheet, Battery jack, Iron bolt, Double sided tapes, Paper clips, Copper
coil, Cells, Compass
Grade - 8
1. Place a magnetic compass near the electromagnet. Move it along the horizontal until a point where
the magnetic needle cannot deflect. Note that minimum distance as X. Now, increase the amount of
current supplied, by increasing the number of batteries.
a. X > Y
b. X = Y
c. X < Y
a. The strength of the magnetic field increases with increase in the amount of current supplied
b. The strength of the magnetic field decreases with increase in the amount of current supplied
c. The strength of the magnetic field remains the same with increase in the amount of current supplied
Checkpoint:
HOTS questions:
2. What happens if two strong electromagnets are kept closer to each otherand an AC power supply is
given to one electromagnet and DC power supply to other?
Grade - 8
Rubric: