1A-244 Engine Control System (6WF1)
Itis necessary to enter (programming) all data into the
‘engine control module (ECM) when the ECM, injector,
Programming
Explanation of Functions and Operations + Injector 1D code
and other such parts are replaced,
Prior Check Points When Programming
When performing programming, check the following + Engine (type, power output range modification)
Moms When Programming is Required
Programming is required when the items below is
replaced.
+ ECM
items as required prior to starting the procedure. + Injector
+ Engine type
Each Item
item Intended use
FO [Fuel FO|Upload Fuel Delivery | Used when replacing the ECM, when data is read into the scan
Delivery Rate Data tool from the ECM before replacement,
cae Fi | Download Fuel Delivery|Used when replacing the ECM, when dala is registered
Rate Data (written) into the ECM from the scan tool after replacement,
F2 | Service Mode Used when replacing the ECM. When data cannot be read from
the ECM before replacement, this is used to write Q adjustment
(uel delivery rate) data to the ECM.
Fi [Injector 1D] FO
Injector 1D Code
Used when checking the injector ID codes of each cylinder.
Code Fi
ID Code Registration
Used when replacing the ECM. Used when data cannot be
uploaded from the ECM before replacement, or when
registering the injector ID code when replacing injectors,
Fo
Tipiead 1D Caria
Tised when replacing the FCM, when data is read intn tha scan
tool from the ECM before replacement,
Fa
Download ID Code
Used when replacing the ECM, when data is registered
(written) into the ECM from the scan tool after replacement,
F4
History Information
Used when viewing the data write history.