Download as pdf or txt
Download as pdf or txt
You are on page 1of 27

1 EvoHeat CS & CS-GEN2 Series Manual

Contents
1. Introduction __________________________________________________________________________________ 2
2. Unit Dimensions ______________________________________________________________________________ 3
3. Safety Instructions _____________________________________________________________________________ 4
4. Installation ___________________________________________________________________________________ 5
4.1 System Installation _________________________________________________________________________ 5
4.2 Location Recommendations __________________________________________________________________ 6
4.3 Airflow Clearances __________________________________________________________________________ 6
4.4 Adequate Water Flow _______________________________________________________________________ 7
4.5 Rubber Feet _______________________________________________________________________________ 7
4.6 Drainage & Condensation ____________________________________________________________________ 7
4.6 Plumbing _________________________________________________________________________________ 7
4.7 Electrical Connection ________________________________________________________________________ 8
4.8 Initial Start-up _____________________________________________________________________________ 8
5. Operation ____________________________________________________________________________________ 9
5.1 Main Controller Interface ____________________________________________________________________ 9
5.2 Functions of the Controller ___________________________________________________________________ 9
5.2.1 Using the HELP Button ___________________________________________________________________ 9
5.2.2 Starting & Shutting Down_________________________________________________________________ 9
5.2.3 Switching Modes ______________________________________________________________________ 10
5.2.4 System State Checking __________________________________________________________________ 10
5.2.5 Changing Temperature__________________________________________________________________ 10
5.2.6 Clock Setting __________________________________________________________________________ 10
5.2.7 Timer Settings _________________________________________________________________________ 11
5.2.8 Keyboard Lock ________________________________________________________________________ 13
5.2.9 Malfunction Display ____________________________________________________________________ 13
6. Troubleshooting _____________________________________________________________________________ 14
6.1 Error Codes ______________________________________________________________________________ 16
7. Appendix ___________________________________________________________________________________ 17
7.1 Cable Specifications ________________________________________________________________________ 17
7.2 Parameter Table __________________________________________________________________________ 17
7.3 Wiring Diagrams __________________________________________________________________________ 18
8. Maintenance ________________________________________________________________________________ 25
8.1 Energy Saving Tips _________________________________________________________________________ 25
9. Warranty ___________________________________________________________________________________ 26
2 EvoHeat CS & CS-GEN2 Series Manual

1. Introduction
This manual contains all the necessary information in regard to the installation, troubleshooting, operation and
maintenance of this unit. Ensure instructions in this manual are adhered to at all times. Failing to comply with these
recommendations will invalidate the warranty.

The EVO CS & CS-GEN2 commercial heat pump is the most efficient way to heat a commercial pool regardless of size
or location. Our commercial heat pumps are ideal for sports and leisure centres, aquaculture, agriculture, water
parks, hotels, resorts, apartments and office builds – there is no job in the field too big for the EVO CS Series!

MODEL EVO CS38 EVO CS47 EVO CS57 CS95-GEN2 CS120-GEN2 CS145-GEN2 CS200-GEN2

Heat output at 24°C


38 47 57 95 120 145 190
air/26°C water (kW)
Heat output at 15°C
31.1 39.7 48.1 72.5 103 120 160
air/26°C water (kW)
Cooling output at 35°C
21.6 28.2 36 64 80 97 119
air/30°C water (kW)
C.O.P. at 24° C air 5.3 5.05 5.14 5.49 5.7 5.69 5.79
Power input at 24 deg
7.16 9.3 11.1 17.3 21 25.5 32.8
air (kW)
Power supply 380-415/3/50
*Max running current
13.8 19.12 25.1 40 46 60 80.1
AMPS per phase
Compressor type Scroll

Refrigerant R410A
PVC water connection
50 50 50 DN 110 DN 110 DN 110 DN 110
(mm)
Water flow rate
200 250 325 483 583 1033 1000
(L/min)
Noise dB(A) at 1M 61 61 61 61 62 63 67

Unit dimensions L/W/H 1490/735 1490/735 1490/735 2170/1070 2175/1070 2175/1070 2180/1070
(mm) /1200 /1200 /1200 /1920 /2030 /2030 /2060

Weight
270/252 300/254 300/260 679/632 694/648 709/664 940/908
packed/unpacked (kg)

*Running current max: 43°C ambient heat /29°C in cooling mode. The data above is based on the EVO heat pump only, it does not include
auxiliary devices. Product specification information provided above is correct at the date of printing, this data may change without notice.
Please speak with an EvoHeat Specialist for the most current product specifications.
3 EvoHeat CS & CS-GEN2 Series Manual

2. Unit Dimensions

CS38,
CS47 &
CS57

CS95-
GEN2

CS120-
GEN2 &
CS145-
GEN2

CS200-
GEN2

CS A (L) B (W) C (H) D E F G H I J

38, 47 & 57 1490 735 1200 1464 480

95 2170 1070 1920 240 160 174

120 & 145 2175 1070 2030 1800 1020 530 400 155

200 2180 1070 2060 900 900 1020 450 160 136 50
4 EvoHeat CS & CS-GEN2 Series Manual

3. Safety Instructions
• Installation, repair or relocations must be done by a fully qualified person and not by the customer. If done
incorrectly it may cause fire, electric shock, water leakage and other hazards.

• Maintenance and operation must be carried out according to the recommended time and frequencies, as
stated in this manual.

• To avoid risk of electrical shock, the unit must have a good power connection and earthing.

• If the supply cord is damaged, it must be replaced.

• Use genuine standard spare parts only.

• When an abnormality (smell of burning, etc.) occurs, stop the unit and disconnect the power or turn off the
breaker. If the unit continues to be operated in an abnormal condition, it may cause a fire or hazards.

• Do not insert fingers or objects into the fans or evaporator of the unit.

• The unit is equipped with an over-load protection system. After a previous stoppage, the unit will not start
for at least 3 minutes.

• For unit cleaning or maintenance, switch off and disconnect the power of the unit.

• Do not install the unit near flammable gas or spray flammable substances near it.

• Ensure the heat pump is installed on a strong and stable platform.

• A circuit breaker must be installed for the unit.

• Use supply wires suitable for 75°C

* Caution: Single wall heat exchanger, not suitable for potable water connection.
5 EvoHeat CS & CS-GEN2 Series Manual

4. Installation
4.1 System Installation

The schematic diagram is for reference only. Please check the water inlet/outlet label on the heat pump while
plumbing the unit.

INSTALLATION ITEMS

EvoHeat only provide the main EvoHeat unit and EvoHeat accessories; other items in the illustration above should be
provided by the user or the installer.

EVOHEAT ACCESSORIES – DO NOT THROW AWAY

All EvoHeat units are provided with rubber feet, controller and leads for the controller– do not throw them away as
they are required as part of the installation.

CHECK HEATER CONDITION ON ARRIVAL

Check the heater packaging upon delivery for any obvious signs of damage. Inform your supplier IMMEDIATELY if
there is any evidence of rough handling. When the heater has been removed from the packaging check the
refrigerant gauge on the front panel of the unit. The gauge should be showing a pressure of approx 10-20 on the
outside red band – any less than this figure means there may be a leak in the refrigerant system, and you should
immediately contact your EvoHeat Dealer.

General installation information disclaimer: Install your EVOHEAT heat pump in accordance with the procedures in
the product manual. Always check that your installation will comply with local building and council regulations.

IMPORTANT: EvoHeat heat pumps MUST be connected by a licensed electrician. Under no circumstances should an
unlicensed person attempt to install or repair an EvoHeat heat pump themselves. Heater electrical installation
undertaken by an unlicensed installer will void the warranty. Correct installation is required to ensure safe and
efficient operation of your pool heater.

Before installation it is very important to ensure 5 variables are carefully checked to allow the unit to operate
correctly.

• Location
• Clearances & Air Flow
• Adequate water flow & plumbing
• Correct electrical connection & supply
6 EvoHeat CS & CS-GEN2 Series Manual

4.2 Location Recommendations


Installation and service must be performed by a qualified installer.

Evo recommend the heat pump should be installed in an outdoor location with appropriate ventilation. Installing the
heater indoors without adequate ventilation, or in a poorly ventilated enclosed space, will result in very poor
performance and can, in extreme cases, damage the heater. Ensure the heater is installed in a well-ventilated area
with plenty of fresh air.

Evo recommend the heat pump should ONLY be installed in a location with appropriate ventilation.

If installing the heater on an existing pump/filtration system, the heater must be installed AFTER the filter and
BEFORE the chlorinator/sanitizer.

The heat pump should be installed on a flat level surface as close as possible to the pool.

The Evo pool heat pump should be installed with a minimum clearance of at least 3.5m to the water’s edge.
Furthermore, EvoHeat recommend installing the heat pump no greater than 7.5 meters away from the water’s edge
due to heat loss from the piping.

A rough estimate of heat loss over a 30m pipe run can be as high as 600 Watts per hour per 5 degrees of
temperature difference between the air/ground and the pool water. These losses need to be taken into account over
long distances and piping may need to be insulated to reduce heat leakage.

The heat pump should be installed a maximum of 5m below the water level of the pool/spa. If further than 5M
please discuss with your EvoHeat specialist for the best advice.

Make sure the heat pump is not located where large amounts of water may run-off from a roof into the unit. Sharp
sloping roofs without gutters will allow excessive amounts of rainwater mixed with debris from the roof to be forced
through the unit. A water deflector may be needed to protect the heat pump.

4.3 Airflow Clearances


The heat pump unit needs continuous fresh air
whilst running. The heater draws up to 47000
m3/h ambient air through the sides and
discharges through the top fan cowl.

Installing the heater indoors or in an enclosed


space will result in very poor performance and
can in extreme cases damage the heater. Ensure
the heater is installed in a well-ventilated area
with plenty of fresh air, a minimum gap between
walls/fences etc of 1000mm on the sides,
800mm on the ends and a 3500mm overhead
clearance.

When units of a similar height are placed side by side, EvoHeat recommend a 1500mm clearance between units.
*Fan discharge distance can be reduced by adding a Plenum to alter the air flow direction. Contact EvoHeat or a
HVAC specialist for further advice. If you do not have a location with these suggested clearances, please contact our
EvoHeat Tech Support Specialist to discuss appropriate installation locations.

Leave sufficient space for unobstructed airflow into and out of the heater. Do not locate the heater in an enclosed
area, or the discharged cold air will recirculate into the unit and consequently lower the heating efficiency as well as
possible icing up.

If you do not have a location with these suggested clearances, please contact our EvoHeat Tech Support Specialist to
discuss appropriate installation locations.
7 EvoHeat CS & CS-GEN2 Series Manual

4.4 Adequate Water Flow


All EVOHEAT heat pumps have a factory preset internal water flow switch. If there is insufficient water flow the
heater will not operate.

It is CRITICAL that there is sufficient water flow to the unit. Incorrect water flow can cause a loss of efficiency and
possible damage to the unit. Optimal water flow rates are listed in the EvoHeat manual. It is imperative that water
flow is kept as close as possible to these flow rates. Correct water flow not only offers optimal heater performance,
but may also prevent possible damage to your heater.

Before connecting the heater to the plumbing, all piping must be thoroughly flushed to ensure no debris can enter
the heater. Failure to remove pipe debris can jam or damage the flow switch and may cause damage to the heater.
When cleaning the pool it is advisable to turn off your heater as restricted water flow may cause the heater to shut
down and indicate low water flow fault (E03 error) or high pressure fault (E01 Error).

IMPORTANT: A Variable speed pump or bypass valve and plumbing MUST be fitted to allow water flow to be
adjusted through the heater. Do not direct connect a water pump with higher flow than required to the heat
pump.

4.5 Rubber Feet


All EvoHeat units are provided with rubber feet which EvoHeat highly recommend being installed. The rubber feet
help reduce vibration of the unit and help provide a space below the heat pump to install the drainage barbs.

4.6 Drainage & Condensation


Whilst the heater is operating, water in the air condenses on the fins of the evaporator.
During times of high humidity, the condensate may be several litres per hour. This may
give the impression that the heater is leaking, however this is a normal function of heat
pumps. The heat pump can also automatically activate the reverse cycle defrost feature
when required which increases condensation produced.

Ensure CS series heat pumps are installed level so condensate is not allowed to pool at
one end of the condensate tray!

Ensure CS-GEN2 series units are installed level to evenly distribute condensate through
the two drainage holes on the condensate pan, located at either end of the heat pump!

The condensate water captured will discharge from the heat pump through one end,
typically where the heat pumps Inlet/Outlet connections are located. The condensate discharges from the heat
pump through a 32mm female threaded connection. Ensure condensate is plumbed away from the heat pump to an
appropriate location, ideally a drain. Please Note: A 32mm Male threaded adapter is NOT supplied with the heat
pump.

4.6 Plumbing
The Swimming Pool Heat Pumps exclusive rated flow titanium heat exchanger requires no special plumbing
arrangements except bypass (please set the flow rate according to the nameplate). The water pressure drop is less
than 10kPa at max.

Flow rate: Since there is no residual heat or flame Temperatures, the unit does not need copper heat sink piping.
PVC pipe can be run straight into the unit.

Location: Connect the unit in the pool pump discharge (return) line downstream of all filter and pool pumps, and
upstream of any chlorinators, ozonators or chemical pumps.

Standard model have slip glue fittings which accept 40 mm PVC pipe for connection to the pool or spa filtration
piping. By using a 50 NB to 40NB you can plumb 40NB.

Give serious consideration to adding a quick coupler fitting at the unit inlet and outlet to allow easy draining of unit
for winterizing and to provide easier access should servicing be required.
8 EvoHeat CS & CS-GEN2 Series Manual

4.7 Electrical Connection


IMPORTANT: Always use a qualified Electrician to perform any electrical work. A licensed electrician must read the
information before connecting.

Ensure the power cable and circuit breaker are of a suitable size for the heater being installed. Also check that there
is adequate voltage and current available at the heater connection to run the unit.

Voltage range should be 220-230 volts for single phase, and 380-400 volts for 3 phase units. Voltage ranges outside
these parameters will cause heater damage and void your warranty.

1. Ensure power is disconnected during installation or service.


2. Always comply with the national and local electrical codes and standards.
3. Ensure electrical cable size is adequate for heater requirements at the installation location.
4. The heater must be equipped with a circuit breaker and isolation device.
5. Circuit breaker must be installed between the heater and the water circulation pump if the water pump is
hard-wired into the heater. Please note recommended circuit breaker sizes make no allowance for a water
pump hard wired into the heater.
6. The unit must be well earthed. Remove the front panel to access the electrical connection terminals of the
heater. The electrical wiring diagram is affixed to the inside of the front panel.

Correct phase connection is important with 3 phase heaters. NOTE: if 2 lights are showing on the 3 PHASE relay
monitor this means the EvoHeat heat pump has been wired correctly (one orange light and one green light). If
only one light is showing, the phases are out of rotation and need to be rotated to get the correct phase rotation.

4.8 Initial Start-up


Note: in order for the unit to heat the pool or spa, the filter pump must be running to circulate water through the heat exchanger.

After installation is completed, follow the steps below:


1. Turn on your filter pump. Check for water leaks and verify flow to and from the pool.
2. Turn on the electrical power supply to the unit, then press the key ON/OFF of wire controller, it should start after
several seconds.
3. After running a few minutes make sure the air leaving the top of the unit is cooler (between 5-10 ℃)
4. With the unit operating turn the filter pump off. The unit should also turn off automatically.
5. Allow the unit and pool pump to run 24 hours per day until desired pool water temperature is reached. (Note:
this may take up to several days depending on the initial water temperature and the size and location of the
pool). When the water-in temperature reaches the set temperature the unit will shut off. The unit will now
automatically restart (as long as your pool pump is running) when the pool temperature drops more than 1℃
below the set temperature.
TIME DELAY
The unit is equipped with a 3-minute built-in solid-state restart delay included to protect control circuit components
and to eliminate restart cycling and contactor chatter. This time delay will automatically restart the unit
approximately 3 minutes after each control circuit interruption. Even a brief power interruption will activate the
solid state 3-minute restart delay and prevent the unit from starting until the 5-minute countdown is completed.
Power interruptions during the delay period will have no effect on the 3-minute countdown.
9 EvoHeat CS & CS-GEN2 Series Manual

5. Operation
5.1 Main Controller Interface

Button Name Function


Press this button to start up/shut off the unit, cancel current operation or go back to
ON/OFF
previous interface.
HELP Press this button to check button function of system state.

MODE Press this button to change the current mode, page up or confirm current operation.

CLOCK Press this button to set the clock or turn the timer on/off.

UP Press this key to select the upwards option or increase the parameter value.

DOWN Press this key to select the downwards option or decrease the parameter value.

5.2 Functions of the Controller


5.2.1 Using the HELP Button
You can use at any interface and it will explain the buttons & functions of the current interface. To exit the help
interface, simply press the ON/OFF button.

EXAMPLE: Press HELP at the Main Interface

5.2.2 Starting & Shutting Down


To turn on/off the unit, press the ON/OFF button for 1 second. The screen will display as following for each state:
10 EvoHeat CS & CS-GEN2 Series Manual

5.2.3 Switching Modes


At the main interface, you can switch between the modes of cooling, economic heating, heating & rapid heating by
pressing . Example: Switch from Cooling mode to Economic Heating

Note: The operation of mode is invalid if the unit you purchase is heating only or cooling only.

5.2.4 System State Checking


At any interface you can enter the system working state by pressing TWICE, then using the UP and Down arrow
keys to highlight the required parameter, then press to enter. To exit, press the ON/OFF button

5.2.5 Changing Temperature


At the main interface, press the UP or DOWN key to adjust the temperature setting as desired. Once complete, press
the button to save the settings and exit. Press the ON/OFF button to exit without saving settings. Refer to the
Parameter Table to set relevant temperature.

5.2.6 Clock Setting


At the main interface press to enter the clock setting interface. Select the parameter you wish to change and
press to make the parameter begin flashing which indicates it can be changed. Press the UP or DOWN keys to
change the parameter value, then press to save. Press the ON/OFF button to return to the main menu.

Note: If there is no operation after 10 seconds, it will return to the main menu and changes will automatically be saved.
To change the date, the same process is followed.
11 EvoHeat CS & CS-GEN2 Series Manual

5.2.7 Timer Settings


Four timer periods can be set according to your needs.

From the main interface, press to enter the timer setting, press DOWN to select Timer, then press to enter
the timer setting interface. The process is much the same as adjusting the Clock settings. To cancel and return to the
previous menu, press the ON/OFF button.

5.2.7.1 Timer
Each timer has an ON value when the unit will turn on an OFF value when the unit will turn off (00:00-00:00).

These timers are required for the Daily Timers & Temperature Timers to work.

Example: TIMER1 Unit is on at 7:30am – and off at 10pm


12 EvoHeat CS & CS-GEN2 Series Manual
5.2.7.2 Daily Timer
The Daily Timer allows you to apply your timers to particular days of the week.

• OFF means that the unit will not run on that day.
• ON means the system will be running for a whole day.
• Applying one timer will have the unit run from A-B.
• Applying two timers will mean the unit runs from A-B, then C-D.

Example: Setting the operation on Friday to run two different timers.


If the Timer2 were 8am-10am & Timer 3 were 1pm-5pm, the unit would operate or stop accordingly.

5.2.7.3 Temperature Timer


The temperature timer will adjust the temperature as desired for your set Timer periods.

Example: If Timer 3 was set for 1pm – 5pm on a Monday, the unit would operate to the set temperature during the
timeframe on the Monday.
13 EvoHeat CS & CS-GEN2 Series Manual

5.2.8 Keyboard Lock


To lock the controller after adjusting settings, at the main interface hold the ON/OFF button for 5 seconds. The
keyboard will be locked and display a lock symbol on the screen. To unlock the screen, hold the ON/OFF button for 5
seconds. Note: If the unit is in alarm state, the keyboard lock is automatically removed.

5.2.9 Malfunction Display


If a fault occurs, there will be a malfunction code showing on the controller screen. Refer to the Malfunction Table
(9.9) to find out the failure cause and solutions.
14 EvoHeat CS & CS-GEN2 Series Manual

6. Troubleshooting
EvoHeat have developed a YouTube Channel where you will find useful videos regarding the CS
Controller usage. www.youtube.com/evoheat

IF YOUR HEAT PUMP ISN’T WORKING, CHECK THE FOLLOWING…


• Is the screen of control panel lit?

If not, make sure the electrical wires and cables are correctly connected and the power is on. Ensure any circuit
breaker devices are set to the ON position and press the ON button on your controller. Check your controller cable is
plugged in and is not damaged. If the unit has been shut off or the power has been interrupted the heater will not
restart for a 5-minute period to protect the compressor. Wait 5 minutes before attempting a restart.

• Is there enough water flow?

If the screen displays a water flow related error check the water flow. Is the water pump in operation and the system
free of debris that may cause a blockage? Disconnect pool cleaners to ensure proper water flow.

• Is the current pool/spa water temperature higher than the set temperature on the controller?

If so the unit will not operate until the pool/spa water temperature falls below the set temperature on the
controller.

• Is your heat pump set to run at the correct time and date?

Please check your current timing or temperature modes on your controller – you may have programmed the unit to
turn on at a different time.

• Does your heat pump have an error message on the screen?

If yes, refer to the error code table 19.

IF YOUR HEAT PUMP IS RUNNING BUT NO HEATING, CHECK THE FOLLOWING…


• Is the fan functioning?

If not contact EvoHeat tech support on 1300 859 933

• Is the air discharged from the top of the fan noticeably cooler than the ambient temperature?

If not, check the refrigerant gauge on the bottom panel of the heater. Another way to determine if the heater is
working correctly is to look at the controller’s screen and check to see if the WATER OUT temp is higher than the
WATER IN temp. Check also the INLET WATER TEMP is lower than the HEAT TEMP set point.

If the gauge shows less than 0.8MPA contact EvoHeat tech support to check the refrigerant system.

Example of normal
Example of empty (loss of refrigerant) (Note: can vary based on ambient
temperature)
15 EvoHeat CS & CS-GEN2 Series Manual
Ensure sufficient fresh airflow around the unit as per installation instructions.

Make sure cold air discharged does not recycle back through the heater. Check the condenser fins. If they are dirty
or blocked use a low flow garden hose only (Pressurised water may cause damage to the heater).

• The unit will periodically defrost when the ambient air temperature is lower than 8 degrees C.

IF YOUR HEAT PUMP IS RUNNING CONTINUOUSLY, CHECK THE FOLLOWING…


• Check the set temperature is at your desired level and that the pool water temperature is at or below this set
point.

• Alternatively, this could be a possible electrical component failure – contact EvoHeat tech support on 1300 859 933

IF YOUR HEAT PUMP HAS WATER APPEARING AROUND THE BASE OF THE UNIT, CHECK THE
FOLLOWING…
The water appearing around the base of your heat pump could be condensation or a possible water leak. To
determine, check the following:

• Check the discharge for the presence of chlorine.

If the water has no chlorine then it is condensation and is it normal – see drainage and condensation for more
information. If the water has chlorine, it is a water leak and you need to contact EvoHeat tech support on 1300 859
933. Or…

• Turn the heater off and run the water pump continuously for a period of 2-4 hours.

If the water dries out, then it was condensation – see drainage and condensation for more information. If there is a
continuous leak contact EvoHeat tech support on 1300 859 933.

DRAINAGE & CONDENSATION


Whilst the heater is operating, water in the air condenses on the fins of the evaporator. In the instance of high
humidity, the condensate may be several litres per hour. This may give the impression that the heater is leaking,
however this is a normal function of heat pumps.

The heater will automatically activate reverse cycle or de-icing mode when required which also increases condensate
discharge. This normally occurs at temperatures below 8°C. The condensate water will discharge through the base of
the heater. As an option a pipe can be connected to the drain on the base of the unit to direct condensate water to
an appropriate location.

NOTE: A quick way to verify that the water is condensation is to shut off the unit and keep the pool pump running. If
the water stops running out of the basepan, it is condensation. AN EVEN QUICKER WAY IS to TEST THE DRAIN WATER
FOR CHLORINE – if the is no chlorine present, then it’s condensation.
16 EvoHeat CS & CS-GEN2 Series Manual

6.1 Error Codes


CODE FAILURE REASON SOLUTION
Power on
Normal working
P01 Inlet temp. sensor failure The temp sensor is broken or short circuit Check or change the temp. sensor
P02 Outlet temp. sensor failure The temp sensor is broken or short circuit Check or change the temp. sensor
P04 Ambient temp. sensor failure The temp sensor is broken or short circuit Check or change the temp sensor
P15 System 1 coil temp. sensor failure The temp sensor is broken or Check or change the temp sensor
short circuit
P25 System 2 coil temp. sensor failure The temp sensor is broken or short circuit Check or change the temp sensor
P35 System 3 coil temp. sensor failure The temp sensor is broken or Check or change the temp sensor
short circuit
P45 System 4 coil temp. sensor failure The temp sensor is broken or short circuit Check or change the temp sensor
P17 System 1 absorb temp. sensor The temp sensor is broken or Check or change the temp sensor
failure short circuit
P27 System 2 absorb temp sensor failure The temp sensor is broken or short circuit Check or change the temp sensor
P37 System 3 absorb temp sensor failure The temp sensor is broken or short circuit Check or change the temp sensor
P47 System 4 absorb temp sensor The temp sensor is broken or Check or change the temp sensor
failure short circuit
P19 System 1 anti-freezing temp sensor The temp sensor is broken or short circuit Check or change the temp sensor
failure
P29 System 2 anti-freezing temp. The temp sensor is broken or Check or change the temp sensor
sensor failure short circuit
P39 System 3 anti-freezing temp. sensor The temp sensor is broken or short circuit Check or change the temp sensor
failure
P49 System 4 anti-freezing temp. The temp sensor is broken or Check or change the temp sensor
sensor failure short circuit
P191 Using side system 1 anti-freeze The temp sensor is broken or short circuit Check or change the temp sensor
temp failure
P291 Using side system 2 anti-freeze The temp sensor is broken or short circuit Check or change the temp sensor
temp failure
P391 Using side system 3 anti-freeze The temp sensor is broken or Check or change the temp sensor
temp failure short circuit
P491 Using side system 4 anti-freeze The temp sensor is broken or short circuit Check or change the temp sensor
temp failure
P151 System 1 coil inlet temp failure The temp sensor is broken or Check or change the temp sensor
short circuit
P251 System 2 coil inlet temp failure The temp sensor is broken or short circuit Check or change the temp sensor
P351 System 3 coil inlet temp failure The temp sensor is broken or Check or change the temp sensor
short circuit
P451 System 4 coil inlet temp failure The temp sensor is broken or short circuit Check or change the temp sensor
E05 System protection The protection system has failed Check each protection point of the
system
E08 Communication Failure Communication failure between wire Check the wire connection between
controller and main board remote wire controller and main board
E11 High pressure 1 protection The high-pressure switch is Check the pressure switch and cold
broken circuit
E21 High pressure 2 protection The high-pressure switch is broken Check the pressure switch and cold
circuit
E31 High pressure 3 protection The high-pressure switch is broken Check the pressure switch and cold
circuit
E41 High pressure 4 protection The high-pressure switch is Check the pressure switch and cold
broken circuit
E12 Low pressure 1 protection The high-pressure switch is broken Check the pressure switch and cold
circuit
E22 Low pressure 2 protection The high-pressure switch is Check the pressure switch and cold
broken circuit
E32 Low pressure 3 Protection The high-pressure switch is broken Check the pressure switch and cold
circuit
E42 Low pressure 4 protection The high-pressure switch is broken Check the pressure switch and cold
circuit
E03 Water flow failure No water/little water in water system Check the pip water flow and water
pump
E04 Electrical-heat over heat failure Electrical-heat is over heat Check or change electrical-heat
17 EvoHeat CS & CS-GEN2 Series Manual
CODE FAILURE REASON SOLUTION
E06 Water-inlet and outlet temp. Water flow is not enough and low Check the pipe water flow and whether
difference differential pressure the water system is jammed or not
E06 System 1/2/3/4 anti-freeze Water flow is not enough and low differential Check the pipe water flow and whether
protection pressure water system is jammed or not
E171 The system 1 use side anti-freezing Water flow is not enough Check the pipe water flow and whether
protection the water system is jammed or not
E271 The system 2 use side anti-freezing Water flow is not enough Check the pipe water flow and whether
protection the water system is jammed or not
E371 The system 3 heat source side anti- Water flow is not enough Check the pipe water flow and whether
freezing protection the water system is jammed or not
E471 The system 4 heat source side anti- Water flow is not enough Check the pipe water flow and whether
freezing protection the water system is jammed or not
E19 The primary anti-freezing The ambient temp is low /
protection
E29 The secondary anti-freezing The ambient temp is low /
protection

7. Appendix
7.1 Cable Specifications
Single Phase Unit
Nameplate maximum Phase line Earth line MCB Creepage Protector Signal Line
current
No more than 10A 2 x 1.5mm2 1.5mm2 20A 30mA less than 0.1 sec
10~16A 2 x 2.5mm2 2.5mm2 32A 30mA less than 0.1 sec
16~25A 2 x 4mm2 4mm2 40A 30mA less than 0.1 sec
25~32A 2 x 6mm2 6mm2 40A 30mA less than 0.1 sec
32~40A 2 x 10mm2 10mm2 63A 30mA less than 0.1 sec
40~63A 2 x 16mm2 16mm2 80A 30mA less than 0.1 sec
n x 0.5mm2
63~75A 2 x 25mm2 25mm2 100A 30mA less than 0.1 sec
75~101A 2 x 25mm2 25mm2 125A 30mA less than 0.1 sec
101~123A 2 x 35mm2 35mm2 160A 30mA less than 0.1 sec
123~148A 2 x 50mm2 50mm2 225A 30mA less than 0.1 sec
148~186A 2 x 70mm2 70mm2 250A 30mA less than 0.1 sec
186~224A 2 x 95mm2 95mm2 280A 30mA less than 0.1 sec

Three Phase Unit


Nameplate maximum Phase line Earth line MCB Creepage Protector Signal Line
current
No more than 10A 2 x 1.5mm2 1.5mm2 20A 30mA less than 0.1 sec
10~16A 2 x 2.5mm2 2.5mm2 32A 30mA less than 0.1 sec
16~25A 2 x 4mm2 4mm2 40A 30mA less than 0.1 sec
25~32A 2 x 6mm2 6mm2 40A 30mA less than 0.1 sec
32~40A 2 x 10mm2 10mm2 63A 30mA less than 0.1 sec
40~63A 2 x 16mm2 16mm2 80A 30mA less than 0.1 sec
n x 0.5mm2
63~75A 2 x 25mm2 25mm2 100A 30mA less than 0.1 sec
75~101A 2 x 25mm2 25mm2 125A 30mA less than 0.1 sec
101~123A 2 x 35mm2 35mm2 160A 30mA less than 0.1 sec
123~148A 2 x 50mm2 50mm2 225A 30mA less than 0.1 sec
148~186A 2 x 70mm2 70mm2 250A 30mA less than 0.1 sec
186~224A 2 x 95mm2 95mm2 280A 30mA less than 0.1 sec
If the unit is to be installed outdoors, ensure that a UV resistant cable is used.

7.2 Parameter Table


Meaning Default Remarks
Set-point of cooling target temperature 27°C Adjustable
Set-point of heating target temperature 27°C Adjustable
Set-point of auto mode target temperature 27°C Adjustable
18

0 1 2 3 4 5 6 7 8 9

N
L1 RED L1(A) 11

L1

L1
L1

L1
L1
L1
L2 WHT L2(B) PM 14

L2

L2
L2

L2
L3 L2 L1
L3 BLU 12
A L3(C) A
N14

L3
L3

L3
N BLK

N
N

N
N
N
N
N
N

L2
TO POWER SUPPLY

L1
L1
415V/3N~/50Hz K3 KM1 KM2

4V

F
N
N
1 3 5 7
4V 02 N

L1
L2
L3
L1
L2
L3
2 4 6 8
7.3 Wiring Diagrams

L11
L12
N

PH

N
N

L1
L2
L3
N
4V1
4V2
1 3 5 7
1 3 5 7 PH 03 N
2 F 4 01 6 N 8 2 4 6 8
KM1 KM2

N
N
KM5 CH1 CH2
4V2

P2
P3

P1
RED

N
V1
V2
B B

U1
U2

W1
W2

N
WHT RED WHT BLU RED WHT BLU 4V1 PH1 PH2
FM1

N
N
V V
U W U W

P2
P3

P1
EvoHeat CS & CS-GEN2 Series Manual

RED 3 3

N
COMP1 COMP2
WHT
FM2
L1 L2 L3 N

C To pump C

N
N
KM2 KM1

K1

K2
AT:Ambient temperature

N
CH:Compressor heater
KM5 K3
COMP:Compressor

K3

K5
CT:Coil temperature EEV2 EEV1
EEV:Electronic expand valve 5 5
N14

D D
L1

4V
K5
K3
K2
K1

PH
ET:Exhaust temperature
FM:Fan motor
L
N
N

FS:Flow switch

RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01

CN5

CN1
CN6

FOHP:Fan-motor overheat protect


HP:High pressure protection
PC4001
IT:Inlet water temperature
KM1:Contactor of compressor1
E E
KM2:Contactor of compressor2

5V
KM5:Contactor of pump
K3:Relay of fan motor

GND 12V
GND NET
GND DI 01
GND
GND AI 01
GND AI 02
GND AI 03
GND AI 04
GND AI 05
GND AI 06
GND AI 07
GND AI 08
GND AI 09
GND AI 10
GND AI 11(50)
GND AI 12(50)
GND DI 02
GND DI 03
GND DI 04
GND DI 05
GND DI 06
GND DI 07
GND DI 08
GND DI 09
GND DI 10
GND DI 11
GND DI 12
GND DI /DO 1
GND DI /DO 2

LP:Low pressure protection


1
4

IT
IT
AT
AT

OT
OT
FS
FS

ET1
ET1
ET2
ET2

CT1
CT1
CT2
CT2

BLU
Y/G
LP1
LP1
LP2
LP2

HP1
HP1
HP2
HP2

SUT1
SUT1
SUT2
SUT2

BRN
OT:Outlet water temperature
4

PH:Pan heater 3
FS

PM:Phase monitor t t t t t t t t t
5K 5K 5K 5K 5K 5K 1 2 3 4
5K 50K 50K
F Controller ON/OFF ON/OFF F
Q: Air switch input output
SUT:Suction temperature IT OT CT1 CT2 AT SUT1 SUT2 ET1 ET2 HP1 LP1 HP2 LP2 FS Remote
FOHP1
FOHP1
FOHP2
FOHP2

Cool/heat
4V: 4 way valve
FOHP1 FOHP2

CODE:20121207-0005
19

0 1 2 3 4 5 6 7 8 9

N
L1 RED L1(A) 11

L1

L1
L1

L1
L1
L1
L2 WHT L2(B) PM 14

L2

L2
L2

L2
L3 L2 L1
L3 BLU 12
A L3(C) A
N14

L3
L3

L3
N BLK

N
N

N
N
N
N
N
N

L2
TO POWER SUPPLY

L1
L1
415V/3N~/50Hz K3 KM1 KM2

4V

F
N
N
1 3 5 7
4V 02 N

L1
L2
L3
L1
L2
L3
2 4 6 8

L11
L12
N

PH

N
N

L1
L2
L3
N
4V1
4V2
1 3 5 7
1 3 5 7 PH 03 N
2 F 4 01 6 N 8 2 4 6 8
KM1 KM2

N
N
KM5 CH1 CH2
4V2

P2
P3

P1
RED

N
V1
V2
B B

U1
U2

W1
W2

N
WHT RED WHT BLU RED WHT BLU 4V1 PH1 PH2
FM1

N
N
V V
U W U W

P2
P3

P1
EvoHeat CS & CS-GEN2 Series Manual

RED 3 3

N
COMP1 COMP2
WHT
FM2
L1 L2 L3 N

C To pump C

N
N
KM2 KM1

K1

K2
AT:Ambient temperature

N
CH:Compressor heater
KM5 K3
COMP:Compressor

K3

K5
CT:Coil temperature EEV2 EEV1
EEV:Electronic expand valve 5 5
N14

D D
L1

4V
K5
K3
K2
K1

PH
ET:Exhaust temperature
FM:Fan motor
L
N
N

FS:Flow switch

RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01

CN5

CN1
CN6

FOHP:Fan-motor overheat protect


HP:High pressure protection
PC4001
IT:Inlet water temperature
KM1:Contactor of compressor1
E E
KM2:Contactor of compressor2

5V
KM5:Contactor of pump
K3:Relay of fan motor

GND 12V
GND NET
GND DI 01
GND
GND AI 01
GND AI 02
GND AI 03
GND AI 04
GND AI 05
GND AI 06
GND AI 07
GND AI 08
GND AI 09
GND AI 10
GND AI 11(50)
GND AI 12(50)
GND DI 02
GND DI 03
GND DI 04
GND DI 05
GND DI 06
GND DI 07
GND DI 08
GND DI 09
GND DI 10
GND DI 11
GND DI 12
GND DI /DO 1
GND DI /DO 2

LP:Low pressure protection


1
4

IT
IT
AT
AT

OT
OT
FS
FS

ET1
ET1
ET2
ET2

CT1
CT1
CT2
CT2

BLU
Y/G
LP1
LP1
LP2
LP2

HP1
HP1
HP2
HP2

SUT1
SUT1
SUT2
SUT2

BRN
OT:Outlet water temperature
4

PH:Pan heater 3
FS

PM:Phase monitor t t t t t t t t t
5K 5K 5K 5K 5K 5K 1 2 3 4
5K 50K 50K
F Controller ON/OFF ON/OFF F
Q: Air switch input output
SUT:Suction temperature IT OT CT1 CT2 AT SUT1 SUT2 ET1 ET2 HP1 LP1 HP2 LP2 FS Remote
FOHP1
FOHP1
FOHP2
FOHP2

Cool/heat
4V: 4 way valve
FOHP1 FOHP2

CODE:20121207-0005
20

0 1 2 3 4 5 6 7 8 9

N
L1 RED L1(A) 11

L1

L1
L1

L1
L1
L1
L2 WHT L2(B) PM 14

L2

L2
L2

L2
L3 L2 L1
L3 BLU 12
A L3(C) A
N14

L3
L3

L3
N BLK

N
N

N
N
N
N
N
N

L2
TO POWER SUPPLY

L1
L1
415V/3N~/50Hz K3 KM1 KM2

4V

F
N
N
1 3 5 7
4V 02 N

L1
L2
L3
L1
L2
L3
2 4 6 8

L11
L12
N

PH

N
N

L1
L2
L3
N
4V1
4V2
1 3 5 7
1 3 5 7 PH 03 N
2 F 4 01 6 N 8 2 4 6 8
KM1 KM2

N
N
KM5 CH1 CH2
4V2

P2
P3

P1
RED

N
V1
V2
B B

U1
U2

W1
W2

N
WHT RED WHT BLU RED WHT BLU 4V1 PH1 PH2
FM1

N
N
V V
U W U W

P2
P3

P1
EvoHeat CS & CS-GEN2 Series Manual

RED 3 3

N
COMP1 COMP2
WHT
FM2
L1 L2 L3 N

C To pump C

N
N
KM2 KM1

K1

K2
AT:Ambient temperature

N
CH:Compressor heater
KM5 K3
COMP:Compressor

K3

K5
CT:Coil temperature EEV2 EEV1
EEV:Electronic expand valve 5 5
N14

D D
L1

4V
K5
K3
K2
K1

PH
ET:Exhaust temperature
FM:Fan motor
L
N
N

FS:Flow switch

RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01

CN5

CN1
CN6

FOHP:Fan-motor overheat protect


HP:High pressure protection
PC4001
IT:Inlet water temperature
KM1:Contactor of compressor1
E E
KM2:Contactor of compressor2

5V
KM5:Contactor of pump
K3:Relay of fan motor

GND 12V
GND NET
GND DI 01
GND
GND AI 01
GND AI 02
GND AI 03
GND AI 04
GND AI 05
GND AI 06
GND AI 07
GND AI 08
GND AI 09
GND AI 10
GND AI 11(50)
GND AI 12(50)
GND DI 02
GND DI 03
GND DI 04
GND DI 05
GND DI 06
GND DI 07
GND DI 08
GND DI 09
GND DI 10
GND DI 11
GND DI 12
GND DI /DO 1
GND DI /DO 2

LP:Low pressure protection


1
4

IT
IT
AT
AT

OT
OT
FS
FS

ET1
ET1
ET2
ET2

CT1
CT1
CT2
CT2

BLU
Y/G
LP1
LP1
LP2
LP2

HP1
HP1
HP2
HP2

SUT1
SUT1
SUT2
SUT2

BRN
OT:Outlet water temperature
4

PH:Pan heater 3
FS

PM:Phase monitor t t t t t t t t t
5K 5K 5K 5K 5K 5K 1 2 3 4
5K 50K 50K
F Controller ON/OFF ON/OFF F
Q: Air switch input output
SUT:Suction temperature IT OT CT1 CT2 AT SUT1 SUT2 ET1 ET2 HP1 LP1 HP2 LP2 FS Remote
FOHP1
FOHP1
FOHP2
FOHP2

Cool/heat
4V: 4 way valve
FOHP1 FOHP2

CODE:20121207-0005
21

0 1 2 3 4 5 6 7 8 9

L2
Q

L1
L1 RED L1(A) 11

L1
L1

L1

L1
L1
L1
L1

L1
N14 N

L2
L2 WHT L2(B) PM 14

L2
L2

L2

L2
L2
L2
L3
L3 BLU L3(C) 12

L3
A A

L3
L3
L3

L3
N BLK

N
N
N
N
N
N

L1
N

L3

L1
L2

L2
L3

L1
C1

L1
TO POWER SUPPLY FU
380-415V~/3N/50Hz 1A 15 13

L1
L1
L1
19 17
FU 1 3 5 7
KM2 KM4 BLU BLK
1A L1 07 L1 HP2 HP1 HP4 HP3
2 4 6 8
KM3

C
L18
FR2 WHT

L1
L2
L3
KM1 CC04 RO04 CC03 RO03 CC02 RO02 CC01 RO01 CC04 RO04 CC03 RO03 CC02 RO02 CC01 RO01
FR4

L1 L1
L1 L1
L1 L1
L1 L1
MTS

PH1
RED FM1

V2

U2
W2
RLY4 RLY3 RLY2 RLY1 RLY4 RLY3 RLY2 RLY1

H
V4

U4
W4
RED WHT BLU

CN3
CN3
KM7 N KM1 KM2 KM3 KM4 RED WHT BLU ORG
V

CN2
CN2
1 3 5 7 FR1
2 N 4 05 6 L18 8 BHB10(1) U W BHB10(2) V
CT1 CT2 CT1 CT2 U W C2

L11
L12
L13
L14
FR3

N
FR7 3
CN4 CN6 COMP2 CN4 CN6 3

V1

U1
W1
B COMP4 B
RED WHT BLU BLU BLK

L11
L12
L13
L14
CN5 CN5

V3

U3
W3

12V
12V

NET
NET

AI01
AI02
AI03
AI04
AI05
AI06
AI07
AI08
AI09
AI01
AI02
AI03
AI04
AI05
AI06
AI07
AI08
AI09

DI01
DI01

GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
RED WHT BLU
V

PH2
WHT
U W
N
N

CH3
CH4

CH1
CH2
Y/G
Y/G

BLU
ET1
ET1
ET2
ET2
ET3
ET3
ET4
ET4
V

L27
BRN
BLU

L17
L37
BRN

N
3 U W 1 3 5 7
RED FM2
2

N
N
N
N
EvoHeat CS & CS-GEN2 Series Manual

TC2 2 L2 4 04 6 N 8
COMP1 t t 3 t t
12V
L2

6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
L2

3 3 ORG
N
N

L1 L2 L3 N COMP3

50K
50K
50K
50K
Detector 2
ET1 ET2 Detector ET3 ET4
FU
FU

3.15A
3.15A

N
N
N
N
C3
TO PUMP 1 3 5 7
2 N 4 01 6 N 8
K6 K5

N
N
N
N
F1

BLK
F2

EEV4 EEV2 BLU

4V
4V
4V
F2
F1

1 3 5 7
C EEV3 EEV1 2 4V 4 03 6 4V 8 1 3 5 7 WHT C

N
N
N
N
2 F2 4 06 6 F1 8
1 3 5 7

4V1
4V2
4V3
4V4
5 5 02 RED FM3

N
N
5 5 N N

N
2 4 6 8

N
N
N
N
N
KM4 KM3 KM2 KM1

N
N
N
N
N ORG

GND
K5

K4
K3
K2
K1
GND

CN7
CN6
CN5
CN4
KM7 K6 FR4 FR3 FR2 FR1
EEV2

K5

EEV
N
N

4V
L1
L1
L1

K7
K6
L18
L17
L16
PZF10

L15
EEV3
12V TC1

CN3
CN2
12V
5 5

L
L
L
N
N

RO 11
RO 10
RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01
D FU
D
AT:Ambient temperature 5A
CH:Crankcase heater CN3 CN2
COMP:Compressor
CT:Coil temperature
EEV:Electronic expansion valve
ET:Environment temperature
FM:Fan motor
FU:Fuse
FR:Thermal relay

GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND

FS:Flow switch
HP:High pressure protection
E E
IT:Inlet water temperature
KM1:Contactor coil of compressor1

5V
GND

RS485B GND
RS485A GND
12V
0-10V
AI 16
AI 15
AI 14
AI 13
AI 12
AI 11
AI 10
AI 09
AI 08
AI 07
AI 06
AI 05
AI 04
AI 03
AI 02
AI 01

DI 11
DI 10
DI 09
DI 08
DI 07
DI 06
DI 05
DI 04
DI 03
DI 02
DI 01

GND
GND
AC12V
AC12V

DI /DO03 GND
DI /DO02 GND
DI /DO01 GND

NET
KM2:Contactor coil of compressor2

2
KM3:Contactor coil of compressor3
19
17
15
13
IT
IT

FR5
AT
AT

HP4

LP4
LP4
LP3
LP3
LP1
LP1
HP3
HP2
HP1
OT
OT

LP2
LP2
CT4
CT4
CT3
CT3
CT2
CT2
CT1
CT1

EEV
SUT4
SUT4
SUT3
SUT3
SUT2
SUT2
SUT1
SUT1

GND
KM4:Contactor coil of compressor4 Y/G BLU BRN HP4 HP3 HP2 HP1
FR7
KM7:Contactor coil of pump 19 17 15 13
3
K5:Relay coil of High-speed fan t t t t t t t t t t t

1
2
5K 5K 5K
HP4
HP3
HP2
HP1

K6:Relay coil of Low-speed fan 5K 5K 5K 5K 5K 5K 5K 5K


LP:Low pressure protection LP4 LP3 LP2 LP1 HP4 HP3 HP2 HP1 SUT4 SUT3 SUT2 SUT1 AT CT4 CT3 CT2 CT1 OT IT
Controller 1 2
OT:Outlet water temperature
F SUT:Suction temperature F
PM:Phase monitor
PH:Pan heater
TC:Transformer
Q:Air switch
4V: 4 way valve FS

CS95-GEN2 CODE:20160512-0003
22

0 1 2 3 4 5 6 7 8 9

Q N
L1 RED L1(A) 11

L1
L1

L1
L1
L1
L1
L1
L1
N14

L1
L2 WHT L2(B) PM 14

L2
L2

L2
L2
L2

L2
L2
L2
L2
L3 L2 L1
L3 BLU 12

L3
L3
L3(C)

L3
L3

L3

L3
A A

L3
N BLK

N
N
N

N
N
N
N

N
N
N
N
N
N

L1
L2
L3
L1
L2
L3
TO POWER SUPPLY FU L1 L2
2A FU
2A

L1
L1
415V/3N~/50Hz

4V
N
N
KM3 KM4

L2
1 3 5 7

L1
L1
L2
L2
L3
L3
KM1 KM2

L1
L1
L2
L2
L3
L3
2 4V 4 06 6 N 8
FU KM4
2A

N
N
N
N
FR4

L1
L2
L3
FR3

PH

4V1
4V2

K7
1 3 5 7

L2
07

VL

UL

VH

UH
WL

WH
1
L1 3
08 5
K4 7 2 PH 4 6 N 8
2 4 6 8

L14
L15
KM1 KM2 KM5
KM3

K7
K7
4V2
P2
P3

P1

K7
K7
L1

K8

VH
WH
UH
UH
B L2 K4 IR4 4V1
B
1 3 5 7 1 3 5 7 FR2

N
N
CH1
CH2

PH1
PH2
2 VH 4 01 6 WH 8 2 UH 4 02 6 K8 8

K8
K8

UH
UH

WH
WH
N
N

VH
VH
FR1

K8
K8
IR5 IR3
EvoHeat CS & CS-GEN2 Series Manual

N
N
FR5

WH
VH

UH

UH

UH
V1
V2

U1
U2

W1
W2
K4 IR4 IR5 IR5 IR3 RED WHT BLU RED WHT BLU

UH
WL
WL

VH
P2
P3

VL
VL

UH
VH
P1

UL
UL
N

WH
WH
1 3 5 7 1 3 5 7 1 3 5 7 V V
2 UH 4 03 6 VH 8 2 WH 4 04 6 UL 8 2 VL 4 05 6 WL 8
U W U W

V2(BLK)
V2(BLK)
U1(YEL)
U1(YEL)
V1(BLK)
V1(BLK)

U2(BRN)
U2(BRN)
W2(BLU)
W2(BLU)
L1 L2 L3 N

W1(WHT)
W1(WHT)
3 3
C COMP1 COMP2
C
FR1

N
FR2
IR3 IR4

U1-1
W2-1
V1-1
TO PUMP

V2-1

U2-1
W1-1
V

N
N

N
N4
N3
U W

U2-2
Y/G

V2-2
V1-2
U1-2
W2-2
W1-2
3 KM5 KM4 KM3 KM2 KM1
V
FM1 U W

K1
Y/G

K2

K3

K5
K4
AT:Ambient temperature
3
CH:Compressor heater FM2 EEV1
COMP:Compressor EEV2
5
N14

K1

K5
K4
K3
K2
5
L1

PH
4V
D CT:Coil temperature D
EEV:Electronic expand valve
L

ET:Exhaust temperature
N
N

CN5

RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01

FM:Fan motor

CN1
CN6

FR:Thermal relay
FS:Flow switch PC4001
FOHP:Fan-motor overheat protect
HP:High pressure protection
IR3/4/5:Relay electronic of high fan motor
E IT:Inlet water temperature E

5V
KM1:Contactor of compressor1
KM2:Contactor of compressor2
KM3:Contactor of high fan motor

GND 12V
GND NET
GND DI 01
GND
GND AI 01
GND AI 02
GND AI 03
GND AI 04
GND AI 05
GND AI 06
GND AI 07
GND AI 08
GND AI 09
GND AI 10
GND AI 11(50)
GND AI 12(50)
GND DI 02
GND DI 03
GND DI 04
GND DI 05
GND DI 06
GND DI 07
GND DI 08
GND DI 09
GND DI 10
GND DI 11
GND DI 12
GND DI /DO 1
GND DI /DO 2

KM4:Contactor of low fan motor


6

IT
IT
FR3

AT
AT

OT
OT
FR5

ET1
ET1
ET2
ET2

CT1
CT1
CT2
CT2

BLU
KM5:Contactor of pump

Y/G
LP1
LP1
LP2
LP2

HP1
HP1
HP2
HP2

SUT1
SUT1
SUT2
SUT2

BRN
FR3
K4:Relay of high fan motor FR5 FR4
3
LP:Low pressure protection
6

1
2
3

OT:Outlet water temperature t t t t t t t t t


5K 5K 5K 5K 5K 5K 5K 50K 50K ON/OFF ON/OFF
PH:Pan heater Controller 1 2 3 4 5 6
F input output F
PM:Phase monitor Remote
FS
FS

IT OT CT1 CT2 AT SUT1 SUT2 ET1 ET2 HP1 LP1 HP2 LP2
Q: Air switch Cool/heat
FOHP2

FOHP2

FOHP1
FOHP1

SUT:Suction temperature
4V: 4 way valve
FS FOHP1 FOHP2

CODE:20160512-0004
23

0 1 2 3 4 5 6 7 8 9

Q
N
L1 RED L1(A) 11

L1

L1

L1
L1
L1
L1
L1

L1
L1
L2 WHT L2(B) PM 14

L2
L2
L2

L2
L2
L2
L2
L2

L2
L3 L2 L1
L3 BLU 12

L3
L3(C)

L3
L3
L3
L3
A A

L3
N BLK

N
N
L1
L2
L3 L3
N
N

N
N
N
N
N
N
N
N
L1
L2
L3
TO POWER SUPPLY FU FU
N14

1A 1A
415V/3N~/50Hz KM4

L1
L2
L3
4V
KM3

WL

VL

N
UL
L22

VH

UH
WH
1 3 5 7
FR4

L1
L1
L2
L2
06

L3
L3
4V N

N N
2 4 6 8

L1
L1
L2
L2
L3
L3
FU FR3

L21
KM5 KM3
1A

N
N

4V1
4V2
KM4

K6

WH
UH
UH

VH
1 3 5 7 1 3 5 7

K4
4V2

L11
2 VH 4 01 6 WH 8 2 UH 4 02 6 K6 8
KM1 KM2 1 3 5 7
L11 08 K4

K6

K6
2 4 6 8

UH
UH
FR5

WH
WH

VH
VH

K4
K4
4V1

K6
K6
B B

P1
P2
P3
K4
K4
FR2

N
FR1 IR5 IR3

L11
L11
N
N
K4 IR4

N
N
WH
VH

UH

UH

UH
KM2

V2
U2
KM1

W2

W1

V1

U1
L1 L2 L3 N K4 IR4 IR5 IR5 IR3
RED WHT BLU RED WHT BLU

L12
L13
WL
WL

VH
VL
VL

UH
VH
UL
UL

UH
WH
WH
EvoHeat CS & CS-GEN2 Series Manual

PH
V 1 3 5 7 1 3 5 7 1 3 5 7
V 1 3 5 7 2 UH 4 03 6 VH 8 2 WH 4 04 6 UL 8 2 VL 4 05 6 WL 8
U W U W PH 07 N
TO PUMP 2 4 6 8

V2-1
V2-2
U1-1
U1-2
V1-1
V1-2

U2-2
W2-1
W2-2
W1-1
W1-2
CH1 CH2

U2-1
3 3
COMP1 COMP2

N
N
PH1 PH2

U1-1
W2-1
V1-1

V2-1

U2-1
W1-1
C V C
U W
Y/G
V2-2
V1-2
U1-2

U2-2
W1-2

W2-2

3 V
FM1 U W
Y/G

N
N
3

N
AT:Ambient temperature

N
KM2 KM1 FM2
CH:Compressor heater KM4 KM3

K1

K2
COMP:Compressor

K3

K4

N
CT:Coil temperature IR4 FR2 FR1
IR3
EEV:Electronic expand valve EEV2 KM5 EEV1
5 5
N14
N14

L1

L14

4V
K5

PH
L15
D ET:Exhaust temperature D

L16

L17
FM:Fan motor
FS:Flow switch
L
N
N

FOHP:Fan-motor overheat protect

RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01

FR: Thermal overload relay

CN1
CN6

FU:Fuse PC4001 FU
5A
HP:High pressure protection
IR3/4/5:Relay electronic of high fan motor
IT:Inlet water temperature
E KM1:Contactor of compressor1 E

5V
KM2:Contactor of compressor2
KM3:Contactor of high fan motor
KM4:Contactor of low fan motor

GND 12V
GND NET
GND DI 01
GND
GND AI 01
GND AI 02
GND AI 03
GND AI 04
GND AI 05
GND AI 06
GND AI 07
GND AI 08
GND AI 09
GND AI 10
GND AI 11(50)
GND AI 12(50)
GND DI 02
GND DI 03
GND DI 04
GND DI 05
GND DI 06
GND DI 07
GND DI 08
GND DI 09
GND DI 10
GND DI 11
GND DI 12
GND DI /DO 1
GND DI /DO 2

KM5:Contactor of pump
6

FR3

FR5

IT
IT
AT
AT
K4:Relay of high fan motor

OT
OT
ET1
ET1
ET2
ET2

CT1
CT1
CT2
CT2

Y/G
BLU
LP1
LP1
LP2
LP2

HP1
HP1
HP2
HP2

SUT1
SUT1
SUT2
SUT2

BRN
FR3
LP:Low pressure protection FR5
3
OT:Outlet water temperature FR4
out

1
2
6

PH:Pan heater t t t t t t t t t
5K 5K 5K 5K 5K 5K 5K 50K 50K
Controller
Remote
Remote
Cool/heat

F PM:Phase monitor 1 2 3 4 5 6
F
Q: Air switch
IT OT CT1 CT2 AT SUT1 SUT2 ET1 ET2 HP1 LP1 HP2 LP2 FS Remote
SUT:Suction temperature
FOHP1
FOHP1
FOHP2

FOHP2

4V: 4 way valve in

FS FOHP1 FOHP2

CS145-GEN2 CODE:20160329-0005
24

0 1 2 3 4 5 6 7 8 9

L1
L1 RED
L(A) 11

L1

L1
L1
L1
L1

L1
L1
L1
L1
L2
N14 N
L2 WHT L2(B) PM 14

L2
L2

L2
L2
L2
L2

L2
L2
L2
L3
L3 BLU L3(C) 12

L3
L3
L3

L3
L3
L3
L3
N BLK

N
N
N
N
N

N
N
N
N
N
N
N
N
N
N
N
TO POWER SUPPLY FU

2
1
FU

L11
L11
A A

L11
415V/3N~/50Hz 1A FU
2A 1A
KM3 KM4

L21

L1
L2
L3
L11
L1
L1

L11
L2
L3
L2
L3

L11
L22

L1
L2
L3

4
3
KM6

L13
L14
L1
L2
L3
L1
L2
L3

10
L1
L2
L3
K6
KM5

6
5

L11
L11
KM7 CH3 CH4 1 3 5 7 KM5 KM6
KM1 2 4 09 6 K6 8

K6
K6
KM2 KM4

L11

L11
L11
KM3

N
N
8
7
FR5 FR6

K6
K6
FR7 FR1
FR2 K6 IR6 FR4

N
N
FR3

N
U2
V2
W2

V1

U1
W1

L11
V3

L11
U3

N
W3
V4

U4
W4
RED WHT BLU
KM1 KM2 RED WHT BLU RED WHT BLU
RED WHT BLU
V V V

N
K5

VH
WH
UH
UH
U W

L15
V

P1
P2
P3
L16
U W U W U W 1 3 5 7 1 3 5 7
3 2 VH 4 03 6 WH 8 2 UH 4 04 6 K5 8
CH1
3 3 3
K5
K5

CH2
UH
UH

WH
WH
COMP1

VH
VH
L1 L2 L3 N COMP2 COMP3 17 COMP4
15 13 19
K5
K5

N
N
B HP4 HP3 B
HP2 HP1 IR9 IR5
N
N

TO PUMP CC04 RO04 CC03 RO03 CC02 RO02 CC01 RO01


WH
VH

UH

UH
UH
CC04 RO04 CC03 RO03 CC02 RO02 CC01 RO01
RLY4 RLY3 RLY2 RLY1 K6 IR6

CN3
RLY4 RLY3 RLY2 RLY1 IR9 IR9 IR5

CN3
WL
WL

VL
VL

UL
UL

WH
EvoHeat CS & CS-GEN2 Series Manual

VH

UH
UH
VH
WH

CN2
1 3 5 7 1 3 5 7 1 3 5 7

CN2
BHB10(2) 2 UH 4 05 6 VH 8 2 WH 4 06 6 UL 8 2 VL 4 07 6 WL 8
CT1 CT2

N
N
CT1 BHB10(1) CT2 CN6
CN6

V2-1
V2-2
U1-1
U1-2

U2-1
U2-2
W2-1
V1-1
V1-2

W2-2
W1-1
W1-2

CN4

N
N
N
N

4V
4V
4V
PH

N
N
N
N
CN4 IR5 IR6

N
CN5
1 3 5 7 1 3 5 7 1 3 5 7

12V
NET
AI01
AI02
AI03
AI04
AI05
AI06
AI07
AI08
AI09

DI01
CN5

GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
2 N 4 01 6 N 8 2 4V 4 02 6 4V 8 2 N 4 08 6 PH 8 FR4 FR3 FR2 FR1

12V
NET
AI01
AI02
AI03
AI04
AI05
AI06
AI07
AI08
AI09

DI01
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND

N
N
N
N
N5
N4
N3
N2

N6
N1

4V1
4V2
4V3
4V4
ET3
ET3
ET4
ET4

Y/G
BLU
BRN
U1-1
W2-1
V1-1

KM6 2

Y/G
ET1
ET1
ET2
ET2
KM5

BLU
V2-1

BRN
U2-1
W1-1

4V1 4V2 4V3 4V4 2 V


TC2 U W

K5
3

K6
U2-2

Y/G
V2-2
V1-2
U1-2
W2-2
W1-2

3 12V

N
N
N
N
PH1 PH2 t t 3

6.8K
V

6.8K
6.8K
6.8K
6.8K
6.8K
6.8K
Detector t t Detector U W

50K
50K
FM1

6.8K
6.8K
6.8K
6.8K
6.8K
6.8K

6.8K
Y/G

50K
50K
ET3 ET4
3
ET1 ET2
C FM2 C

N4
N3
N2
N1

N
KM7 KM4 KM3 KM2 KM1
EEV4 EEV2

K4
K3
K2
K1

K7
EEV3 EEV1

N
N

4V
5

PH
L1
L1
L1
5

K7
K6
K5
K4
K3
K2
K1
5 5

GND
GND

CN7
CN6
CN5
CN4
L
L
L
N
EEV2 N

EEV
PZF10 EEV3

RO 11
RO 10
RO 09
RO 08
RO 07
RO 06
RO 05
RO 04
RO 03
RO 02
RO 01
D 12V D

CN3
CN2
CN3 CN2
5 5

PC8001
AT:Ambient temperature
CH:Crankcase heater
COMP:Compressor TC1

GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND

CT:Coil temperature 12V


EEV:Electronic expand valve
ET:Environment temperature
FR:Thermal relay

5V
GND

RS485B GND
RS485A GND
12V
0-10V
AI 16
AI 15
AI 14
AI 13
AI 12
AI 11
AI 10
AI 09
AI 08
AI 07
AI 06
AI 05
AI 04
AI 03
AI 02
AI 01

DI 11
DI 10
DI 09
DI 08
DI 07
DI 06
DI 05
DI 04
DI 03
DI 02
DI 01

GND
GND
AC12V
AC12V

DI /DO03 GND
DI /DO02 GND
DI /DO01 GND

NET
FM:Fan motor

8
FU:Fuse

6
19
17
15
13
IT
IT

FR7
AT
AT

HP4
HP3
HP2
HP1
OT
OT

LP4
LP6
LP3
LP5
LP2
LP2
LP1
LP1
12V
12V

CT4
CT4
CT3
CT3
CT2
CT2
CT1
CT1

FR5
EEV
SUT4
SUT4
SUT3
SUT3
SUT2
SUT2
SUT1
SUT1

GND
9
Y/G BLU BRN

GND
E FS:Flow switch HP4 HP3 HP2 HP1 E
FOHP:Fan-motor overheat protect 19 17 15 13
3 FR5
HP4
HP3
HP2
HP1

HP:High pressure protection FR7 t t t t t t t t t t t


IT:Inlet water temperature 5K 5K 5K 5K 5K 5K 5K 5K 5K 5K 5K
SUT4 SUT3 SUT2 SUT1 AT CT4 CT3 CT2 CT1 OT IT
IR5/6/9:Relay electronic of high fan motor FR6 LP4 LP3 LP2 LP1
Controller
KM1:Contactor of compressor1 HP4 HP3 HP2 HP1

KM2:Contactor of compressor2
KM3:Contactor of compressor3
KM4:Contactor of compressor4
KM5:Contactor of high fan motor
KM6:Contactor of low fan motor

N
3
6

1
7
9
GND
KM7:Contactor of pump
K6:Relay of high fan motor
1 2 3 4 5 6 7 8 9 10
SUT:Suction temperature
LP:Low pressure protection

FS
FS
F OT:Outlet water temperature F

FOHP1
FOHP1
FOHP2
FOHP2
PM: Phase monitor
PH: Pan heater 220V
Alarm
Q:Micro circuit breaker out On/off
FOHP1 FOHP2 FS input
TC:transformer
4V: 4 way valve

CODE:20161112-0006
25 EvoHeat CS & CS-GEN2 Series Manual

8. Maintenance
DO I NEED TO GET MY UNIT SERVICED?
It is highly recommended that you get your EvoHeat unit serviced at least once a year by your local certified air
conditioning or refrigeration technician. If your unit is located in a coastal area, more frequent maintenance may be
necessary.

During the service, they will check the operational pressures of the refrigeration system and give the unit and fins a
good clean to ensure maximum performance.

DO WE HAVE RECOMMENDED SERVICE AGENTS?


EvoHeat have a large database of recommended service agents. Please contact EvoHeat tech support on 1300 859
933 for your local service agent details.

SHOULD I CHECK MY UNIT REGULARLY?


We recommend you check your unit regularly to avoid potential issues and damage to your heat pump.

WHAT SHOULD I BE CHECKING REGULARLY?


Ensure that there is water flowing through the heat pump. If there is air or small amounts of water entering into the
heat pump it will negatively will influence the unit’s performance and reliability.

The area around the unit should be dry, clean and well ventilated. Make sure there is nothing blocking the airflow of
the heater. Check the condensate pans regularly and clear any leaf litter or debris that may gather there.

Check the power supply and cable connection often, should the unit begin to operate abnormally, switch it off and
contact the qualified technician

I AM LOCATED IN A SUB-ZERO CLIMATE, WHAT SHOULD I DO WITH MY UNIT?

Discharge all water in the water pump and water system, so that freezing of the water in the pump or water system
does not occur. You should discharge the water at the bottom of water pump if the unit will not be used for an
extended period. You should check the unit thoroughly and fill the system with water fully before using it for the first
time after a period of time.

8.1 Energy Saving Tips


If your pool water is allowed to cool significantly, it may take several days to return to the desired swimming
temperature. For weekend use, it is more economical to maintain the pool water temperature at or near your
desired swimming temperature.

If you do not plan to use your pool for a prolonged period, then you might choose to turn the heat pump completely
off or decrease the temperature setting of the control several degrees to minimize energy consumption.

TIPS

• Use an accurate pool thermometer. A difference of 2ºC, between 26ºC and 28ºC, will significantly increase
energy consumption.
• Carefully monitor the water temperature of your pool in the summertime. You can reduce heat pump usage due
to warmer air temperatures.
• When the pool is not used for long periods, turn off the heat pump.
• Where possible, shelter the pool from prevailing winds with well-trimmed hedges or other landscaping, cabanas,
or fencing.
• Always use a high-quality pool cover when practical. Besides providing a valuable water saving feature, a pool
cover will dramatically reduce heat loss and reduce your pool heating running costs by up to 70%!
26 EvoHeat CS & CS-GEN2 Series Manual

9. Warranty

Please refer to the EvoHeat website for warranty details

• Australia: www.evoheat.com.au
• South East Asia: www.evoheat.com.sg

1. Warranty terms are from date of purchase.

2. This warranty excludes any defect or injury caused by or resulting from misuse, abuse, neglect, accidental
damage, improper voltage, vermin infestation, incompetent installation, any fault not attributable to faulty
manufacture or parts, any modifications which affect the reliability or performance of the unit.

3. This warranty does not cover the following:

a. Natural Disasters (hail, lightening, flood, fire etc.)


b. Rust or damage to paintwork caused by a corrosive atmosphere
c. When serviced by an unauthorized person without the permission of Evo Industries
d. When a unit is installed by an unqualified person
e. Where a unit is incorrectly installed
f. When failure occurs due to improper or faulty installation
g. Failure due to improper maintenance (refer Operating Instructions)
h. ‘No Fault Found’ service calls where the perceived problem is explained within the
i. Costs associated with delivery, handling, freighting, or damage to the product in transit.

4. If warranty service is required you should:

a. contact Evo Industries Australia on 1300 859 933 or via our Contact page on our web site
b. provide a copy of your receipt as proof of purchase
c. have completed the online warranty registration or provide a completed warranty card.

5. Onsite technical service is available within the normal operating area of your Evo Industries authorized Service
Centre. Service outside this area will incur a traveling fee.

6. Unless otherwise specified to the purchaser, the benefits conferred by this express warranty and additional to
all other conditions, warranties, rights and remedies expressed or implied by the Trade Practices Act 1974 and
similar consumer protection provisions contained in legislation of the States and Territories and all other
obligations and liabilities on the part of the manufacturer or supplier and nothing contained herein shall
restrict or modify such rights, remedies, obligations or liabilities.

Warranty Registration
EvoHeat highly recommend customers to complete their warranty details online to
ensure efficient warranty claim processing.

To register your warranty, scan our QR Code or head to our website and fill in the
Warranty Registration Form: https://evoheat.com.au/warranty-registration/

Updated 01/09/21

You might also like