Professional Documents
Culture Documents
Chemistry Final Step-C - Mole Concept
Chemistry Final Step-C - Mole Concept
5. 150 mL of solution of I2 is divided into two unequal parts. 1st part reacts with 15 mL of 0.4 M Hypo solution in acidic
medium. 2nd part was added to 100 mL of 0.3 M NaOH solution and residual base required 10 mL of 0.3 M H2SO4
solution for complete neutralization. What was the initial concentration of I2?
(A) 0.08 M (B) 0.1 M (C) 0.2 M (D) 0.3 M
6. A sample of HCN yields potassium cyanide when titrated with 100 ml of 1 M KOH. The same HCN sample when
titrated against 5 M KMnO4 solution in acidic medium, the products formed are Mn2+, NO 3 and CO2. The volume of
KMnO4 required would be:
(A) 400 ml (B) 120 ml (C) 200 ml (D) 40 ml
7. 1 mol of MnO 24 in alkaline aqueous medium disproportionates to :
2 1 1 2
(A) mol of MnO 4 and mol of MnO2 (B) mol of MnO4 and mol of MnO2
3 3 3 3
1 2 2 1
(C) mol of Mn2O7 and mol of MnO2 (D) mol of Mn2O7 and mol of MnO2
3 3 3 3
8. RH2 (ion exchange resin) can replace Ca2+ in hard water in a following way: RH 2 + Ca 2+ RCa 2H .
2+
1 L of hard water after passing through RH2 has pH = 2. Hence, hardness in ppm of Ca is :
(A) 200 (B) 100 (C) 50 (D) 125
Paragraph for Questions 9 - 10
Air sample from an industrial area of Delhi, which is heavily polluted by CO2, was collected and analysed. One such sample of
224 L of air measured at STP was passed through 500 mL of 0.1 M KOH solution, where CO2(g) was absorbed completely.
50 mL of the above solution was then treated with excess of BaCl2 solution where all the carbonate was precipitated as
BaCO3(s). The solution was filtered off and the filtrate required 30 mL of 0.1 M HCl solution for neutralisation.
9. The ppm strength of CO2 (g) volume by volume (mL of CO2 per 106 mL of air) is
(A) 224 (B) 2240 (C) 100 (D) 1000
10. The weight of the precipitate of BaCO3(s) obtained from 50 mL of the above test solution is:
(Ba = 137, C = 12, O = 16, Mw(BaCO3) = 197g mol–1)
(A) 3.94 g (B) 0.394 g (C) 0.197 g (D) 1. 97 g
12. If instead of Fe, plate of Cu is put in Fe2(SO4)3 then number of moles of FeSO4 formed will be:
(A) 0.0075 (B) 0.005 (C) 0.001 (D) 0.002
15. 100 mL of M/10 Ca(MnO4)2 in acidic medium can be reduced completely with :
100
(A) 100 mL of 1 M FeSO4 solution. (B) mL of 1 M FeC2O4 solution.
3
(C) 16.6 mL of 1 M K2Cr2O7 solution. (D) 50 mL of 1 M C2O 24 solution.
17. (x) g of H2O2 requires 100 mL of M/5 KMnO4 in a titration having pOH =1. Which of following statement(s) is(are)
correct?
(A) The value of x is 1.7 g. (B) The value of x is 0.34 g.
(C) MnO 4 changes to MnO 24 (D) H2O2 changes to O2.
18. 20 mL of 6 M HCl is mixed with 50 mL of 2 M Ba(OH)2 and 30 mL of water is added. Select the correct statement(s):
(A) [OH–]mix = 0.8 M (B) [Cl–]mix = 1.2 M
(C) [Ba2+]mix = 0.2 M (D) 40 mmol of OH– are in excess.
19. A sample of oleum is labelled as 112% . Which of the following statement(s) is(are) correct for this sample?
(A) Addition of 9 g of water will leave 1/6 mole of SO3 unreacted in it
(B) Addition of 9 g of water will make total mass of H2SO4 as 95.7 grams
(C) 53.3 g of H2SO4 is present in sample and rest is unreacted SO3
(D) Addition of 12 g of water would react with 53.3 g of unreacted SO3
20. The hardness of water due to HCO 3 is 122 ppm. Select the correct statement(s).
(A) The hardness of water in terms of CaCO3 is 200 ppm.
(B) The hardness of water in terms of CaCO3 is 100 ppm.
(C) The hardness of water in terms of CaCl2 is 222 ppm.
(D) The hardness of water in terms of MgCl2 is 95 ppm.
21. One mole of Fe2S3 , 2 moles of H2O and 3 moles of O2 are allowed to react in following way :
2Fe 2S3 (s) + 6H 2 O(l) + 3O 2 (g) 4Fe(OH) 3 (s) 6S(s)
Select the corect statement(s).
(A) H2O would act as limiting reagent. (B) 1.33 moles of Fe(OH)3 is formed.
(C) 6 moles of S is formed. (D) It is a non redox reaction.
22. Half litre each of three samples of H2O2 labelled as 10 volume , 15 volume , 20 volume are mixed and then solution is
made 3 litre by addition of water. Select the correct statement(s).
(A) Final H2O2 solution would be labelled as 7.5 volume
(B) Normality of final H2O2 solution is 1.34
(C) Normality of final H2O2 solution is 1.5
(D) Final H2O2 solution would be labelled as 6.5 volume
25. A 2 O n is oxidised to AO3 by KMnO4 solution in acidic medium. If 1.34 mmol of A 2 O n requires 32.2 mL of
0.05M acidified KMnO4 solution for complete oxidation, which of the following statement(s) is (are ) correct ?
(A) The value of n 2
(B) Empirical formula of oxide of AO
(C) 1 mol of A 2 O n would require 1 mol of acidified K 2 Cr2 O7 solution
(D) 'A' can be metal belonging to Group-II of Periodic Table
26. 1.25g of an acid is completely neutralised by 25 mL of a 0.25 M Ba(OH)2 solution. Which of the following
statement(s) is (are) correct ?
(A) If the acid is dibasic, its molar mass would be 200
(B) If the acid is monobasic, its molar mass would be 400
(C) 0.50 g of the same acid would neutralize completely 12.5 mL of a 0.40 M NaOH solution
(D) 1g of the same acid would neutralize completely 25 mL of a 0.40 M Ca(OH)2 solution
27. 5 mmol of SO 2 Cl2 is hydrolysed completely to make a 100 mL solution. Which of the following statements is(are)
correct ? (Assume no gases were allowed to escape out of solution)
(A) The solution would be 0.05 M in H 2SO 4
(B) The solution would be 0.05 M in HCl
(C) If 10 mL of the stock solution is neutralised by 0.2 M NaOH, 10 mL of this base solution would be required
(D) If 10 mL of the solution is titrated with excess of AgNO3 , 1.5mmol of AgCl would be formed
28. Given two mixtures: (A) NaOH and Na2CO3 (B) and NaHCO3 and Na2CO3.
100 mL of mixture (A) required ‘a’ and ‘b’mL of 1M HCl in separate titration using phenolphthalein and methyl orange
indicators while 100 mL of mixture' (B) required ‘x’ and ‘y’ mL of same HCl solution is separate titration using the
same indicators.
(P) 2.5 mol each of ferric oxalate and ferrous oxalate mixture will 1. 11.0
require x mol of KMnO4 in acidic medium for complete
oxidation.
(Q) 2.5 mol each of ferric oxalate and ferrous oxalate mixture will 2. 7.0
require x mol of K2Cr2O7 in acidic medium for complete
oxidation.
(R) 2.5 mol each of CuS and Cu2S mixture will require x mol of 3. 4.5
KMnO4 in acidic medium for complete oxidation.
(S) 2 mol each of KMnO4 and K2Cr2O7 mixture will require x mol 4. 3.75
of H2O2 in acidic medium for complete reduction.
Codes :
P Q R S P Q R S
(A) 2 3 4 1 (B) 3 4 2 1
(C) 4 2 1 3 (D) 3 1 2 4
Codes :
P Q R S P Q R S
(A) 2 3 4 1 (B) 1 3 2 4
(C) 2 4 3 1 (D) 4 1 3 2
33. 0.58 g of CH3(CH2)n COOH was burnt in excess of air and resulting gases (CO2 and H2O) were passed through
excess NaOH. Then resulting solution was divided in two equal parts.
One part required 50 mL of 1.0 M HCl for complete neutralisation using phenolpthalein as indicator whereas another
part required 80 ml of same HCl using methyl orange. Find the value of n.
solution to oxidise to Sn 4 and Fe3 in acidic medium, Sn 2 Fe 2 Cr2 O27 Cr3 Sn 4 Fe3 . Thus, x is :
1
37. Amount of Mohr's salt (FeSO4 (NH 4 ) 2 SO 4 6H 2O) having molar mass 392.0 g mol that must be dissolved in 250
1
mL solution to prepare an aqueous solution of density 1.00 g mL to have Fe2 ion concentration 1 ppm by weight
is x 10 3 g. Find the numerical value of x.
38. RH 2 is an ion exchange resin used to purify water in RO. It can replace Ca 2 in hard water.
RH 2 Ca 2 RCa 2H
Water coming out of ion exchange resin has [H ] 0.01M. The, hardness of water in ppm of Ca 2 ion is ________.
39. In the Solvay process for producing sodium carbonate (Na 2 CO3 ), the following reactions occurs in sequence.
2NaHCO3 Na 2CO3 H 2 O CO 2
How much of Na 2CO 3 (in kg) would be produced per kg of NH3 used if the process were 100% efficient ?
40. In one reaction with a 95% yield, 225 mL of 1.50 M Na 2CO3 (aq), 22.1 g NO and a large excess O 2 are allowed to
react 2Na 2 CO3 (aq) 4NO(g) O 2 (g) 4NaNO 2 (aq) 2CO 2 (g)
What mass of NaNO 2 (in g) is obtained based on experimental yield ?
41. A solution contains 6.0 micromoles of Na 2 SO4 in 250 mL solution. Assuming no change in volume on dissolution,