Professional Documents
Culture Documents
The Volume of Oil in The Nissan Qashqai Gearbox. Oil Change in A Manual Transmission Nissan
The Volume of Oil in The Nissan Qashqai Gearbox. Oil Change in A Manual Transmission Nissan
The maintenance regulation prescribes the following: it is necessary to change the oil in
a manual gearbox every 80-90 thousand km. The type and specification of the oil that is
suitable for your car can be found in the instructions for your car.
1. Remove the protection of the engine and gearbox from the bottom of the car. In some
cars, such protection may not be available, because is optional equipment.
2. Now we examine the box, check: the seal of the right half shaft, the seal of the left half
shaft, anthers of the half shafts. They should not show signs of oil. They may be wet
from water, but should not be wet from gearbox oil.
4. This is the filler plug. It is also the oil level in the box:
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 1/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
5. Unscrew the manual transmission drain plug in advance by preparing and substituting
a container under it to drain the oil. Wait until the oil has completely drained.
6. Replace a sealing ring on a drain stopper. This must be done so that during further
operation of the car oil does not leak. This is how the old and new seal ring looks:
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 2/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
7. Now take the filler syringe (available at the auto parts store) and the canister with new
oil and fill the gear oil into the syringe.
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 3/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
8. Insert the syringe tube into the filler hole and use the piston to pour oil into the box.
You will need up to 3 liters of oil.
9. As we said above, the filler hole is part-time and the level of oil in the manual
transmission. Those. the oil must be poured into the box until it runs back. As soon as
the oil begins to slowly pour back from the filler hole of the box, this means that there is
already enough oil in the box.
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 4/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
10. We twist the filler hole with a stopper, put back the protection on the engine (if it
was) and that’s all.
Just like that, the oil in the manual gearbox of Nissan cars changes.
Almera N16 3
(Manual)
Almera 3
classic B10
(manual
transmission)
Micra K12 3
(Manual)
Note E11 HR 3
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 5/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
(Manual)
Primera P12 3
QG (Manual)
Tiida C11 3
HR12
(Manual)
Maxima A33 3
(Manual)
Juke F15 3
(Manual)
Quashqai 3
Q10 (Manual)
Navara D40 3
(Manual)
Pathfinder 3
R51 (Manual)
Patrol Y61 3
(Manual)
X-Trail T30 / 3
T31 (Manual)
Terrano R20 / 3
F15 (Manual)
On a note
Many Nissan car owners with a manual gearbox cannot find the drain plug in their car.
The thing is that this cork may look like an ordinary bolt. On the Nissan Maxima A32, the
drain plug is located to the right under the inner CV joint of the drive.
\u003e Checking the level, topping up and changing the oil in a 6-speed manual
gearbox RS6F52A Nissan Qashqai
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 6/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
However, sometimes the need to change the oil may arise earlier: for example, when
switching to a different viscosity oil, when repairing a gearbox, etc.
NOTES.
Fill in a manual gearbox with API GL4 / GL5 quality grade oil; SAE 75W-90. If the vehicle
is operated at an ambient temperature below -10 ° C, we recommend the use of API GL4
/ GL5 quality oil; SAE 80W-90.
You will need: a hexagon wrench “10”, a syringe, a funnel, a wide tank for draining oil, a
ruler or tape measure.
To check the oil level, top up or replace it in a manual gearbox, do the following.
2. Clear off a stopper of a control (bulk) opening located on top on a transmission case.
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 7/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
4. ... turn out and take out a stopper from an aperture in a transmission case.
5. Insert the dipstick into the inspection (filling) hole. Mark the position of the dipstick
from the top edge of the gearbox.
HELPFUL ADVICE.
To measure the oil level in a 6-speed manual gearbox, we recommend using the engine
oil level indicator (dipstick). Before measuring the gearbox oil level, carefully wipe off the
pointer (dipstick).
6. Measure the level from the top edge of the oil film to the marked position of the top
edge of the gearbox on the dipstick.
The oil level should be: - for a car with front-wheel drive - 43.0-48.0 mm; - for a car with
all-wheel drive - 85.0-90.0 mm.
7. If the oil level is very low, install a funnel in the control (filling) hole and fill the oil to
the desired level. Wrap a stopper and remove streaks of oil.
NOTE.
The plug of the control (bulk) hole is sealed with an aluminum washer. At installation of
a stopper replace a washer.
8. To replace the oil in the gearbox, remove the crankcase cover (see).
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 8/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
11. ... remove the plug and drain the oil into a previously prepared container.
12. The drain plug is sealed with an aluminum washer. Be sure to replace it.
14. Fill the gearbox with oil to the required level (see paragraphs 2-7).
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 9/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
15. Screw a stopper of a control (bulk) opening, tighten the moment of 35 N · m and
remove smudges of oil.
In this article, we will talk about how to change the oil in a manual gearbox of a Nissan
car. This manual is suitable for most models with manual transmission, as the principle
is the same. So let's go.
The maintenance regulation prescribes the following: it is necessary to change the oil in
a manual gearbox every 80-90 thousand km. The type and specification of the oil that is
suitable for your car can be found in the instructions for your car.
1. Remove the protection of the engine and gearbox from the bottom of the car. In some
cars, such protection may not be available, because is optional equipment.
2. Now we examine the box, check: the seal of the right half shaft, the seal of the left half
shaft, anthers of the half shafts. They should not show signs of oil. They may be wet
from water, but should not be wet from gearbox oil.
4. This is the filler plug. It is also the oil level in the box:
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 10/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
5. Unscrew the manual transmission drain plug in advance by preparing and substituting
a container under it to drain the oil. Wait until the oil has completely drained.
6. Replace a sealing ring on a drain stopper. This must be done so that during further
operation of the car oil does not leak. This is how the old and new seal ring looks:
7. Now take the filler syringe (available at the auto parts store) and the canister with new
oil and fill the gear oil into the syringe.
8. Insert the syringe tube into the filler hole and use the piston to pour oil into the box.
You will need up to 3 liters of oil.
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 11/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
9. As we said above, the filler hole is part-time and the level of oil in the manual
transmission. Those. the oil must be poured into the box until it runs back. As soon as
the oil begins to slowly pour back from the filler hole of the box, this means that there is
already enough oil in the box.
10. We twist the filler hole with a stopper, put back the protection on the engine (if it
was) and that’s all.
Just like that, the oil in the manual gearbox of Nissan cars changes.
On a note
Many Nissan car owners with a manual gearbox cannot find the drain plug in their car.
The thing is that this cork may look like an ordinary bolt. On the Nissan Maxima A32, the
drain plug is located to the right under the inner CV joint of the drive.
Oil change in a manual Thermostat vaz 2112 16 valve Fuel filter: purpose, types,
transmission Nissan features of replacement
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 12/13
21/3/2020 The volume of oil in the Nissan Qashqai gearbox. Oil change in a manual transmission Nissan
DIY shock absorber strut We change the timing chain The purpose of the buttons
repair - can you do it yourself and tensioner, signs and on the console of the vaz
replacement interval 2110
Copyright © 2019 Car Portal. Engine. Cooling system. Fuel system.
https://tehno-vostok.ru/en/transmissiya-korobka-peredach/the-oil-in-the-gearbox-is-nissan-kashkay-oil-change-in-the-manual-gearbox-of-nissan/ 13/13