Professional Documents
Culture Documents
Department of Mechanical Engineering, UMT Lahore Batch 2016: Encircle All The Correct Answers
Department of Mechanical Engineering, UMT Lahore Batch 2016: Encircle All The Correct Answers
Batch 2016
Time: 15 mins Quiz # 1
Section 1
Encircle all the correct answers.
1. The process which involves pouring of molten metal into a sand mold and allowing the metal to solidify is
called______________
a) Solid Patterns b) Split Patterns c) Cope and drag pattern d) Match plate pattern
3. Patterns in which two pieces of the split pattern are attached to opposite sides of wood or metal plate
are__________
a) Split patterns b) Match plate pattern c) Solid Patterns d) Cope and drag pattern
4. Metal Casting Processes divide into __________________ categories based on the mold type.
5. For Sand casting, indicators used to determine the quality of sand are_____________________.
a) Ceramic mold casting b) Vacuum molding c) Plaster mold casting d) Shell molding
a) low production rate b) high production rate c) expandable molds d) better surface finish
9. ___________________ usually performed on casted parts after been removed from mold.
Section 2
Encircle the correct answer
1. A cupola is a horizontal cylindrical furnace equipped with a tapping spout near its base T/F
2. Chaplets are metal supports used to hold the core in place in the sand mold. T/F
3. Micro porosity is a network of small voids throughout the casting caused by
localized solidification shrinkage. T/F
4. Cold chamber machines are faster than hot chamber machines. T/F
5. Pipes and Tubes are the examples of true centrifugal casting process. T/F