Professional Documents
Culture Documents
E-Series Articulate Dump Truck Sales Training: Next We'll Take A Look at The Electrical System
E-Series Articulate Dump Truck Sales Training: Next We'll Take A Look at The Electrical System
3/24/2014 11:12:27 AM 46
E-Series Articulate Dump Truck Sales Training
The batteries are mounted inside the left front panel. High capacity batteries,
ordered thru parts, can be installed.
For temperatures below -25 degrees Celsius (-13 degrees Fahrenheit), two 1400
cold cranking amp batteries are recommended.
3/24/2014 11:12:27 AM 47
E-Series Articulate Dump Truck Sales Training
A 12-volt accessory power port and a Service ADVISOR connector are mounted in
the left front console.
The fuse and relay box are located to the left of the operator. The cover is easily
lifted and has a decal to identify all of the fuse locations and amperage ratings.
3/24/2014 11:12:28 AM 48
E-Series Articulate Dump Truck Sales Training
Located just inside the door and left of the operator’s seat is the electrical load
center. Solid-state electronics eliminate the use of unsealed connections, relays and
rocker switches.
Behind the access panel you’ll find the:
• Chassis Control Unit (CCU)
• Transmission Control Unit (TCU)
• The 24 to 12-volt converter
• And the JDLink™ controllers
3/24/2014 11:12:28 AM 49
E-Series Articulate Dump Truck Sales Training
The controllers for the On Board Weighing and Tire Pressure Monitoring systems
are mounted on top of the rear frame cross-tube
3/24/2014 11:12:28 AM 50
E-Series Articulate Dump Truck Sales Training
The dump body position sensor is located on the rear frame, near the dump body
pivots. The sensor sends a varying voltage signal to the Chassis Controller and
uses this signal to calculate the dump body position.
3/24/2014 11:12:28 AM 51
E-Series Articulate Dump Truck Sales Training
In the rear of the ADT, you can easily locate the reverse alarm, lights, and camera.
The lights illuminate and the alarm sounds when the transmission is in reverse.
3/24/2014 11:12:29 AM 52