Kenwood DDX396 DDX376BT DDX276BT DDX26BT DDX419BT Manual EN

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 72

MONITOR WITH DVD RECEIVER ENGLISH

INSTRUCTION MANUAL

DDX396 (Region 1 – DVD Region Code 1 Area) DDX26BT (Region 1 – DVD Region Code 1 Area)

DDX376BT (Region 1 – DVD Region Code 1 Area) DDX419BT (Region 4 – DVD Region Code 4 Area)

DDX276BT (Region 1 – DVD Region Code 1 Area)

This instruction manual is used to describe the models listed above. Model availability and features (functions) may differ depending on the country and
sales area.
Take the time to read through this instruction manual.
Familiarity with installation and operation procedures will help you obtain the best performance from your new DVD-receiver.
For your records
Record the serial number, found on the back of the unit, in the spaces designated on the warranty card, and in the space provided below. Refer to the model and
serial numbers whenever you call upon your Kenwood dealer for information or service on the product.
Model DDX396/DDX376BT/DDX276BT/DDX26BT/DDX419BT Serial number
US Residents Only
Register Online
Register your Kenwood product at www.kenwood.com/usa/

© 2018 JVC KENWOOD Corporation B5A-2606-10 (KN/RN)

01_DDX_2019ST_KNRN_COVER.indd 1 20/8/2018 4:05:15 PM


Important Notice
To ensure proper use, please read through this For DDX419BT:
manual before using this product. It is especially
CAUTIONS
important that you read and observe WARNINGS To care for the unit
and CAUTIONS in this manual. • If you have parked the car for a long time in hot or
Please keep the manual in a safe and accessible cold weather, wait until the temperature in the car
place for future reference. becomes normal before operating the unit.
To care for the monitor The marking of products using lasers
• The monitor built into this unit has been produced The label is attached to the chassis/case and says
WARNINGS with high precision, but it may have some ineffective that the component uses laser beams that have been
To prevent accidents and damages dots. This is inevitable and is not considered classified as Class 1. It means that the unit is utilizing
• DO NOT install any unit or wire any cable in a defective. laser beams that are of a weaker class. There is no
location where; • Do not expose the monitor to direct sunlight. danger of hazardous radiation outside the unit.
– it may obstruct the steering wheel and gearshift • Do not operate the touch panel using a ball-point
lever operations. pen or similar tool with a sharp tip. For DDX396/DDX376BT/DDX276BT/DDX26BT:
– it may obstruct the operation of safety devices such Touch the keys on the touch panel with your finger CAUTION
as air bags. directly (if you are wearing a glove, take it off). Use of controls or adjustments or performance
– it may obstruct visibility. • When the temperature is very cold or very hot... of procedures other than those specified herein
• DO NOT raise the volume level too much, as this will – Chemical changes occur inside, causing may result in hazardous radiation exposure. In
make driving dangerous by blocking outside sounds, malfunction. compliance with Federal Regulations, the following
and may cause hearing loss. – Pictures may not appear clearly or may move are reproductions of labels on, or inside the product
• DO NOT operate the unit while driving. If you need slowly. Pictures may not be synchronized with relating to laser product safety.
to operate the unit while driving, be sure to look the sound or picture quality may decline in such
around carefully. environments.
• Stop the car before performing any complicated On the volume setting
operations. • Digital devices produce very little noise compared
• The driver must not watch the monitor while driving. with other sources. Lower the volume before playing
these digital sources to avoid damaging the speakers
Location : Top plate
by sudden increase of the output level.

i ENGLISH

00_DDX_2019ST_KN_RN.indb i 31/5/2018 2:44:19 PM


Important Notice
For DDX396/DDX376BT/DDX276BT/DDX26BT: For DDX396/DDX376BT/DDX276BT/DDX26BT: This transmitter must not be co-located or operated in
CAUTION FCC WARNING conjunction with any other antenna or transmitter.
This equipment may generate or use radio
This equipment complies with FCC/IC radiation frequency energy. Changes or modifications to this
exposure limits set forth for an uncontrolled Supplier’s Declaration of Conformity
equipment may cause harmful interference unless
environment and meets the FCC radio frequency Trade Name: KENWOOD
the modifications are expressly approved in the
(RF) Exposure Guidelines and RSS-102 of the IC radio Products: MONITOR WITH DVD RECEIVER
instruction manual. The user could lose the authority
frequency (RF) Exposure rules. This equipment has Model Name: DDX396/DDX376BT/
to operate this equipment if an unauthorized change
very low levels of RF energy that is deemed to comply DDX276BT/DDX26BT
or modification is made.
without maximum permissive exposure evaluation Responsible Party: JVCKENWOOD USA CORPORATION
(MPE). But it is desirable that it should be installed and 2201 East Dominguez Street,
FCC NOTE
operated keeping the radiator at least 20 cm or more Long Beach, CA 90810, U.S.A.
This equipment has been tested and found to comply
away from person’s body. PHONE: 310 639-9000
with the limits for a Class B digital device, pursuant
• Contains Transmitter Module to Part 15 of the FCC Rules. These limits are designed
THIS DEVICE COMPLIES WITH PART 15 OF THE FCC
FCC ID: ZWY8811X to provide reasonable protection against harmful
RULES. OPERATION IS SUBJECT TO THE FOLLOWING
• Contains Transmitter Module interference in a residential installation.
TWO CONDITIONS:
IC: 12033A-8811X This equipment may cause harmful interference to
(1) THIS DEVICE MAY NOT CAUSE HARMFUL
radio communications, if it is not installed and used
INTERFERENCE, AND
For DDX396/DDX376BT/DDX276BT/DDX26BT: in accordance with the instructions. However, there
(2) THIS DEVICE MUST ACCEPT ANY INTERFERENCE
IC (Industry Canada) Notice is no guarantee that interference will not occur in a
RECEIVED, INCLUDING INTERFERENCE THAT
This device complies with Industry Canada’s licence- particular installation. If this equipment does cause
MAY CAUSE UNDESIRED OPERATION.
exempt RSSs. Operation is subject to the following two harmful interference to radio or television reception,
conditions: which can be determined by turning the equipment
(1) This device may not cause interference; and off and on, the user is encouraged to try to correct the
(2) This device must accept any interference, including interference by one or more of the following measures:
interference that may cause undesired operation of • Reorient or relocate the receiving antenna.
the device. • Increase the separation between the equipment and
receiver.
• Connect the equipment into an outlet on a
circuit different from that to which the receiver is
connected.
• Consult the dealer or an experienced radio/TV
technician for help.

ENGLISH ii

00_DDX_2019ST_KN_RN.indb ii 31/5/2018 2:44:20 PM


About this manual Contents
The displays and panels shown in this manual are Component Names and Operations ............... 3 Using an external component via ADS adapter—
examples used to provide clear explanations of the OEM Features ................................................................................ 32
Basic Operations ................................................. 4
operations. For this reason, they may be different Bluetooth® .........................................................33
How to reset your unit .................................................................4
from the actual displays or panels. Turning on the power ..................................................................4 Information ...................................................................................... 33
Turning off the power ..................................................................4 Preparation ....................................................................................... 33
Illustrations of DDX396 are mainly used for Connection....................................................................................... 33
Putting the unit in standby .......................................................4
explanation. Bluetooth mobile phone ......................................................... 35
Turning off the screen ..................................................................4
Adjusting the volume ...................................................................4 Bluetooth audio player ............................................................. 37
This manual mainly explains operations using the
Attenuating the sound ...............................................................5 KENWOOD Music Mix ............................................................ 37
buttons on the monitor panel and keys on the
Bluetooth settings ....................................................................... 38
touch panel. For operations using the remote Getting Started ................................................... 5
controller, see page 48. Initial settings .....................................................................................5 Settings ..............................................................39
Registering a security code .......................................................6 Audio settings ................................................................................ 39
< > indicates the various screens/menus/ Clock settings.....................................................................................6 Display settings.............................................................................. 43
operations/settings that appear on the touch Input settings .................................................................................. 45
Various Screens and Operations ..................... 7
panel. System settings.............................................................................. 45
Home screen ......................................................................................7
Source control screen...................................................................8 Remote Controller ............................................48
[ ] indicates the keys on the touch panel. List/setting screen...........................................................................9 Preparation ....................................................................................... 49
Basic operations for RC-DV340 (supplied) .................... 49
Indication language: English indications are used Disc ......................................................................10
Basic operations for KNA-RCDV331 (optionally
for the purpose of explanation. You can select the Video ...................................................................11 purchased)........................................................................................ 51
indication language from the <Setup> menu. KENWOOD Remote APP ...................................................... 53
USB ......................................................................13
(Page 45)
Android...............................................................15 Installation and Connection ...........................53
Before installation ........................................................................ 53
iPod/iPhone .......................................................15 Installing the unit.......................................................................... 55
Radio ...................................................................16 Removing the unit ..................................................................... 55
SiriusXM® Satellite Radio ................................18 Wiring connection ....................................................................... 56
Connecting external components .................................... 57
Pandora® ............................................................25
References .........................................................57
iHeartRadio ........................................................27 Maintenance ................................................................................... 57
Spotify ................................................................29 More information ......................................................................... 57
Other External Components ..........................31 Troubleshooting ...............................................61
AV-IN ................................................................................................... 31 Specifications ....................................................64
Rear view camera ........................................................................ 32 Trademarks and licenses.......................................................... 68

2 ENGLISH

00_DDX_2019ST_KN_RN.indb 2 31/5/2018 2:44:20 PM


Component Names and Operations
DDX396/DDX376BT 8 Volume/ATT knob 6 MENU/DISP OFF button
• Volume (Turn): Adjusts the audio volume. • MENU (Press): Pops up the short-cut menu.
• ATT (Press): Attenuates the sound. • DISP OFF (Hold): Turns off the screen.
9 CAM button 7 TEL/VOICE button
• (Press): Displays the picture from the connected • TEL (Press): Displays the phone control screen.
rear view camera. • VOICE (Hold): Activates voice dialing.
8 Volume J/K buttons
DDX276BT/DDX26BT/DDX419BT • (Press): Adjusts the audio volume.
9 CAM/ATT button
• CAM (Press): Displays the picture from the
connected rear view camera.
• ATT (Hold): Attenuates the sound.

1 Reset button
• Resets the unit.
2 Loading slot
3 Screen (touch panel)
4 Monitor panel
5 HOME button
• (Press): Turns on the power.
• (Hold): Turns off the power. 1 Reset button
• HOME (Press): Displays the Home screen while • Resets the unit.
the power is on. 2 Loading slot
6 MENU/DISP OFF button 3 Screen (touch panel)
• MENU (Press): Pops up the short-cut menu. 4 Monitor panel
• DISP OFF (Hold): Turns off the screen. 5 HOME button
7 TEL/VOICE button • (Press): Turns on the power.
• TEL (Press): Displays the phone control screen. • (Hold): Turns off the power.
• VOICE (Hold): Activates voice dialing. • HOME (Press): Displays the Home screen while
the power is on.

ENGLISH 3

00_DDX_2019ST_KN_RN.indb 3 31/5/2018 2:44:20 PM


Basic Operations
How to reset your unit 2 Put the unit in standby. Adjusting the volume
On the source/option selection screen, touch as
If the unit fails to operate properly, press the reset follows: DDX396/DDX376BT
button.

You can adjust the volume (00 to 35) by turning


Turning on the power Turning off the screen the knob to the right to increase and to the left to
decrease.
On the monitor panel
DDX276BT/DDX26BT/DDX419BT

(Hold)
Turning off the power To turn on the screen: Press DISP OFF on the
monitor panel or touch the screen.

On the pop-up short-cut menu You can adjust the volume (00 to 35) by pressing J to
(Hold) increase and pressing K to decrease.
1 Display the pop-up short-cut menu. • Holding J increases the volume continuously to
level 15.
Putting the unit in standby

1 Display the source/option selection


screen. 2 On the pop-up short-cut menu, touch as
On the Home screen, touch as follows: follows:

To turn on the screen: Touch the screen.

4 ENGLISH

00_DDX_2019ST_KN_RN.indb 4 31/5/2018 2:44:20 PM


Basic Operations Getting Started
Attenuating the sound Initial settings <Language>
Select the text language used for on-screen
DDX396/DDX376BT DDX276BT/DDX26BT/ When you power on the unit for the first time or reset information.
DDX419BT the unit, the <Initial Setup> screen appears. • English (Initial)/Español/Français/Deutsch/
Italiano/Nederlands/Ελληνικά/Português/Türkçe/
Perform the initial settings. Čeština/Polski/Magyar/Руccĸий/ / /
(Hold) Initial Setup / / / /Bahasa
Demonstration ON OFF Malaysia/Bahasa Indonesia/
The ATT indicator lights up. Language English – For external monitors, only English/Spanish/
Rear Camera Enter French/German/Italian/Dutch/Russian/Portuguese
User Customize Enter
are available. If another language has been
To cancel attenuation:
Viewing Angle Enter
For DDX396/DDX376BT: Press the same button again. selected, the text language for external monitors
For DDX276BT/DDX26BT/DDX419BT: Press and hold Finish will be set to English.
the same button again. • GUI Language (Local (the language selected above)
(Initial)/English): Selects the language used for
E.g. Initial settings screen for DDX396 displaying operation keys and menu items.
<Rear Camera> (Page 45)
Once completed, Home screen appears.
Make the settings to display the picture from the
connected rear view camera.
<Demonstration>
<User Customize> (Page 43)
• ON (Initial): Activates the display demonstration.
Change the display design.
• OFF: Deactivates the display demonstration.
<Viewing Angle> (Page 44)
Select the viewing angle in relation to the monitor to
make the image on the screen easier to see.
• Under 0° (Initial)/5°/10°/15°/20°

ENGLISH 5

00_DDX_2019ST_KN_RN.indb 5 31/5/2018 2:44:20 PM


Getting Started

Registering a security code To clear the registered security code: Touch [CLR] 3 Set the clock time.
for <Security Code> in step 2.
(Only for DDX419BT) Clock
Then, enter the current security code to clear and
Synchronize Radio Data System
touch [Enter].
1 Display the Home screen.
AM10 : 28
• When the unit has been reset or disconnected from
the battery, you are required to enter the security Reset

code. Enter the correct security code, then touch


[Enter].
2 Display the <Security Code Set> screen.
On the Home screen, touch as follows: Clock settings E.g. Clock settings screen for DDX396

1 Display the Home screen. <Synchronize>


• Radio Data System (Initial): Synchronizes the
Then, on the <Setup> screen, touch as follows: clock time with FM RBDS.
[System]  <Security Code> : [SET] • OFF: Sets the clock manually. Touch [J]/[K] to
adjust the hour, then minute.
3 Enter a four-digit number (1), then
– Touching [Reset] will set the minute to “00”.
confirm the entry (2). 2 Display the <Clock> screen.
On the Home screen, touch as follows:

Then, on the <Setup> screen, touch as follows:


[System]  <Clock> : [Enter]
• You can also display the <Clock> screen by
touching the clock area on the Home screen.
• To delete the last entry, touch [Clear].
• To cancel the setting, touch [Cancel].
4 Repeat step 3 to confirm your security
code.
Now, your security code is registered.

6 ENGLISH

00_DDX_2019ST_KN_RN.indb 6 31/5/2018 2:44:21 PM


Various Screens and Operations
You can display or change to other screens at any time Available playback sources and options [Pandora]*1 Switches to the Pandora broadcast.
to show information, change the AV source, change
Touch 1 to display the source/option selection screen. [Spotify] Switches to the Spotify application.
the settings, etc.
[iHeartRadio]*1 Switches to the iHeartRadio
Home screen broadcast.
Radio SiriusXM DISC USB iPod [STANDBY] Puts the unit in standby.
• You can customize the Home screen. (Page 44)
• To display the Home screen from other screens, press To change the page: Touch [ ]/[ ]. Current page is
HOME. Now
Playing
AndroidTM BT Audio TEL AV-IN OEM Features
shown by the page indication on the top of the screen.

E.g. Source/option selection screen for DDX396 To return to the Home screen: Touch [ ] on the
source/option selection screen.
Touching the operation keys performs the following
actions: *1 Only for DDX396/DDX376BT/DDX276BT/DDX26BT.
*2 Only for DDX396/DDX376BT/DDX276BT.
[Radio] Switches to the radio broadcast.
Now
Playing
[SiriusXM]*1 Switches to the SiriusXM® radio
broadcast.
[DISC] Plays a disc.

Touching the operation keys performs the following [USB] Plays files on a USB device.
actions: [iPod] Plays an iPod/iPhone.
1 Displays all playback sources and options. [Android™] Plays an Android device.
2 Displays the <Setup> screen. [BT Audio] Plays a Bluetooth audio player.
3 Displays the current playing source control screen.
4 Displays the <Clock> screen. [TEL] Displays the phone control screen.
5 Selects or changes the playback source. [AV-IN] Switches to an external component
connected to the AV-IN input
terminal.
[OEM Switches to the source connected
Features]*2 via ADS adapter.

ENGLISH 7

03_DDX_2019ST_KNRN_Body01.indd 7 20/8/2018 4:14:51 PM


Various Screens and Operations
7 Displays/hides other available operation keys* 8
Source control screen
8 Operation keys*
[ ] Displays the <Equalizer> screen.
You can perform the playback operation from the 9 IN indicator (lights up while a disc is inserted)
source control screen during playback. p Playing time/playback status [ ] Displays the folder list/track list/audio
• The operation keys and information displayed vary q Playback mode indicator (Repeat/Random) menu/video menu.
depending on the selected source/disc type/file type w File type indicator [S]/[T] • (Touch) Selects an item (chapter/
being played. e Current playback item information folder/track/audio file/video file).
• If the operation keys are not displayed on the screen, (folder no./file no./track no./total track no./playback • (Hold) Reverses/forwards search.
touch the screen to show them. file type) • (Hold) Plays in slow-motion while
paused for video playback.
* See the following “Common operation keys on source control [IW] Starts/pauses playback.
screen”. [ ] Selects random playback mode.*

Common operation keys on source control screen * About playback mode:


• The appearance of the operation keys may differ, – Available playback mode differs depending on the source, disc
however the similar operation keys have the same type, connected device, etc.
operations. – You cannot activate repeat playback mode and random
• Available operation keys differ depends on the playback mode at the same time.
selected source or connected device. – To cancel the playback mode, touch repeatedly until the
E.g. Common audio playback source screen for indicator disappears.
DDX396 Touching the operation keys performs the following
actions:
1 Displays/hides short-cut source selection keys 7
2 Playback source or media type
3 Picture/artwork (shown if the file contains the [ ] Displays other available operation keys
information) besides those shown on 8.
4 Short-cut source selection keys • To hide the window, touch [ ].
• Touching [ ] on 1 to display the keys, or [ ] [ ][ ] Selects a folder.
to hide them.
[ ] Selects repeat playback mode.*
5 Clock display
6 Track/file/song/video information [o] Stops playback.
• Touching [<] scrolls the text if not all of the text [MODE] Displays the setting screen of the current
is shown. playback source.

8 ENGLISH

00_DDX_2019ST_KN_RN.indb 8 31/5/2018 2:44:21 PM


Various Screens and Operations
Using the pop-up short-cut menu Using touch screen operation during
While displaying the source control screen, you can playback
jump to another screen by touching the operation
keys on the pop-up short-cut menu.
1 Display the pop-up short-cut menu.

2 Select an item to jump to by touching as Touching the areas performs the following actions: Touching the operation keys performs the following
follows. actions:
1 Displays the video control menu while playing a
[Eject] Ejects the disc from loading slot. video. 1 Enters alphabet search* to list the items in
[Screen Displays the picture adjustment 2 While playing a video: Displays the source control alphabetical order. When a keypad appears, touch
Adjustment] screen. screen. the first letter you want to search for.
[Display OFF] Turns off the screen. While playing an audio file: Displays the playback • For “USB” source, you can switch between the
operation keys. folder list and file list by touching [ ] or [ ].
[Camera] Displays the picture from the Then, touch [OK] to start searching.
3 Goes to the previous chapter/track.*
connected rear view camera. 2 Returns to the root folder.
4 Goes to the next chapter/track.*
[SETUP] Displays the <Setup> screen. 3 Returns to the upper layer.
[Current Displays the current source * Not available for video from an external component (AV-IN). 4 Closes the current screen.
Source] control screen. 5 Exits from the current screen or returns to the
previous screen.
List/setting screen 6 Changes the page to display more items.
To close the pop-up menu: Touch the screen
Below are the common operation keys which appear
anywhere other than the pop-up short-cut menu. * Alphabet search is not available:
on the list/setting screen.
• The appearance of the operation keys may differ, – For Android source
however the similar operation keys have the same – When the playlist is selected
operations.
• Available operation keys differ depends on the
setting screens. Not all these operation keys are
shown on every screen.

ENGLISH 9

00_DDX_2019ST_KN_RN.indb 9 31/5/2018 2:44:21 PM


Disc
• If a disc does not have a disc menu, all tracks on it will Selecting a folder/track on the list
be played repeatedly until you change the source or
Ejecting a disc
eject the disc. 1 Display the folder/track list.
• For playable disc types, file types and other
1 Display the pop-up short-cut menu. On the source control screen, touch as follows:
information, see pages 57 and 58.
• If “ ” appears on the screen, the unit cannot accept
the operation you have tried to do.
– In some cases, without showing “ ”, operations
2 Select the folder (1), then the item (2) in
will not be accepted. 2 Eject the disc. the selected folder.
• When playing back a multi-channel encoded disc,
the multi-channel signals are downmixed. DISC

Folder Name 1 File Name 1


Folder Name 2 File Name 2
Inserting a disc Folder Name 3 File Name 3
• When removing a disc, pull it out horizontally. Folder Name 4 File Name 4
Label side up • You can eject a disc while playing another AV source. Folder Name 5 File Name 5
• If the ejected disc is not removed within 15 seconds,
the disc is automatically inserted again into the
loading slot to protect it from dust. Select an item in each layer until you reach and
select the desired file.
Playback operations
Settings for disc playback
Audio playback information and key
E.g. Inserting a disc for DDX396 operation • Available items shown on the <DISC Mode> screen
differ depending on the type of disc/file being
• For playback information, see “Source control screen”
The source changes to “DISC” and playback starts. played back.
on page 8.
• The IN indicator lights up while a disc is inserted. • For key operations on the touch panel, see “Common 1 Display the <DISC Mode> screen.
operation keys on source control screen” on On the source control screen, touch as follows:
page 8.

10 ENGLISH

00_DDX_2019ST_KN_RN.indb 10 31/5/2018 2:44:21 PM


Disc Video
2 Make the settings. <Down Mix> Playback operations
DISC Mode When playing back a multi-channel disc, this
Menu Language English SET setting affects the signals reproduced through the Video playback information on the source
Subtitle Language English SET front and/or rear speakers. control screen
Audio Language SET
English • Dolby Surround: Reproduces multi-channel
Dynamic Range Control Dialog
Dolby Surround Stereo
surround sound by connecting an amplifier
Down Mix

Screen Ratio 16:9


compatible with Dolby Surround.
• Stereo (Initial): Reproduces stereo playback
sound.
<Menu Language>*1 <Screen Ratio>
Select the initial disc menu language. (Initial: Select the monitor type to watch a wide screen
English) picture on the external monitor.
<Subtitle Language>*1
16:9 (Initial) 4:3 LB 4:3 PS
Select the initial subtitle language or turn subtitles
off (Off). (Initial: English)
E.g. Video playback source control screen for
<Audio Language>*1
DDX396
Select the initial audio language. (Initial: English)
<File Type>*2
<Dynamic Range Control>
Select the playback file type when a disc contains 1 Media type
You can change the dynamic range while playing
different types of files. 2 Playback status
Dolby Audio encoded discs.
• Audio: Plays back audio files. 3 Current playback item information
• Wide: Reproduces powerful sound at a low
• Still image: Plays back still picture files. (title no./chapter no./folder no./file no./track no.)
volume level with its full dynamic range.
• Video: Plays back video files. 4 Playing time
• Normal: Reduces the dynamic range a little.
• Audio&Video (Initial): Plays back audio files and 5 IN indicator (lights up while a disc is inserted)
• Dialog (Initial): Reproduces movie dialog more
video files. 6 Playback mode indicator (Repeat/Random)
clearly.
7 File type indicator
*1 For list of language codes, see page 59.
*2 For playable file types, see page 57.
If the disc contains no files of the selected type, the existing
files are played in the following priority: audio, video, then still
picture. You can change these settings only while playback is
stopped.

ENGLISH 11

00_DDX_2019ST_KN_RN.indb 11 31/5/2018 2:44:22 PM


Video
Video menu control operations Touching the operation keys performs the following [Picture Displays the picture adjustment screen.
You can display the video menu control during video actions: Adjust] 1 Touch [DIM ON] or [DIM OFF] to
playback. 1 turn on or off the dimmer.
• Available operation keys differ depend on the [ZOOM]*1 Displays the picture size selection 2 Touch [+]/[–] to adjust the other
selected disc type and file type. screen. items.
1 Touch [ Zoom] to change the • <Bright>: Adjusts the brightness
Video playback except VCD magnification level of the picture (−15 to +15).
Menu Control (Zoom1, Zoom2, Zoom3, Full: • <Contrast>: Adjusts the contrast
Initial). (−10 to +10).
2 Touch [J] [K] [H] [I] to move the • <Black>: Adjusts the blackness
zooming frame. (−10 to +10).
• <Color>: Adjusts the color
[Aspect] Displays the aspect ratio selection
(−10 to +10).
screen.
• <Tint>: Adjusts the tint (−10 to +10).
Touch [ Aspect] to select the aspect
• <Sharpness>: Adjusts the sharpness
E.g. Video menu control screen for DDX396 ratio.
(−2 to +2).
<Full>*2: For 16:9 original pictures
4:3 signal 16:9 signal [Audio] Selects the audio type.
[Subtitle] Selects the subtitle type.
[Angle] Selects the view angle.
<Just>: For viewing 4:3 pictures *1 When [Aspect] is set to <Just> or <Auto>, the picture is
naturally on the wide screen zoomed with the aspect ratio of the <Full> setting.
4:3 signal 16:9 signal This feature may not be used for some video sources.
*2 Only for DDX419BT: While DivX is played back with <Screen
Ratio> set to [16:9] (Page 11 for discs/Page 14 for USB),
<Normal>*2: For 4:3 original pictures the aspect ratio may not be set correctly.
4:3 signal 16:9 signal

<Auto>: For “DISC” source and


“USB” source only: The aspect ratio is
automatically selected to match the
incoming signals.

12 ENGLISH

00_DDX_2019ST_KN_RN.indb 12 31/5/2018 2:44:22 PM


Video USB
2 Touching the operation keys performs the following You can connect a USB mass storage class device such
[ MENU] actions: as a USB memory, digital audio player, etc. to the unit.
Displays the disc menu (DVD).
• For playable file types and other information, see
1
[T MENU] Displays the disc menu (DVD). pages 57 and 60.
[ZOOM] • You cannot connect a PC or portable HDD to the
[Highlight] Switches to the direct disc menu mode.
Touch the target item to select. [Aspect] Refer to “Video playback except VCD” on USB input terminal.
[Picture page 12. • You cannot connect a USB device via a USB hub.
[CUR] Displays the menu/scene selection
screen. Adjust]
• [J] [K] [H] [I]: Selects an item. Connecting a USB device
2
• [Enter]: Confirms the selection. USB device* (commercially available)
• [Return]: Returns to the previous [ MENU] Displays the disc menu.
screen. [Audio] Selects the audio channel
(ST: stereo, L: left, R: right).
Video playback for VCD [Direct]* Displays or hides the direct selection
buttons. Rear panel
Menu Control
1 Touch [DIR/CLR] to select a track
directly on a VCD.
2 Touch the numbers ([0], [1] to [9]) to
select the desired track.
3 Touch [Enter] to confirm.

To delete the last entry, touch [DIR/


E.g. Video menu control screen for DDX396 CLR].
[Return] Displays the previous screen or menu.
* You need to stop playback to deactivate the PBC function when
The source changes to “USB” and playback starts.
playing a VCD with PBC activated.
• All tracks in the USB device will be played repeatedly
until you change the source or disconnect the USB
device.

* Use CA-U1EX for extending the cable if necessary. (Max 500 mA,
5V)

ENGLISH 13

00_DDX_2019ST_KN_RN.indb 13 31/5/2018 2:44:22 PM


USB

Playback operations Selecting a folder/track on the list 2 Enter the alphabet to search.
Touch the first letter you want to search for, then
Playback information and key operation 1 Display the folder/track list. touch [OK].
• For playback information, see “Source control screen” On the source control screen, touch as follows:
on page 8. Settings for USB playback
• For key operations on the touch panel, see “Common
operation keys on source control screen” on 1 Display the <USB Mode> screen.
page 8. 2 Select the folder (1), then the item (2) in On the source control screen, touch as follows:
the selected folder.
Selecting the file type to play USB
You can specify the file type to play. Folder Name 1 File Name 1
Folder Name 2 File Name 2
USB
Folder Name 3 File Name 3 2 Make the settings.
Folder Name 4 File Name 4
USB Mode
Folder Name 5 File Name 5
Screen Ratio 16:9

Drive Select Next


File type Audio E.g. USB list screen for DDX396
Select an item in each layer until you reach and
select the desired file.
E.g. USB source control screen for DDX396

Select the file type as follows: Selecting a folder/track using alphabet


<Screen Ratio>
search
[Audio] Plays back audio files. Select the monitor type to watch a wide screen
(Applicable only for audio file type) picture on the external monitor.
[Video] Plays back video files.
You can search for a folder or an audio file by entering 16:9 (Initial) 4:3 LB 4:3 PS
[Photo] Plays back still picture files. the first letter you want to search for.
If the USB contains no files of the selected type, the
existing files are played in the following priority: audio, 1 Select the list (folder or track) to search.
video, then still picture. You can change these settings On the USB list screen, touch as follows:
<Drive Select>
only while playback is stopped. • Next: Switch between internal memory and the
memory source of the connected device (such as
a mobile phone).
• [ ]: Folder list
• [ ]: Track list
14 ENGLISH

03_DDX_2019ST_KNRN_Body01.indd 14 31/5/2018 4:48:41 PM


Android iPod/iPhone
Connecting an Android device Playback operations Connecting an iPod/iPhone
This unit supports Android OS 4.1 and above. Playback information and key operation • For playable iPod/iPhone types and other
information, see page 60.
Android (commercially available) Android
• You cannot watch video.
HANDMODE

Wired connection
iPod/iPhone iPod/iPhone 30-pin
S IW T Lightning model connector model
(commercially available) (commercially available)
USB cable (commercially available)
E.g. Android source control screen for DDX396

Touching the operation keys performs the following


actions:
[S]/[T] Selects an audio file.
USB Audio cable USB Audio cable
Rear panel [IW] Starts/pauses playback.
for iPod/iPhone: for iPod/iPhone:
KCA-iP103 (optional KCA-iP102 (optional
accessory) accessory)

Rear panel

When connecting an Android device, “HAND MODE” is


shown. You can control Android device using a media
player application installed in the Android device.

The source changes to “iPod” and playback starts.

ENGLISH 15

00_DDX_2019ST_KN_RN.indb 15 31/5/2018 2:44:22 PM


iPod/iPhone Radio
Bluetooth connection 2 Select a category (1), then select a Listening to the radio
Pair the iPod/iPhone with this unit via Bluetooth.
desired item (2).
(Page 33)
iPod The unit switches to FM alarm scene automatically
Playlists Artist 000000001 when receiving an alarm signal from FM broadcast.
Selecting the playback device via the Artist Artist 000000002

connection method Album Artist 000000003


Playback information on the source control
Songs Artist 000000004
screen
See <Smartphone Setup> on page 46 for more
Podcasts Artist 000000005
information.
Radio

Playback operations Select an item in each layer until you reach and
select the desired file.
Playback information and key operation • Available categories differ depending on the type
• For playback information, see “Source control screen” of iPod/iPhone.
on page 8.
• For key operations on the touch panel, see “Common Settings for iPod/iPhone playback
operation keys on source control screen” on
page 8. 1 Display the <iPod Mode> screen.
1 Selects the band (AM/FM1/FM2/FM3)
On the source control screen, touch as follows:
Additional keys operations. Touching the operation 2 Current station frequency/RBDS status
keys performs the following actions: 3 Text information
• Touching [<] scrolls the text if not all of the text
[ ] Switches the device on <Smartphone is shown.
Setup> screen. (Page 46) • Touching [Radio Text] switches the information
2 Make the settings. between Radio Text, Radio Text Plus and PTY
iPod Mode code.
Selecting an audio file from the menu Artwork ON OFF 4 Displays the preset stations window (Page 18)
1 Display the audio menu. 5 [P1] – [P5]
On the source control screen, touch as follows: • (Touch) Selects a preset station.
• (Hold) Presets the current station.
<Artwork>
• ON (Initial): Shows the artworks of the playing
files.
• OFF: Hides the artworks of the playing files.

16 ENGLISH

00_DDX_2019ST_KN_RN.indb 16 31/5/2018 2:44:22 PM


Radio
6 Displays/hides other available operation keys* • If the TI indicator lights up in orange, Presetting stations in the memory
7 TI indicator tune into another station providing
8 ST/MONO indicator Radio Broadcast Data System signals. You can preset five stations for each band.
The ST indicator lights up when receiving an FM • The volume adjustment for Traffic
stereo broadcast with sufficient signal strength. Information is automatically Automatic presetting — AME (Auto
9 Seek mode indicator memorized. The next time the unit Memory)
p Operation keys* switches to Traffic Information, the On the source control screen, touch as follows:
volume is set to the memorized level.
See the following “Operation keys on source control screen”. • To deactivate, touch [TI] again.

Operation keys on source control screen p (Hold)


• The appearance of the operation keys may differ, [PTY]* (For FM RBDS features) The local stations with the strongest signals are found
however the similar operation keys have the same Enters PTY search mode. and stored automatically.
operations. 1 Touch [PTY].
• See also “Common operation keys on source control 2 Touch and hold a PTY code to search
screen” on page 8.
Manual presetting
for.
If there is a station broadcasting a 1 Tune in to a station you want to preset.
Touching the operation keys performs the following program of the same PTY code as you
actions: have selected, that station is tuned in.
6 [SEEK] Changes the seek mode for [S]/[T].
• AUTO1 (Initial): Auto search
[AME ] (Hold) Presets stations automatically. 2 Select a preset number to store into.
• AUTO2: Tunes in preset stations one
[MONO]* Activates monaural mode for better FM after another Radio
reception (stereo effect will be lost). • MANU: Manual search P1

• The MONO indicator lights up while [S]/[T] Searches for a station.


monaural mode is activated. • The search method differs according
• To deactivate, touch [MONO] again. to the selected seek mode (see above).
[TI]* (For FM RBDS features) (Hold)
Activates TI standby reception mode. * Appears only when FM is selected as the source.
• When TI is activated, the unit is ready
to switch to traffic information if E.g. Radio source control screen for DDX396
available. The TI indicator lights up in
white. The station selected in step 1 is stored into the
preset number [P1] to [P5] you have selected.

ENGLISH 17

00_DDX_2019ST_KN_RN.indb 17 31/5/2018 2:44:23 PM


Radio SiriusXM® Satellite Radio (Only for DDX396/DDX376BT/DDX276BT/DDX26BT)

Only SiriusXM® brings you more of what you love


Selecting a preset station Activating subscription
to listen to, all in one place. Get over 140 channels,
1 Select the band, then display the preset
including commercial-free music plus the best sports, 1 Check your Radio ID.
news, talk, comedy and entertainment. Welcome to The SiriusXM Satellite Radio ID is required
station window. the world of satellite radio. A SiriusXM Connect Vehicle for activation and can be found by tuning to
On the source control screen, touch as follows: Tuner and subscription are required. Channel 0 as well as on the label found on the
For more information, visit <www.siriusxm.com>. SiriusXM Connect Vehicle Tuner and its packaging.
• The Radio ID does not include the letters I, O, S or
Preparation F.

2 Select a preset station. Connecting the SiriusXM Connect Vehicle 2 Activate the subscription.
Radio
For users in the U.S.A:
Tuner • Online: Visit <www.siriusxm.com/activatenow>
P1
Perform this installation when you install the unit for • Phone: Call SiriusXM Listener Care at
the first time. 1-866-635-2349
Antenna For users in Canada:
• Online: Visit <www.siriusxm.ca/subscribe-now>
SiriusXM Connect Vehicle • Phone: Call XM Customer Care at 1-877-438-9677

E.g. Preset station window for DDX396


Tuner (commercially 3 Confirm the activation.
available) A confirmation message appears. Touch [Return].
Rear panel
To hide the window: Touch [ ].
Listening to the SiriusXM® Satellite Radio
Playback information on the source control
screen

SiriusXM

18 ENGLISH

00_DDX_2019ST_KN_RN.indb 18 31/5/2018 2:44:23 PM


SiriusXM® Satellite Radio
1 Displays/hides other available operation keys* Operation keys on source control screen q
2 Selects the band (SXM1/SXM2/SXM3/SXM4) • See also “Common operation keys on source control
[ ] Displays the <Channel List> screen.
3 Channel number screen” on page 8.
4 Text information [IW] Starts/pauses the content replay.
• Touching [] scrolls the text if not all of the text Touching the operation keys performs the following [CHJ]/[CHK] Selects the channel.
is shown. actions: • To select a channel, make sure
• Touching [Song Title]/[Info]/[Category] 1 “SEEK1” is selected as the seek
switches the information. mode.
5 Displays the preset channel window [MODE] Displays the <SiriusXM Mode>
screen. • To select a preset channel, make
• To hide the window, touch [ ]. sure “SEEK2” is selected as the seek
6 [P1] – [P5] [ ] (Hold) Registers the current artist to
mode.
• (Touch) Selects a preset channel. the alert contents.
• (Hold) Presets the current channel. [ ] (Hold) Registers the current song to
7 Playback status and time code for the buffered data the alert contents. Selecting a channel on the list
and replay mode [ ] Activates or deactivates the content You can obtain information on channels or select a
• The time code shows you the point in the Replay alert for traffic and weather. channel to listen to.
buffer you are listening to. (E.g. “–5:00” means
that you are listening to audio that is 5 minutes
[SEEK] Changes the seek mode for [CHJ]/ 1 Display the <Channel List> screen.
[CHK]. On the source control screen, touch as follows:
behind the current broadcast.)
• SEEK1 (Initial): Skips to another
8 Replay time bar for replay mode
available channel.
• Black: The remaining capacity
• SEEK2: Skips to another preset
• Blue: The amount of buffered contents
channel.
9 Signal strength indicator 2 Select a category (1), and then select a
p Seek mode indicator [SCAN] Starts TuneScan™.
channel (2).
q Operation keys* [S]/[T]/ Performs playback operations during
Channel List Channel
[Live] content replay.
All Channels 100Ch Channel Name
* See the following “Operation keys on source control screen”.
[ ] Changes the page in the window to Category Name 1 105Ch Channel Name
display other operation keys. Category Name 2 110Ch Channel Name
Category Name 3 115Ch Channel Name
Category Name 4 120Ch Channel Name

ENGLISH 19

00_DDX_2019ST_KN_RN.indb 19 31/5/2018 2:44:23 PM


SiriusXM® Satellite Radio
• To list all the channels, touch [All Channels].
Selecting a preset channel Replaying content
• Touch the info change key above the list
([Channel]/[Artist]/[Song Title]/[Info]) to You can pause, rewind and replay the contents from
display other information in the following order:
1 Select the band, then display the preset
the currently tuned channel.
Channel, Artist, Song Title, Content Info. channel window. • The SiriusXM Connect Vehicle Tuner continually
On the source control screen, touch as follows:
buffers up to 60 minutes of audio.
Presetting channels in the memory • If you change to another channel during playback,
the buffered contents will be lost.
You can preset five channels for each band. • The time code is updated every second.
1 Tune in to a channel you want to preset. 2 Select a preset channel. 1 Display the operation keys for replay.
On the source control screen, touch as follows:
SiriusXM
P1 Channel Name
100Ch

Channel Name
105Ch

2 Select a preset number to store into. 110Ch


Channel Name

SiriusXM 115Ch
Channel Name
2 Perform the replay operations.
P1 Channel Name
100Ch 120Ch
SiriusXM
105Ch

110Ch
• You can also select a preset channel by touching
115Ch
[P1]–[P5].
(Hold)
120Ch
To hide the window: Touch [ ].
The channel selected in step 1 is stored into the 3 Select “SEEK2” as the seek mode to jump
preset number [P1] to [P5] you have selected. to the selected preset channel.

20 ENGLISH

00_DDX_2019ST_KN_RN.indb 20 31/5/2018 2:44:23 PM


SiriusXM® Satellite Radio

[IW] Starts/pauses playback. TuneStart™ Content Alert


[S]/[T] Skips the current track/segment. When you select a SmartFavorites channel, you can The unit informs you when receiving the content you
• Touching [S] within 2 seconds listen to the current song from the beginning. are interested in, such as music, information about a
of the beginning of the current
track/segment returns to the
1 Display the <SiriusXM Mode> screen. sports team, weather and traffic information.
On the source control screen, touch as follows:
previous track.
• Touching [S] after 2 seconds or
Registering items for Contents Alert
more of the current track returns You can register your favorite artists, songs or teams.
to the beginning of the track. Up to 50 contents can be registered.
(Hold) Reverses/forwards search. 2 Activate TuneStart™. For artists/songs
[Live] Returns to the live position. On <SiriusXM Mode> screen, touch as follows: While listening to your favorite artist/song:
<TuneStart> : [ON]
On the source control screen, touch as follows:
SiriusXM Satellite Radio features To deactivate TuneStart: Touch [OFF] in step 2.

SmartFavorites TuneScan™
(Hold)
User stored channels (P1 to P5) of the current band You can get a short preview of the songs you have
are recognized as SmartFavorites channels. SiriusXM missed on each of your SmartFavorites music channels Touching the operation keys performs the following
Connect Vehicle Tuner automatically buffers their and the currently tuned music channel. actions:
broadcast content in the background. When you select Activate TuneScan™ to start scanning the first
a SmartFavorite channel, you can rewind and replay up 6 seconds of the recorded music contents. [ ] (Hold) Registers the artist of the current
to 30 minutes of any of the missed news, talk, sports or song.
music content. On the source control screen, touch as follows: [ ] (Hold) Registers the current song.
• SmartFavorites is available only when you connect
an SXV200 or later SiriusXM Connect Vehicle Tuner.
• If you change to another band, the buffered content
is cleared and new channels in the current band will
start buffering. The unit starts scanning.
• To select the previous/next content, touch
[S] or [T].
• To end scanning and continue listening to the
current song/content, touch [SCAN] again.
• To exit scanning, touch and hold [SCAN].

ENGLISH 21

00_DDX_2019ST_KN_RN.indb 21 31/5/2018 2:44:24 PM


SiriusXM® Satellite Radio
For teams To delete the registered items: Touch and hold the
Selecting items for Content Alert item you want to delete in step 2.
1 Display the <Alert Team Select> screen. You can select items (artists/songs/teams) from the The [ ] icon and a check mark appear beside the
On the source control screen, touch as follows: registered items on the list to inform you once the unit selected item. Touch the [ ] icon to delete.
receives the information.
To delete all registered contents: Touch and hold
For artists/songs/teams [All Clear ] for <Content Alerts Contents Set> in
Then, on the <SiriusXM Mode> screen, touch as 1 Display the <Content Alerts Contents Set> step 1.
follows: screen.
<Alert Team Select> : [Enter] On the source control screen, touch as follows: For traffic and weather information

2 Select the league (1) and the team (2), 1 Display the <SiriusXM Mode> screen.
then register into the content alert (3). On the source control screen, touch as follows:

Alert Team Select

League1 Team1 Then, on the <SiriusXM Mode> screen, touch as


League2 Team2
follows:
League3 Team3

League4 Team4
<Content Alerts Contents Set>: [Set] 2 Select the city you desire traffic and
League5 Team5
2 Select the category (1), then the item (2). weather information for.
Content Alerts Contents Set SiriusXM Mode
Content Alerts ON OFF
Artist 000Ch Ch Name
Content Alerts Contents Set Set All Clear
Title 000Ch Ch Name
Alert Team Select Enter
Team 000Ch Ch Name
Traffic Weather Jump City Select
000Ch Ch Name
Los Angeles
000Ch Ch Name
SiriusXM Reset Reset

A check mark appears beside the selected item. • When traffic and weather broadcast is received, the
• To show the details of the item, touch [<]. unit automatically switches the channel.

22 ENGLISH

00_DDX_2019ST_KN_RN.indb 22 31/5/2018 2:44:24 PM


SiriusXM® Satellite Radio

Activating Content Alert Switching to registered content Setting reception restrictions


For artists/songs/teams When an artist/song/team registered for Content Alert
You can limit access to SiriusXM channels, such as
is being broadcasted, an alert appears on the screen.
1 Display the <SiriusXM Mode> screen. those with mature content.
On the source control screen, touch as follows:
Touch [Jump], then select the item to jump to on the
<Content Alerts> screen. Setting or changing the parental code
• The initial setting is “0000”.
Content Alerts
• Changing the code does not change the
Artist 1/ Channel Name
Artist 2/ Channel Name
<Parental Lock>/<Parental Lock Channel
2 Activate Content Alert. Song 1/ Channel Name Selection> settings.
On <SiriusXM Mode> screen, touch as follows: Song 2/ Channel Name

<Content Alerts> : [ON]


Team 1/ Channel Name 1 Display the <Parental Code Check>
Team 2/ Channel Name
screen.
On the source control screen, touch as follows:
To deactivate Content Alert: Touch [OFF] in step 2.
• To show the details of the item, touch [<].
For traffic and weather information
Make sure <Content Alerts> is set to [ON], then on
the source control screen, touch as follows: Then, on the <SiriusXM Mode> screen, touch as
follows:
<Parental Code> : [Change]
2 Enter the initial four-digit code (0000) (1),
• When a traffic and weather broadcast for the and then touch [Enter] (2) to confirm.
selected city is received, the unit automatically Parental Code Check
switches the channel.
****
Clear 1 2 3
To deactivate the Content Alert: Touch [ ] again. 4 5 6
7 8 9
Cancel 0 Enter

• To clear the last entry, touch [Clear].


• To cancel setting the code, touch [Cancel].

ENGLISH 23

00_DDX_2019ST_KN_RN.indb 23 31/5/2018 2:44:24 PM


SiriusXM® Satellite Radio

3 Enter a new four-digit code, then touch To deactivate parental lock for all locked channels:
Parental Lock channel selection Select [All Clear] for <Parental Lock Channel
[Enter] to confirm. This option allows you to manually select the channels Selection> in step 1, then enter the parental code.
4 Repeat step 3 above to confirm the new to be locked by the parental control feature.
code. • You can only change the setting if
Skipping unwanted channels
<Parental Control> is set to [User].
If you do not want to receive some channels, you can
Activating parental control 1 Display the <Parental Lock Channel skip them.
You can set the parental control feature to lock any Selection> screen.
SiriusXM channels or automatically lock all channels On the source control screen, touch as follows:
1 Display the <Skip Channel Selection>
classified as “mature” by SiriusXM®.
screen.
On the source control screen, touch as follows:
1 Display the <SiriusXM Mode> screen.
On the source control screen, touch as follows:
Then, on the <SiriusXM Mode> screen, touch as
follows:
<Parental Lock Channel Selection> [SET] Then, on the <SiriusXM Mode> screen, touch as
follows:
2 Enter the parental code. <Skip Channel Selection> : [SET]
2 Select the desired mode for <Parental The <Parental Lock Channel Selection> screen
Control>. appears. 2 Select a category (1), then a channel (2).
A check mark appears beside the selected channel.
[OFF] Deactivates parental control. 3 Select a category (1), then a channel (2).
Skip Channel Selection
[Mature] Locks channels classified as “mature” A check mark appears beside the selected channel.
All Channels 100Ch Channel Name
by SiriusXM®. Parental Lock Channel Selection Category Name 1 105Ch Channel Name

Category Name 2 110Ch Channel Name


[User] Locks selected channels. All Channels 100Ch Channel Name

Category Name 1 105Ch Channel Name Category Name 3 115Ch Channel Name

Category Name 2 110Ch Channel Name Category Name 4 120Ch Channel Name

3 Enter the parental code to confirm your Category Name 3 115Ch Channel Name

selection. Category Name 4 120Ch Channel Name

• To list all the channels, select [All Channels].

• To list all the channels, select [All Channels]. 3 Repeat step 2 to skip multiple channels.
4 Repeat step 3 to set the parental lock on To clear the channel skipping for all skipped
multiple channels. channels: Touch and hold [All Clear ] for <Skip
Channel Selection> in step 1.

24 ENGLISH

00_DDX_2019ST_KN_RN.indb 24 31/5/2018 2:44:24 PM


SiriusXM® Satellite Radio Pandora® (Only for DDX396/DDX376BT/DDX276BT/DDX26BT)

You can stream Pandora from iPhone/iPod touch or Install the latest version of the Pandora application on
Resetting the SiriusXM Satellite Radio
Android devices. your smartphone.
settings • Pandora is only available in certain countries. For • For Android devices: Search for “Pandora” in Google
You can reset all the SiriusXM settings you made and more information, visit <www.pandora.com/legal>. Play to find and install the most recent version.
restore the initial settings. • Because Pandora is a third-party service, the • For iPhone/iPod touch: Search for “Pandora” in the
specifications are subject to change without Apple iTunes App Store to find and install the most
1 Display the <SiriusXM Mode> screen. prior notice. Accordingly, compatibility may be recent version.
On the source control screen, touch as follows: impaired or some or all of the services may become
unavailable. Connecting the device
• Some functions of Pandora cannot be operated from For Android devices
this unit. Pair the Android device with this unit via Bluetooth.
• For issues using the application, contact Pandora at (Page 33)
2 Reset the setting. <pandora-support@pandora.com>.
On the <SiriusXM Mode> screen, touch and hold For iPhone/iPod touch
as follows: Preparation • Via USB input terminal: Connect iPhone/iPod touch
<SiriusXM Reset> : [Reset ] with the cable. (Page 15)
Installing the application – For Lightning models: Use KCA-iP103 (optional
Your smartphone must has built in Bluetooth and the accessory).
following profiles must be supported: – For 30-pin connector models: Use KCA-iP102
• SPP (Serial Port Profile) (optional accessory).
• A2DP (Advanced Audio Distribution Profile) • Via Bluetooth: Pair the iPhone/iPod touch with this
Establish an Internet connection using LTE, 3G, EDGE, unit. (Page 33)
or WiFi.
Ensure you are logged in to your smartphone Selecting the device
application. If you do not have a Pandora account, you
For selecting the playback device via the connection
can create one for free from your smartphone or at
method to use, see <Smartphone Setup> on
<www.pandora.com>.
page 46.

ENGLISH 25

00_DDX_2019ST_KN_RN.indb 25 31/5/2018 2:44:25 PM


Pandora®
Operation keys on source control screen
Playback operations Selecting a station from the list
• The appearance of the operation keys may differ,
Playback information and key operation however the similar operation keys have the same 1 Display the list selection screen.
operations. On the source control screen, touch as follows:
• See also “Common operation keys on source control
Pandora screen” on page 8.

Touching the operation keys performs the following


actions: 2 Select the list type.
1 Pandora

[ ] Adds the current artist to the station list.


[ ] Adds the current track to the station list.
Station List Genre List
You can also operate Pandora with optional remote [ ] Bookmarks the current track.
controller, KNA-RCDV331. [ ] Switches the device on <Smartphone
You can only control play, pause and skip with the
Setup> screen. (Page 46)
remote controller.
[Station List] Selects from the station names.
4
1 Displays/hides other available operation keys* [Genre List] Selects from the genres.
[ ] Displays the list selection screen.
2 Picture data
3 Track information [ ] Thumbs down to the current track and
• Touching [<] scrolls the text if not all of the text skips to the next track.
is shown. [ ] Registers the current track as a favorite.
4 Operation keys*
5 Playing time/playback status [IW] Starts/pauses playback.
[T] Skips the current track.
* See the following “Operation keys on source control screen”. • Not available when the Pandora skip
reaches its limit.

26 ENGLISH

00_DDX_2019ST_KN_RN.indb 26 31/5/2018 2:44:25 PM


Pandora® iHeartRadio (Only for DDX396/DDX376BT/DDX276BT/DDX26BT)

3 Select a station from the list. iHeartRadio is a free, all-in-one digital radio service that Install the latest version of the iHeartRadio application
On the station list: lets you listen to your favorite live stations or create on your smartphone.
commercial-free, all-music custom stations featuring • For Android devices: Search for “iHeartRadio for Auto”
Pandora
songs from the artists you select and similar music. in Google Play to find and install the most recent
Shuffle By Date

Station Name
version.
By Name

Station Name You can stream iHeartRadio from iPhone/iPod touch or • For iPhone/iPod touch: Search for “iHeartRadio for
Station Name Android devices. Auto” in the Apple iTunes App Store to find and
Station Name • Because iHeartRadio is a third-party service, the install the most recent version.
Station Name
specifications are subject to change without
prior notice. Accordingly, compatibility may be Connecting the device
• To play all the songs in the registered stations impaired or some or all of the services may become For Android devices
randomly, touch [Shuffle]. unavailable. Pair the Android device with this unit via Bluetooth.
• To sort the list in reverse chronological order, • Some functions of iHeartRadio cannot be operated (Page 33)
touch [By Date]. from this unit.
• To sort the list in alphabetical order, touch [By • For issues using the application, contact iHeartRadio For iPhone/iPod touch
Name]. at <http://www.iheart.com/>. • Via USB input terminal: Connect iPhone/iPod touch
• The indicator appears on the right of the with the cable. (Page 15)
item when the station is shared. Preparation – For Lightning models: Use KCA-iP103 (optional
accessory).
On the genre list: Installing the application – For 30-pin connector models: Use KCA-iP102
Pandora Your smartphone must has built in Bluetooth and the (optional accessory).
Genre Name 1 Song Name 1 following profiles must be supported: • Via Bluetooth: Pair the iPhone/iPod touch with this
Genre Name 2 Song Name 2 • SPP (Serial Port Profile) unit. (Page 33)
Genre Name 3 Song Name 3 • A2DP (Advanced Audio Distribution Profile)
Genre Name 4 Song Name 4 Establish an Internet connection using LTE, 3G, EDGE, Selecting the device
Genre Name 5 Song Name 5 or WiFi.
For selecting the playback device via the connection
Ensure you are logged in to your smartphone
method to use, see <Smartphone Setup> on
application. If you do not have a iHeartRadio account,
page 46.
1 Select a genre. you can create one for free from your smartphone or at
2 Select a station. <http://www.iheart.com/>.
The selected station is added to the station list.

ENGLISH 27

00_DDX_2019ST_KN_RN.indb 27 31/5/2018 2:44:25 PM


iHeartRadio
Operation keys on source control screen *1 Appears only for the custom station screen.
Playback operations
• The appearance of the operation keys may differ, *2 Appears only for the live station screen.
Playback information and keys operation however the similar operation keys have the same
operations. Selecting the variety level for your custom
• See also “Common operation keys on source control station
iHeartRadio screen” on page 8.
1 Display the variety level selection screen.
Touching the operation keys performs the following On the source control screen, touch as follows:
actions:
1
[ ] Creates a custom station from the
currently playing track content
information. 2 Select the variety type.
You can also operate iHeartRadio with optional remote [ ] Saves the current station to the Discovery Tuner

controller, KNA-RCDV331. <Favorites> list.


Familiar Less Familiar
You can only control play, pause and skip with the [ ]*1 Displays the variety level selection
remote controller. screen.
[ ] Switches the device on <Smartphone Mixed
1 Displays/hides other available operation keys* Setup> screen. (Page 46)
2 Picture data
3 Track information 4
• Touching [<] scrolls the text if not all of the text [Familiar] Distributes well-known tracks.
[ ] Displays the <Station Search> screen
is shown. or the station list. [Mixed] Distributes a mix of artists and
4 Operation keys* track names.
[ ] Dislikes the currently playing content.
5 Playback status [Less Familiar] Distributes a wide variety of
[ ] Likes the currently playing content. tracks including lesser-known
* See the following “Operation keys on source control screen”. ones.
[Io]*2 Starts/stops playback.
[IW]*1 Starts/pauses playback.
[SCAN]*2 Scans stations randomly.
[T]*1 Skips the current track.

28 ENGLISH

00_DDX_2019ST_KN_RN.indb 28 31/5/2018 2:44:25 PM


iHeartRadio Spotify
With Spotify, your music is everywhere. Working out,
Searching for a station Editing the <Favorites> list partying or relaxing, the right music is always at your
1 Display the <Station Search> screen. 1 Display the <Station Edit> screen. fingertips. There are millions of songs on Spotify—from
On the source control screen, touch as follows: On the source control screen, touch as follows: old favorites to the latest hits. Just choose the music
you love, or let Spotify surprise you.

You can stream Spotify from iPhone/iPod touch or


Android devices.
2 Select a station. Then, on the <Station Search> screen, touch as • Because Spotify is a third-party service, the
• The items displayed on the <Station Search> follows: specifications are subject to change without
screen differ depending on the information sent prior notice. Accordingly, compatibility may be
from iHeartRadio. impaired or some or all of the services may become
Station Search unavailable.
Favorites • Some functions of Spotify cannot be operated from
Recent Stations
Live Radio
2 Select stations (1), then delete the this unit.
selected stations (2). • For issues using the application, contact Spotify at
Artist Radio
Podcasts • A check mark appears beside the selected station. <www.spotify.com>.
Station Edit
Station 01 Preparation
Station 02
• To return to the top layer, touch [ ]. Station 03 Installing the application
• To return to the upper layer, touch [ ]. Station 04
Station 05
Your smartphone must has built in Bluetooth and the
Station 06 following profiles must be supported:
• SPP (Serial Port Profile)
• A2DP (Advanced Audio Distribution Profile)
• To return to the top layer, touch [ ]. Establish an Internet connection using LTE, 3G, EDGE,
• To return to the upper layer, touch [ ]. or WiFi.
Ensure you are logged in to your smartphone
application. If you do not have an Spotify account, you
can create one for free from your smartphone or at
<www.spotify.com>.

ENGLISH 29

00_DDX_2019ST_KN_RN.indb 29 31/5/2018 2:44:25 PM


Spotify
Install the latest version of the Spotify application on Operation keys on source control screen
Playback operations
your smartphone. • The appearance of the operation keys may differ,
• For Android devices: Search for “Spotify” in Google Playback information and key operation however the similar operation keys have the same
Play to find and install the most recent version. operations.
• For iPhone/iPod touch: Search for “Spotify” in the • See also “Common operation keys on source control
Apple iTunes App Store to find and install the most Spotify screen” on page 8.
recent version.
Touching the operation keys performs the following
Connecting the device actions:
For Android devices 1
Pair the Android device with this unit via Bluetooth. [ ]*3 Thumbs down to the current track and
(Page 33) skips to the next track.

For iPhone/iPod touch [ ]*3 Registers the current track as a favorite.


• Via USB input terminal: Connect iPhone/iPod touch You can also operate Spotify with a remote controller,
[ ]*4 *5 Activates/deactivates the shuffle
with the cable. (Page 15) RC-DV340*1.
playback mode.
– For Lightning models: Use KCA-iP103 (optional You can only control play, pause and skip with the
remote controller. [ ]*4 Repeats all tracks/cancels the repeat
accessory). playback.
– For 30-pin connector models: Use KCA-iP102
1 Displays/hides other available operation keys*2 [ ]*4 *5 Repeats the current track/cancels the
(optional accessory).
2 Picture data repeat playback.
• Via Bluetooth: Pair the iPhone/iPod touch with this
unit. (Page 33) 3 Track information [ ] Creates a new station.
• Touching [<] scrolls the text if not all of the text
is shown. [ ] Switches the device on <Smartphone
Selecting the device • Touching [ ]/[ ] changes the displayed Setup> screen. (Page 46)
For selecting the playback device via the connection information between artist ( ) and album ( ). 4
method to use, see <Smartphone Setup> on 4 Operation keys*2
page 46. 5 Playing time/playback status [ ] Displays the Spotify menu screen.
6 Progress bar [ ]*5 [ ] Selects a track.

*1 For DDX396/DDX376BT/DDX276BT/DDX26BT: Purchase optional [ ][ ] Starts (I)/pauses (W) playback.


remote controller, KNA-RCDV331. [ ] Saves the current track/artist to <Your
*2 See “Operation keys on source control screen”. Library>.

30 ENGLISH

03_DDX_2019ST_KNRN_Body01.indd 30 20/8/2018 4:21:33 PM


Spotify Other External
*3 Not available for tracks in a playlist.
*4 Not available for tracks in the Radio.
Selecting a track Components
*5 Available only for premium account users. 1 Display the Spotify menu screen.
AV-IN
On the source control screen, touch as follows:
Creating your station (Start Radio) Connecting an external component
Start Radio is to start a radio channel based on the See page 57 for more information.
currently played track.
2 Select the list type, then select a desired Starting playback
Create your station. item.
On the source control screen, touch as follows:
• The list types displayed differ depending on the 1 Select “AV-IN” as the source.
information sent from Spotify. 2 Turn on the connected component and
Spotify start playing the source.
Your Library
Browse
Station is created and playback starts automatically. Radio
Changing the AV-IN name
• You can personalize your station using thumb up You can change the AV-IN name displayed on the
([ ]) or thumb down ([ ]). source control screen.
– You cannot thumb up or down while playing tracks • This setting does not affect the source name
in a playlist. displayed on the Home screen.
– Personalizing stations may not be available • To return to the top layer, touch [ ].
depending on the track.
1 Display the <VIDEO Mode> screen.
• To return to the upper layer, touch [ ]. On the source control screen, touch as follows:

2 Select an AV-IN name.


VIDEO Mode

AV-IN Name VIDEO

ENGLISH 31

03_DDX_2019ST_KNRN_Body01.indd 31 20/8/2018 4:21:44 PM


Other External Components

Rear view camera Operations while the camera screen is Using an external component via ADS
Install the rear view camera (separately purchased) in displayed adapter—OEM Features
the appropriate position according to the instructions To adjust the picture (Only for DDX396/DDX376BT/DDX276BT)
supplied with the rear view camera. Touch the area shown below. By connecting this unit to the bus system of the
vehicle using iDataLink (commercially available), this
Connecting a rear view camera unit can access the satellite radio source provided for
See page 57 for more information. the vehicle and vehicle information can be displayed
• To use the rear view camera, a reverse lead (REVERSE) on this unit.
connection is required. (Page 56) Video menu control is shown. For details, see “Video • Displayable screens, button names, and screen
menu control operations” on page 12. names vary depending on the type of the connected
• To exit video menu control, touch the same area iDataLink and the model of the vehicle.
Using the rear view camera
again. • For details, visit <www.idatalink.com/>.
• For rear camera settings, see <Rear Camera> on
page 45.
To display parking guide line Connecting an ADS adapter
To display the rear view camera screen Set <Parking Guidelines> to [ON] (Page 45) or See page 57 for more information.
The rear view screen is displayed by shifting the gear touch the area shown below.
to the reverse (R) position when <Rear Camera Using an external component via an ADS
Interruption> is set to [ON]. (Page 45) adapter
• A caution message appears on the screen. To • For settings to use an ADS adapter, see page 46.
remove the caution message, touch the screen.
• To close the parking guidelines, touch the same area 1 Select “OEM Features” as the source.
You can also display the picture from the rear view again. On the Home screen, touch as follows:
camera manually without shifting the gear to the
reverse (R) position. To exit the camera screen
Press HOME on the monitor panel or touch the area
On the pop-up short-cut menu, touch as follows: shown below.
2 Turn on the connected component and
start playing the source.

32 ENGLISH

00_DDX_2019ST_KN_RN.indb 32 31/5/2018 2:44:26 PM


Other External Components Bluetooth®
[Satellite Displays the control screen of the Information Connection
Radio] satellite radio source provided for the
vehicle. Bluetooth is a short-range wireless radio When you connect a Bluetooth device to the unit for
communication technology for mobile devices such as the first time:
[Media Displays the control screen of the
mobile phones, portable PCs and other devices. 1 Register the device by pairing the unit and the
Player] media player source provided for the
Bluetooth devices can be connected without cables device.
vehicle.
and communicate with each other. 2 Connect the device to the unit. (Page 34)
[TEL] Displays the control screen of the
Bluetooth Hands Free function Note Registering a new Bluetooth device
provided for the vehicle. • While driving, do not perform complicated Pairing allows Bluetooth devices to communicate with
[BT Displays the control screen of the operations such as dialing numbers, using the phone each other.
Streaming] Bluetooth streaming function book, etc. When you perform these operations, stop • The pairing method differs depending on the
provided for the vehicle. your car in a safe place. Bluetooth version of the device.
[Gauges] Displays the information about the • Some Bluetooth devices may not connect to this unit – For devices with Bluetooth 2.1:
instruments such as a speedometer. depending on the Bluetooth version of the device. You can pair the device and the unit using SSP
• This unit may not work for some Bluetooth devices. (Secure Simple Pairing) which only requires
[Climate] Displays the information about the air
• Connecting conditions may vary depending on your confirmation.
conditioner of the vehicle.
environment. – For devices with Bluetooth 2.0:
[Parking Displays the information about • For some Bluetooth devices, the device is
Assist] the Parking Distance Sensor of the You need to enter a PIN code both on the device
disconnected when the unit is turned off. and unit for pairing.
vehicle. • If your mobile phone supports PBAP (Phone Book • Once the connection is established, it is registered in
[Vehicle Info] Displays the information about the Access Profile), you can display the following items the unit even if you reset the unit. Up to five devices
tire pressures of the vehicle. on the touch panel when the mobile phone is can be registered in total.
[Radar Displays the information about the connected. • Two devices for Bluetooth phone and one for
Detector] Radar Detector. – Phone book Bluetooth audio can be connected at a time.
– Dialed calls, received calls, and missed calls (up to However, when “BT Audio” is selected as the source,
10 entries in total) you can connect up to five Bluetooth audio devices
and switch between these five devices.
Preparation • To use the Bluetooth function, you need to turn on
the Bluetooth function of the device.
Connect and install the microphone beforehand. For
details, see page 56.

ENGLISH 33

00_DDX_2019ST_KN_RN.indb 33 31/5/2018 2:44:27 PM


Bluetooth®
Auto pairing Pairing a Bluetooth device using a PIN code 4 Select the unit (“DDX3eX”/“DDX3”/
When <Auto Pairing> is set to [ON] (page 39), (for Bluetooth 2.0)
“DDX2”/“DDX4”) on your Bluetooth
iOS (such as iPhone) devices are automatically paired
when connected via USB.
1 Display the <PIN Code Set> screen. device.
On the Home screen, touch as follows: • If a PIN code is required, enter “0000” (initial) or
new PIN code you have entered in step 2.
Pairing a Bluetooth device using SSP
• When pairing is completed, the device is
(for Bluetooth 2.1)
registered on the <Paired Device List> screen.
When the Bluetooth device is compatible with
Bluetooth 2.1, a pairing request is sent from the Then, on the <Setup> screen, touch as follows:
Note
available device. [System]  <Bluetooth Setup> : [Enter]
• The PIN code is initially set to “0000”.
1 Search for the unit (“DDX3eX”/“DDX3”/
On the <Bluetooth Setup> screen, touch as
• The maximum number of digits in the PIN code is 15.
“DDX2”/“DDX4”) from your Bluetooth
follows:
device. <PIN Code> : [0000] Connecting/disconnecting a registered
2 Confirm the request both on the device Bluetooth device
2 Change the PIN code.
and the unit. If you wish to skip changing the PIN code, go to 1 Display the <Paired Device List> screen.
On the device: step 3. On the Home screen, touch as follows:
PIN Code Set

0000
1 2 3

4 5 6
Then, on the <Setup> screen, touch as follows:
7 8 9
[System]  <Bluetooth Setup> : [Enter]
0 Enter Clear
On the unit:
On the <Bluetooth Setup> screen, touch as
follows:
• To delete the last entry, touch [Clear]. <Paired Device List> : [Enter]
• To delete the PIN code, touch and hold [Clear].
3 Search for the unit (“DDX3eX”/“DDX3”/
“DDX2”/“DDX4”) from your Bluetooth
device.

To reject the request: Touch [Cancel].

34 ENGLISH

00_DDX_2019ST_KN_RN.indb 34 31/5/2018 2:44:27 PM


Bluetooth®

2 Select the device (1) you want to connect, • The status is shown as follows:
<Connecting>: Connection is in progress.
During a call...
then select [Connection] (2).
<Connected>: A connection has been established. 1
Device Name 1
2
Device Name 2

Paired Device List <Connect Ready>: A connection can be established. Talking... Name
1234XXXXXX
Device Name 1 <Disconnecting>: Disconnection is in progress.
NR LEVEL – 0 +
Device Name 2 <Disconnected>: No connection is established.
Device Name 3 OK EC LEVEL – 0 +
• When a Bluetooth mobile phone is connected, the
Device Name 4 Connection
signal strength and battery level are displayed when DTMF MIC LEVEL – 0 +
Device Name 5 Remove
the information is acquired from the device.

To delete the registered device: Perform step 1, Touching the operation keys performs the following
3 Select the device (1) to connect, then select the device you want to delete in step 2, then actions:
return to the <Paired Device List> (2). touch [Remove].
BT Connection Settings • A confirmation message appears. Touch [Yes]. [ ] Ends a call.
Device Name [ ]/ Switches between handsfree mode and
Connected ON OFF Bluetooth mobile phone [ ] phone mode.
Connect Ready ON OFF

When a call comes in... [DTMF] Enters DTMF (Dual Tone Multi
Frequency), then sends text using the
1 2
Device Name 1 Device Name 2
keypad.
Incoming Call
NR LEVEL Adjusts the noise reduction level.
Name [–] / [+] (–5 to 5)
Select [ON] (to connect) or [OFF] (to disconnect). 1234XXXXXX
: Mobile phone EC LEVEL Adjusts the echo volume level.
: Audio device [–] / [+] (–5 to 5)
MIC LEVEL Adjusts the volume level of the
4 Connect the selected device.
Touching the operation keys performs the following [–] / [+] microphone. (–10 to 10)
Paired Device List actions:
Perform the following actions on the monitor panel to
Device Name 1
Device Name 2 [ ] Answers a call. adjust the volume of the call or earpiece.
Device Name 3 OK DDX396/DDX376BT: Turn the volume knob.
Device Name 4 Connection
[ ] Rejects a call. DDX276BT/DDX26BT/DDX419BT: Press volume J/K
Device Name 5 Remove button.
• Call information is displayed if acquired.
• Phone operation is not available while the picture
from the rear view camera is displayed.

ENGLISH 35

00_DDX_2019ST_KN_RN.indb 35 31/5/2018 2:44:27 PM


Bluetooth®

3 Select a contact (1), then make a call (2). When item 4 is selected in step 2:
Making a call
When item 1, 2 or 3 is selected in step 2: Enter the phone number (1), then make a
1 Display the phone control screen. 1
Device Name 1
2
Device Name 2 call (2).
On the Home screen, touch as follows: Name 1 1 2
1234XXXXXX Device Name 1 Device Name 2
Name 2
2345XXXXXX 1234XXXXXX X
Name 3
3456XXXXXX 1 2 3
A-Z
Name 4 4 5 6
4567XXXXXX
7 8 9
Name 5
2 Select a method to make a call. 8901XXXXXX * 0/+ #

1 2
Device Name 1 Device Name 2
To use alphabet search in the phone book
1234XXXXXX X
1 Touch [ A-Z ]. • To enter “+”, touch and hold [0/+].
1 2 3 2 Touch the first letter you want to search for on • To delete the last entry, touch [ X ].
4 5 6
the keypad.
7 8 9
0/+ #
To search for a number, touch [1,2,3...]. When item 5 is selected in step 2:
*
3 Select a contact you want call from the list.
Say the name of the person you want to
Phone book search results: call.
1 From the call history* (missed calls/received
“Sort order”, “display order” or any other equivalent • Available only when the connected mobile
calls/dialed calls)
settings of the phone may affect and show phone has a voice recognition system.
2 From the phone book*
different search results (page display) of the phone • If the unit cannot find the target, “Please speak
3 From the preset list (Page 37)
book shown on the main unit. into the microphone” appears. Touch [Start],
4 Use direct number entry
then say the name again.
5 Use voice dialling
To display other phone numbers in the same • To cancel voice dialling, touch [Cancel].
* Applicable only for mobile phone compatible with PBAP (Phone contact
Book Access Profile). You can store up to 10 phone numbers per
contact.
1 Touch [ ].
2 Select a contact you want call from the list.

36 ENGLISH

03_DDX_2019ST_KNRN_Body01.indd 36 20/8/2018 4:28:45 PM


Bluetooth®

Switching between two connected devices Presetting phone numbers Bluetooth audio player
You can change the device to use when 2 devices are You can preset up to five phone numbers.
connected.
1 Display the phone control screen.
KENWOOD Music Mix
On the Home screen, touch as follows: When “BT Audio” is selected as the source, you can
On the phone control screen: connect up to five Bluetooth audio devices at the
1
Device Name 1
2
Device Name 2
same time. You can easily switch between these five
1234XXXXXX X devices by playing music from the device.
1 2 3
4 5 6
7 8 9 2 Select call history or phone book calling
* 0/+ # method (1), then select a contact (2) to
preset.
1 2
Device Name 1 Device Name 2
The active device is highlighted. Name 1
1234XXXXXX
Name 2
2345XXXXXX
Name 3
3456XXXXXX
A-Z
Name 4
4567XXXXXX
Name 5
8901XXXXXX

BT Audio

3 Select a preset number to store into.


1 2
Device Name 1 Device Name 2

1234XXXXXX

2345XXXXXX

3456XXXXXX

No preset

No preset
(Hold)

To delete the contact in the preset number: Touch


[ ] besides the contact on the preset list.

ENGLISH 37

00_DDX_2019ST_KN_RN.indb 37 31/5/2018 2:44:27 PM


Bluetooth®
1 Tag data* (current track title/artist name/album
Selecting an audio file from the menu Bluetooth settings
title)
• Pressing [<] scrolls the text if not all of the text is 1 Display the audio menu. You can change various settings for using Bluetooth
shown. On the source control screen, touch as follows: devices on the <Bluetooth Setup> screen.
2 Signal strength and battery level
(Appear only when the information is acquired
1 Display the <Bluetooth Setup> screen.
On the Home screen, touch as follows:
from the device.)
3 Playing time*/playback status*
4 Connected device name 2 Select a category (1), then select a
• Touching the device name switches to another desired item (2).
connected Bluetooth audio device. Then, on the <Setup> screen, touch as follows:
BT Audio
[System]  <Bluetooth Setup> : [Enter]
* Available only for devices compatible with AVRCP 1.3. Playlists
Artist 2 Make the settings.
Album
Bluetooth Setup
Playback information and key operation Songs
Paired Device List Enter
• For playback information, see “Source control screen” Genre
PIN Code 0000
on page 8. Device Name DDX3eX
• For key operations on the touch panel, see “Common Device Address 01:20:03:40:05:60:07

operation keys on source control screen” on Auto Connect ON OFF


BT Audio Bluetooth HF/Audio Front Only All
page 8.
Artist 1
Artist 2
Additional keys operations. Touching the operation
Artist 3 <Paired Device List>
keys performs the following actions: Artist 4 Display the list of registered devices. You can
Artist 5
[ ] Displays <Bluetooth Setup> screen. connect a device or delete registered devices.
<PIN Code>
Change the PIN code of the unit.
Select an item in each layer until you reach and
select the desired file. <Device Name>
Show the device name of this unit to be shown on
the Bluetooth device — “DDX3eX”/“DDX2”/
“DDX3”/“DDX4”.
<Device Address>
Show the device address of the unit.

38 ENGLISH

00_DDX_2019ST_KN_RN.indb 38 31/5/2018 2:44:28 PM


Bluetooth® Settings
<Auto Connect> Audio settings <Equalizer>
• ON (Initial): Automatically establishes a The following adjustments are memorized for each
connection with the last connected Bluetooth Display the <Audio> screen. source until you adjust the sound again. If the source
device when the unit is turned on. On the Home screen, touch as follows: is a disc, the adjustments are stored for each of the
• OFF: Cancels. following categories.
<Bluetooth HF/Audio> • DVD/VCD
Select the speakers used for Bluetooth mobile • CD
phones and Bluetooth audio players. • DivX*1/MPEG1/MPEG2/MP3/WMA/WAV/AAC/FLAC
Then, on the <Setup> screen, touch [Audio].
• Front Only: Front speakers only. You cannot adjust the sound when the unit is in
Setup
• All (Initial): All speakers. standby.
Audio Equalizer Enter
<Auto Response>
Display Sound Effect Enter
• ON: The unit answers the incoming calls Input Fader / Balance Enter
Selecting a preset sound mode
automatically in 5 seconds. System Speaker / X’over Enter Select a preset sound mode on the <Equalizer>
• OFF (Initial): The unit does not answer the calls Time Alignment Enter screen.
automatically. Answer the calls manually. • Natural (Initial)/Rock/Pops/Easy/Top40/Jazz/
<Auto Pairing> Powerful/User
• ON (Initial): Establishes pairing automatically E.g. Audio settings screen for DDX396 Equalizer SRC Name
with an iOS device (such as iPhone) connected Preset Natural Q factor 1.5
[dB]

via USB. (Auto pairing may not work for some You cannot change the <Audio> screen in the +9
+7
+5
+3
devices depending on the iOS version.) following situations: 0
-3
-5

• OFF: Cancels. • When the AV source is turned off. -7


-9
62.5 100 160 250 400 630 1k 1.6k 2.5k 4k 6.3k 10k 16k [Hz]

<Initialize> • When the Bluetooth phone is used (making or Bass EXT ON OFF EQ INIT

Touch and hold [Enter] to reset all settings you receiving a call, during a call, or while voice dialling). SW LEVEL 0 ALL SRC

have made for using Bluetooth mobile phones and


Bluetooth audio players. • To apply the adjusted equalizer to all playback
sources, touch [ALL SRC], then touch [OK] to
confirm.

ENGLISH 39

00_DDX_2019ST_KN_RN.indb 39 31/5/2018 2:44:28 PM


Settings
<Sound Effect> <Stage EQ>
Store your own sound adjustments Moves the center of the sound to the lower or higher
Adjust the sound effect.
1 Select a preset sound mode. point. Select the height.
• OFF (Initial)/Low/Middle/High
2 Select a band (1) and adjust the level (2), <Loudness>
then adjust the sound (3). Adjusts loudness.
*1 You cannot change the setting when “Radio” is selected as the
• OFF (Initial)/Low/High
Equalizer SRC Name source.
Preset Natural Q factor 1.5 *2 This function works only when “DISC”/ “USB”/ “iPod”/
[dB] <Bass Boost>
+9
+7 “Android™” is selected as the source.
+5
+3
0
Selects the bass boost level.
-3
-5
-7 • OFF (Initial)/Level 1/Level 2/Level 3/Level 4/
-9
62.5 100 160 250 400 630 1k 1.6k 2.5k 4k 6.3k 10k 16k [Hz]
Level 5 <Fader/Balance>
Bass EXT ON OFF EQ INIT
Touch [J]/[K]/[H]/[I] or drag the mark to adjust.
SW LEVEL 0 ALL SRC
<Drive Equalizer>
Reduces the driving noise by raising the bandwidth. <Fader>
• OFF (Initial)/ON Adjusts the front and rear speaker output balance.
Adjust the sound as follows: When using a two-speaker system, set the fader to the
<Space Enhancer>*1 center (0).
<Q factor>
Virtually enhances the sound space using the Digital • F15 to R15 (Initial: 0)
Adjusts the width of the frequency.
Signal Processor (DSP) system. Select the enhance
• 1.35/1.5 (Initial)/2.0
level. <Balance>
<Bass EXT> • OFF (Initial)/Small/Medium/Large Adjusts the left and right speaker output balance.
Activates/deactivates bass. • L15 to R15 (Initial: 0)
• ON/OFF (Initial) <Supreme>*2
<SW LEVEL> Restores the sound lost due to audio compression to a To clear the adjustment: Touch [Center].
Adjusts the subwoofer level.*2 realistic sound.
• –50 to +10 (Initial: 0) • OFF/ON (Initial)
• To clear the adjustment, touch [EQ INIT].
<Realizer>
3 Repeat step 2 to adjust the level of other Virtually makes the sound more realistic using the
bands. Digital Signal Processor (DSP) system. Select the sound
level.
*1 Only for DDX419BT. • OFF (Initial)/Level 1/Level 2/Level 3
*2 Not adjustable when <None> is selected for subwoofer on the
<Speaker Select> screen. (Page 41)

40 ENGLISH

00_DDX_2019ST_KN_RN.indb 40 31/5/2018 2:44:28 PM


Settings
<Speaker/X’over> 4 Select the crossover network mode. 2 Select the speaker type (1), select the size
Crossover network mode settings [2way] Select this when connecting speakers of the selected speaker (2), then display
(Only for DDX396/DDX419BT) in a 2-way system (front/rear). the <X’over> screen (3).
Before making any settings for the speakers and [3way] Select this when connecting speakers
crossover frequency, select the appropriate crossover in a 3-way system (tweeter/mid
network mode according to the speaker system (2-way range/woofer).
speaker system or 3-way speaker system).
A confirmation message appears. Touch [Yes] to
• Connecting 3-way speakers with 2-way crossover
confirm.
network mode selected may damage the speakers.

1 Display the source/option selection screen. Setting the speakers and crossover
On the Home screen, touch as follows: frequency
• If a speaker is not connected, select <None>.
1 Select a car type (1), select the location • When setting the front speakers, also select the
of the speakers (2), then display the speaker size for <Tweeter>.
<Speaker Select> screen (3).
2 Put the unit in standby.
On the source/option selection screen, touch as
follows:

3 Press the following buttons/knob on the


monitor panel at the same time to display • Only for DDX396/DDX419BT: Speaker location
the <X’over Network> screen. selection is available only when <X’over
• DDX396: MENU button and ATT knob Network> is set to [2way].
• DDX419BT: MENU button and CAM button

ENGLISH 41

00_DDX_2019ST_KN_RN.indb 41 31/5/2018 2:44:28 PM


Settings

3 Adjust the crossover frequency of the <Time Alignment> Determining the value for <Position DTA>
selected speaker. Make fine adjustments to the delay time of the speaker adjustment
• Adjustable items vary depending on the selected output to create a more suitable environment for your If you specify the distance from the center of the
speaker type/speaker size/crossover settings. car. currently set listening position to every speaker, the
delay time will be automatically computed and set.
<TW Gain (L)>/<TW Gain (R)> 1 Determines the center of the currently set
Adjusts the output volume of the tweeter (left/
Select the listening position (1), select
[Distance] or [Gain](2) to make an listening position as the reference point.
right). 2 Measures the distances from the reference point
adjustment , then adjust each speaker
<TW FREQ> to the speakers.
Adjusts the crossover frequency for the tweeter. setting (3).
3 Calculates the differences between the distance
<Gain> of the furthest speaker and other speakers.
Adjusts the output volume of the selected speaker. 4 Sets the DTA value calculated in step 3 for
<HPF FREQ> individual speakers.
Adjusts the crossover frequency for the front or rear 5 Adjusts gain for individual speakers.
speakers (high pass filter).
E.g. When <Front All> is selected as the listening
<LPF FREQ> position
Adjusts the crossover frequency for the speaker
(low pass filter). 1 Select from <All>, <Front L>, <Front R> or
<Slope> <Front All>. +3.5 ft
Adjusts the crossover slope. • Only for DDX396/DDX419BT: <Front All> is
<Phase> selectable only when <X’over Network> is set to
Selects the phase for the speaker. [2way]. (Page 41) 1.4 ft
2 Select an item to adjust.
2.45 ft
[Distance] Adjusts the digital time alignment
value. 4.9 ft +2.45 ft
[Gain] Adjusts the output volume of the
selected speaker.
3 To determine the adjustment value, see the +0 ft
following “Determining the value for <Position
DTA> adjustment”.

To initialize the setting value: Touch [Initialize].

42 ENGLISH

00_DDX_2019ST_KN_RN.indb 42 31/5/2018 2:44:28 PM


Settings
<Volume Offset> <Dimmer> Only for DDX396/DDX376BT/DDX419BT:
<Panel Color>: Change the illumination color of the
Adjust and store the auto-adjustment volume level for • Auto (Initial): Dims the screen and button
buttons on the monitor panel.
each source. If the source is a disc, the adjustment is illumination when you turn on the headlights.
stored for each of the following categories: – The ILLUMI lead connection is required.
• DVD/VCD (Page 56)
• CD • ON: Activates dimmer.
• DivX*/MPEG1/MPEG2/MP3/WMA/WAV/AAC/FLAC • OFF: Deactivates dimmer.

The volume level will automatically increase or <User Customize>


decrease when you change the source.
You can change the display design. While playing a
• –15 to +6 (Initial: 00)
video or picture, you can capture an image and use • You can also adjust the illumination color yourself.
the captured image as a background. Touch [Edit] to display the illumination color
* Only for DDX419BT.
• You cannot capture copyrighted content and adjustment screen, then select the dimmer setting
images. and adjust the color. The adjustment is saved in
Display settings • When using a JPEG file as the background, make sure [User].
that the resolution is 800 x 480 pixels. • Selecting [Scan] changes the illumination color
Display the <Display> screen. • The color of the captured image may look different gradually.
On the Home screen, touch as follows: from that of the actual scene.
Storing your own scene for the background
<Background>: Change the background design.
image
Then, on the <Setup> screen, touch [Display]. 1 While playing a video or picture, display
Setup
the <User Customize> screen.
On the <Display> screen, touch as follows:
Audio Dimmer Auto
<User Customize>: [Enter]
Display User Customize Enter
Input OSD Clock ON OFF 2 Display the background design selection
System Demonstration ON OFF
screen, then touch [ Capture].
Scroll ON Once OFF

E.g. Display settings screen for DDX396

ENGLISH 43

00_DDX_2019ST_KN_RN.indb 43 31/5/2018 2:44:29 PM


Settings

3 Adjust the image (1), then capture the <Demonstration> <Screen Adjustment>
image (2). • ON (Initial): Activates the display demonstration. Adjust the brightness and blackness of the screen.
• OFF: Deactivates the display demonstration. Select [DIM ON] (dimmer on) or [DIM OFF] (dimmer
off), then change the following settings:
<Scroll>
<Bright>
• ON (Initial): Scrolls the displayed information
Adjusts brightness.
repeatedly.
• –15 to +15 (Initial: 0 for dimmer on, +15 for dimmer
Capture Cancel
• Once: Scrolls the displayed information once.
off)
• OFF: Cancels.
<Black>
E.g. Image adjustment screen for DDX396 Touching [<] scrolls the text regardless of this setting.
Adjusts blackness.
• –10 to +10 (Initial: 0)
[J][K][H][I] Moves the zooming frame. <Home Customize>
[ ] Magnifies the scene. Arrange the items to display on the Home screen. <Video Output>
<OFF>/<Zoom1>/<Zoom2>/
Select the color system of the external monitor.
<Zoom3> Select an item (1) to replace, then select the • NTSC (Initial)/PAL
[IW]* Starts/pauses playback. item (2) you want to display in the selected
Advances scenes frame by frame. position. “Please Power Off” appears when the setting is
[ ]*
Repeat this step to place icons for other items. changed. Turn off the power, then turn on to enable
A confirmation message appears. Touch [Yes] • Only selectable sources are shown. the change.
to store the newly captured image. (The existing
image is replaced with the new one.) HOME Pandora
<Viewing Angle>
Customize
• To return to the previous screen, touch [No].
• To cancel the capture, touch [Cancel]. Select the viewing angle in relation to the monitor to
make the image on the screen easier to see.
* Not displayed when playing an external component connected to • Under 0° (Initial)/5°/10°/15°/20°
the AV-IN input terminal. iPod TEL R di
Radio

<OSD Clock>
E.g. Home customize screen for DDX396
• ON: Displays the clock while a video source is
playing.
• OFF (Initial): Cancels.

44 ENGLISH

00_DDX_2019ST_KN_RN.indb 44 31/5/2018 2:44:29 PM


Settings
<Guidelines Setup> <Parking Assist Position>
Input settings
Adjust the parking guidelines according to the size of Select where information about obstacles is displayed
Display the <Input> screen. the car, parking space and so on. on the screen.
On the Home screen, touch as follows: When adjusting the parking guidelines, make sure to • Left/Right (Initial)
use the parking brake to prevent the car from moving.
System settings
Select the mark (1), then adjust the position of the
selected mark (2). Display the <System> screen.
Then, on the <Setup> screen, touch [Input]. On the Home screen, touch as follows:
Setup
Audio Rear Camera Enter
Display Parking Assist Enter
Input
Then, on the <Setup> screen, touch [System].
System
Initialize Setup
Audio Language English
Display Clock Enter

E.g. Input settings screen for DDX396 Input Smartphone Setup Enter
Make sure that A and B are horizontally parallel, and System Bluetooth Setup Enter
that C and D are the same length. OEM Setup Enter
<Rear Camera> • Touch and hold [Initialize ] for 2 seconds to set all
Configure the rear view camera settings. the marks to the initial default position.
E.g. System settings screen for DDX396
<Rear Camera Interruption> <Parking Assist> <Language>
• ON: Displays the picture from the rear view camera
(Only for DDX396/DDX376BT/DDX276BT) Select the text language used for on-screen
when you shift the gear to the reverse (R) position.
– A caution message appears on the screen. To information. For details, see “Initial settings” on
Configure settings for using the ADS adapter. page 5.
remove the caution message, touch the screen.
• OFF (Initial): Select this when no camera is <Parking Assist Display> “Please Power Off” appears when the setting is
connected. When an ADS adapter is connected, you can display changed. Turn off the power, then turn on to enable
information about obstacles around the car. the change.
<Parking Guidelines> • ON: Always displays information.
• ON (Initial): Displays the parking guidelines. • Dyn. (Initial): Displays information when the sensor
<Clock>
• OFF: Hides the parking guidelines. detects obstacles.
• OFF: Cancels. Set the clock. For details, see “Clock settings” on
page 6.

ENGLISH 45

00_DDX_2019ST_KN_RN.indb 45 31/5/2018 2:44:29 PM


Settings
<Smartphone Setup> If [Android/Other] is selected in step 1: <OEM Setup>
Specify the connection method of Android/iPod/ Smartphone Setup (Only for DDX396/DDX376BT/DDX276BT)
iPhone. Bluetooth
Get information, and change the settings for using the
1 Select the device type (1), then touch ADS adapter.
[Change] (2).
Smartphone Setup Next <Beep>
Initial Information
For DDX396/DDX419BT, this setting is available only
Device Type iPod / iPhone

Connection Type Bluetooth


when 2-way speaker system is selected. (Page 41)
The <Paired Device List> screen appears. Go to
Device Name Device Name • ON (Initial): Activates the key-touch tone.
Device Type Select
step 3.
iPod / iPhone Android / Other Change
• OFF: Deactivates the key-touch tone.
3 When selecting [Bluetooth] as the
connection method: Select the device (1), <SETUP Memory>
then press [OK] (2) to connect. Memorize, recall, or clear the settings you have made.
2 Select the connection method (1), then • If the device is already connected, skip step 1. • The memorized settings are kept even when the unit
confirm the selection ([OK] or [Next]) (2). Paired Device List is reset.
If [iPod/iPhone] is selected in step 1: Device Name 1 • Available only when <SETUP Memory> is set to
Smartphone Setup Device Name 2 [Unlock] (selected initially).
Device Name 3 OK
USB 1 Wire Bluetooth
Device Name 4 Connection Touch [Yes] to display the setting screen, then select
Device Name 5 Remove an operation:
• Recall: Recalls the memorized settings.
OK • Memory: Memorizes the current settings.
• Clear: Clears the currently memorized settings and
<Bluetooth Setup>
return to the factory (initial) settings.
Configure settings for using a Bluetooth device, such • Cancel: Cancels.
[USB 1 Wire] Select this when the device is as connection and other general operations. For
connected via the USB input details, see “Bluetooth settings” on page 38. A confirmation message appears. Touch [Yes].
terminal (cable from the rear
panel). You can also set to lock the <SETUP Memory> from
being changed. Touch [Lock] to lock the settings.
[Bluetooth] Select this when the device is
• Some items in <Setup> menu, e.g. <Speaker/
connected via Bluetooth. (Go to
X’over>, cannot be adjusted when [Lock] is
step 3.)
selected.

46 ENGLISH

04_DDX_2019ST_KNRN_Body02.indd 46 31/5/2018 4:49:47 PM


Settings
<DivX(R) VOD> • To reset the touch position, touch [Reset]. 4 Repeat steps 2 and 3 to register other
• To cancel the current operation, touch [Cancel].
(Only for DDX419BT) buttons.
This unit has its own Registration Code. Once you <Steering Remote Control Setting> 5 Touch [Done] to finish the procedure.
have played back a file with the Registration Code
(Only for DDX419BT) • The unit can register/change all of the buttons’
recorded, this unit’s Registration Code is overwritten
functions at the same time. To do this, press all
for copyright protection. Assign functions to the keys of the remote controller
buttons in turn and after pressing all of them, touch
• Touch [Enter] to display the information. on the steering wheel.
[Done] on the <Steering Remote Control Setting>
• To return to the previous screen, touch [OK]. • This function is available only when your car is
screen. However, new functions cannot be learned
equipped with the electrical steering remote
after this operation.
<Security Code> controller.
• When changing the functions already learned, touch
• You can only register/change the functions while
(Only for DDX419BT) the assigned function you want to change in step 3
you are parked.
and then touch to select the new function from the
Register the security code for the unit. (Page 6) • If your steering remote controller is not compatible,
function list.
learning may not be completed and an error
• Confirm the contents of the settable functions in the
<Serial Number> message may appear.
function list. You cannot edit the function list.
(Only for DDX396/DDX376BT/DDX276BT/DDX26BT) • For connection, see page 57 for more information.

Displays the serial number. 1 Touch [Set] for <Steering Remote Control To initialize the setting: Touch [Initialize] for
Setting> to display the setting screen. <Steering Remote Control Setting>.
• A confirmation message appears. Touch [Yes].
<Touch Panel Adjust> 2 Press and hold a button on the steering – To cancel the initialization, touch [No].
Adjust the touch positions of the buttons on the remote controller to register or change.
screen.
3 Select a function to assign to the selected
Touch the center of the marks at the upper left (1), button.
the lower center (2), then the upper right (3) as
Steering Remote Control Setting
instructed. Please select the function to assign to the button.

Touch Panel Adjust VOL


VOL
ATT
Done SRC

Cancel Reset

ENGLISH 47

00_DDX_2019ST_KN_RN.indb 47 31/5/2018 2:44:29 PM


Settings Remote Controller
<System Information> • For DDX419BT: This unit can be operated using the
remote controller (RC-DV340) supplied with this unit.
CAUTION
Update the system by connecting a USB device • Put the Remote Controller in a place where it will
• For DDX396/DDX376BT/DDX276BT/DDX26BT:
containing an update file. not move during braking or other operations. A
Optional remote controller KNA-RCDV331 is
• To obtain the update file, visit dangerous situation could result if the Remote
designed for controlling this unit. Refer to the
<www.kenwood.com/cs/ce/>. Controller falls down and gets wedged under the
instruction manual that comes with the remote
controller. pedals while driving.
Connect a USB device with the update file to the unit. • Do not leave the battery near fire or under direct
sunlight. A fire, explosion or excessive heat
Remote sensor*
generation may result.
• Do not recharge, short, break up or heat the battery,
or place it in an open fire. Such actions may cause
the battery to leak fluid. If spilled fluid comes in
contact with your eyes or clothing, immediately rinse
<Application Version> with water and consult a physician.
Updates the system application. • Place the battery out of reach of children. In the
<System Version> unlikely event that a child swallows the battery,
Updates the system. immediately consult a physician.
• If you turned the power off then on or turn the * DO NOT expose the remote sensor to bright
ignition switch off then on after selecting <Update>, light (direct sunlight or artificial lighting).
the unit will reset.
<DVD Version>
Updates the DVD system application.
The system update starts. It may take a while.
If the update has been completed successfully,
“Update Completed” appears, then reset the unit.
RC-DV340
• Do not disconnect the USB device while updating.
• If the update has failed, turn the power off and then
on, and retry the update.

<Open Source Licenses>


Shows the Open Source Licenses.

48 ENGLISH

00_DDX_2019ST_KN_RN.indb 48 31/5/2018 2:44:30 PM


Remote Controller

Preparation Remote Controller mode switch Basic operations for RC-DV340 (supplied)
The functions operated from the remote controller
Battery installation differ depending on the position of the mode switch.
Common operations (AUD mode)
Use two “AAA”/“R03”-size
SRC • Selects the source.
batteries.
• Hangs up the incoming/current call.
Insert the batteries with the + AUD
and – poles aligned properly, t
DVD t
J/K VOL Adjusts the volume level.
AUDt
following the illustration inside DVDt TV t ATT Attenuates/restores the sound.
T Vt t
the case. NAV

• Always insert batteries from DISP/V.SEL Switches to the current source control
– poles to avoid bending the screen.
springs. • AUD mode: Switch to this mode when controlling a ENTER Enters options.
• If the Remote Controller selected source or tuner source, etc. Answers incoming calls.
operates only over shorter distances or does not • DVD mode: Switch to this mode when playing DVDs
operate at all, it is possible that the batteries are or CDs etc. with the player integrated in this unit. FNC/PBC/ Switches the control screen.
depleted. In such instances, replace both batteries • TV mode: Not used. MENU
with new ones. • NAV mode: Not used. MODE/TOP Changes the aspect ratio.
• The position of the remote control mode switch is MENU • The aspect ratio changes each time
indicated in the title of each mode, e.g., “AUD mode”. you press this key.
• When controlling a player that is not integrated in OPEN Not used for this unit.
the unit, select “AUD” mode.

ENGLISH 49

00_DDX_2019ST_KN_RN.indb 49 31/5/2018 2:44:30 PM


Remote Controller

DVD/VCD (DVD mode) DIRECT Enters direct search mode. iPod/Android (AUD mode)
CLEAR Deletes a character while in direct
J/K/H/I Moves the cursor when displaying a S/T Selects music/videos.
search mode.
menu.
I/W Starts/pauses playback.
S/T Selects a track.
I/W Starts/pauses playback.
Music Disc/Audio file/Video file/Picture file
(AUD mode) USB (AUD mode)
o Stops and memorizes the point
where the disc stops. AM –/FM + Selects a folder. AM –/FM + Selects a folder.
0–9 • Specifies the number to search for S/T Selects a track/file. S/T Selects a file.
in direct search.
• 1/2: Fast forwards/backwards. I/W Starts/pauses playback. I/W Starts/pauses playback.
– Fast forward/backward speed 0–9 Specifies the number to search for in
changes each time you press this direct search.
key. Searching for an item directly
DIRECT Enters direct search mode.
• 4/5: Slow forwards/backwards While listening to the radio or during disc playback,
during pause. you can search for a station frequency/chapter/title/
folder/file/track directly using the number buttons.
MODE/TOP Shows the disc top menu. Radio (AUD mode) • To search for a track from the VCD menu, perform
MENU
AM –/FM + Selects the band. during PBC playback.
FNC/PBC/ Shows the disc menu.
MENU S/T Searches for stations.* 1 Press DIRECT to enter the search mode.
SUBTITLE Changes the subtitle language. • Each time you press DIRECT, the item to search
I/W Changes the seek mode (AUTO1, for changes.
ZOOM Changes the zoom ratio. AUTO2, MANU).
• The zoom ratio changes each time 0–9 • Specifies preset number. (1-5) 2 Press a number button to select a desired
you press this key. • Specifies the frequency of the item (station frequency/chapter/title/
ANGLE Changes the picture angle. station to receive to search for in folder/file/track).
• The picture angle changes each direct search. • To erase a misentry, press CLEAR.
time you press this key. DIRECT Enters direct search mode. 3 Confirm the selection.
AUDIO Changes the voice language. • For station frequency: Press S/T.
* The search method differs according to the selected seek mode.
• The voice language changes each • For others: Press ENTER.
time you press this key.
To exit the search mode: Press DIRECT.

50 ENGLISH

00_DDX_2019ST_KN_RN.indb 50 31/5/2018 2:44:30 PM


Remote Controller

Basic operations for KNA-RCDV331 MAP DIR/OPEN Not used for this unit. * +/CLEAR Deletes a character while in direct
(optionally purchased) search mode.
NAV/DISP Not used for this unit.
# BS/DIRECT Enters direct search mode.
ZOOM OUT/IN Not used for this unit.
ROUTE M/ Shows the disc top menu.
2 ZONE Not used for this unit.
MODE/
R.VOL Not used for this unit. TOP MENU
VOICE/FNC/ • Shows the disc menu.
* Available only when the AUD mode is selected. MENU/PBC • Turns the playback control on or
off while playing VCD.
DVD/VCD (DVD mode) CANCEL/ Displays previous screen.
RETURN
J/K/H/I Moves the cursor when displaying
a menu. AUDIO Changes the voice language.
• The voice language changes
H/S / T/I Selects a track.
each time you press this key.
J/FM+ / K/AM− Selects a folder.
Common operations (AUD/DVD mode) SUBTITLE Changes the subtitle language.
POSITION/IW Starts/pauses playback.
ANGLE Changes the picture angle.
SRC* • Selects the source. MENU/o Stops and memorizes the point • The picture angle changes each
• Hangs up the incoming/current where the disc stops. time you press this key.
call.
0–9 • Specifies the number to search ZOOM Changes the zoom ratio.
VOL J/K Adjusts the volume level. for in direct search. • The zoom ratio changes each
ATT Attenuates/restores the sound. • 1/2: Fast forwards/backwards. time you press this key.
• 4/5: Slow forwards/backwards.
VOICE/FNC/ For discs/USB/iPod: Switches to the
(For DVD only)
MENU/PBC* current source control screen.
– Slow forward/backward speed
ENTER Enters options. changes each time you press
Answers incoming calls. this key.

ROUTE M/ Changes the aspect ratio.


MODE/ • The aspect ratio changes each
TOP MENU* time you press this key.
VIEW/AV OUT Switches the AV source to be
output.

ENGLISH 51

00_DDX_2019ST_KN_RN.indb 51 31/5/2018 2:44:30 PM


Remote Controller

Music Disc/Audio file/Video file/Picture file iPod/Android (AUD mode) Searching for an item directly
(AUD mode) While listening to the radio or during disc playback,
H/S / T/I Selects music/videos.
you can search for a station frequency/chapter/title/
J/FM+ / K/AM− Selects a folder. POSITION/IW Starts/pauses playback. folder/file/track directly using the number buttons.
H/S / T/I Selects a track/file. • To search for a track from the VCD menu, perform
during PBC playback.
POSITION/IW Starts/pauses playback. USB (AUD mode)
0–9 Specifies the number to search for
1 Press # BS/DIRECT to enter the search
in direct search. J/FM+ / K/AM− Selects a folder. mode.
• Each time you press # BS/DIRECT, the item to
# BS/DIRECT Enters direct search mode. H/S / T/I Selects a file.
search for changes.
POSITION/IW Starts/pauses playback.
2 Press a number button to select a desired
Radio/SiriusXM*1 (AUD mode) item (station frequency/chapter/title/
folder/file/track).
J/FM+ / K/AM− Selects the band. • To erase a misentry, press * +/CLEAR.
H/S / T/I Searches for stations.*2 3 Confirm the selection.
POSITION/IW Changes the seek mode (AUTO1, • For station frequency: Press H/S / T/I.
AUTO2, MANU). • For others: Press ENTER.
0–9 • Specifies preset number. (1-5)
• Specifies the frequency of the To exit the search mode: Press # BS/DIRECT.
station to receive to search for in
direct search.
# BS/DIRECT Enters direct search mode.

*1 Only for DDX396/DDX376BT/DDX276BT/DDX26BT.


*2 The search method differs according to the selected seek mode.

52 ENGLISH

00_DDX_2019ST_KN_RN.indb 52 31/5/2018 2:44:30 PM


Remote Controller Installation and Connection
KENWOOD Remote APP WARNINGS Before installation
KENWOOD Remote is an application that connects • DO NOT connect the ignition wire (red) and the
and controls compatible KENWOOD car receivers via
Precautions on installation and connection
battery wire (yellow) to the car chassis (ground), you
Bluetooth® like a wireless remote control. may cause a short circuit, that in turn may start a fire. • Mounting and wiring this product requires skills and
• DO NOT cut out the fuse from the ignition wire (red) experience. For best safety, leave the mounting and
You can also operate this unit from a Smartphone and the battery wire (yellow). The power supply must wiring work to professionals.
using KENWOOD Remote APP. be connected to the wires via the fuse. • Mount the unit so that the mounting angle is 30° or
This application can display the source information • Always connect the ignition wire (red) and the less.
of this unit on the smartphone’s screen, and enables battery wire (yellow) to the power source running • Make sure to ground the unit to a negative 12 V DC
the user to make an audio setting using the graphic through the fuse box. power supply.
user interface of this application. • Do not install the unit in a location exposed to direct
This application also works as a free standalone sunlight or excessive heat or humidity. Also avoid
CAUTIONS places with too much dust or the possibility of water
music player application, when your Smartphone is
not connected to this unit. • Install this unit in the console of your car. splashing.
• For details, visit <www.kenwood.com/car/app/ • Do not touch the metal parts of this unit during and • Do not use your own screws. Use only the screws
kenwood_remote/eng/>. shortly after the use of the unit. Metal parts such as provided. If you use the wrong screws, you could
the heat sink and enclosure become hot. damage the unit.
• When parking at a low ceiling area, turn off the unit • After the unit is installed, check whether the brake
to store the antenna. As when the unit is installed in lamps, blinkers, wipers, etc. on the car are working
the car with the function of auto antenna; the radio properly.
antenna extends automatically when you turn on • Do not press hard on the panel surface when
the unit with the antenna control wire (ANT. CONT) installing the unit to the car. Otherwise scratches,
connected. (Page 56) damage, or failure may result.
• If the power is not turned on (“Miswiring DC Offset
Error”, “Warning DC Offset Error” is displayed),
the speaker wire may have a short circuit or have
touched the chassis of the car and the protection
function may have been activated. In this case, the
speaker wire should be checked.
• Keep all cables away from heat dissipating metal
parts.

ENGLISH 53

00_DDX_2019ST_KN_RN.indb 53 31/5/2018 2:44:30 PM


Installation and Connection
• If your car’s ignition does not have an ACC position,
connect the ignition wires to a power source that
Parts list for installation Installation procedure
Note: This parts list does not include all the package
can be turned on and off with the ignition key. If you
contents.
1 Remove the key from the ignition and
connect the ignition wire to a power source with a disconnect the · battery.
constant voltage supply, such as with battery wires, ¥ Wiring harness (× 1)
the battery may be drained. ø Extension wire, 2 m (× 1) 2 Make the proper input and output wire
• If the fuse blows, first make sure the wires are not π Flat head screws, M5 × 8 mm (× 6) connections for each unit.
touching to cause a short circuit, then replace the old [ Round head screws, M5 x 8 mm (× 6)
“ Microphone, 3 m (× 1) 3 Connect the speaker wires of the wiring
fuse with one with the same rating.
harness.
• Insulate unconnected wires with vinyl tape or other
similar material. To prevent a short circuit, do not Only for DDX396/DDX419BT 4 Connect the wires of the wiring harness
remove the caps and do not let the cable out at the ] Trim plate (× 1) in the following order: ground, battery,
ends of the unconnected wires or the terminals. ignition.
• Secure the wires with cable clamps and wrap vinyl Only for DDX396
tape around the wires that comes into contact with ‘ Mounting sleeve (× 1) 5 Connect the wiring harness to the unit.
\ Extraction keys (× 2)
metal parts to protect the wires and to prevent short 6 Install the unit in your car.
circuit. Make sure that the unit is installed securely in place.
• Connect the speaker wires correctly to the terminals Only for DDX419BT
If the unit is unstable, it may malfunction (e.g., the
to which they correspond. The unit may be damaged « Audio and video cable (× 1)
sound may skip).
or fail to work if you share the · wires or ground Å Steering remote cable (× 1)
them to any metal part in the car. 7 Reconnect the · battery.
• When only two speakers are being connected to the 8 Press the reset button on the monitor
system, connect both connectors either to the front panel. (Page 4)
output terminals or to the rear output terminals (do
not mix front and rear). For example, if you connect 9 Configure <Initial Setup>. (Page 5)
the ª connector of the left speaker to a front output
terminal, do not connect the · connector to a rear
output terminal.

54 ENGLISH

04_DDX_2019ST_KNRN_Body02.indd 54 20/8/2018 4:29:56 PM


Installation and Connection

Installing the unit Installing the trim plate 2 Remove from the upper two catches of
(Only for DDX396/DDX419BT) the trim plate (]).
Installing the unit using the mounting
bracket removed from the car
]
π/[

The frame can be removed from the top side in the


Car bracket same manner.
π/[
3 Remove the unit by inserting the two
Removing the unit extraction keys (\), then pulling them as
Note: Select the appropriate screws (supplied) for the (Only for DDX396)
mounting bracket. illustrated.
1 Engage the catch pins on the extraction
Installing the unit using the mounting keys (\) and remove the two locks on the \
sleeve lower part of the trim plate (]).
(Only for DDX396)
]
Catch
Lock

Be careful to avoid injury from the catch pins on


\ the extraction key.

Bend the tabs of the mounting sleeve with a


screwdriver or similar utensil and attach it in place.

ENGLISH 55

00_DDX_2019ST_KN_RN.indb 55 31/5/2018 2:44:31 PM


Installation and Connection

Wiring connection
10 A fuse *1 Only for DDX396/DDX376BT/DDX276BT/
DDX26BT.
“ *2 Only for DDX396/DDX376BT/DDX276BT.
*3 Only for DDX419BT.
*4 Only for DDX396/DDX419BT: For 3-way
speaker system connection, see also page
57.

Connect the antenna cord to the antenna terminal


*1 *2 *3 USB input terminal (1 m)
Purple with white stripe
REVERSE To the car’s reverse lamp harness when using the optional rear view camera
Light green To the car’s parking brake detection switch harness
¥ PRK SW
Extension wire ( ø ) (For best safety, be sure to connect the parking sensor.)
White ] / White with black stripe [
To front speakers/mid range speakers*4 (left)
Gray ] / Gray with black stripe [
To front speakers/mid range speakers*4 (right)
Green ] / Green with black stripe [
To rear speakers/tweeter speakers*4 (left)
Purple ] / Purple with black stripe [
To rear speakers/tweeter speakers*4 (right)
Brown
MUTE Not used.
Orange with white stripe
ILLUMI To the car light control switch
Light blue with yellow stripe STEERING WHEEL
REMOTE INPUT
REMOTE CONT To the OE remote adapter (not supplied) which is compatible with your car
Blue with white stripe (12 V 350 mA) ANT.CONT To the power control terminal when using the optional power amplifier (Or)
P.CONT
To the control terminal of the motor antenna or to the power terminal for the booster amplifier of film-type antenna
Red (Ignition wire)
Ignition key switch
Yellow (Battery wire) Car fuse
Black (Ground wire)
Car battery
To the car chassis

56 ENGLISH

04_DDX_2019ST_KNRN_Body02.indd 56 20/8/2018 4:34:58 PM


Installation and Connection References
7 Rear view camera input (R-CAM)
Connecting external components Maintenance
8 Output terminals*5
• Left output (White) Cleaning the unit
• Right output (Red) • Do not use any solvent (for example, thinner,
REAR: Rear speaker preouts benzine, etc.), detergent, or insecticide. This may
FRONT: Front speaker preouts damage the monitor or the unit.
SW: Subwoofer preouts • Gently wipe the panel with a soft, dry cloth.
For 3-way crossover*6:
Handling discs
REAR: Tweeter preouts
• Do not touch the recording surface of the disc.
FRONT: Mid-range speaker preouts
• Do not stick tape etc. on the disc, or use a disc with
SW: Woofer preouts
tape stuck on it.
• Do not use any accessories for the disc.
*1 Only for DDX396/DDX376BT/DDX276BT/DDX26BT.
• Clean from the center of the disc and move outward.
*2 Only for DDX396/DDX376BT/DDX276BT.
• Clean the disc with a dry silicone or soft cloth. Do not
*3 Only for DDX419BT.
1 Expansion port for connecting SiriusXM Connect *4 Use the audio and video cable («: supplied for DDX419BT) to
use any solvents.
Vehicle Tuner (EXT I/F) (commercially available)*1 • When removing discs from this unit, pull them out
connect an external component.
2 iDatalink input for connecting an ADS adapter *5 When connecting an external amplifier, connect its ground wire
horizontally.
(commercially available)*2 • Remove burrs from the center hole and disc edge
to the chassis of the car; otherwise the unit may be damaged.
3 Steering wheel remote controller input *6 Only for DDX396/DDX419BT.
before inserting a disc.
(REMO-IN)*3
• Connect to the car’s steering remote harness More information
using the steering remote cable (Å). Contact
your KENWOOD dealer for details. About playable files
4 Microphone input (MIC) (Page 56) Audio files
5 Audio video input (AV-IN)*4 • This unit can play back the following files with
Connect the following type of 4-pole mini plug: following codec and extension code:
13 1 Left audio – For disc: MP3 (.mp3), WMA (.wma), WAV (.wav),
2 Right audio AAC (.m4a)
24 3 Ground – For USB mass storage class device: MP3 (.mp3),
4 Composite video WMA (.wma), WAV (.wav), AAC (.aac, .m4a),
6 Video output (V-OUT) FLAC (.flac)

ENGLISH 57

04_DDX_2019ST_KNRN_Body02.indd 57 20/8/2018 4:35:10 PM


References
• This unit can play back files that meet the conditions – AAC files copy-protected with FairPlay (except Picture files
below: those stored on an iPod/iPhone). • This unit can play back the following files with
– Bit rate: – Files which have data such as AIFF, ATRAC3, etc. following codec and extension code:
MP3: 8 kbps – 320 kbps – JPEG (.jpg, .jpeg)
WMA: For disc: 5 kbps – 320 kbps Video files • Other playable conditions:
For USB : 32 kbps – 192 kbps • This unit can play back the following files with – Resolution: 32 × 32 to 8 192 × 7 680 (It may take
AAC: 16 kbps – 320 kbps following codec and extension code: time to display the file depending on its resolution.)
– Sampling frequency: – DivX* (.divx, .div, .avi) regardless of the letter case— – Baseline JPEG files
MP3: 16 kHz – 48 kHz upper/lower • This unit cannot play back the following files:
WMA: 8 kHz – 48 kHz – MPEG1/MPEG2 (.mpg, .mpeg) – Progressive JPEG files
WAV: 44.1 kHz • Streams that conform to: – Lossless JPEG files
AAC: 32 kHz – 48 kHz – DivX*:
FLAC: 8 kHz – 96 kHz Audio: MP3 or Dolby Audio About disc playback
– Files recorded in VBR (variable bit rate), and have a – MPEG1/MPEG2:
Playable disc types
discrepancy in elapsed time indication Audio: MPEG1 Audio Layer-2 or Dolby Audio
• CD-DA: Audio CD, CD Text
• This unit can show or display the following: Video: MPEG system/program stream
• DVD Video: Region code: 1 or 4 (depending on the
– Tag: • Other playable conditions:
country and sales area)
MP3: ID3 Tag (version 1.0/1.1/2.2/2.3/2.4) – Video file size: Less than 2 GB
• Dual Disc: DVD side
WMA Tag – DivX*: Bit rate: 8 Mbps (maximum for average video
• VCD: Video CD (PBC compatible)
WAV Tag signals)
• DVD Recordable/Rewritable (DVD-R/-RW, +R/+RW)
AAC Tag – MPEG1/MPEG2: File format: MP@ML (Main Profile at
– DVD Video: UDF bridge
FLAC Tag Main Level)/SP@ML (Simple Profile at Main Level)/
– ISO 9660 level 1, level 2, Romeo, Joliet
– Jacket picture: MP@LL (Main Profile at Low Level)
– Other playable formats:
Picture size: 32 × 32 to 1 232 × 672 resolution • This unit cannot play back the following files:
DVD-R recorded in multi-border format (except for
Data size: Less than 500 KB – DivX files encoded in the interlaced scanning
dual layer discs)
File type: JPEG mode.
Finalized +R/+RW (Video format only)
• This unit cannot play back the following files: • CD Recordable/Rewritable (CD-R/-RW):
– MP3 files encoded with MP3i and MP3 PRO format. * Only for DDX419BT.
– ISO 9660 level 1, level 2, Romeo, Joliet
– MP3 files encoded with Layer 1/2. • Other informations:
– WMA files encoded with lossless, professional, and – While playing a DVD Video, DTS sound cannot be
voice format. reproduced or emitted from this unit.
– WMA files which are not based upon Windows
Media® Audio.
– WMA/AAC files copy-protected with DRM.

58 ENGLISH

00_DDX_2019ST_KN_RN.indb 58 31/5/2018 2:44:31 PM


References
– This unit can recognize a total of 5 000 files and Language codes (for DVD language selection) LV Latvian, Lettish SM Samoan
250 folders (a maximum of 999 files per folder) in a AA Afar GD Scots Gaelic MG Malagasy SN Shona
recordable/rewritable disc. AB Abkhazian GL Galician MI Maori SO Somali
– Use only “finalized” recordable/rewritable discs. AF Afrikaans GN Guarani MK Macedonian SQ Albanian
– This unit can play back multi-session recordable/ AM Ameharic GU Gujarati ML Malayalam SR Serbian
rewritable discs; however, unclosed sessions will be
AR Arabic HA Hausa MN Mongolian SS Siswati
skipped while playing.
AS Assamese HI Hindi MO Moldavian ST Sesotho
AY Aymara HR Croatian MR Marathi SU Sundanese
Unplayable disc types and formats
• DVD-Audio/DVD-ROM discs AZ Azerbaijani HU Hungarian MS Malay (MAY) SW Swahili
• SVCD (Super Video CD), CD-ROM, CD-I (CD-I Ready), BA Bashkir HY Armenian MT Maltese TA Tamil
DTS-CD BE Byelorussian IA Interlingua MY Burmese TE Telugu
• MPEG4/DivX*/AAC (.aac)/FLAC/MKV/DVD–VR/ BG Bulgarian IE Interlingue NA Nauru TG Tajik
DVD+VR/DVD-RAM recorded on DVD-R/RW or BH Bihari IK Inupiak NE Nepali TH Thai
+R/+RW BI Bislama IN Indonesian NO Norwegian TI Tigrinya
• MPEG4/DivX*/AAC (.aac)/FLAC/MKV recorded on BN Bengali, Bangla IS Icelandic OC Occitan TK Turkmen
CD-R/RW BO Tibetan IW Hebrew OM (Afan) Oromo TL Tagalog
• DVD-RW dual layer discs BR Breton JA Japanese OR Oriya TN Setswana
• +RW double layer discs CA Catalan JI Yiddish PA Panjabi TO Tonga
• Non-DVD side of a “DualDisc” which does not comply CO Corsican JW Javanese PL Polish TR Turkish
with the “Compact Disc Digital Audio” standard CS Czech KA Georgian PS Pashto, Pushto TS Tsonga
• Discs that are not round.
CY Welsh KK Kazakh QU Quechua TT Tatar
• Discs with coloring on the recording surface or discs
DZ Bhutani KL Greenlandic RM Rhaeto-Romance TW Twi
that are dirty.
EL Greek KM Cambodian RN Kirundi UK Ukrainian
• Recordable/Rewritable discs that have not been
finalized. EO Esperanto KN Kannada RO Rumanian UR Urdu
• 3 inch discs. Attempting to insert these discs using ET Estonian KO Korean (KOR) RW Kinyarwanda UZ Uzbek
an adapter may cause a malfunction. EU Basque KS Kashmiri SA Sanskrit VI Vietnamese
• Some recordable/rewritable discs or files may not be FA Persian KU Kurdish SD Sindhi VO Volapuk
played back due to their characteristics or recording FI Finnish KY Kirghiz SG Sangho WO Wolof
conditions. FJ Fiji LA Latin SH Serbo-Croatian XH Xhosa
FO Faroese LN Lingala SI Singhalese YO Yoruba
* Only for DDX396/DDX376BT/DDX276BT/DDX26BT. FY Frisian LO Laothian SK Slovak ZU Zulu
GA Irish LT Lithuanian SL Slovenian

ENGLISH 59

00_DDX_2019ST_KN_RN.indb 59 31/5/2018 2:44:31 PM


References
• Electrostatic shock at connecting a USB device may iPod/iPhone that can be connected
About USB playback cause abnormal playback of the device. In this case, • Via the USB terminal:
Important disconnect the USB device then reset this unit and Made for
Make sure all important data has been backed up to the USB device. – iPod nano (7th Generation)
avoid losing the data. • Do not pull out and connect the USB device – iPod touch (5th and 6th Generation)
We bear no responsibility for any loss of data stored in repeatedly while “Reading” is shown on the screen. – iPhone 4S, 5, 5C, 5S, 6, 6 Plus, 6S, 6S Plus, SE, 7,
the devices while using this unit. • Operation and power supply may not work as 7 Plus, 8, 8 Plus, X
intended for some USB devices. • Via Bluetooth:
Playable files on a USB device • Do not leave a USB device in the car, or expose to Made for
• This unit can play the following types of files stored direct sunlight or high temperatures to prevent – iPod touch (5th and 6th Generation)
in a USB mass storage class device. deformation or damage to the device. – iPhone 4S, 5, 5C, 5S, 6, 6 Plus, 6S, 6S Plus, SE, 7,
– JPEG/Divx*/MPEG1/MPEG2/MP3/WMA/WAV/AAC 7 Plus, 8, 8 Plus, X
(.aac/.m4a)/FLAC Unplayable USB device
• This unit can recognize: • This unit may not play back files in a USB device Notes on using an iPod/iPhone
– A total of 5 000 files properly when using a USB extension cable. • When operating an iPod/iPhone, some operations
– 250 folders for video files and a maximum of 999 • USB devices equipped with special functions such as may not be performed correctly or as intended. In
files per folder data security functions cannot be used with the unit. this case, visit the following KENWOOD web site:
– 250 folders for photo files and a maximum of 999 • Do not use a USB device with 2 or more partitions. <www.kenwood.com/cs/ce/>
files per folder • Depending on the shape of the USB devices and • When you turn on this unit, the iPod/iPhone is
– 999 folders for audio files and a maximum of 999 connection ports, some USB devices may not be charged through the unit.
files per folder attached properly or the connection might be loose. • The text information may not be displayed correctly.
• The maximum number of characters (when the • This unit may not recognize a memory card inserted • For some iPod/iPhone models, the performance may
characters are 1 byte): into a USB card reader. be abnormal or unstable during operation. In this
– Folder names: 50 characters case, disconnect the iPod/iPhone device, then check
– File names: 50 characters its condition.
About iPod/iPhone
Important If the performance is not improved or slow, reset
* Only for DDX419BT. your iPod/iPhone.
Make sure all important data has been backed up to
Notes on using a USB device avoid losing the data.
• Avoid using the USB device if it might affect driving We bear no responsibility for any loss of data stored in
safety. the devices while using this unit.
• When connecting with a USB cable, use a USB 2.0
cable.

60 ENGLISH

00_DDX_2019ST_KN_RN.indb 60 31/5/2018 2:44:31 PM


Troubleshooting
What appears to be trouble is not always serious. “Learning Process Failed” appears.*2 Tracks on the recordable/rewritable discs are not
Check the following points before calling a service  Your steering remote controller is not compatible, played back as you have intended them to play.
center. learning may not be completed. Consult your car  Playback order may differ from the one played back
• For operations with external components, refer also audio dealer for details. using other players.
to the instructions supplied with the adapters used *1 For DDX396/DDX376BT/DDX276BT/DDX26BT: Purchase optional “Region Code Error” appears.
for connection (as well as the instructions supplied remote controller, KNA-RCDV331.  You have inserted a DVD Video disc of an incorrect
with the external components). *2 Only for DDX419BT. region code. Insert a correct region code disc.

General Discs USB


No sound comes out of the speakers. Recordable/Rewritable discs cannot be played back. “Reading” does not disappear from the screen.
 Adjust the volume to the optimum level.  Insert a finalized disc.  Turn the power off and on again.
 Check the cords and connections.  Finalize the discs with the component which you
used for recording. While playing a track, sound is sometimes
No picture is displayed on the screen.
interrupted.
 Turn on the screen. (Page 4) Tracks on the Recordable/Rewritable discs cannot  The tracks are not properly copied into the USB
The unit does not work at all. be skipped. device. Copy the tracks again, and try again.
 Reset the unit. (Page 4)  Insert a finalized disc.
 Finalize the discs with the component which you Tracks are not played back as you have intended
The remote controller*1 does not work. used for recording. them to play.
 Replace the battery.  Playback order may differ from the one played back
Playback does not start. using other players.
“No Signal”/“No Video Signal” appears.  The format of files is not supported by the unit.
 Start playback on the external component The source does not change to “USB” when you
connected to the AV-IN input terminal. No picture appears on the external monitor. connect a USB device while listening to another
 Check the cords and connections.  Connect the video cord correctly. source or “USB Device Error” appears when you
 Signal input is too weak.  Select the correct input on the external monitor. connect a USB device.
 The USB port is drawing more power than the
“Miswiring DC Offset Error”/“Warning DC Offset DivX*/MPEG1/MPEG2/MP3/WMA/WAV/AAC discs
design limit.
Error” appears. cannot be played back.
 Turn the power off and unplug the USB device.
 A speaker cord has shorted or it has come into  Record the tracks using a compatible application
Then, turn on the power and reattach the USB
contact with the car chassis. Wire or insulate the on the appropriate discs. (Page 58)
device.
speaker cord as appropriate, then reset the unit.  Add appropriate extension codes to the file names.
 If the above does not solve the problem, turn
“Parking off” appears. * Only for DDX419BT. the power off and on (or reset the unit) before
 No playback picture is shown when the parking replacing with another USB device.
brake is not engaged.

ENGLISH 61

00_DDX_2019ST_KN_RN.indb 61 31/5/2018 2:44:31 PM


Troubleshooting
Android Sound is distorted. “Please update Pandora App” appears.
 Deactivate the equalizer either on this unit or the  The Pandora application on your iPod touch/
Sound cannot be heard during playback.
iPod/iPhone. iPhone/Android is not the latest version. Update
 Reconnect the Android device.
the application.
 Launch any media player application on the A lot of noise is generated.
Android device and start playback.  Turn off (uncheck) “VoiceOver” on the iPod/ iPhone. “Please check device.” appears.
For details, visit <http://www.apple.com>.  The Pandora application on your iPod touch/
Sound output only from the Android device.
iPhone/Android has not started up.
 Use another media player application. No operations are available when playing back a
 The Pandora application is not installed on the
 Restart the Android device. track containing artwork.
connected device.
 If this does not solve the problem, the connected  Operate the unit after the artwork has loaded.
 An error has occurred on the Pandora application.
Android device is unable to route the audio signal
to unit. “Authorization Error” appears.
“Login Error” appears.
 If USB connection does not work, connect the  Check whether the connected iPod/iPhone is
 You have not been signed into Pandora.
Android device via Bluetooth or through the AV-IN compatible with this unit. (Page 60)
jack on the rear panel. “No skips remaining” appears.
Radio  No more songs can be skipped.
“NO DEVICE” or “READING” keeps flashing.
AME automatic presetting does not work. “Failed to save your thumb rating” appears.
 Reconnect the Android device.
 Store stations manually. (Page 17)  Thumb-up/down is prohibited.
 If USB connection does not work, connect the
Android device via Bluetooth or through the AV-IN Static noise while listening to the radio. “No Station” appears.
jack on the rear panel.  Connect the antenna firmly.  No station is available.

iPod/iPhone “No Active Station” appears.


AV-IN  No station is being played.
No sound comes out of the speakers. No picture appears on the screen.
 Disconnect the iPod/iPhone, then connect it again.  Turn on the video component if it is not on. “Station limit reached” appears.
 Select another source, then reselect “iPod”.  Connect the video component correctly.  The station list is full and no more stations can be
registered.
The iPod/iPhone does not turn on or does not
work. Pandora*/iHeartRadio*/Spotify “Failed to save your bookmark” appears.
 Check the connection. The application does not work.  The unit has failed to save a bookmark. Try the
 Update the firmware version.  The application on your iPod touch/iPhone/ operation again.
 Charge the battery. Android is not the latest version. Update the
 Reset the iPod/iPhone. application.

62 ENGLISH

04_DDX_2019ST_KNRN_Body02.indd 62 5/6/2018 4:33:38 PM


Troubleshooting
“Limited Connectivity” appears. “SXM Check Tuner” appears. Bluetooth
 The connection with the Pandora application  Make sure the SiriusXM Connect Vehicle Tuner is
Phone sound quality is poor.
cannot be established. connected to the unit.
 Reduce the distance between the unit and the
“Pandora not available” appears. “SXM Chan Unavailable” appears. Bluetooth mobile phone.
 You cannot use the Pandora application from (Appears on the screen for about 5 seconds, then  Move the car to a place where you can get a better
the area where you are currently trying to access returns to the previous channel): signal reception.
Pandora.  The selected channel is no longer available. Select
The sound is interrupted or skipped while using a
another channel or continue listening to the
“Try again later” appears. Bluetooth audio player.
previous channel.
 The Pandora server is under maintenance.  Reduce the distance between the unit and the
“SXM Ch Unsubscribed” appears. Bluetooth audio player. Disconnect the device
“Station does not exist” appears. connected for Bluetooth phone.
(Appears on the screen for about 5 seconds, then
 The selected station has been deleted by another  Turn off, then turn on the unit.
returns to the previous channel)
device or has expired.
 The selected channel is not part of your current (When the sound is not yet restored) connect the
“Cannot create a Station” appears. subscription plan. Call 1-866-635-2349 to subscribe. player again.
 You cannot create a station during the read- The connected audio player cannot be controlled.
“SXM Subscription Updated – Press Return to
only mode or when network connection is not  Check whether the connected audio player
Continue” appears.
established.
 Your subscription has been updated. Press the supports AVRCP (Audio/Video Remote Control
* Only for DDX396/DDX376BT/DDX276BT/DDX26BT. appropriate button to continue. Profile).

“SXM Channel Locked” appears. The Bluetooth device does not detect the unit.
SiriusXM Satellite Radio*  The selected channel has been locked by the  Search from the Bluetooth device again.
“SXM No Signal” appears. parental controls. Enter the unlock code when you
The unit does not pair with the Bluetooth device.
 Make sure the SiriusXM Satellite Radio antenna is are asked.
 For devices compatible with Bluetooth 2.1:
mounted outside the car. Move the car to an area
“SXM Incorrect Lock Code” appears. Register the device using a PIN code. (Page 34)
with a clear view of the sky.
 The selected channel is a mature or parental lock  For devices compatible with Bluetooth 2.0:
“SXM Check Antenna” appears. channel, and locked by the parental lock or user Enter the same PIN code for both the unit and
 Check the SiriusXM Satellite Radio antenna lock code. Enter the correct lock code. target device. If the PIN code of the device is not
connection, and make sure the antenna is firmly indicated in its instructions, try “0000” or “1234.”
* Only for DDX396/DDX376BT/DDX276BT/DDX26BT.
attached to the tuner.  Turn off, then turn on the Bluetooth device.
 Check whether the SiriusXM Satellite Radio antenna
cable is bent or broken. If it is damaged, replace the
whole antenna unit.

ENGLISH 63

00_DDX_2019ST_KN_RN.indb 63 31/5/2018 2:44:31 PM


Troubleshooting Specifications
Echo or noise occurs. “Hung Up Error” appears.
 Adjust the microphone unit position.  The call has not ended yet. Park your car, and use
Monitor section
 Adjust the echo volume or noise reduction volume. the connected mobile phone to end the call. Picture Size (W × H) 6.2 inches (diagonal) wide
(Page 35) 137.5 mm × 77.2 mm
“Pick Up Error” appears.
(5-7/16" × 3-1/16")
The unit does not respond when you try to copy  The unit has failed to receive a call.
the phone book to the unit. Display System Transparent TN LCD panel
The Bluetooth connection between the Bluetooth
 You may have tried to copy the same entries (as Drive System TFT active matrix system
device and the unit is unstable.
stored) to the unit. Number of Pixels 1 152 000
 Delete the unused registered Bluetooth device
(800H × 480V × RGB)
“Connection Error” appears. from the unit. (Page 35)
 The device is registered but the connection has Effective Pixels 99.99%
failed. Connect the registered device. (Page 34) Pixel Arrangement RGB striped arrangement
“Please Wait...” appears. Back Lighting LED
 The unit is preparing to use the Bluetooth function.
If the message does not disappear, turn off and
USB interface section
turn on the unit, then connect the device again (or
reset the unit). USB Standard USB 2.0 Full Speed/High
Speed
“No Voice Device” appears.
 The connected mobile phone does not have a Compatible Device Mass Storage Class
voice recognition system. File System FAT 16/32
Maximum Power DC 5 V 1.5 A
“No Data” appears.
Supply Current
 No phone book data is contained in the connected
Bluetooth phone. D/A Converter 24 bit
Audio Decoder MP3/WMA/AAC (.aac/.m4a)/
“Initialize Error” appears.
WAV/FLAC
 The unit has failed to initialize the Bluetooth
module. Try the operation again. Video Decoder DivX*/MPEG1/MPEG2/JPEG

“Dial Error” appears. * Only for DDX419BT.


 Dialing has failed. Try the operation again.

64 ENGLISH

04_DDX_2019ST_KNRN_Body02.indd 64 6/6/2018 9:19:16 AM


Specifications

DVD player section Bluetooth section 2 Way X'Over


Tweeter: Frequency (Hz):
D/A Converter 24 bit Technology Bluetooth V3.0
1k/1.6k/2.5k/4k/5k/6.3k/8k/
Audio Decoder Linear PCM/Dolby Audio/ Frequency 2.402 GHz to 2.480 GHz 10k/12.5k
MP3/WMA/WAV/AAC (.m4a) RF Output Power +4 dBm (MAX), Power Class 2 Gain (dB):
Video Decoder DivX*/MPEG1/MPEG2/JPEG (E.I.R.P.) –8/–7/–6/–5/–4/–3/–2/–1/0
Wow & Flutter Below Measurable Limit Maximum Line of sight approx. 10 m Front/Rear (HPF): Frequency (Hz):
Frequency Response 96 kHz Sampling: Communication (32.8 ft) Through/30/40/50/60/70/
20 Hz to 22 000 Hz Range 80/90/100/120/150/180/
48 kHz Sampling: Audio Codec SBC/AAC 220/250
20 Hz to 22 000 Hz Profile HFP (Hands Free Profile) 1.6 Slope (dB/Oct.):
44.1 kHz Sampling: A2DP (Advanced Audio −6/−12/−18/−24
20 Hz to 20 000 Hz Distribution Profile) 1.3 Gain (dB):
Total Harmonic 0.010% (1 kHz) AVRCP (Audio/Video Remote –8/–7/–6/–5/–4/–3/–2/–1/0
Distortion Control Profile) 1.5 Subwoofer (LPF): Frequency (Hz):
Signal to Noise Ratio 90 dB GAP (Generic Access Profile) 30/40/50/60/70/80/90/100/
PBAP (PhoneBook Access 120/150/180/220/250/
Dynamic Range 90 dB Through
Profile) 1.2
Disc Format DVD-Video/VIDEO-CD/CD-DA SDP (Service Discovery Profile) Slope (dB/Oct.):
Sampling Frequency 44.1 kHz/48 kHz/96 kHz SPP (Serial Port Profile) 1.2 −6/−12/−18/−24
Quantifying Bit 16 bit/20 bit/24 bit Phase: Normal/Reverse
Number Gain (dB):
DSP section –8/–7/–6/–5/–4/–3/–2/–1/0
* Only for DDX419BT.
Equalizer Band: 13 Band
Frequency (Hz) (BAND1–13):
62.5/100/160/250/400/630/
1k/1.6k/2.5k/4k/6.3k/10k/
16k
Gain (dB):
–9/−8/−7/−6/−5/−4/−3/−2/
−1/0/1/2/3/4/5/6/7/8/9
Q factor: 1.35/1.5/2.0

ENGLISH 65

00_DDX_2019ST_KN_RN.indb 65 31/5/2018 2:44:32 PM


Specifications
3 Way X'Over * Position AM tuner section
Tweeter (HPF): Frequency (Hz): 2 Way X'over: Front/Rear/Subwoofer Delay
0 ft to 20 ft (0.07 ft Step) Frequency Range 530 kHz to 1 700 kHz (10 kHz)
1k/1.6k/2.5k/4k/5k/6.3k/8k/
10k/12.5k 3 Way X'over *: Tweeter/Mid Range/ Usable Sensitivity 29 dBμ
Slope (dB/Oct.): Subwoofer Delay
−6/−12 0 ft to 20 ft (0.07 ft Step)
Phase: Normal/Reverse Gain: −8 dB to 0 dB Video section
Gain (dB): Subwoofer Level −50 dB to +10 dB Color System of NTSC/PAL
–8/–7/–6/–5/–4/–3/–2/–1/0 External Video Input
* Only for DDX396/DDX419BT.
Mid Range (HPF): Frequency (Hz): External Video Input 1 Vp-p/75 Ω
Through/30/40/50/60/70/ Level (mini jack)
80/90/100/120/150/180/
FM tuner section
External Audio Max 2 V/25 kΩ
220/250 Frequency Range DDX396/DDX376BT/ Input Level (mini
Slope (dB/Oct.): DDX276BT/DDX26BT: jack)
−6/−12 87.9 MHz to 107.9 MHz
Video Input Level for 1 Vp-p/75 Ω
Mid Range (LPF): Frequency (Hz): (200 kHz)
Rear Camera (RCA
1k/1.6k/2.5k/4k/5k/6.3k/8k/ DDX419BT:
jack)
10k/12.5k/Through 87.5 MHz to 108.0 MHz
(50 kHz) Video Output Level 1 Vp-p/75 Ω
Slope (dB/Oct.):
(RCA jack)
−6/−12 Usable Sensitivity 7.2 dBf (0.63 μV/75 Ω)
Phase: Normal/Reverse (S/N: 30 dB)
Gain (dB): Quieting Sensitivity 15.2 dBf (1.58 μV/75 Ω)
–8/–7/–6/–5/–4/–3/–2/–1/0 (DIN S/N: 46 dB)
Subwoofer (LPF): Frequency (Hz): Frequency Response 30 Hz to 15 kHz
Through/30/40/50/60/70/ (±3.0 dB)
80/90/100/120/150/180/
Signal to Noise Ratio 68 dB (MONO)
220/250
Slope (dB/Oct.): Selectivity > 80 dB (±400 kHz)
−6/−12 Stereo Separation 40 dB (1 kHz)
Phase: Normal/Reverse
Gain (dB):
–8/–7/–6/–5/–4/–3/–2/–1/0

66 ENGLISH

00_DDX_2019ST_KN_RN.indb 66 31/5/2018 2:44:32 PM


Specifications

Audio section General


Maximum Power 50 W × 4 Operating Voltage 12 V DC car battery
(Front & Rear) Installation DDX396:
Full Bandwidth 22 W × 4 (at less than 1% Dimensions With sleeve:
Power (Front & Rear) THD) (W × H × D) 182 mm × 111 mm
Preout Level DDX396: × 160 mm
5 V/10 kΩ (7-3/16" × 4-3/8" × 6-5/16")
Without sleeve:
DDX376BT: 178 mm × 100 mm ×
4 V/10 kΩ 162 mm
DDX276BT/DDX26BT/ (7" × 3-15/16" × 6-3/8")
DDX419BT: DDX376BT/DDX276BT/
2.5 V/10 kΩ DDX26BT/DDX419BT:
Preout Impedance ≤ 600 Ω 178 mm × 100 mm ×
162 mm
Speaker Impedance 4 Ω to 8 Ω
(7" × 3-15/16" × 6-3/8")
Weight (Main Unit) DDX396: 2.0 kg (4.4 lbs)
(including trim plate and
sleeve)
DDX376BT/DDX276BT/
DDX26BT: 1.7 kg (3.8 lbs)
DDX419BT: 1.8 (4.0 lbs)
(including trim plate)

Design and specifications are subject to change


without notice.

ENGLISH 67

00_DDX_2019ST_KN_RN.indb 67 31/5/2018 2:44:32 PM


Specifications
• THIS PRODUCT IS LICENSED UNDER THE AVC PATENT and/or other materials provided with the
Trademarks and licenses
PORTFOLIO LICENSE FOR THE PERSONAL USE OF A distribution.
• Dolby, Dolby Audio and the double-D symbol are CONSUMER OR OTHER USES IN WHICH IT DOES NOT – Neither the name of the Xiph.org Foundation
trademarks of Dolby Laboratories. RECEIVE REMUNERATION TO nor the names of its contributors may be used to
• “DVD Logo” is a trademark of DVD Format/Logo (i) ENCODE VIDEO IN COMPLIANCE WITH THE AVC endorse or promote products derived from this
Licensing Corporation registered in the US, Japan STANDARD ("AVC VIDEO") AND/OR (ii) DECODE software without specific prior written permission.
and other countries. AVC VIDEO THAT WAS ENCODED BY A CONSUMER THIS SOFTWARE IS PROVIDED BY THE COPYRIGHT
• The “AAC” logo is a trademark of Dolby Laboratories. ENGAGED IN A PERSONAL ACTIVITY AND/OR WAS HOLDERS AND CONTRIBUTORS “AS IS” AND ANY
• Microsoft and Windows Media are either registered OBTAINED FROM A VIDEO PROVIDER LICENSED TO EXPRESS OR IMPLIED WARRANTIES, INCLUDING,
trademarks or trademarks of Microsoft Corporation in PROVIDE AVC VIDEO. NO LICENSE IS GRANTED OR BUT NOT LIMITED TO, THE IMPLIED WARRANTIES OF
the United States and/or other countries. SHALL BE IMPLIED FOR ANY OTHER USE. ADDITIONAL MERCHANTABILITY AND FITNESS FOR A PARTICULAR
• Use of the Made for Apple badge means that an INFORMATION MAY BE OBTAINED FROM MPEG LA, PURPOSE ARE DISCLAIMED. IN NO EVENT SHALL
accessory has been designed to connect specifically L.L.C. SEE HTTP://WWW.MPEGLA.COM THE FOUNDATION OR CONTRIBUTORS BE LIABLE
to the Apple product(s) identified in the badge, and • Sirius, XM and all related marks and logos are FOR ANY DIRECT, INDIRECT, INCIDENTAL, SPECIAL,
has been certified by the developer to meet Apple trademarks of Sirius XM Radio Inc. All rights reserved. EXEMPLARY, OR CONSEQUENTIAL DAMAGES
performance standards. Apple is not responsible for • Pandora, the Pandora logo, and the Pandora trade (INCLUDING, BUT NOT LIMITED TO, PROCUREMENT
the operation of this device or its compliance with dress are trademarks or registered trademarks of OF SUBSTITUTE GOODS OR SERVICES; LOSS OF USE,
safety and regulatory standards. Please note that Pandora Media, Inc., used with permission. DATA, OR PROFITS; OR BUSINESS INTERRUPTION)
the use of this accessory with an Apple product may • SPOTIFY and the Spotify logo are among the HOWEVER CAUSED AND ON ANY THEORY OF
affect wireless performance. registered trademarks of Spotify AB. LIABILITY, WHETHER IN CONTRACT, STRICT LIABILITY,
• Apple, iPhone, iPod, iPod nano, iPod touch, and • iHeartRadio® and iHeartAuto™ are trademarks owned OR TORT (INCLUDING NEGLIGENCE OR OTHERWISE)
Lightning are trademarks of Apple Inc., registered in by iHeartMedia, Inc. All uses are authorized under ARISING IN ANY WAY OUT OF THE USE OF THIS
the U.S. and other countries. license. SOFTWARE, EVEN IF ADVISED OF THE POSSIBILITY OF
• This item incorporates copy protection technology • libFLAC SUCH DAMAGE.
that is protected by U.S. patents and other Copyright (C) 2000-2009 Josh Coalson • DIVX
intellectual property rights of Rovi Corporation. Copyright (C) 2011-2013 Xiph.Org Foundation – This DivX Certified® device can play DivX® Home
Reverse engineering and disassembly are prohibited. Redistribution and use in source and binary forms, Theater video files up to 576p (including .avi, .divx).
• Font for this product is designed by Ricoh. with or without modification, are permitted provided Download free software at www.divx.com to
• Android is a trademark of Google LLC. that the following conditions are met: create, play and cast digital videos.
• The Bluetooth® word mark and logos are registered – Redistributions of source code must retain the – DivX®, DivX Certified® and associated logos are
trademarks owned by the Bluetooth SIG, Inc. and any above copyright notice, this list of conditions and trademarks of DivX, LLC and are used under license.
use of such marks by JVC KENWOOD Corporation is the following disclaimer.
under license. Other trademarks and trade names are – Redistributions in binary form must reproduce the
those of their respective owners. above copyright notice, this list of conditions and
the following disclaimer in the documentation

68 ENGLISH

00_DDX_2019ST_KN_RN.indb 68 31/5/2018 2:44:32 PM


00_DDX_2019ST_KN_RN.indb 69 31/5/2018 2:44:32 PM
For updated information (the latest Instruction Manual, system updates, new functions, etc.),
please visit the following website:

<www.kenwood.com/cs/ce/>

00_DDX_2019ST_KN_RN.indb 1 31/5/2018 2:44:32 PM

You might also like