Professional Documents
Culture Documents
Material Safety Data Sheet: Section 1 - Product and Company Identification
Material Safety Data Sheet: Section 1 - Product and Company Identification
Component B
Revised: 10.4.08
EMERGENCY CONTACT:
-1-
PTU™
Component B
-2-
PTU™
Component B
SPILLS OR LEAKS: Contain any spills with dikes or absorbents to prevent migration and entry into sewers or
streams. Take up small spills with dry chemical absorbent. Large spills may be taken up with pump or
vacuum and finished off with dry chemical absorbent. May require excavation of contaminated soil.
DISPOSAL METHODS: To the best of SPI’s knowledge, this product is not regulated by CERCLA/RCRA as a
hazardous waste or material. However, this product has not been tested for the toxicity characteristic via
the Toxicity Characteristic Leaching Procedure. Therefore, it may be disposed of as an industrial waste, in
a manner acceptable to good waste management practice and in compliance with applicable local, state and
federal regulations.
STORAGE REQUIREMENTS: Store in well ventilated, cool, dry area. Purge with nitrogen and close container
when not in use.
TSCA:
THIS MATERIAL IS IN COMPLIANCE WITH THE TOXIC SUBSTANCES CONTROL ACT (15 USC
2601 – 2629).
The information and recommendations in this publication is to the best of our knowledge, reliable. The toxicity and risk
characteristics of products made by SPI will necessarily differ from the toxicity and risk characteristics that occur when such
products are used with other materials during a manufacturing process. The resulting risk characteristics should be
determined and made known to ultimate end-users and processors. The user is responsible to comply with all applicable
federal, state, or local laws and regulations. SPI makes no warranties of any kind, expressed or implied, including those of
merchantability and fitness for a particular purpose.
-3-
PTU™
Component B
PTU™
Component B
Revised: 10.4.08
-4-