Professional Documents
Culture Documents
Quiz B31.3 Final
Quiz B31.3 Final
1. How is a fluid service classified in which the potential for personnel exposure is judge to be significant
and a single exposure to a very small quantity, can produce serious health damages by breathing or
body contact, even when prompt restorative measures are taken
a) M
b) H
c) D
d) N
2. What is the minimal extension of inspection in a circumferential and girth weld in Normal fluid?
a) 25%
b) 10%
c) 5%
d) 100%
3. The pressure test for a pneumatic leak test shall be ____% of design pressure
a) 150
b) 50
c) 125
d) 110
4. What must a non-toxic flammable liquid have if it is used as a leak testing medium in hidrotastic test?
6. Before bolting up flanged joints, the Inspector should check alignment to the design plane. It should
be within ____ mm/mm measured across any diameter
a) 1/200
b) 1/10
c) 1/100
d) 1/250
Adiestramiento para certificación
API 570 “Inspección, reparación y alteración
De Sistemas de tuberías”
a) Category H
b) Category N
c) Category D
d) Category M
9. What is the basic quality factor assigned to static and centrifugal casting that meet the specification:
a) 1.00
b) 0.70
c) 0.80
d) 0.95
OPEN BOOK
10. What would be the minimum temperature without impact testing for a material 2” thick and ASTM
A672 Gr C55?
a) 90° F
b) 26° F
c) -20° F
d) -4° F
11. An ASTM A106 Grade B pipe operates at 300 psi and 600° F with the test being conducted at 100° F.
The hydrostatic test pressure required would be:
a) 500 psi
b) 487 psi
c) 588 psi
d) 330 psi
12. A piping system may be subject to a preliminary test (before hydrostatic test) using air at no more
than ___ psi gage to locate major leaks
a) 15
b) 45
c) 35
d) 25
Adiestramiento para certificación
API 570 “Inspección, reparación y alteración
De Sistemas de tuberías”
13. What is the shell test pressure for a flanged fitting of specification A217 Gr WC9 of Class 600 that will
operate at 800° F?
a) 2275 psi
b) 1500 psi
c) 1015 psi
d) 2250 psi
50 °F