Exercise Guide: Altalink C8000 Series

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

May 2017

Exercise Guide
AltaLink C8000 Series
Practice using the Xerox® AltaLink® C8000 Series Multifunction Printers.

Use Printer Services User-Level Maintenance


Use the System Administrator Guide and the User Use the User Guide, System Administrator Guide, and
Guide to: Instruction Sheets to:
 Download and install the print/scan drivers, and  Locate the serial number and software version
print a job (from USB or network)
 Replace the Toner Cartridges, Drum Cartridges,
 Configure wireless or network connections Waste Toner Cartridge, Transfer Belt Cleaner, and
DADF Feed Rollers
 Generate simplex and duplex copies from thep
glass and DADF  Check and report the fault history
 Configure the Address Book for a contact  Update the printer software – download the latest
version from www.support.xerox.com/support/ and
 Scan an image using scanning apps (Scan To…, use EWS to install the update
Scan To USB, Scan to Desktop)
 Email a document to a recipient
 Print the user-level test pages for image quality, a
configuration page, and an Error Message Report

©2017 Xerox Corporation. All rights reserved. Xerox®, Xerox and Design®, and AltaLink® are trademarks of Xerox Corporation in the United States
and/or other countries.
Perform Service-Call Complete Service Repairs
Procedures and Adjustments
Use the Service Manual EDOC to: Use the Service Manual EDOC to:
 Locate and read the Chapter 1 Service  Perform GP9, the firmware upgrade procedure
Call Procedures using a USB Flash Drive
 Within Chapter 6 General Procedures &  Remove the following covers:
Information / Detailed Maintenance
 L/H Cover Unit (Rep 14.1)
Activities (HFSI) section, study the High
Frequency Service Items table to review  Top Cover (Rep 14.2)
the items you should check or clean
 Rear Lower Cover (Rep 14.3)
 Enter service diagnostics and perform the
following tests:
 Locate and (as time allows), remove the
following parts:
 dc120 and dc122 to check fault
 Control Panel (Rep 6.5)
counters and fault history
 HVPS Rep 1.1
 dc135 CRU/HFSI
 MDM PWB (Rep 1.6)
 dc612 Print Test Pattern
 SBC SD Card (Rep 1.11)
 SBC PWB (Rep 1.12)
 Main LVPS (Rep 1.17)
 Main Drive Assembly Replacement
(Rep 4.2)
 Drum/Developer Assembly (Rep 4.4)
 Tray 1 Feeder Replacement (Rep 7.1)
 IIT PWB (Rep 6.12)
 LPH (Rep 9.10)
 DADF (Rep 55.1)

©2017 Xerox Corporation. All rights reserved. Xerox®, Xerox and Design®, and AltaLinkk® are trademarks of Xerox Corporation in the United States
and/or other countries.

You might also like