Professional Documents
Culture Documents
Jahh 65C R3B V2
Jahh 65C R3B V2
Internal SBT on low and high band allow remote RET control from the radio over the RF jumper
cable
One RET for 700MHz, one RET for 850MHz, and one RET for both high bands to ensure same tilt
level for 4x Rx or 4x MIMO
Internal filter on low band and interleaved dipole technology providing for attractive, low wind
load mechanical package
Separate RS-485 RET input/output for low and high band
Supports re-configurable antenna sharing capability enabling control of the internal RET system
using up to two separate RET compatible OEM radios
General Specifications
Antenna Type Sector
Band Multiband
Performance Note Outdoor usage | Wind loading figures are validated by wind tunnel
measurements described in white paper WP-112534-EN
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
JAHH-65C-R3B-V2
Internal Bias Tee Port 1 | Port 5
Dimensions
Width 350 mm | 13.78 in
Array Layout
Port Configuration
Page 2 of 6
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
JAHH-65C-R3B-V2
Electrical Specifications
Impedance 50 ohm
Operating Frequency Band 1695 – 2360 MHz | 698 – 803 MHz | 824 – 894 MHz
Polarization ±45°
Electrical Specifications
Frequency Band, MHz 698–803 824–894 1695–1880 1850–1990 1920–2200 2300–2360
Gain, dBi 15.6 16.1 18.2 18.6 18.8 18.9
Beamwidth, Horizontal, 67 64 62 60 61 63
degrees
Beamwidth, Vertical, degrees 9.9 8.4 5.6 5.2 4.9 4.5
Beam Tilt, degrees 0–11 0–11 0–10 0–10 0–10 0–10
USLS (First Lobe), dB 22 23 18 18 18 18
Front-to-Back Ratio at 180°, 33 31 30 34 37 35
dB
Isolation, Cross Polarization, 25 25 25 25 25 25
dB
Isolation, Inter-band, dB 30 30 30 30 30 30
VSWR | Return loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
JAHH-65C-R3B-V2
PIM, 3rd Order, 2 x 20 W, dBc -153 -153 -153 -153 -153 -153
Input Power per Port at 50°C, 200 200 250 250 250 200
maximum, watts
Mechanical Specifications
Effective Projective Area (EPA), frontal 0.4 m² | 4.306 ft²
Wind Loading @ Velocity, frontal 425.0 N @ 150 km/h (95.5 lbf @ 150 km/h)
Wind Loading @ Velocity, lateral 361.0 N @ 150 km/h (81.2 lbf @ 150 km/h)
Wind Loading @ Velocity, maximum 900.0 N @ 150 km/h (202.3 lbf @ 150 km/h)
Wind Loading @ Velocity, rear 451.0 N @ 150 km/h (101.4 lbf @ 150 km/h)
Page 4 of 6
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
JAHH-65C-R3B-V2
Regulatory Compliance/Certifications
Agency Classification
CHINA-ROHS Above maximum concentration value
ISO 9001:2015 Designed, manufactured and/or distributed under this quality management system
ROHS Compliant/Exempted
Included Products
BSAMNT-3 – Wide Profile Antenna Downtilt Mounting Kit for 2.4 - 4.5 in (60 - 115 mm) OD round members.
Kit contains one scissor top bracket set and one bottom bracket set.
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
Page 5 of 6
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
BSAMNT-3
Wide Profile Antenna Downtilt Mounting Kit for 2.4 - 4.5 in (60 - 115 mm)
OD round members. Kit contains one scissor top bracket set and one
bottom bracket set.
General Specifications
Application Outdoor
Color Silver
Dimensions
Compatible Diameter, maximum 115 mm | 4.528 in
Material Specifications
Material Type Galvanized steel
Packaging quantity 1
Regulatory Compliance/Certifications
Agency Classification
CE Compliant with the relevant CE product directives
CHINA-ROHS Below maximum concentration value
ISO 9001:2015 Designed, manufactured and/or distributed under this quality management system
REACH-SVHC Compliant as per SVHC revision on www.commscope.com/ProductCompliance
ROHS Compliant
Page 6 of 6
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: August 12, 2021