Professional Documents
Culture Documents
Sinutrain For Sinumerik Operate 4.8 Ed.2
Sinutrain For Sinumerik Operate 4.8 Ed.2
The information provided as follows takes priority over that obtained from other
documents. Please read the notes carefully since they contain important information
on installation and use.
Siemens supplies part of its software with copy protection. Protected programs or
software packages can only be executed with the requisite license key or
authorizations.
1.1 Introduction
The controller-identical NC programming workstation SinuTrain for SINUMERIK
Operate is a product of the Siemens AG Digital Factory unit. SinuTrain simulates a
SINUMERIK 840D sl with the SINUMERIK Operate user interface on your PC.
Operating systems
· Windows 7 SP1 (32-bit and 64-bit; Starter, Web Edition and Embedded are
not supported)
· Windows 8.1 (32-bit and 64-bit, the RT edition is not supported)
· Windows 10 (64-bit, Mobile, Mobile Enterprise and S editions are not
supported)
Information regarding the operating systems can be obtained on the Microsoft
homepage.
Functional scope:
The entire functional scope for SINUMERIK is available without restriction for all
available licenses (with the exception of "Basic").
Notes:
Software version 4.8 Ed.2 is a stand-alone product and is installed independently of
older SinuTrain software packages. It is therefore available to run simultaneously
with an existing SinuTrain version.
An alternative file path can be set up for the installation of SinuTrain for SINUMERIK
Operate. It should be noted in this regard that a maximum path length of 256
characters may not be exceeded.
Note:
Once installed, SinuTrain can be accessed by several users through their own
respective Windows account. The user-specific SinuTrain data is located in separate
storage paths accordingly.
Following the uninstallation of SinuTrain, this data is retained in the following path:
C:\Users\<Domain user
name>\AppData\Roaming\Siemens\SinuTrain\SINUMERIK CNC-SW 840D sl 4.8
SP4
Following uninstallation, this data can be saved, deleted or reused in the event that
the SinuTrain software is reinstalled.
· Problems with the installation system may occur when working with SinuTrain for
SINUMERIK Operate if a security software is being used, for example an active
virus scanner. These problems may include not being able to activate the
SinuTrain for SINUMERIK Operate licenses, for example. This problem can be
rectified by switching off the security software prior to working with SinuTrain for
SINUMERIK Operate.
Note: Compatibility of the software components has been tested for typical virus
scanners in the commercial environment.
An overview of tested virus scanners can be found at
http://support.automation.siemens.com/WW/view/en/19577116. Compatibility
with other security software products cannot be guaranteed.
· Other software installed on the PC may restrict the application of SinuTrain for
SINUMERIK Operate. An overview of the recognized software products can be
obtained from the FAQ pages of Siemens Industry Support at
http://support.automation.siemens.com.
· Parts of the SinuTrain for SINUMERIK Operate software use shared software
libraries, such as the Qt class library. If other software products are installed on
the PC which also use an older version of this software libraries, this could
influence the execution characteristics of SinuTrain for SINUMERIK Operate.
The respective software should be uninstalled if any problems occur.
· The NUM key must be deactivated when working with SinuTrain for SINUMERIK
Operate.