Professional Documents
Culture Documents
Before Calling Service: If You Have Further Questions or Damaged Accessory Parts, Contact Us at 1-800-SAMSUNG (726-7864)
Before Calling Service: If You Have Further Questions or Damaged Accessory Parts, Contact Us at 1-800-SAMSUNG (726-7864)
If you have further questions or damaged accessory parts, contact us at 1-800-SAMSUNG (726-7864)
1. Automatic Ice Maker does not work 6. Water dispenser dripping (On some 10. Display 13. Moving and Installing
• Allow your refrigerator to operate and 12 models) • When installing, servicing or cleaning behind the
The display may differ depending on models.
cool down for 24 hours (1 full day) be- 9 3
• If the water line is not inserted into the coupler refrigerator, be sure of the following:
For details, refer to the user manual “Using the control
fore the ice maker starts producing ice. 6
properly, air could penetrate into the water line • To protect your floor's finish when moving the
panel.
causing water dripping from the water dispenser. refrigerator, cut a large section of the cardboard
• To fill the ice bucket to maximum ca-
• CAUTION : Insert the water line into the coupler com- carton and place under the refrigerator where
pacity, dispense a few cubes 8 and 16
pletely and slide in the clip at the end of the coupler. you are working.
hours after installation.
• Pull the unit straight out and push back in
• If ICE OFF is lit, the ice maker will not make ice. Red Clip
(1/4")
straight after finishing.
• To activate the ice maker, press the ICE OFF
but-ton on the control panel so it is no lon- <sample>
ger lit.
Cabinet
Tube • Recommended Temp Settings : 0ºF(-18ºC) for
2. Slow Ice cube freezing Dispenser
Door Tube
freezer and 37ºF(3ºC) for refrigerator.
• Filter indicator : The filter Indicator will be Red If you
• Check if the ice bucket is completely
1. T he Water Line must be fully Inserted to the center use water about 300 gallons (6 month) Reset the indi-
inserted. (On some models)
of transparent coupler to prevent water leakage cator (it will be Blue) after replacing the filter by holding
• Freezer temp may not be enough; from the dispenser. the "Ice Type/Water/Hold 3 sec for Filter Reset"
set it to -2ºF(-19ºC) or lower. 2. Insert the clip in the install pack and check that it button for 3 seconds.
holds the line firmly. • Ice off : Press the “Ice Off” button to turn the ice
3. Small or bubbled ice cubes or Slow Center of transparent coupler making function off.
water dispensing 14. Leveling & Door Alignment
• If the water filter is clogged, small or bubbled ice • Insert a flat-blade screwdriver into a slot on the
cubes may be produced.
clip A (1/4”)
(6.35mm) 11. Cool Select Pantry (On some models) control lever, turn it clockwise or counter-clock-
• Replace the water filter cartridge with a new one. wise to level the door.
• You can select your Pantry
temperature from among the
4. Water filter replacement 7. Fridge or freezer Compartments are following.
• Slowly turn the water filter 90°
warm Wine Party Dishes (38°F[3°C]) Control Lever
clockwise so it is aligned with the • Allow your refrigerator to operate and cool down for Fresh (38°F[3°C]) Flat-blade screw driver(-)
printing mark on the cover, lock- 24 hours (1 full day) to reach to the set temperature. Chilled (34°F[1°C])
ing the filter in position. • Also, when you put room temperature or warmer Deli (41°F[5°C]) • Open the freezer drawer to gain an access to the
Make sure to align the water filter food into your refrigerator, it may need an additional adjustable hinge pin. Next, adjust the refrigerator
label mark with center of cover fil- 24 hours for the fridge to reach the set temperature. door using the provided 0.16 inch wrench.
ter printing as illustrated.
• If you are in trouble of inserting the 8. Moisture forms on outside/inside of
water filter as high pressure of water, shut off the
water supply valve. For details, refer to the “Chan- refrigerator
RAISE
gig the water filter” section of the User Manual. • Wipe off the condensation with a dry towel (This
may occur during hot and humid seasons.) • If you need to add more height to the door, insert
After installation or when replacing the
• If the condensation occurs on the doors, turn off the provided snap rings.
water filter, dispense at least
1 gallon (2~3minutes) of water to the Energy Saving function.
PUSH
remove trapped air from the water line. • If you open the doors frequently or for too long, it
Otherwise, water may drip after dis- may cause moisture inside the fridge. 12. Food stored in refrigerator is frozen
pensing water. (On some models) • If food with too much moisture is stored near the • For details, refer
9. Noise Clicks, Pops, Cracks, Snaps cooling vents, it may get frozen. Be sure to keep to the user manual “Adjusting the level”
5. Water is not cool enough (On some moist food away from the cooling vents.
models) • These noises may be heard occasionally inside
the refrigerator. This is normal. This sound occurs
• The first glass of water may not be cold enough when various items contract or expand while
because the stored water in the water valve has temperatures are changing; especially during
not cooled completely. Dispense several glasses defrosting. This may also occur when electronic
of water and then it would be cool. devices including the ice maker are operating.
DA99-04014A REV(0.3) ENGLISH