Professional Documents
Culture Documents
TM-1816 - AVEVA Everything3D™ (2.1) Cable Tray Modelling (Rev 2.0) - Chapter 08
TM-1816 - AVEVA Everything3D™ (2.1) Cable Tray Modelling (Rev 2.0) - Chapter 08
If Isodraft is to be used to produce isometric plot files of cable trays there are a number of points that the user
must consider.
The cable tray must be data consistency checked and any errors removed before an isometric plot is
generated.
Any Branches that make up a cable tray must connect to the Main Branch. It is not possible to have a
branch off a branch, as this will cause ISODRAFT to fail.
8.2 Isodraft
When the Cable Tray Design is complete, and data consistency errors have been checked and rectified, it is
possible to produce an Isometric plot of the Cable Tray. To do this the user must switch to the Isodraft module.
This is done by selecting the Projects tab, then selecting Modules and Isodraft.
Once the user has entered the Isodraft Module, ensure the explorer is set to Model Explorer within the Display
drop down menu.
© Copyright 2013
AVEVA Solutions Limited and its subsidiaries.
70
www.aveva.com
All rights reserved.
AVEVA Everything3D (2.1)
Cable Tray Modelling TM-1816
Refer to the AVEVA Plant Isodraft Reference Manual for Isodraft functionality.
© Copyright 2013
AVEVA Solutions Limited and its subsidiaries. 71 www.aveva.com
All rights reserved.
AVEVA Everything3D (2.1)
Cable Tray Modelling TM-1816
1. Select all of the main branch cable trays created previously. Run a data consistency check and correct
any errors that may occur.
Switch modules to Isodraft and create an isometric drawing for each of the cable tray.
© Copyright 2013
AVEVA Solutions Limited and its subsidiaries.
72
www.aveva.com
All rights reserved.