Professional Documents
Culture Documents
Kongu Engineering College: Department of Mechanical Engineering
Kongu Engineering College: Department of Mechanical Engineering
(Autonomous)
PERUNDURAI, ERODE - 638 060
SCHOOL OF BUILDING AND MECHANICAL SCIENCES
DEPARTMENT OF MECHANICAL ENGINEERING
ASSIGNMENT-1
SUBJECT : 14MEE08 – GAS DYNAMICS AND JET PROPULSION
SEM / YEAR: VII- Semester / 4TH Year
SET NO:- 3
Q.NO. Questions
The pressure, temperature and Mach number at the entry of a flow passage are 2.45
bar, 26.5◦C and 1.4 respectively. If the exit Mach number is 2.5, determine for
adiabatic flow of a perfect gas (γ=1.3, R = 0.469 kJ/kg.K);
1. (i) Stagnation temperature
(ii) Temperature and velocity of gas at exit, and
(iii) The flow rate per square metre of the inlet cross-section
Air (γ=1.38, cp = 1.05 kJ/kg.K) at p1 = 5 x 105 N/m2 and T1 = 550 K flows with a
velocity of 200m/s in a 30 cm duct. Calculate:
(i) Mass flow rate
2. (ii) Stagnation temperature
(iii) Mach number
(iv) Stagnation pressure values assuming the flow as compressible and
incompressible
An aircraft is flying at an altitude of 14000 m at a Mach number of 0.82. The cross
sectional area of the inlet diffuser before the L.P compressor stage is 0.5 m2.
Determine
3.
(i) The mass of air entering the compressor per second.
(ii) The speed of the aircraft
(iii) The stagnation pressure and temperature of air at the diffuser entry.
4. Give the difference between nozzle and venture.