Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

Gsm Based Motor Control with 3 phase detection http://www.nskelectronics.com/gsm_based_mot...

NSKELECTRONICS
Gsm Based Motor Control with 3 phase detection
NSK PRODUCTS > Agricultural Automation

For More Updates Visit our New Website www.nskelectronics.in

GSM Based motor Control with 3 phase detection

In GSM based, the GSM Pump Controllers (Mobile Pump Starter) are specifically design to operate remote located
submersible pumps and motors for benefit of farmers, agriculture people and industries where wireless pump and
motor control required.Our GSM based mobile pump controller is manufactured with advanced micro controller
technology and quality process.

About 3 phase detection :

After Power Up 3 Phase will be checked


If all the 3 phase is present SMS will 3- PHASE - MODE , If any phase is absent SMS will be 1- Phase / Mode
If AUTO Mode is On After Testing 3 Phase , Motor will get ON after 5 Sec ( using Commands thru SMS u can
On/OFF AUTO Mode)

Advantages of NEW Wireless Pump Controller

• SIMPLE SMS BASED SWITCHING ON AND OFF THE PUMP.


• MESSAGE 1 TO ON THE PUMP AND MESSAGE 0 TO OFF THE PUMP
• MISSED CALLED BASED SWITCHING AFTER 3 RINGS.

1 of 2 Sunday 12 February 2017 08:26 PM


Gsm Based Motor Control with 3 phase detection http://www.nskelectronics.com/gsm_based_mot...

• AUTO MODE AND MANUAL MODE OPTION.


• OPTION FOR ACCEPTING MESSAGES FORM REGISTERD NUMBER OR ANY NUMBER.
• MOBILE NUMBER CHANGING OPTION.
• OPTION FOR CHANGING THE DELAY OF THE PUMP ON TIME
• OPTION FOR CHECKING THE SIM CARD BALANCE
• OPTION FOR CHANGING FORM 3 PHASE TO 2/3 MODE
• OPTION FOR CHECKING THE STATUES OF THE PUMP
• OPTION FOR CHECKING THE SINGLE STRENGTH OF THE DEVICE.
• 3 PHASE DETECTION SYSTEM.MOTOR DOES NOT START IF ALL THE 3 PHASE IS NOT PRESENT.
• SMS REPLY FOR EVERY OPERATION WITH FEEDBACK.
• POWER ON SMS WITH THE STATUES DISPLAY.
• DRY RUN PROTECTION SENSOR.(SENSOR LEADS OPTIONAL)
• MOTOR/PUMP TRIP SMS.

Specification

NOTE : 3 Phase sensing is used to Sence only at startup While Auto Mode is ON

• Board working Voltage is 12VAC/ 1.5 amps. If 3 phase is connected Use 440 / 12vAc 2 amps Transformer
• External High Gain Antenna with Kit Included.
• SIM card Insert Type

Search

2 of 2 Sunday 12 February 2017 08:26 PM

You might also like