Professional Documents
Culture Documents
LM 358
LM 358
LM158A-LM258A-LM358A
Rev 3
July 2005 1/16
www.st.com 16
LM158-LM258-LM358-LM158A-LM258A-LM358A
Order Codes
Temperature
Part Number Package Packaging Marking
Range
LM158N DIP-8 Tube LM158N
LM158D -55°C, +125°C
SO-8 Tube or Tape & Reel 158
LM158DT
LM258AN DIP-8 Tube LM258A
LM258AD
SO-8 Tube or Tape & Reel 258A
LM258ADT
TSSOP-8
LM258APT Tape & Reel 258A
(Thin Shrink Outline Package)
LM258AST -40°C, +105°C miniSO-8 Tape & Reel K408
LM258N DIP-8 Tube LM258N
LM258D
SO-8 Tube or Tape & Reel 258
LM258DT
TSSOP-8
LM258PT Tape & Reel 258
(Thin Shrink Outline Package)
LM358N LM358N
DIP-8 Tube
LM358AN LM358AN
LM358D
358
LM358DT
SO-8 Tube or Tape & Reel
LM358AD
0°C, +70°C 358A
LM358ADT
LM358PT TSSOP-8 358
Tape & Reel
LM358APT (Thin Shrink Outline Package) 358A
LM358ST K405
miniSO-8 Tape & Reel
LM358AST K404
2/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Absolute Maximum Ratings
Toper Operating Free-air Temperature Range -55 to +125 -40 to +105 0 to +70 °C
Tstg Storage Temperature Range -65 to +150 °C
Tj Maximum Junction Temperature 150 °C
3/16
Typical Application Schematic LM158-LM258-LM358-LM158A-LM258A-LM358A
V CC
6µA
4µA 100µA
Q5
Q6
CC
Q2 Q3
Inverting Q7
input Q1 Q4
R SC
Non-inverting Q11
Output
input
Q13
Q10 Q12
Q8 Q9
50µA
GND
4/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Electrical Characteristics
3 Electrical Characteristics
Table 2. Electrical characteristics for VCC + = +5V, VCC -= Ground, Vo = 1.4V, Tamb = +25°C (unless
otherwise specified)
LM158A-LM258A LM158-LM258
LM358A LM358
Symbol Parameter Unit
Min. Typ. Max. Min. Typ. Max.
5/16
Electrical Characteristics LM158-LM258-LM358-LM158A-LM258A-LM358A
Table 2. Electrical characteristics for VCC + = +5V, VCC -= Ground, Vo = 1.4V, Tamb = +25°C (unless
otherwise specified)
LM158A-LM258A LM158-LM258
LM358A LM358
Symbol Parameter Unit
Min. Typ. Max. Min. Typ. Max.
Slew Rate
SR VCC = 15V, V i = 0.5 to 3V, RL = 2kΩ, V/µs
CL = 100pF, unity Gain 0.3 0.6 0.3 0.6
µV/
DV io Input Offset Voltage Drift 7 15 7 30
°C
pA/
DIIio Input Offset Current Drift 10 200 10 300
°C
1. Vo = 1.4V, Rs = 0Ω, 5V < VCC+ < 30V, 0 < Vic < VCC+ - 1.5V
2. The direction of the input current is out of the IC. This current is essentially constant, independent of the state of the output
so no loading change exists on the input lines.
3. The input common-mode voltage of either input signal voltage should not be allowed to go negative by more than 0.3V. The
upper end of the common-mode voltage range is VCC+ - 1.5V, but either or both inputs can go to +32V without damage.
4. Due to the proximity of external components insure that coupling is not originating via stray capacitance between these
external parts. This typically can be detected as this type of capacitance increases at higher frequencies.
6/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Electrical Characteristics
Figure 2. Open loop frequency response Figure 3. Large signal frequency response
VO VO
100 VI 15 VI
VCC/2
+ +7V + 2k W
80
VCC = 30V &
60 -55°C Tamb +125°C 10
40
5
20 VCC = +10 to + 15V &
-55°C Tamb +125°C
0 0
1.0 10 100 1k 10k 100k 1M 10M 1k 10k 100k 1M
Figure 4. Voltage follower pulse response Figure 5. Voltage follower pulse response
RL 2 k W
OUTPUT VOLTAGE (mV)
OUTPUT
3 VCC = +15V
+
2 450 eO
el - 50pF
1
400
0 Input
350
3
Output
VOLTAGE (V)
2 300
INPUT
Tamb = +25°C
1
VCC = 30 V
250
0 10 20 30 40 0 1 2 3 4 5 6 7 8
VCC = +30V
70
VCC = +30 V
60 1
50
VCC = +15 V v cc
40 v cc /2
-
30 0.1 IO
20 VCC = +5 V + VO
10
Tamb = +25°C
0.01
0
-55 -35 -15 5 25 45 65 85 105 125 0,001 0,01 0,1 1 10 100
7/16
Electrical Characteristics LM158-LM258-LM358-LM158A-LM258A-LM358A
8 90
V CC
-
80
5 - IO 50
4 40
Independent of V CC 30
3
20
T amb = +25°C
2 10
1 0
0,001 0,01 0,1 1 10 100 -55 -35 -15 5 25 45 65 85 105 125
Figure 10. Input voltage range Figure 11. Positive supply voltage
120
INPUT VOLTAGE (V)
10
Négative 80 R L = 2k W
5 Positive 40
0 5 10 15 0 10 20 30 40
POWER SUPPLY VOLTAGE (±V) POSITIVE SUPPLY VOLTAGE (V)
120
SUPPLY CURRENT (mA)
mA ID
3
80 R L = 2k W -
2
+
40
Tamb = 0°C to +125°C
1
Tamb = -55°C
0 10 20 30 0 10 20 30
8/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Electrical Characteristics
100
75 1.2
1.05
0.9
50
0.75 VCC = 15V
0.6
25 0.45
Tamb= +25°C
0.3
0.15
0
0 10 20 30 -55-35-15 5 25 45 65 85 105 125
POSITIVE SUPPLY VOLTAGE (V) TEMPERATURE (°C)
Figure 16. Power supply rejection ratio Figure 17. Common mode rejection ratio
115 115
110 110
105 SVR 105
100 100
95 95
90 90
85 85
80 80
75 75
70 70
65 65
60-55-35-15 5 25 45 65 85 105 125 60-55-35-15 5 25 45 65 85 105 125
TEMPERATURE (°C) TEMPERATURE (°C)
9/16
Typical Applications LM158-LM258-LM358-LM158A-LM258A-LM358A
4 Typical Applications
(single supply voltage) Vcc = +5Vdc
Rf
100k W
AV= -
Rf A V = 1 + R2
R1
R1 10k W
R1 (as shown A V = -10) (As shown A V = 101)
CI 10kW
Co 1/2 eO +5V
1/2
LM158 0
2VPP LM158
eo
RB RL
6.2kW 10k W
eI ~ R2 R3
VCC 100k W 100kW R2
(V)
1M W
R1
O
10k W
e
C1
10mF
0
e I (mV)
R1 R2 e1 100kW
100kW 1MW
A = 1 + R2
V
R1
C1 (as shown A V = 11)
0.1mF
1/2 eO
Co 100kW
1/2 LM158
LM158 0 2VPP
CI eo e2 100k W
RB RL
6.2kW 10k W e3 100kW
R3
eI ~ 1M W
R4 100kW
100kW
e4 100kW
VCC
C2 R5
10mF 100kW eo = e1 + e 2 - e3 - e 4
where (e1 + e 2) ≥ (e3 + e 4)
to keep eo ≥ 0V
Figure 22. High input Z, DC differential amplifier Figure 23. High input Z adjustable gain DC
instrumentation amplifier
R1
100k W
R2 R4 R3 R4
100k W 100k W
100kW 100kW 1/2
e1 LM158
R1 eO
1/2
100kW LM158
R3 R2 Gain adjust
100kW 2k W R5
1/2 100k W
LM158 1/2
+V1 LM158 Vo R6
100k W
R7
100k W
1/2
+V2 LM158
e2
if R1 = R5 and
if R1 = R5 and R3 = R4 = R6 = R7 R3 = R4 = R6 = R7
eo = [1 + 2R1
----------- ] ( (e 2 + e1) e o = [ 1 + 2R1
R2 ----------- ] ( (e2 + e 1)
R2
As shown eo = 101 (e2 + e 1)
10/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Typical Applications
Figure 24. Using symmetrical amplifiers to Figure 25. Low drift peak detector
reduce input current
1/2 IB
I IB LM158 eo
I
eI 1/2
IB LM158 eo
IB 1/2
2N 929 LM158
C Zo
eI 2I B
1mF
0.001mF
ZI
IB 2N 929 0.001mF
IB
1/2 2IB IB
3MW LM158
R 3R 1/2
Input current compensation 1MW 3MW LM158
IB
1.5MW Input current
IB compensation
R1
100kW
C1
330pF
R2 1/2
100kW LM158 R5
470kW
+V1
R4
10MW 1/2
LM158
C2
R6
R3 330 pF 470kW
100kW Vo
1/2 R7
LM158 100kW
VCC
C3
R8 10mF
100kW
11/16
Package Mechanical Data LM158-LM258-LM358-LM158A-LM258A-LM358A
mm. inch
DIM.
MIN. TYP MAX. MIN. TYP. MAX.
A 3.3 0.130
a1 0.7 0.028
B 1.39 1.65 0.055 0.065
B1 0.91 1.04 0.036 0.041
b 0.5 0.020
b1 0.38 0.5 0.015 0.020
D 9.8 0.386
E 8.8 0.346
e 2.54 0.100
e3 7.62 0.300
e4 7.62 0.300
F 7.1 0.280
I 4.8 0.189
L 3.3 0.130
Z 0.44 1.6 0.017 0.063
P001F
12/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Package Mechanical Data
mm. inch
DIM.
MIN. TYP MAX. MIN. TYP. MAX.
e 1.27 0.050
k 8˚ (max.)
0016023/C
13/16
Package Mechanical Data LM158-LM258-LM358-LM158A-LM258A-LM358A
14/16
LM158-LM258-LM358-LM158A-LM258A-LM358A Package Mechanical Data
mm. inch
DIM.
MIN. TYP MAX. MIN. TYP. MAX.
A 1.2 0.047
e 0.65 0.0256
K 0˚ 8˚ 0˚ 8˚
L1 1 0.039
0079397/D
15/16
R e v is io n H is to r y LM158-LM258-LM358-LM158A-LM258A-LM358A
6 Revision History
Information furnished is believed to be accurate and reliable. However, STMicroelectronics assumes no responsibility for the consequences
of use of such information nor for any infringement of patents or other rights of third parties which may result from its use. No license is
granted by implication or otherwise under any patent or patent rights of STMicroelectronics. Specifications mentioned in this publication are
subject to change without notice. This publication supersedes and replaces all information previously supplied. STMicroelectronics products
are not authorized for use as critical components in life support devices or systems without express written approval of STMicroelectronics.
16/16